2003 Peugeot 307 CC power steering

PEUGEOT SERVICING25
TYPE A AND C SERVICES AND THE INTERMEDIATE VISIT
Level
Operations Operation descriptions1st service visitA C Intermediate
DRAIN AND REFILLÐ Engine oil
Ð Oil filterÐ Fuel filter*REPLACEÐ Air filter elementÐ Spark plugsÐ Engine oil (check + top-up)Ð Manual gearbox oil (check + top-up)Ð Battery (check + top-up) if removable capLEVELSÐ Front windscreen wash (check + top-up)Ð Coolant (check + top-up)Ð Brake fluid (check + top-up)Ð Power steering fluid (check + top-up according to specification)Ð Operation of lights and indicatorsÐ Condition of glass, headlamp and light lenses and mirrorsÐ HornÐ Windscreen jetsÐ Condition of wiper bladesÐ Condition and tension of the ancillary drive beltsÐ HandbrakeÐ Condition of hydraulic circuits (hoses and covers) and check for leaksCHECKÐ Condition of rubber boots and gaitersÐ Brake pad wear Ð Play in hubs, link rods, ball joints, flexible mountingsÐ Shock absorbers: check for leaksÐ Rear drum brake lining wearÐ Condition and pressure of tyres (including spare tyre)Ð Emission control check according to current legislationÐ Passenger compartment filter (according to specification) Ð Visual check of the whole vehicle by a PEUGEOT dealer
SERVICE*Ð Courtesy vehicle
ROAD TEST
: All driving conditions: If there are specific conditions * According to destination.22-09-2003

22-09-2003
PEUGEOT SERVICING27
Recommended lubricants The oils which appear in the table opposite are suitable for most pur-poses. The diagram opposite states the optimum range of viscosity depend-ing on the temperatures at which theoils are to be used. It is also possible to use 'superior quality' synthetic oils. In the absence of semi-synthetic or
synthetic oils, oils of API SH/SJ qualitymay be used by following the 'arduousconditions' servicing schedule whichspecifies shorter service intervals. Do not hesitate to ask for advice
from an approved PEUGEOT dealerto maintain driving pleasure and tominimise the maintenance cost ofyour vehicle. For vehicles outside Europe, please
contact a local PEUGEOT dealer.
ONLY ONLY
Manual ESSO GEAR OIL BVTOTAL TRANSMISSION BVgearbox 75W-80 PR 9736.41 75W-80 PR 9730.A2
ONLY
Automatic ESSO ATF 4HP20-AL4
gearbox PR 9736.22
Power steering FLUIDE DA PR 9730.A1
Brake fluid PEUGEOT DOT4Coolant
PROCOR TM108/GLYSANTIN G33 or REVKOGEL 2000ONLY Protection to minus 35 ¡C
Other recommended products

22-09-2003
PRACTICAL INFORMATION127
1 -
Power steering reservoir.
2 - Windscreen/headlamp* wash
reservoir.
3 - Coolant reservoir. 4 -
Brake fluid reservoir.
5 - Battery.
6 - Fuse box.
7 - Air filter. 8 -
Dipstick.
9 - Engine oil reservoir.
* According to destination.
1.6 LITRE 16V PETROL ENGINE

22-09-2003
PRACTICAL INFORMATION
128
1 -
Power steering reservoir.
2 - Windscreen/headlamp* wash
reservoir.
3 - Coolant reservoir. 4 -
Brake fluid reservoir.
5 - Battery.
6 - Fuse box.
7 - Air filter. 8 -
Dipstick.
9 - Engine oil reservoir.
* According to destination.
2 LITRE 16V PETROL ENGINE

22-09-2003
PRACTICAL INFORMATION129
1 -
Power steering reservoir
2 - Windscreen/headlamp* wash reservoir
3 - Coolant reservoir 4 -
Brake fluid reservoir
5 - Battery
6 - Fuse box
7 - Air filter 8 -
Dipstick
9 - Engine oil filler cap
* According to destination.
2 LITRE 16V (180 bhp) PETROL ENGINE

22-09-2003
PRACTICAL INFORMATION
130
CHECKING THE LEVELS Oil level 
Check the level regularly and top
up between changes. The maxi-mum consumption is 0.5 l per600 miles (1,000 km). Check the level with the vehicle level, engine cold, using the oil levelgauge on the instrument panel orthe dipstick.
Dipstick There are two marks onthe dipstick: A=maximum
Never fill past this mark
B= minimum
To maintain the reliability of engines and emissioncontrol systems, the useof additives in engine oilis prohibited.
Oil change According to the information given in
"PEUGEOT SERVICING" .
Note: avoid used oil coming into
prolonged contact with the skin. Viscosity selection In all cases, the oil selected must meet the manufacturer's requirements. Brake fluid level:
Ð The level must always be between
the DANGER and MAXIMUM
marks in the reservoir.
Ð If the level drops substantially, contact a PEUGEOT dealer
immediately.
Fluid change:
Ð must be carried out according to the manufacturer's servicing schedule.
Ð use fluids recommended by the manufacturer, which fulfil DOT4standards.
Note: brake fluid is harmful to health
and very corrosive. Avoid all contactwith the skin. Cooling system Use the fluid recommended by the
manufacturer. When the engine is warm, the tem- perature of the coolant is controlled
by the engine fan. As this fan canoperate with the ignition keyremoved and because the coolingsystem is pressurised, wait for atleast one hour after the engine hasstopped before carrying out anywork. Slacken the cap to the first notch torelease the pressure to prevent anyrisk of scalding. When the pressurehas dropped, remove the cap andtop up the level. Note:
the coolant does not need to
be changed. Used oil Do not dispose of used oil, brake fluid or coolant into drains or into theground. Power steering reservoir  Open the reservoir, with the engine at ambient temperature.The level should always beabove the MIN. mark and closeto the MAX. mark.
Windscreen and headlamp* wash level For best quality cleaning and for your
safety, we would advise that you use
products recommended by PEUGEOT.
* According to destination.

22-09-2003
PRACTICAL INFORMATION
140
Engine compartment fuses Fuse box
To access the fuse box in the engine compartment (next to the battery): 
unclip the cover.
Carefully close the cover and refit the style cover when you havefinished.
Fuse N¡ Rating Functions 1* 50 A Fan unit.
2* 30 A ESP/ABS pump motor.
3* 30 A ESP/ABS solenoid valves.
4* 70 A Built-in Systems Interface supply.
5* 70 A Built-in Systems Interface supply.
6* 60 A Retractable roof pump.
7* 30 A Ignition switch.
8* 70 A Power steering electro-pump unit.
Rating Functions
FV1* 20 A Single speed fan unit.
FV2* 30 A Dual-speed fan unit.
The electrical system of your vehicle is designedto operate with standardor optional equipment.
Before installing other electricalequipment or accessories on yourvehicle, contact a PEUGEOT deal-
er. PEUGEOT will not accept respon- sibility for the cost incurred inrepairing your vehicle or for recti-fying the malfunctions resulting
from the installation of accessoriesnot supplied and not recommend-ed by PEUGEOT and not installedin accordance with its instructions,in particular where the equipmentin question consumes more than
10 milliamperes.
* The maxi-fuses provide additional protection for the electrical sys-
tems. All work on the maxi-fusesand external fuses must be car-
ried out by a PEUGEOT dealer.
External
fuse N¡

22-09-2003
PRACTICAL INFORMATION141
Fuse N¡ Rating
Functions
1 10 A Automatic gearbox reversing lights switch - Automatic gearbox starting inhibitor relay control - Manual gearbox reversing lights switch -
Vehicle speed sensor.
2 15 A Canister solenoid valve - Fuel pump.
3 10 A Power steering control unit - ABS or ESP control unit.
4 10 A Injection control unit - Fan unit relay control - Additional heating relay control -
Automatic gearbox control unit - Automatic gearbox sequential control -
Automatic gearbox shiftlock relay.
5Ð Not used.
6 15 A Front fog lamps.
7Ð Not used.
8 20 A Fan unit relay control - Engine ECU supply.
9 15 A Left-hand dipped beam.
10 15 A Right-hand dipped beam.
11 10 A Right-hand main beam.
12 10 A Left-hand main beam.
13 15 A Horn.
14 10 A Wash-wipe pump.
15 30 A Oxygen sensors - Exhaust gas recirculation solenoid valve - Ignition coil -
Injectors supply.
16 30 A Petrol engine air pump with automatic gearbox.
17 30 A Low/high speed wiper.
18 40 A Air conditioning blower.