2003 GMC SAFARI radiator

2. Then keep turning the
pressure cap, but now
push down as you
turn it. Remove
the pressure cap.
3. Fill the radiator with the proper DEX-COOL
®
coolant mixture, up to the base of thefiller
neck. SeeEngine Coolant on page 5-25for more
information about the proper coolant mixture.
5-34
2003 - Safari OM

4. Thenfill the coolant recovery tank to the ADD mark.
5. Put the cap back on the coolant recovery tank,
but leave the pressure cap off.6. Start the engine and let it run until you can feel the
upper radiator hose getting hot. Watch out for the
engine cooling fan.
7. By this time, the coolant level inside the radiator
filler neck may be lower. If the level is lower, add
more of the proper DEX-COOL
®coolant mixture
through thefiller neck until the level reaches
the base of thefiller neck.
Then replace the pressure cap. At any time during
this procedure if coolant begins toflow out of
thefiller neck, reinstall the pressure cap. Be sure
the arrow on the pressure cap lines up.
5-35
2003 - Safari OM

93,000 Miles (155 000 km)
❑Change engine oil andlter (or every 3 months,
whichever occursrst).An Emission Control Service.
❑Lubricate chassis components (or every 3 months,
whichever occursrst).(See footnote #.)
❑Check rear/front axleuid level and adduid as
needed. Check constant velocity joints and axle seals
for leaking.
96,000 Miles (160 000 km)
❑Change engine oil andlter (or every 3 months,
whichever occursrst).An Emission Control Service.
❑Lubricate chassis components (or every 3 months,
whichever occursrst).(See footnote #.)
❑Check rear/front axleuid level and adduid as
needed. Check constant velocity joints and axle seals
for leaking.
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-58for proper rotation pattern and additional
information.(See footnote +.)
99,000 Miles (165 000 km)
❑Change engine oil andlter (or every 3 months,
whichever occursrst).An Emission Control Service.
❑Lubricate chassis components (or every 3 months,
whichever occursrst).(See footnote #.)
❑Check rear/front axleuid level and adduid as
needed. Check constant velocity joints and axle seals
for leaking.
100,000 Miles (166 000 km)
❑Inspect spark plug wires.An Emission Control
Service.
❑Replace spark plugs.An Emission Control Service.
❑If you haven’t used your vehicle under severe service
conditions listed previously and, therefore, haven’t
changed your automatic transmissionuid, change
both theuid andlter.
❑Change transfer caseuid.
❑Inspect Positive Crankcase Ventilation (PCV) valve.
An Emission Control Service.
150,000 Miles (240 000 km)
❑Drain,ush and rell cooling system (or every
60 months since last service, whichever occursrst).
SeeEngine Coolant on page 5-25for what to use.
Inspect hoses. Clean radiator, condenser, pressure
cap and neck. Pressure test cooling system and
pressure cap.An Emission Control Service.
❑Inspect engine accessory drive belt.An Emission
Control Service.
6-18
2003 - Safari OM

100,000 Miles (166 000 km)
❑Inspect spark plug wires.An Emission Control
Service.
❑Replace spark plugs.An Emission Control Service.
❑If you haven’t used your vehicle under severe service
conditions listed previously and, therefore, haven’t
changed your automatic transmissionuid, change
both theuid andlter.
❑Change transfer caseuid.
❑Inspect Positive Crankcase Ventilation (PCV) valve.
An Emission Control Service.
150,000 Miles (240 000 km)
❑Drain,ush and rell cooling system (or every
60 months since last service, whichever occursrst).
SeeEngine Coolant on page 5-25for what to use.
Inspect hoses. Clean radiator, condenser, pressure
cap and neck. Pressure test the cooling system
and pressure cap.An Emission Control Service.
❑Inspect engine accessory drive belt.An Emission
Control Service.
6-26
2003 - Safari OM

Part C: Periodic Maintenance
Inspections
Listed in this part are inspections and services which
should be performed at least twice a year (for instance,
each spring and fall).You should let your dealer’s
service department do these jobs. Make sure any
necessary repairs are completed at once.
Proper procedures to perform these services may be
found in a service manual. SeeService Publications
Ordering Information on page 7-10.
Steering, Suspension and Front
Drive Axle Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chang, etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out-of-position parts as well as open seams,
holes, loose connections or other conditions which
could cause a heat build-up in theoor pan or could let
exhaust fumes into the vehicle. SeeEngine Exhaust
on page 2-30.
Fuel System Inspection
Inspect the complete fuel system for damage or leaks.
Engine Cooling System Inspection
Inspect the hoses and have them replaced if they
are cracked, swollen or deteriorated. Inspect all pipes,
ttings and clamps; replace as needed. Clean the
outside of the radiator and air conditioning condenser.
To help ensure proper operation, a pressure test of
the cooling system and pressure cap is recommended
at least once a year.
6-32
2003 - Safari OM

Horn ............................................................... 3-5
How to Add Coolant to the Coolant
Recovery Tank............................................5-31
How to Add Coolant to the Radiator..................5-33
How to Add Fluid............................................5-25
How to Check........................................5-23, 5-58
How to Check Lubricant...................................5-49
How to Check Power Steering Fluid..................5-37
How to Inspect the Engine Air Cleaner/Filter.......5-22
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-18
Hydroplaning..................................................4-17
I
If No Steam Is Coming From Your Engine..........5-29
If Steam Is Coming From Your Engine...............5-28
If the Light Is Flashing.....................................3-31
If the Light Is On Steady.................................3-31
If You Are Stuck in Sand, Mud, Ice or Snow.......4-28
If You Do Decide To Pull A Trailer.....................4-32
If You’re Caught in a Blizzard...........................4-26
Ignition Positions.............................................2-19
Ignition Transmission Lock Check......................6-30Infants and Young Children, Restraints...............1-38
Inflation -- Tire Pressure..................................5-58
Inspection
Brake System.............................................6-33
Engine Cooling System................................6-32
Exhaust System..........................................6-32
Fuel System...............................................6-32
Part C - Periodic Maintenance.......................6-32
Steering, Suspension and Front Drive Axle
Boot and Seal.........................................6-32
Throttle System...........................................6-33
Transfer Case and Front Axle
(All-Wheel Drive)......................................6-33
Installing a Garage Door Opener.......................2-40
Instrument Panel
Cluster.......................................................3-24
Overview..................................................... 3-2
Instrument Panel Brightness Control..................3-15
Instrument Panel Fuse Block............................5-86
Interior Lamps................................................3-15
J
Jump Starting.................................................5-43
7
2003 - Safari OM

R
Radiator Pressure Cap....................................5-27
Radios..........................................................3-37
AM-FM Radio.............................................3-38
Care of Your CD Player...............................3-49
Care of Your CDs ........................................3-49
Radio with CD............................................3-40
Rear Seat Audio..........................................3-45
Setting the Time for Radios with HR and
MN Buttons.............................................3-37
Setting the Time for Radios with the Set
Button....................................................3-37
Theft-Deterrent............................................3-46
Understanding Reception..............................3-49
Reading Lamps..............................................2-40
Rear Air Conditioning System...........................3-20
Rear Axle......................................................5-49
Locking........................................................ 4-8
Rear Climate Control System............................3-21
Rear Doors....................................................2-13
Rear Heating System......................................3-19
Rear Safety Belt Comfort Guides......................1-32
Rear Seat Audio (RSA)....................................3-45
Rear Seat Operation......................................... 1-7
Rear Seat Outside Passenger Positions.............1-29
Rear Seat Passengers, Safety Belts..................1-29
Rear Window Defogger....................................3-21Rearview Mirrors.............................................2-32
Reclining Seatbacks.......................................... 1-4
Recreational Vehicle Towing.............................4-29
Reinstalling the Engine Cover...........................5-21
Remote Keyless Entry System............................ 2-4
Remote Keyless Entry System, Operation............ 2-5
Removing the Engine Cover.............................5-17
Removing the Flat Tire and Installing the
Spare Tire..................................................5-70
Removing the Rear Seats.................................. 1-7
Removing the Spare Tire and Tools...................5-66
Removing the Wheel Covers............................5-69
Replacement Bulbs.........................................5-56
Replacing Brake System Parts
..........................5-42
Replacing Restraint System Parts After
a Crash
.....................................................1-69
Replacing the Rear Seats
.................................. 1-9
Reporting Safety Defects
Canadian Government
..................................7-10
General Motors
...........................................7-10
United States Government
.............................. 7-9
Reprogramming a Single HomeLink
®Button
.......2-37
Resetting Defaults
...........................................2-37
Restraint System Check
...................................6-28
Checking Your Restraint Systems
...................1-68
Replacing Restraint System Parts After
a Crash
..................................................1-69
11
2003 - Safari OM