2003 MERCEDES-BENZ E-CLASS brake fluid

307 Practical hints
What to do if …
Except Canada:;Canada only:3
Brakes overheated!
Drive carefully!
The brake system is overheated due to an
excessive load on the brakes.

Relieve the load on the brake sys-
tem.

Drive more smoothly and think
ahead to avoid unnecessary braking.

When driving down slopes, shift into
a lower gear to use the engine’s brak-
ing power (
page 153).

Cautiously continue driving so that
the air stream will cool down the
brakes.
Display
Possible cause
Suggested solution
Warning!
G
Driving while these messages are displayed
can result in an accident. Have your brake
system checked immediately.
If there is a malfunction in the SBC brake
system, we recommend that the vehicle be
transported with all wheels off the ground
using flatbed or appropriate wheel lift/dolly
equipment. A tow bar must be used if cir-
cumstances do not permit the use of the
recommended towing methods and the ve-
hicle requires towing with all four wheels on
the ground. Towing the vehicle with all four
wheels on the ground is only permissible for
distances up to 30 miles (50 km) and at a
speed not to exceed 30 mph (50 km/h). For
more information, refer to "Towing the vehi-
cle" (
page 348).
If the SBC brake system enters its
limp-home (emergency operation) mode,
the driver must apply significantly greater
brake pedal pressure and depress the pedal
much further than normal to obtain braking
effect. If necessary, apply full pressure to
the brake pedal. Brakes are only applied to
the front wheels. Stopping distance is in-
creased!
Low brake fluid in the reservoir may cause
the braking system to fail!
Don’t add brake fluid before checking the
brake system. Overfilling the brake fluid
ProCarManuals.com

308 Practical hintsWhat to do if …reservoir can result in spilling brake fluid on
hot engine parts and the brake fluid catch-
ing fire. You can be seriously burned.iIf you find that the brake fluid in the
brake fluid reservoir has fallen to the
minimum mark or below, have the
brake system checked for brake pad
thickness and leaks.!Brake pad thickness must be visually
inspected at the intervals specified in
the Service Booklet.
ProCarManuals.com

366 Technical dataFuels, coolants, lubricants etc.
Fuels, coolants, lubricants etc.CapacitiesVehicle components and their respective
lubricants must match. Therefore use only
brands tested and recommended by us.Please refer to the Factory Approved Ser-
vice Products Pamphlet, or inquire at your
authorized Mercedes-Benz Center.
Model
Capacity
Fuels, coolants, lubricants etc.
Engine with oil filter
E320
E500
8.5 US qt (8.0 l)
8.0 US qt (7.5 l)
Recommended engine oils
Automatic transmission
8.0 US qt (7.5 l)
MB Automatic Transmission Oil
1
1MB part no. 001 989 21 03 10Rear axle
E320
E500
1.06 US qt (1 l)
1.37 US qt (1.3 l)
Hypoid gear oil SAE 85 W 90
Power steering
approx. 1.1 US qt (1.0 l)
MB Power Steering Fluid (Pentosin
CHF 11S)
Front wheel hubs
approx. 3.0 oz (85 g) each
High temperature roller bearing grease
Brake system
0.64 US qt (0.6 l)
MB Brake Fluid (DOT 4+)
Cooling system
E320
E500
approx. 10.7 US qt (10 l)
approx. 11.9 US qt (11.3 l)
MB 325.0 Anticorrosion / Antifreeze
Fuel tank including a reserve of
21.12 US gal (80.0 l)
2.38 US gal (9.0 l)
Premium unleaded gasoline:
Posted Octane 91 (Avg. of 96
RON / 86 MON)
Air conditioner system
R-134a refrigerant and special PAG lu-
bricant oil (never R-12)
ProCarManuals.com

368 Technical dataFuels, coolants, lubricants etc.Engine oils
Engine oils are specifically tested for their
suitability in our engines. Therefore, use
only engine oils recommended by
Mercedes-Benz. Information on recom-
mended brands is available in the Factory
Approved Service Products Pamphlet, or at
your authorized Mercedes-Benz Center.
Please follow FSS recommendations for
scheduled oil changes. Failure to do so
could result in engine damage not covered
by the Mercedes-Benz Limited Warranty.
Engine oil additives
Do not blend oil additives with engine oil.
They may be harmful to the engine opera-
tion.
Damage or malfunctions resulting from
blending oil additives are not covered by
the Mercedes-Benz Limited Warranty.Air conditioner refrigerant
R-134a (HFC) refrigerant and special PAG
lubricating oil is used in the air conditioner
system.
Never use R-12 (CFC) or mineral-based lu-
bricating oil. Otherwise damage to the
system will occur.
Brake fluid
During vehicle operation, the boiling point
of the brake fluid is continuously reduced
through the absorption of moisture from
the atmosphere. Under extremely strenu-
ous operating conditions, this moisture
content can lead to the formation of bub-
bles in the system, thus reducing the sys-
tem’s efficiency.
Therefore, the brake fluid must be re-
placed every two years, preferably in the
spring.
Only brake fluid approved by
Mercedes-Benz is recommended. Your au-
thorized Mercedes-Benz Center will pro-
vide you with additional information.
ProCarManuals.com

391 Index
Storing exterior mirror parking
position 111
MON 260
MON (Motor Octane Number) 378
Mph or km/h in speedometer 134
Multicontour seat* 104
Multifunction display 121, 378
Selecting language 135
Standard display 125
Multifunction display messages
ABS 296
BAS 297, 298
Batteries 303, 304
Brake pads 305
Coolant 311, 312
Coolant level 311
Distronic* 300
Doors 323
Easy-entry/exit feature 310
Engine oil level 300
Fuel reserve tank 313, 323
Hood 313
Key 313, 323
KEYLESS-GO* card 309
Lamps 313–??
Parking brake 310SBC brake system 305, 306
Seat belts 310
Steering gear oil level 318
Telephone* 309
Trunk lid 310
Washer fluid 311
Multifunction steering wheel 24, 122,
378
Buttons 122
N
Network provider 148
Night security illumination 114
O
Occupant safety 56
Airbags 57
Children and airbags 58
Children in the vehicle 65
Fastening the seat belt 40
Infant and child restraint systems 65
Seat belts 40, 59
Oil
Viscosity 376
One-touch gearshifting 152
Canceling gear range limit 152
Downshifting 152Upshifting 152
Opening 331
Ashtray 231
Doors from the inside 93
Glove box 226
Side windows 184
Sliding/pop-up roof* 187
Sliding/pop-up roof* with
SmartKey 188, 192
Trunk 88, 96
Trunk from the inside 94
Windows 184
Windows with SmartKey 185
Operating
Cassette player 128
CD player* 127, 128
Garage door opener 246
Integrated remote control 246
Radio 127
Safety 16
Telephone* 147
Vehicle outside the USA and
Canada 13
Operating safety 16
Operator’s Manual 10
Outside temperature indicator 120
ProCarManuals.com

398 Index
Cigarette lighter 232
Garage door opener 243
Tele Aid* 234
Telephone* 233
V
Vehicle
Individual settings 130, 132
Proper use of 16
Towing 348
Vehicle care
Parktronic* system sensor 284
Vehicle level
Changing 210
Setting 210
Automatic 210
Manual 210
Vehicle level control system
AIRMATIC DC 209
Vehicle tool kit 326
VIN (Vehicle Identification Number) 380
Voice recognition system* 380W
Warning lamps see Lamps, indicator and
warning
Warning sounds
Distance warning function* 205
Distronic* 199
Drivers seat belts 61
Parking brake 45
Warranty coverage 357
Weights 365
Wheel change 338
Tightening torque 342
Window curtain airbags 61
Windshield
Defogging 166, 177
Windshield washer fluid
Message in display 311
Wiping with 48Windshield wipers 47
Fast wiper speed 47
Intermittent wiping 47
Replacing wiper blades 337
Single wipe 48
Switching on 47
Wiping with windshield washer
fluid 48
Winter driving
Block heater 274
Snow chains 274
Tires 273
Transmission program mode 155
Wiping
And washing simultaneously 48
Interval 47
With windshield washer fluid 48
X
Xenon headlamps
Bi-Xenon 375
ProCarManuals.com