2003 MERCEDES-BENZ ML320 change wheel

238 Practical hintsWhere will I find ...?Vehicle jack
Please also observe the safety guidelines
in the “Flat tire” section (
page 255)
when using the jack.
Vehicle with CD-changer*
To access the vehicle tool kit, swing the
CD-changer out of the panel.
1Screw
2CD-changer

Turn screw1 counterclockwise.

Swing the CD-changer2 out of the pan-
el.
Electric air pump (ML 55 AMG)
The electric air pump is located behind the
spare wheel.
Remove the spare wheel (
page 240).
1Electric air pump

Open the strap and remove the electric
air pump.
Warning!
G
The jack is designed exclusively for jacking
up the vehicle at the jack take-up brackets
built into both sides of the vehicle. To help
avoid personal injury, use the jack only to lift
the vehicle during a wheel change. Never
get beneath the vehicle while it is supported
by the jack. Keep hands and feet away from
the area under the lifted vehicle. Always
firmly set parking brake and block wheels
before raising vehicle with jack.
Do not disengage parking brake while the
vehicle is raised. Be certain that the jack is
always vertical (plumb line) when in use, es-
pecially on hills. Always try to use the jack
on level surface.
Make sure that the jack arm is fully seated
in the jack take-up bracket. Always lower
the vehicle onto sufficient capacity jack-
stands before working under the vehicle.

239 Practical hints
Where will I find ...?
Spare wheel (space-saver tire)
Use the spare wheel only temporarily,
while observing the following restrictions:

Do not exceed vehicle speed of
50 mph (80 km / h).


Drive to the nearest repair facility to
have the flat tire repaired or replaced
as appropriate.


Do not operate vehicle with more than
one spare wheel mounted.Removing spare wheel (except
ML 55 AMG)
The spare wheel is located behind the rear
bumper.
1Cover

Hold left and right side of cover1 and
pull away from bumper.2Screw
3Spare wheel carrier
4Lever

Turn screw2 counterclockwise using
the wrench (
page 237).
Screw2 remains in spare wheel
carrier3.

Lift spare wheel carrier slightly and
push lever4 to the right using screw-
driver (
page 237).

Swing spare wheel carrier down and
pull it out from under the bumper.
Warning!
G
The dimensions of the spare wheel are dif-
ferent from those of the road wheels. As a
result, the vehicle handling characteristics
change when driving with a mounted spare
wheel.iPlease comply with the instructions for
“Mounting the spare wheel”
(page 255).
Warning!
G
Exercise care when removing or installing
spare wheel to prevent personal injury.

255 Practical hints
Flat tire
Flat tire
Mounting the spare wheel Preparing the vehicle

Park the vehicle as far as possible from
moving traffic on a hard surface.

Turn on the hazard warning flashers.

Engage the steering wheel lock in the
straight ahead position and set the
parking brake.

Move the selector lever toP.

Have any passenger exit the vehicle at
a safe distance from the roadway.

Take the spare wheel out of its carrier
(page 239).
ML 55 AMG: (
page 240).Lifting the vehicle

Prevent the vehicle from rolling away
by blocking wheels with wheel chocks
(not included) or other sizable objects.
When changing wheel on a level surface:

Place one chock in front of and one be-
hind the wheel that is diagonally oppo-
site to the wheel being changed.
When changing wheel on a hill:

Place chocks on the downhill side
blocking both wheels of the other axle.

Take the two-piece wheel wrench and
the jack out of the rear compartment
area (
page 237). Assemble wheel
wrench.
Warning!
G
The dimensions of the spare wheel are dif-
ferent from those of the road wheels. As a
result, the vehicle handling characteristics
change when driving with a mounted spare
wheel. Adapt your driving style accordingly.
The spare wheel is for temporary use only.
When driving with spare wheel mounted, en-
sure proper tire pressure and do not exceed
vehicle speed of 50 mph (80 km/h).
Drive to the nearest Mercedes-Benz Light
Truck Center as soon as possible to have the
spare wheel replaced with a regular road
wheel.
Never operate the vehicle with more than
one spare wheel mounted.

256 Practical hintsFlat tire

On wheel to be changed, loosen but do
not yet remove the wheel bolts (ap-
proximately one full turn with wrench).
The jack take-up brackets are located di-
rectly behind the front wheel housings and
in front of the rear wheel housings.1Take-up bracket
2Jack

Place jack on firm ground.

Position jack2 under the take-up
bracket1 so that it is always vertical
(plumb-line) as seen from the side,
even if the vehicle is parked on an in-
cline.

Jack up the vehicle until the wheel is a
maximum of 1.2 in (3 cm) from the
ground. Never start engine while vehi-
cle is raised.
Warning!
G
The jack is designed exclusively for jacking
up the vehicle at the jack take-up brackets
built into both sides of the vehicle. To help
avoid personal injury, use the jack only to lift
the vehicle during a wheel change. Never
get beneath the vehicle while it is supported
by the jack. Keep hands and feet away from
the area under the lifted vehicle. Always
firmly set parking brake and block wheels
before raising vehicle with jack.
Do not disengage parking brake while the
vehicle is raised. Be certain that the jack is
always vertical (plumb line) when in use, es-
pecially on hills. Always try to use the jack
on level surface. Make sure that the jack
arm is fully seated in the jack take-up brack-
et. Always lower the vehicle onto sufficient
capacity jackstands before working under
the vehicle.
!Do not position the jack on the body of
the vehicle, as this may cause damage
to the vehicle.

302 IndexCargo floor plates 144
Installing 144
Removing 144
Storing 144
Cargo tie-down rings 140
Catalytic converter 198
CD-changer* 238
Center console 27
Lower part 28
Upper part 27
Central locking
Automatic 89
From inside 89
Switch 90
Unlocking from inside 89, 90
Central locking switch 90
Certification label 276
Charge indicator lamp 233
Charging
Vehicle battery 262
Chart
Fuses 271
CHECK ENGINE malfunction indicator
lamp 232
Checking
Coolant level 201, 206Oil level 201, 203
Tire inflate pressure 201
Vehicle lighting 201
Checking weights
Trailer and vehicle 193
Checklist
Off-road driving 187
Returning from off-road driving 191
Child safety 63
Airbags 56
Infant and child restraint systems 54,
60, 63
LATCH child seat mounts 68
Child safety switch see Blocking of rear
door window operation 69
Cigarette lighter
Front center console 156
Cleaning
Cup holder 221
Gear selector lever 221
Hard plastic trim items 221
Headlamps 121
Headliner 221
Instrument cluster 221
Leather upholstery 222
Light alloy wheels 221MB Tex upholstery 222
Plastic and rubber parts 222
Seat belts 221
Steering wheel 221
Windows 220
Windshield 48
Wiper blades 220
Cleaning and care of the vehicle see
Vehicle care 217
Clock 26, 112
Closing
Glove box 152
Hood 203
Liftgate 88
Rear quarter windows* 136
Side windows 135
Sliding/pop-up roof 246
Sliding/pop-up roof* 137
Closing sliding/pop-up roof
In an emergency 246
Cockpit 22, 293
Combination switch 102
High beam flasher 47, 102
Turn signals 47
Windshield wipers 47

317 Index
Tilt
Head restraint 36
Time
Setting hours 112
Setting minutes 112
Tire inflation pressure
Checking 201, 211
Tire speed rating 184, 296
Tire traction 183
Tires 209, 279, 291
Direction of rotation 210
Driving instructions 182
Retreads 209
Rims and tires 279
Rotating 212
Service life 210
Temperature 211
Temperature grades 292
Tread depth 213
Wear pattern 212
Winter 213
Tools 237
Vehicle jack 237
Vehicles with CD-changer* 238
Wheel bolt wrench 237Tow-away alarm 29, 79
Arming 79
Disarming 79
Disarming for transport 79
Towing
Trailer 192
Towing a trailer 194
Automatic transmission 117
Towing eyes
Front 269
Rear 269
Towing the vehicle 267
Stranded vehicle 270
Tracking services
For stolen vehicle 168
Traction 291, 296
Trailer
Attaching 194
Loading 193
Towing 194
Trailer hitches 192
Trailer towing 192
Attaching a trailer 194
Checking weights 193
Electrical connections 192
Hitches 192Loading 193
Parking 196
Weights and ratings 193
Trailer weights and ratings 193
Transfer case 296
Transmission control – LOW RANGE
mode 118
Switching off 118
Switching on 118
Transmission selector lever 245
Unlocking manually 245
Tread depth (tires) 213
Treadwear 291
Trip computer
Average fuel consumption 175
Compass 173
Distance remaining 175
Selecting functions 172
Setting date 172
Stop watch 175
Switching on 172
Trip computer* 29, 172
Country 176
Language 176
Trip odometer
Resetting 112

319 Index
Vehicle lighting
Checking 201
Vehicle tool kit 237
Vehicle with CD-changer* 238
Vehicle washing 219
VIN (Vehicle Identification Number) 276,
297
Voice control system* 297
W
Warning indicators
Parktronic* 150
Warning sounds
Drivers seat belts 60
Parking brake 46
Warranty coverage 275
Washer fluid see Windshield washer fluid
Washing the vehicle 217
Wear pattern (tires) 212
Weights 283
Wheel bolt wrench 237
Wheel change
Tightening torque 258
Wheels
Rotating 212
Tires and wheels 209Window curtain airbags 59
Windows see Side windows
Windshield
Defogging 128
Refilling washer fluid 208
Replacing wiper blades 254
Washer fluid 208, 290
Washer system 290
Windshield washer fluid 290
Filler neck 208
Mixing ratio 290
Refilling 208
Wiping with 48
Windshield washer system 290
Windshield wipers 47, 122
Intermittent 47
Interval wiping 122
Normal wiper speed 47
Rain sensor* 122
Rear window wiper/washer 48
Replacing wiper blades 254
Simultaneous wiping and washing 48
Single wipe 48
Switching on 47
Wiping with windshield washer fluid 48Winter driving 213
Block heater 214
Snow chains 214
Tires 213
Winter tires 280
Winter driving instructions 184
Winter tires 213, 280
Wiper blades
Cleaning 220
Installing 254
Removing 254
Replacing 254
Wiper switch 47
Wiper/washer
Rear window 48
Wiping
And washing simultaneously 48
Intermittent 47, 122
With windshield washer fluid 48
Wiping and washing simultaneously 48
X
Xenon headlamps
Bi-Xenon 293