2003 HONDA PILOT brake

To jump start your vehicle, f ollow
these directions closely:
If your vehicle’s battery has run
down,youmaybeabletostartthe
engine by using a booster battery.
Although this seems like a simple
procedure, you should take several
precautions.
Put the transmission in Neutral or
Park, and set the parking brake. Open the hood and check the
physical condition of the battery
(see page ). In very cold
weather, check the condition of
the electrolyte. If it seems slushy
or like ice, do not try jump starting
until it thaws.
Turn of f all the electrical acces-
sories: heater, A/C, climate
control, stereo system, lights, etc.
Your vehicle has the Immobilizer
System. You should use a
properly-coded master or valet key
to start the engine (see page ).
A key that is not properly coded
will cause the immobilizer system
indicator in the dash panel to blink
rapidly.
Do you have f uel? Turn the
ignition switch to ON (II) for a
minute and watch the f uel gauge.
The low f uel level warning light
may not be working, so you were
not reminded to f ill the tank.
There may be an electrical
problem, such as no power to the
f uel pump. Check all the f uses
(see page ).
If youfindnothingwrong,youwill
need a qualif ied technician to f ind
the problem. See on page . You cannot start your Honda by
pushing or pulling it. 1.
2.
80
356 358 302
CONT INUED
Jump Starting
Emergency
Towing
If Your Engine Won’t Start, Jump Starting
T aking Care of t he Unexpect ed343
A battery can explode if you do
not follow the correct procedure,
seriously injuring anyone
nearby.
Keep all sparks, open flames,
and smoking materials away
from the battery. If a battery sits in extreme cold, the
electrolyte inside can f reeze.
Attempting to jump start with a f rozen
battery can cause it to rupture.

If you see steam and/or spray
coming f rom under the hood, turn
of f the engine.
If you do not see steam or spray,
leave the engine running and
watch the temperature gauge. If
the high heat is due to overloading
(climbing a long, steep hill on a
hot day with the A/C running, for
example), the engine should start
to cool down almost immediately.
If it does, wait until the tempera-
ture gauge comes down to the mid-
point then continue driving. Saf ely pull to the side of the road.
Put the transmission in Neutral or
Park and set the parking brake.
Turn of f the heating and cooling/
climate control system and all
otheraccessories.Turnonthe
hazard warning indicators.
Keep the ends of the jumper cables
away from each other and any metal
on the vehicle until all are
disconnected. Otherwise, you may
cause an electrical short.
The pointer of your vehicle’s
temperature gauge should stay in
the midrange under most conditions.
Itmaygohigherif youaredrivingup
a long steep hill on a very hot day. If
it climbs to the red mark, you should
determine the reason. Your vehicle can overheat for several
reasons, such as lack of coolant or a
mechanical problem. The only
indication may be the temperature
gauge climbing to or above the red
mark. Or you may see steam or
spray coming f rom under the hood.
In either case, you should take
immediate action.
1.
2. 3.
CONT INUED
T aking Care of t he Unexpect ed
Jump Starting, If Your Engine Overheats
If Your Engine Overheats
345
Steam and spray from an
overheated engine can
seriously scald you.
Do not open the hood if steam
is coming out.
Driving with the temperature gauge
pointer at the red mark can cause
serious damage to your engine.

However, if the brake pedal does not
f eel normal, you should take
immediate action. Because of the
brake system’s dual-circuit design, a
problem in one part of the system
will still give you braking at two
wheels. You will f eel the brake pedal
go down much f arther bef ore the
vehicle begins to slow down, and you
will have to press harder on the
pedal. The distance needed to stop
will be much longer. If it comes on at any other time, it
indicates a problem with the vehicle’s
brake system. In most cases, the
problem is a low f luid level in the
brake f luid reservoir. Press lightly on
the brake pedal to see if it f eels
normal. If it does, check the brake
f luid level the next time you stop at a
service station (see page ). If the
f luid level is low, take the vehicle to
your dealer and have the brake
system inspected f or leaks or worn
brake pads.Slow down by shif ting to a lower
gear, and pull to the side of the road
when it is saf e. Because of the
longer distance needed to stop, it is
hazardous to drive the vehicle. You
should have it towed, and repaired as
soon as possible. (See
on page .)
If you must drive the vehicle a short
distance in this condition, drive
slowly and cautiously.
The Brake System Indicator comes
on when you turn the ignition ON
(II). If the parking brake is not set, it
goes of f af ter you start the engine. If
the parking brake is set, it goes of f
when you f ully release the parking
brake with the engine running. 295
358Emergency
Towing
Brake System Indicator
T aking Care of t he Unexpect ed351
BRAKE SYSTEM INDICATOR
U. S. indicator shown

µ µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
Specif ications
T echnical Inf ormation363
Tires Alignment Engine
Fuses
Lights
Battery 60 W/55 W
12 V
Size
Pressure60 psi (420 kPa , 4.2 kgf/cm
)
32 psi (220 kPa , 2.2 kgf/cm)
T155/90D16 110M P235/70R16 104S
Toe-in
Camber
Caster
1°88’0°50’ 0°50’
0.00 in (0.0 mm)
0.00 in (0.0 mm)
Type
BorexStroke
Displacement
Compression ratio
Spark plugs
10.0 : 1
211.8 cu-in (3,471 cm
)
3.50 x 3.66 in (89.0 x 93.0 mm)
Interior
Under-hood
12 V
12 V
12 V
12 V
12 V
12 V
12 V
12 V
12 V Water cooled 4-stroke SOHC,
V6 gasoline engine
Headlights
Front side marker lights
Front turn signal lights/
Parking lights
Rear side marker lights
Rear turn signal/hazard lights
Stop/Taillights
Backup lights
License plate lights
High-mount brake light
Individual map lights
Tailgate light
Vanity mirror light
Door (Courtesy) light
Grabrail lights
Console lights 12 V
12 V
12 V
5W
27 W/8 W
5W
21 W/5 W
21 W/5 W
21 CP (18 W)
5W
18 W
6.2 W
5W
1.1 W
3.8 W
Capacity 12 V 65 AH/20 HR14 V 12 V 12.4 W
1.4 W See page
357or the fuse label
attached to the dashboard.
See page 357or the fuse label
attached to the inside of the fuse
box door under the dashboard.
See page 356or the fuse box
cover.
See spark plug maintenance
section page 301 .
Front/Rear
Spare
Front/Rear
Spare Front
Rear
Front
Rear
Front
Driver’s side
Passenger’s side
(1157 NA)
(168)
(7443)
(7443) (921)
(168)
(921)
(204)
(HB2)
(168)

Then drive in city/suburban
traffic for at least 10 minutes.
When traf f ic conditions allow, let
the vehicle coast f or several
seconds without using the
accelerator pedal or the brake
pedal.
If the testing f acility determines
the readiness codes are still not
set, see your Honda dealer.
St at e Emissions T est ing
T echnical Inf ormation372

CONT INUED
...
Accessories and Modif ications . 223
................................
Accessories .223
...
Additional Safety Precaution . 224
............................
Modif ications .224
ACCESSORY (Ignition Key .......................................
Position) .82
............
Accessory Power Sockets . 110
....................
Additives, Engine Oil . 284
...............................
Airbag (SRS) .9, 50
.....................
Air Cleaner Element .297
......
Air Conditioning System . 118,130
..............................
Maintenance .306
.....................
Rear A/C Control .135
.................................
Usage .118, 130
...............
Air Outlets (Vents) . 120,128
.......................
Air Pressure, Tires .308
.......................
Alcohol in Gasoline .366
.......
Aluminum Wheels, Cleaning . 327
......................................
Antif reeze .287
Anti-lock Brakes (ABS) ....................
Indicator Light .63, 243
...................................
Operation .242
..............
Anti-thef t, Audio System . 153
.
Anti-thef t Steering Column Lock . 81..........................
Appearance Care .325
................
Audio System . 137,153,168
...
Automatic Seat Belt Tensioners . 48
...
Automatic Lighting Off Feature . 73
.............
Automatic Speed Control . 207
..............
Automatic Transmission . 233
..........................
Capacity, Fluid .362
...............
Checking Fluid Level . 293
.......................................
Shif ting .234
.
Shif t Lever Position Indicator . 233
................
Shif t Lever Positions . 234
....................
Shif t Lock Release . 236
Battery Charging System ...........................
Indicator .62, 348
............................
Jump Starting .343
..............................
Maintenance .302
............................
Specif ications .363
..............................
Bef ore Driving .215
....................................
Belts,Seat .8,46
.........................
Beverage Holders .105
.................................
Body Repairs .332 Brakes
...........
Anti-lock System (ABS) . 242
.............
Break-in, New Linings . 216
...........................................
Fluid .295
....................
Bulb Replacement .320
.......................................
Parking .104
.................
System Indicator . 63,351
........................
Wear Indicators .241
.............................
Braking System .241
.................
Break-in, New Vehicle . 216
..
Brightness Control, Instruments . 73
........................
Brights, Headlights .72
Bulb Replacement ..........................
Back-up Lights .321
..............................
Brake Lights .320
......................
Cargo Area Light .323
................
Front Parking Lights . 318
........
Front Side Marker Lights . 319
.................................
Headlights .317
..............
Individual Map Lights . 322
...................
License Plate Light . 321
.................................
Rear Bulbs .320
............................
Specif ications .363
............
Turn Signal Lights . 318,320
..............................
Bulbs, Halogen .317
Index
A
B
I

Î
................................
Cancel Button .209
............................
Capacities Chart .362
.............
Carbon Monoxide Hazard . 56
.............................
Carrying Cargo .225
Cassette Player ............................................
Care .181
...................
Operation . 149,160,178
..............
CAUTION, Explanation of . ii
..................
CD Changer . 145,165,184
......................
CD Player .143, 163,182
........................
Certif ication Label .360
............................................
Chains .315
Change Oil ........................................
How to .285
.............................
When to .274, 276
....................
Changing a Flat Tire .335
............
Changing Engine Coolant . 289
...
Charging System Indicator . 62,348
............
Checklist, Bef ore Driving . 231
..................
Childproof Door Locks . 87
.....................................
Child Saf ety .21
.......................................
Child Seats .21
..........
Tether Anchorage Points . 42
....................
Cleaner Element, Air . 297Cleaning
....................
Aluminum Wheels .327
...................................
Carpeting .328
......................................
Exterior .326
.........................................
Fabric .329
.......................................
Interior .328
.......................................
Leather .329
...................................
Seat Belts .329
...........................................
Vinyl .329
....................................
Windows .330
...............
Climate Control System . 128
......................................
Coat Hook .111
.....................
Code, Audio System .189
........................
CO in the Exhaust .368
........................................
Coin Box .111
............
Cold Weather, Starting in . 232
..............................
Compact Spare .334
...............
Consumer Inf ormation . 374
.............
Controls, Instruments and . 59
Coolant ........................................
Adding .287
....................................
Checking .221
.........................
Proper Solution .287
...................................
Replacing .289
...................
Temperature Gauge . 68
....................
Corrosion Protection .331 Crankcase Emissions Control
........................................
System .368
............
Cruise Control Operation . 207
Customer Relations ................................
Inf ormation .374
................
DANGER, Explanation of . ii
...................................
Dashboard .2, 60
................
Daytime Running Lights . 73
............
Def ects, Reporting Saf ety . 376
................
Def ogger, Rear Window . 77
......
Def rosting the Windows . 125,133
....................................
Dimensions .362
...............
Dimming the Headlights . 72
Dipstick ..........
Automatic Transmission . 293
..................................
Engine Oil .220
..........................
Directional Signals .74
........
Disc Brake Wear Indicators . 241
.....................
Disposal of Used Oil .286
Doors ..............
Locking and Unlocking . 82
....................
Lockout Prevention . 83
......................
Power Door Locks .82
Index
C
D
II

CONT INUED
..........
DOT Tire Quality Grading . 364
.....................................
Drive Belts .307
...........
Driver and Passenger Safety . 5
...........................................
Driving .229
....................................
Economy .222
.........................
In Bad Weather .245
................
In Foreign Countries . 367
..................
Dust and Pollen Filter . 307
...................................
DVD Player .190
..............................
Economy, Fuel .222
............
Emergencies on the Road . 333
.............
Battery, Jump Starting . 343
...........
Brake System Indicator . 351
................
Changing a Flat Tire . 335
.....
Charging System Indicator . 348
..................
Checking the Fuses . 353
.....
Low Oil Pressure Indicator . 347
...
Malf unction Indicator Lamp . 349
..................
Overheated Engine . 345
.........................
Emergency Brake .104
......................
Emergency Flashers .76
......................
Emergency Towing .358
.......................
Emissions Controls .368 Engine
....
Coolant Temperature Gauge . 68
.................................
Drive Belts .307
Malf unction Indicator ................................
Lamp .62, 349
........
Oil Pressure Indicator . 62,347
..............
Oil, What Kind to Use . 283
...............................
Overheating .345
............................
Specif ications .363
............................
Speed Limiter .236
.......................................
Starting .232
......................
Ethanol in Gasoline .366
.
Evaporative Emissions Controls . 368
...............................
Exhaust Fumes .56
Exhaust Gas Recirculation ........................................
System .369
Expectant Mothers, Use of Seat ........................................
Belts by .19
..................
Exterior, Cleaning the . 326
............................
Fabric, Cleaning .329
..........................
Fan, Interior .118, 131
Features, Comfort and ..............................
Convenience .117 ....................
Filling the Fuel Tank . 217
Filters ...............................................
Air .297
.......................
Air Conditioning .306
...............................................
Oil .285
.............
Flashers, Hazard Warning . 76
...................
Flat Tire, Changing a . 335
Fluids ..........
Automatic Transmission . 293
..........................................
Brake .295
..........................
Power Steering .296
..................
Windshield Washer . 292
FM Stereo Radio ...................................
Reception .176
...................
Folding the Third Seat . 95
.....
Foreign Countries, Driving in . 367
..........................
Four-way Flashers .76
.................................................
Fuel .216
......................
Fill Door and Cap .217
...........................................
Gauge .68
................
Octane Requirement . 216
...............................
Oxygenated .366
........................
Reserve Indicator .65
........................
Tank, Filling the .217
.....................
Fuses, Checking the .353
Index
E
F
III