2003 CHEVROLET S10 heater

Cooling System
When you decide it's safe to lift the hood, here's what
you'll see:
A. Coolant Recovery Tank
B. Radiator Pressure Cap
C. Engine Cooling Fan
If the coolant inside the coolant recovery tank is boiling,
don't do anything else until it cools down. The vehicle
should be parked on a level surface.When the engine is cold, the coolant level should be at
least up to the ADD mark. If it isn't, you may have a
leak at the pressure cap or in the radiator hoses, heater
hoses, radiator, water pump or somewhere else in
the cooling system.
5-32

{CAUTION:
Heater and radiator hoses, and other engine
parts, can be very hot. Do not touch them. If
you do, you can be burned.
Do not run the engine if there is a leak. If you
run the engine, it could lose all coolant. That
could cause an engine ®re, and you could be
burned. Get any leak ®xed before you drive the
vehicle.
If there seems to be no leak, start the engine again.
The engine cooling fan speed should increase when idle
speed is doubled by pushing the accelerator pedal
down. If it doesn't, your vehicle needs service. Turn off
the engine.
Notice:Engine damage from running your engine
without coolant isn't covered by your warranty.
Notice:When adding coolant, it is important that
you use only DEX-COOLž(silicate-free) coolant.
If coolant other than DEX-COOLžis added to
the system, premature engine, heater core or
radiator corrosion may result. In addition, the engine
coolant will require change sooner Ð at 30,000 miles
(50 000 km) or 24 months, whichever occurs ®rst.
Damage caused by the use of coolant other
than DEX-COOL
žis not covered by your new vehicle
warranty.
5-33

How to Add Coolant to the Coolant
Recovery Tank
If you haven't found a problem yet, but the coolant level
isn't at the ADD mark, add a 50/50 mixture ofclean,
drinkable waterand DEX-COOLžengine coolant at the
coolant recovery tank. SeeEngine Coolant on
page 5-27for more information.
{CAUTION:
Adding only plain water to your cooling system
can be dangerous. Plain water, or some other
liquid such as alcohol, can boil before the
proper coolant mixture will. Your vehicle's
coolant warning system is set for the proper
coolant mixture. With plain water or the wrong
mixture, your engine could get too hot but you
would not get the overheat warning. Your
engine could catch ®re and you or others could
be burned. Use a 50/50 mixture of clean,
drinkable water and DEX-COOL
žcoolant.
Notice:In cold weather, water can freeze and crack
the engine, radiator, heater core and other parts.
Use the recommended coolant and the proper
coolant mixture.
{CAUTION:
You can be burned if you spill coolant on hot
engine parts. Coolant contains ethylene glycol
and it will burn if the engine parts are hot
enough. Do not spill coolant on a hot engine.
5-34

Chains, Tires..................................................5-70
Charging System Light....................................3-29
Checking Brake Fluid......................................5-43
Checking Coolant............................................5-28
Checking Engine Oil........................................5-15
Checking the Fluid Level..................................5-23
Checking Things Under the Hood......................5-10
Checking Your Restraint Systems......................1-65
Check...........................................................3-33
Engine Light...............................................3-33
Gages Warning Light...................................3-38
Chemical Paint Spotting...................................5-90
Child Restraints..............................................1-36
Child Restraint Systems...............................1-36
Infants and Young Children...........................1-32
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-44
Older Children.............................................1-30
Securing a Child Restraint Designed for the
LATCH System........................................1-46
Securing a Child Restraint in a Center Seat
Position..................................................1-49
Securing a Child Restraint in a Rear Outside
Seat Position...........................................1-46
Securing a Child Restraint in the Right Front
Seat Position...........................................1-49
Top Strap Anchor Location............................1-43
Top Strap...................................................1-41
Where to Put the Restraint...................1-39, 1-40
Cigarette Lighter.............................................3-18Cleaning Aluminum Wheels..............................5-89
Cleaning Exterior Lamps/Lenses.......................5-87
Cleaning Fabric/Carpet....................................5-84
Cleaning Glass Surfaces..................................5-86
Cleaning Interior Plastic Components.................5-86
Cleaning Leather............................................5-85
Cleaning the Mirror.........................................2-39
Cleaning the Photocells...................................2-39
Cleaning the Top of the Instrument Panel...........5-86
Cleaning the Windshield and Wiper Blades.........5-88
Cleaning Tires................................................5-89
Cleaning Vinyl................................................5-85
Cleaning Wood Panels....................................5-86
Cleaning........................................................5-84
Inside of Your Vehicle..................................5-84
Outside of Your Vehicle................................5-87
Underbody Maintenance...............................5-90
Weatherstrips..............................................5-87
Climate Control System...................................3-18
Outlet Adjustment........................................3-21
Clutch, Hydraulic.............................................5-26
Compact Disc Messages.................3-52, 3-62, 3-73
Compact Spare Tire........................................5-83
Content Theft-Deferrent....................................2-17
Control of a Vehicle.......................................... 4-6
Coolant.........................................................3-32
Engine Temperature Gage............................3-32
Heater, Engine............................................2-24
Cooling System..............................................5-32
Cooling.........................................................3-19
3

E
Electrical System............................................5-93
Add-On Equipment......................................5-93
Fuses and Circuit Breakers...........................5-93
Headlamps.................................................5-93
Power Windows and Other Power Options......5-93
Windshield Wiper Fuses...............................5-93
Electronic Transfer Case..................................2-30
Emissions Inspection and Maintenance
Programs...................................................3-35
Engine Compartment Fuse Block......................5-96
Engine Coolant Level Check.............................6-26
Engine Oil Additives........................................5-18
Engine Oil Level Check...................................6-26
Engine..........................................................5-19
Air Cleaner/Filter.........................................5-19
Battery.......................................................5-45
Check and Service Engine Soon Light............3-33
Compartment Overview................................5-12
Coolant Heater............................................2-24
Coolant Temperature Gage...........................3-32
Coolant......................................................5-27
Cooling System Inspection............................6-32
Exhaust.....................................................2-37
Fan Noise..................................................5-39
Oil .............................................................5-15
Overheating................................................5-30
Starting......................................................2-22
Entry Lighting.................................................3-15Environmental Concerns..................................4-16
Exit Lighting...................................................3-16
Express Down Window....................................2-15
Extended Cab (Jump Seat)..............................1-48
Extender, Safety Belt.......................................1-29
Exterior Lamps...............................................3-12
F
Filter.............................................................5-19
Engine Air Cleaner......................................5-19
Finding a PTY Station.....................3-48, 3-56, 3-66
Finding a Station....................3-42, 3-45, 3-53, 3-63
Finish Care....................................................5-88
Finish Damage...............................................5-89
Five-Speed....................................................2-28
Fixed Mast Antenna........................................3-76
Flash-To-Pass Feature....................................... 3-7
Flat Tire, Changing.........................................5-72
Flat Tire........................................................5-71
Fluid.............................................................5-22
Automatic Transmission................................5-22
Manual Transmission....................................5-25
Power Steering...........................................5-39
Windshield Washer......................................5-40
FM ...............................................................3-74
Fog Lamps....................................................3-15
Following Distance..........................................4-61
Four-Wheel Drive....................................2-29, 5-52
5

T
Tachometer....................................................3-26
Tailgate Lubrication Service..............................6-28
Tailgate.........................................................2-13
Taillamps.......................................................5-59
Temperature and Compass Display....................2-44
Testing the Alarm............................................2-18
Theft-Deterrent, Radio.....................................3-74
Theft-Deterrent Systems...................................2-17
Content Theft-Deterrent................................2-17
Passlock
ž...................................................2-19
Third Door.....................................................2-12
Throttle System Inspection...............................6-32
Tilt Wheel........................................................ 3-5
Time Delay....................................................2-39
Tire In¯ation Check.........................................6-26
Tires.............................................................5-62
Buying New Tires........................................5-66
Chains.......................................................5-70
Changing a Flat Tire....................................5-72
Compact Spare Tire.....................................5-83
If a Tire Goes Flat.......................................5-71
In¯ation -- Tire Pressure...............................5-63
Inspection and Rotation................................5-64
Uniform Tire Quality Grading.........................5-67
Wheel Alignment and Tire Balance.................5-68
Wheel Replacement.....................................5-68
When It Is Time for New Tires......................5-65Tires (cont.)
To Use the Engine Coolant Heater....................2-24
Top Strap Anchor Location...............................1-43
Top Strap......................................................1-41
Torque Lock...................................................2-35
Total Weight on Your Vehicle's Tires..................4-58
Towing..........................................................4-44
Recreational Vehicle.....................................4-44
Towing a Trailer..........................................4-54
Your Vehicle...............................................4-44
Trailer Brakes.................................................4-60
Trailer...........................................................4-53
Recommendations.......................................4-53
Transfer Case and Front Axle (Four-Wheel Drive)
Inspection...................................................6-32
Transfer Case................................................5-52
Transmission Operation, Automatic....................2-25
Transmission Operation, Manual........................2-28
Transmission, Transaxle, Transfer Case Unit
Repair Manual............................................7-10
Transmission..................................................5-22
Fluid, Automatic...........................................5-22
Fluid, Manual..............................................5-25
Up-Shift Light..............................................3-30
Transportation Options...................................... 7-8
Traveling to Remote Areas...............................4-16
Trip Odometer................................................3-25
Truck-Camper Loading Information....................4-51
Turn and Lane-Change Signals.......................... 3-6
Turn Signal/Multifunction Lever........................... 3-6
14