2003 Peugeot 307 SW Turbo

14-04-2003
Zero re-set
Your PEUGEOT dealer carries out this operation after each service.
However, if you carry out the service yourself, the re-set procedure is asfollows: Switch off the ignition,
 Press and hold the trip recorder re-set button,
 Switch on the ignition.
The display begins a countdown. When the display shows 0, release the button; the service symbol disap-pears. Important: after this operation, if you
wish to disconnect the battery, lock the vehicle and wait for at least fiveminutes, otherwise the zero re-setwill not be registered. MAINTENANCE OF PARTS SUBJECT TO WEAR and a check of consumables Certain essential components on your vehicle are subject to checks at specific frequencies: ¥ The
brake fluid is to be replaced at a maximum of every 36,000/40,000 miles
(60 000 km) or every two years.
¥ The passenger compartment filter must be checked at each serviceby a
PEUGEOT dealer (services and intermediate visits) or more often, depending
on the environment (dust, pollution, etc.)
¥ Replacement of the timing belt: consult a PEUGOT dealer.
¥ For the 2 litre HDI turbo diesel engine (110 bhp) , maintenance of the
particulate emission filter and topping up of the additive reservoir must be
carried out at a maximum of every 72,000 miles (120 000 km) , by a
PEUGEOT dealer.
¥ Air bags and pretensioning parts on seat belts must be checked every
10 years .
¥ The check on tyre inflation pressure must be carried out cold at least once a
month .
PEUGEOT SERVICING 21

14-04-2003
PEUGEOT SERVICING23
MAINTENANCE CYCLE FOR YOUR 307 SW DIESEL
Service every 2 years or 12,000 miles (20 000 km) maximum
1st service at 6,000 (10 000 km) or 6 months*.
This is necessary
in order to benefit from the warranty.
+ maintenance of
particulate emission filter
2,0 l HDI 110 bhp + maintenance of
particulate emission filter for engine
2.0 l HDI 110 bhp
These services are to be carried out: - imperatively with 5W40 synthetic oil for the HDI Turbo Diesel engines fitted with a particulate emissions filter ,
- with synthetically based oil , synthetic oil or Fuel Economy oil for the other HDI Turbo Diesel engines .
Arduous conditions of use (see corresponding section).
* Whichever comes first.
Intermediate top-up visit included in the Fixed Services.
72,000 (120 000) 84,000 (140 000) 96,000 (160 000) 108,000 (180 000) 120,000 (200 000) 132,000 (220 000) 144,000 (240 000)
MILES (KM) 12,000 (20 000) 24,000 (40 000) 36,000 (60 000) 48,000 (80 000) 60,000 (100 000)

14-04-2003
DIESEL
DIESEL
PETROL PETROL
(1) Minimum grade: Petrol engines ACEA A3 and API SH/SJ; Diesel engines: ACEA B3 and API CF/CD
ACEA = Association des Constructeurs EuropŽens Automobiles (Association of European Automobile Manufacturers) -
API = American Petroleum Institute.
If oil is used which does not conform to the ACEA A3-B3 standards, this requires the "Arduous Conditions" servicing schedule to be followed, which involves shorter intervals between services.
* This Fuel Economy oil can only be used in engines designed for its use.
Use 5W40 synthetic oil only for HDI Turbo Diesel engines fitted with a particulate emission filter.
26
TRADE NAMES OF APPROVED AND RECOMMENDED ENGINE LUBRICANTS IN EUROPE (1)

14-04-2003
PRACTICAL INFORMATION
138
1 -
Power steering reservoir.
2 - Windscreen/headlamp* wash
reservoir.
3 - Coolant reservoir. 4 -
Brake fluid reservoir.
5 - Battery.
6 - Fuse box.
7 - Air filter. 8 -
Dipstick.
9 - Engine oil reservoir.
10 - Priming pump.
* According to destination.
2 LITRE TURBO DIESEL HDI ENGINE (90 bhp/110 bhp)

14-04-2003
TECHNICAL DATA161
3HRHYB 3HRHSB
Manual Manual
(5 speed) (5 speed) DIESEL ENGINES
ENGINES 2 litre T
urbo HDI 90 bhp 2 litre Turbo HDI 110 bhp
Cubic capacity (cm 3
) 1 998 1 997
Bore x stroke (mm) 85 x 88 85 x 88 EU standard maximum
power (kW) 66 79
Maximum power at engine
speed (rpm) 4 000 4 000
EU standard maximum torque (Nm)205250
Maximum torque at engine speed (rpm)1 9001 750
Fuel Diesel Diesel
Catalytic converter Yes Yes
Particulate emission filter Non Yes
OIL CAPACITIES (litres)
Engine (with cartridge replacement) 4,5 4,5
Gearbox-Final drive 1,9 1,85
MODELS: Model codes GEARBOX

14-04-2003
Consumption In accordance with directive 99/100 [In MPG (litres/100km)]
Engine Gearbox Model Circuit Circuit Circuit Emission of
codes Urban Inter-urban Mixed CO 2by
weight (g/km)
1,6 litre 16V Manual 9,9 6,3 7,7 178
1,6 litre 16V Automatic 11,2 6,4 8,3 194
2 litre 16V Manual 3HRFNC/IF 11,5 6,3 8,3 194
2 litre 16V Automatic 3HRFNE 13,1 6,5 8,8 206
2 litre Turbo HDI 90 hpManual3HRHYB 7,1 4,5 5,4 143
2 litre Turbo HDI 110 hpManual3HRHSB 7,2 4,4 5,4 143
TECHNICAL DATA
162
Fuel consumption values correct at time of printing. 3HNFUB
3HNFUC/IF
3HNFUE
3HNFUF/IF

14-04-2003
PETROL
Engine 1,6 litre 16V 2 litre 16V
Gearbox Manual Automatic Manual Automatic
Model codes : 3HNFUB 3HNFUE 3HRFNC/IF 3HRFNE 3HNFUC/IF 3HNFUF/IF
¥ Kerb weight 1399 1435 1430 1466
¥ Gross vehicle weight (GVW) 1923 1959 1941 1977
¥ Gross train weight (GTW*) 3023 3059 3441 3477
¥ Unbraked trailer 695 715 715 730
¥ Braked trailer (within GTW) 1100 1100 1500 1500
TECHNICAL DATA 163
Weights and Towing loads (in kg)
* The speed of a towing vehicle is limited to 60mph (100 km/h). DIESEL
Engine 2 litre Turbo HDI 90 hp 2 litre Turbo HDI 110 hp
Gearbox Manual Manual
Model codes : 3HRHYB 3HRHSB
¥ Kerb weight 1465 1496
¥ Gross vehicle weight (GVW) 1984 2016
¥ Gross train weight(GTW*) 3484 3516¥ Unbraked trailer 730 745
¥ Braked trailer (within GTW) 1500 1500