2003 TOYOTA MR2 SPYDER oil viscosity

1342003 MR2 from Aug. ’03 Prod. (OM17511U)
To allow proper operation of your
vehicle’s ventilation system, keep
the inlet grilles in front of the wind-
shield clear of snow, leaves, or oth-
er obstructions.
If you smell exhaust fumes in the
vehicle, drive with the windows
open. Have the cause immediately
located and corrected.
FUNCTIONS OF ENGINE OIL
Engine oil has the primary functions of
lubricating and cooling the inside of the
engine, and plays a major role in main-
taining the engine in proper working order.
ENGINE OIL CONSUMPTION
It is normal that an engine should con-
sume some engine oil during normal
engine operation. The causes of oil
consumption in a normal engine are as
follows.
Oil is used to lubricate pistons, piston
rings and cylinders. A thin film of oil
is left on the cylinder wall when a pis-
ton moves downwards in the cylinder.
High negative pressure generated when
the vehicle is decelerating sucks some
of this oil into the combustion chamber.
This oil as well as some part of the oil
film left on the cylinder wall is burned
by the high temperature combustion
gases during the combustion process.
Oil is also used to lubricate the stems
of the intake valves. Some of this oil
is sucked into the combustion chamber
together with the intake air and is
burned along with the fuel. High tem-
perature exhaust gases also burn the
oil used to lubricate the exhaust valve
stems.The amount of engine oil consumed de-
pends on the viscosity of the oil, the
quality of the oil and the conditions the
vehicle is driven under.
More oil is consumed by highspeed driv-
ing and frequent acceleration and decel-
eration.
A new engine consumes more oil, since
its pistons, piston rings and cylinder walls
have not become conditioned.
Oil consumption:
Max. 1.0 L per 1000
km (1.1 qts./600 miles, 0.9 lmp.qts./600
miles)
When judging the amount of oil con-
sumption, note that the oil may become
diluted and make it difficult to judge
the true level accurately.
As an example, if a vehicle is used for
repeated short trips, and consumes a nor-
mal amount of oil, the dipstick may not
show any drop in the oil level at all, even
after 1000 km (600 miles) or more. This
is because the oil is gradually becoming
diluted with fuel or moisture, making it
appear that the oil level has not changed.
The diluting ingredients evaporate out
when the vehicle is then driven at high
speeds, as on an expressway, making it
appear that oil is excessively consumed
after driving at high speeds.
03 07.07
Facts about engine oil
consumption

1562003 MR2 from Aug. ’03 Prod. (OM17511U)
Do not drive in excess of the speed
limit. Even if the legal speed limit
permits it, do not drive over 140
km/h (85 mph) unless your vehicle
has highspeed capability tires.
Driving over 140 km/h (85 mph) may
result in tire failure, loss of control
and possible injury. Be sure to con-
sult a tire dealer to determine
whether the tires on your vehicle
are highspeed capability tires or
not before driving at such speeds.
Do not continue normal driving
when the brakes are wet. If they are
wet, your vehicle will require a lon-
ger stopping distance, and it may
pull to one side when the brakes
are applied. Also, the parking brake
will not hold the vehicle securely.
Winter driving tips
Make sure your coolant is properly pro-
tected against freezing.
Only use “Toyota Super Long Life Coolant”
or similar high quality ethylene glycol
based nonsilicate, nonamine, nonnitrite,
and nonborate coolant with longlife hy-
brid organic acid technology.
See “Checking the engine coolant level” in
Section 72 for details of coolant type
selection.
“Toyota Super Long Life Coolant” is pre-
mixed with 50% coolant and 50% deion-
ized water. This coolant provides protec-
tion down to about 35C (31 F).
NOTICE
Do not use plain water alone.
Check the condition of the battery and
cables.
Cold temperatures reduce the capacity of
any battery, so it must be in top shape
to provide enough power for winter start-
ing. Section 73 tells you how to visually
inspect the battery. Your Toyota dealer
and most service stations will be pleased
to check the level of charge. Make sure the engine oil viscosity is
suitable for the cold weather.
See page 206 in Section 72 for recom-
mended viscosity. Leaving a heavy sum-
mer oil in your vehicle during winter
months may cause harder starting. If you
are not sure about which oil to use, call
your Toyota dealer—he will be pleased to
help.
Keep the door locks from freezing.
Squirt lock deicer or glycerine into the
locks to keep them from freezing.
Use a washer fluid containing an anti-
freeze solution.
This product is available at your Toyota
dealer and most auto parts stores. Follow
the manufacturer ’s directions for how
much to mix with water.NOTICE
Do not use engine antifreeze or any
other substitute because it may dam-
age your vehicle’s paint.
03 07.07

2072003 MR2 from Aug. ’03 Prod. (OM17511U)
Recommended viscosity:SAE 5W30
OIL008
Outside temperature
SAE 5W30 is the best choice for good
fuel economy, and good starting in cold
weather.
If SAE 5W30 oil is not available, SAE
10W30 oil may be used. However, it
should be replaced with SAE 5W30 at
the next oil change.
SOIL13
API service symbol
ILSAC certification mark
Oil identification marks
Either or both API registered marks are
added to some oil containers to help
you select the oil you should use.
The API Service Symbol is located any-
where on the outside of the container.
The top portion of the label shows the oil
quality by API (American Petroleum
Institute) designations such as SL. The
center portion of the label shows the SAE
viscosity grade such as SAE 5W30.
“EnergyConserving” shown in the lower
portion, indicates that the oil has
fuelsaving capabilities.
The ILSAC (International Lubricant Stan-
dardization and Approval Committee) Certi-
fication Mark is displayed on the front of
the container.
03 07.07

2392003 MR2 from Aug. ’03 Prod. (OM17511U)
Service specifications
ENGINE
Valve clearance (engine cold), mm (in.):Intake 0.15—0.25 (0.006—0.010)
Exhaust 0.25—0.35 (0.010—0.014)
Spark plug type: DENSO SK16R11
NGK IFR5A11
Spark plug gap, mm (in.): 1.1 (0.043) ENGINE LUBRICATION
Oil capacity (drain and ref
ill),
L (qt., Imp. qt.):
With filter 3.7 (3.9, 3.3)
Without filter 3.5 (3.7, 3.1)
“Toyota Genuine Motor Oil” is f illed in
your Toyota vehicle. Use Toyota approved
“Toyota Genuine Motor Oil” or equivalent
to satisfy the following grade and viscos-
ity. Oil grade:
API grade SL “EnergyConserving” or
ILSAC multigrade engine oil.
Recommended oil viscosity: SAE 5W30
OIL008
Outside temperature
Please contact your Toyota dealer for fur-
ther details.
03 07.07

2402003 MR2 from Aug. ’03 Prod. (OM17511U)
COOLING SYSTEM
Total capacity, L (qt., Imp. qt.):10.4 (11.0, 9.2)
Coolant type: “Toyota Super Long Life Coolant” is
filled in your Toyota vehicle at factory
fill. In order to avoid technical problems,
only use “Toyota Super Long Life
Coolant” or similar high quality ethylene
glycol based nonsilicate, nonamine,
nonnitrite, and nonborate coolant with
longlife hybrid organic acid technology.
Do not use plain water alone.
Please contact your Toyota dealer for
further details.
BATTERY
Open voltage
∗ at 20 °C (68 °F):
12.6—12.8 V Fully charged
12.2—12.4 V Half charged
11.8—12.0 V Discharged
∗: Voltage that is checked 20 minutes af-
ter the key is removed with all the lights
turned off
Charging rates:
5 A max. CLUTCH (manual transmission only)
Pedal free play, mm (in.):
5—15 (0.2—0.6)
Fluid type: SAE J1703 or FMVSS No.116 DOT 3
MANUAL TRANSAXLE
Oil capacity, L (qt., Imp. qt.): Vehicle with limitedslip differential
1.8 (1.9, 1.6)
Vehicle without limitedslip differential 1.9 (2.0, 1.7)
Oil type: Gear oil API GL4 or GL5
Recommended oil viscosity: SAE 75W90
SEQUENTIAL MANUAL TRANSAXLE
Oil capacity, L (qt., Imp. qt.): Vehicle with limitedslip differential2.1 (2.2, 1.8)
Vehicle without limitedslip differential
2.3 (2.4, 2.0)
Oil type: Gear oil API GL4 or GL5
Recommended oil viscosity: SAE 75W90 SEQUENTIAL MANUAL TRANSMISSION
SYSTEM
Fluid type:
Sequential M/T Fluid or equivalent
NOTICE: Using Fluid other than Toyota
Genuine Sequential M/T Fluid may
cause deterioration in shift performance
and durability, and ultimately damage
the sequential manual transmission of
your vehicle.
03 07.07

2512003 MR2 from Aug. ’03 Prod. (OM17511U)
MirrorsFolding rear view 66 . . . . . . . . . . . . . . . . . .
Outside rear view 64 . . . . . . . . . . . . . . . . .
Power rear view 65 . . . . . . . . . . . . . . . . . . .
N
New vehicle breakin 130
. . . . . . . . . . . . . . .
O
Odometer 75
. . . . . . . . . . . . . . . . . . . . . . . . . .
Oil Consumption 134
. . . . . . . . . . . . . . . . . . . .
Power steering 210
. . . . . . . . . . . . . . . . . . .
Viscosity and grade 206,239
. . . . . . . . . .
Oil power steering 210
. . . . . . . . . . . . . . . . . .
Open door warning light 77
. . . . . . . . . . . . . .
Operation in foreign countries 132 . . . . . . .
Overheating, Engine 166
. . . . . . . . . . . . . . . .
Overheating, Engine coolant 74
. . . . . . . . . .
Overview Engine compartment 198
. . . . . . . . . . . . . .
Instrument cluster 4
. . . . . . . . . . . . . . . . . .
Instrument panel 2
. . . . . . . . . . . . . . . . . . .
P
Parking brake
Operation 97 . . . . . . . . . . . . . . . . . . . . . . . .
Reminder light 97 . . . . . . . . . . . . . . . . . . . .
Parking brake reminder light 77 . . . . . . . . . .
Parts and tools 203 . . . . . . . . . . . . . . . . . . . . . Passenger airbag manual
onoff switch 45 . . . . . . . . . . . . . . . . . . . . .
Passenger ’s seat belt reminder light 77 . . . . . . . . . . . . . . . . . . . . .
Polishing 185 . . . . . . . . . . . . . . . . . . . . . . . . . .
Power door lock switch 12 . . . . . . . . . . . . . .
Power rear view mirror control 65 . . . . . . . .
Power steering fluid level 210 . . . . . . . . . . .
Power window switches 13 . . . . . . . . . . . . . .
Power window lock switch 14 . . . . . . . . . . . .
Pretensioners (seat belt pretensioners) 35 . . . . . . . . . . .
Protecting your Toyota
from corrosion 184 . . . . . . . . . . . . . . . . . . .
R
Radiator
Coolant, Engine 208 . . . . . . . . . . . . . . . . . .
Rear view mirror, Antiglare inside 66 . . . . . . . . . . . . . . . . . .
Rear view mirror, Power controlled 65 . . . . . . . . . . . . . . . . . .
Rear view mirrors, Folding 66 . . . . . . . . . . .
Rear view mirrors, Outside 64 . . . . . . . . . . .
Rear window defogger switch 71 . . . . . . . . .
Reporting safety defects
for U.S. owners 246 . . . . . . . . . . . . . . . . . .
S
Seat adjustment precautions
Front seats 28 . . . . . . . . . . . . . . . . . . . . . . .
Seat belt extender 34 . . . . . . . . . . . . . . . . . . . Seat belts
Cleaning 188 . . . . . . . . . . . . . . . . . . . . . . . .
Fastening 31 . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt precautions 31 . . . . . . . . . . . . . .
Seat belt pretensioners 35 . . . . . . . . . . . .
Seating capacity 149 . . . . . . . . . . . . . . . . . . .
Seats 28 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sequential manual transmission Driving with a sequential manual transmission 85 . . . . . . . . . . .
Shift pattern 85 . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 88 . . . . . . . . . . . . . . . . . . . .
Service and maintenance 192 . . . . . . . . . . .
Service reminder indicators 77 . . . . . . . . . .
Side door locks 11 . . . . . . . . . . . . . . . . . . . . .
Side vents 119 . . . . . . . . . . . . . . . . . . . . . . . . .
Soft top 20 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Spare fuse 224 . . . . . . . . . . . . . . . . . . . . . . . .
Spare tire 169 . . . . . . . . . . . . . . . . . . . . . . . . .
Spark plugs lridiumtipped spark plugs 135 . . . . . . . .
Specifications 237 . . . . . . . . . . . . . . . . . . . . .
SRS driver and passenger airbags 37 . . . . . . . . . . . . . . . .
SRS warning light 77 . . . . . . . . . . . . . . . . . . .
Starting Cold weather 154 . . . . . . . . . . . . . . . . . . . .
Engine 154 . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump starting 163 . . . . . . . . . . . . . . . . . . . .
Steering Column lock 84 . . . . . . . . . . . . . . . . . . . . . .
Tilt steering wheel 64 . . . . . . . . . . . . . . . . .
Suspension and chassis 140 . . . . . . . . . . . .
03 07.07