2003 CHEVROLET CORVETTE coolant

1. Park the vehicle on a level surface. You can
remove the coolant surge tank pressure cap
when the cooling system, including the coolant
surge tank pressure cap and upper radiator hose, is
no longer hot. Turn the pressure cap slowly
counterclockwise about one-quarter turn and
then stop.
If you hear a hiss, wait for that to stop. A hiss
means there is still some pressure left.
2. Then keep turning the pressure cap slowly, and
remove it.3. Then ®ll the coolant surge tank with the proper
mixture, to the FULL COLD mark on the coolant
surge tank.
5-33

4. With the coolant surge tank pressure cap off, start
the engine and let it run until you can feel the upper
radiator hose getting hot. Watch out for the
engine cooling fan(s).
By this time, the coolant level inside the coolant
surge tank may be lower. If the level is lower, add
more of the proper mixture to the coolant surge tank
until the level reaches the FULL COLD mark on
the coolant surge tank.5. Then replace the pressure cap. Be sure the
pressure cap is hand-tight and fully seated.
5-34

Windshield Washer Fluid
What to Use
When you need windshield washer ¯uid, be sure to read
the manufacturer's instructions before use. If you will
be operating your vehicle in an area where the
temperature may fall below freezing, use a ¯uid that has
sufficient protection against freezing.
Adding Washer Fluid
Open the cap with the
washer symbol on it. See
Engine Compartment
Overview on page 5-12for
reservoir location. Add
washer ¯uid until the tank
is full.
Notice:
·When using concentrated washer ¯uid, follow
the manufacturer's instructions for adding
water.
·Don't mix water with ready-to-use washer ¯uid.
Water can cause the solution to freeze and
damage your washer ¯uid tank and other parts
of the washer system. Also, water doesn't
clean as well as washer ¯uid.
·Fill your washer ¯uid tank only three-quarters
full when it's very cold. This allows for
expansion if freezing occurs, which could
damage the tank if it is completely full.
·Don't use engine coolant (antifreeze) in your
windshield washer. It can damage your
washer system and paint.
5-36

75,000 Miles (125 000 km)
qInspect engine air cleaner ®lter. If necessary, replace
the ®lter. If vehicle is driven in dusty/dirty conditions,
inspect ®lter at every engine oil change. See
Engine Air Cleaner/Filter on page 5-18for more
information.An Emission Control Service. (See
footnote ².)
90,000 Miles (150 000 km)
qReplace engine air cleaner ®lter. SeeEngine Air
Cleaner/Filter on page 5-18for more information.An Emission Control Service.
100,000 Miles (166 000 km)
qReplace spark plugs.An Emission Control Service.
qInspect spark plug wires.An Emission Control
Service.
qChange automatic transmission ¯uid and ®lter.
Manual transmission ¯uid doesn't required change.
150,000 Miles (240 000 km)
qDrain, ¯ush and re®ll the cooling system (or every
60 months since last service, whichever occurs
®rst). See
Engine Coolant on page 5-23for what to
use.An Emission Control Service.
qInspect engine accessory drive belt.An Emission
Control Service.
6-7

Part B: Owner Checks and Services
Listed in this part are owner checks and services
which should be performed at the intervals speci®ed to
help ensure the safety, dependability and emission
control performance of your vehicle.
Be sure any necessary repairs are completed at once.
Whenever any ¯uids or lubricants are added to your
vehicle, make sure they are the proper ones, as shown
in Part D.
At Each Fuel Fill
It is important for you or a service station attendant to
perform these underhood checks at each fuel ®ll.
Engine Oil Level Check
Check the engine oil level and add the proper oil if
necessary. SeeEngine Oil on page 5-13for further
details.
Engine Coolant Level Check
Check the engine coolant level and add DEX-COOLž
coolant mixture if necessary. SeeEngine Coolant
on page 5-23for further details.
Windshield Washer Fluid Level Check
Check the windshield washer ¯uid level in the windshield
washer tank and add the proper ¯uid if necessary.
See
Windshield Washer Fluid on page 5-36for further
details.
At Least Once a Month
Tire In¯ation Check
Make sure tires are in¯ated to the correct pressures.
SeeTires on page 5-54for further details.
Cassette Tape Player Service
Clean cassette tape player. Cleaning should be done
every 50 hours of tape play. SeeAudio System(s)
on page 3-62for further details.
Power Antenna Service
Clean power antenna mast. SeeAudio System(s) on
page 3-62for further details.
6-8

Part D: Recommended Fluids and
Lubricants
Fluids and lubricants identi®ed below by name, part
number or speci®cation may be obtained from your
dealer.
Usage Fluid/Lubricant
Engine OilThe engine requires a special
engine oil meeting GM Standard
GM4718M. Oils meeting this
standard may be identi®ed as
synthetic, and should also be
identi®ed with the American
Petroleum Institute Certi®ed for
Gasoline Engines starburst symbol.
However, not all synthetic API oils
with the starburst symbol will meet
this GM standard. You should look
for and use only an oil that meets
GM Standard GM4718M. For the
proper viscosity, see
Engine Oil on
page 5-13.
Usage Fluid/Lubricant
Engine Coolant50/50 mixture of clean, drinkable
water and use only
DEX-COOL
žCoolant. SeeEngine
Coolant on page 5-23.
Hydraulic Brake
SystemDelco Supreme 11 Brake Fluid or
equivalent DOT-3 brake ¯uid.
Windshield
Washer SolventGM Optikleen
žWasher Solvent or
equivalent.
Hydraulic
Clutch SystemHydraulic Clutch Fluid (GM Part No.
U.S. 12345347, in Canada
10953517, or equivalent DOT-3
brake ¯uid).
Power Steering
SystemGM Power Steering Fluid (GM Part
No.U.S. 1052884, in Canada
993294, or equivalent).
Manual
TransmissionDEXRON
ž-III Automatic
Transmission Fluid.
Automatic
TransmissionDEXRON
ž-III Automatic
Transmission Fluid.
6-14

Audio System(s) (cont.)
Understanding Radio Reception.....................3-77
Automatic Transmission Check........................... 6-9
Automatic Transmission Shift Lock Control
System Check.............................................6-10
Automatic Transmission...................................2-21
Fluid..........................................................5-20
Operation...................................................2-24
B
Battery Replacement......................................... 2-8
Battery Run-Down Protection............................3-17
Battery..........................................................5-40
Before Leaving on a Long Trip.........................4-24
Body Lubrication Service................................... 6-9
Brake Fluid....................................................5-37
Brake Wear...................................................5-39
Brake............................................................2-30
Parking......................................................2-30
System Inspection.......................................6-13
System Warning Light..................................3-35
Brakes..........................................................5-37
Braking in Emergencies..................................... 4-8
Braking........................................................... 4-6
Break-In, New Vehicle.....................................2-19
Bulb Replacement...........................................5-47
Back-Up Lamps...........................................5-51
Halogen Bulbs............................................5-47Bulb Replacement (cont.)
Headlamps.................................................5-47
Replacement Bulbs......................................5-51
Taillamps and Turn Signal Lamps..................5-49
Buying New Tires...........................................5-59
C
California Fuel.................................................. 5-5
Canada ± Customer Assistance.......................... 7-4
Canadian Owners................................................ ii
Canadian Roadside Assistance........................... 7-7
Capacities and Speci®cations............................5-92
Carbon Monoxide...................4-27, 4-35, 2-11, 2-35
Care of.........................................................5-77
Safety Belts................................................5-77
Your Cassette Tape Player............................3-78
Your CD Player...........................................3-79
Your CDs ...................................................3-79
Cargo Cover..................................................2-42
Cassette Tape Messages.................................3-66
Cassette Tape Player Service............................. 6-8
CD Adapter Kits.............................................3-66
CD Changer, Trunk-Mounted............................3-71
Center Console Storage Area...........................2-39
Chains, Tires..................................................5-64
Check Engine Light.........................................3-38
Checking Coolant............................................5-25
Checking Engine Oil........................................5-13
2

Checking Things Under the Hood......................5-10
Checking Your Restraint Systems......................1-48
Check...........................................................3-38
Engine Light...............................................3-38
Gages Warning Light...................................3-42
Chemical Paint Spotting...................................5-81
Child Restraints..............................................1-26
Child Restraint Systems...............................1-26
Infants and Young Children...........................1-23
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-31
Older Children.............................................1-21
Securing a Child Restraint Designed for
the LATCH System...................................1-33
Securing a Child Restraint in the Passenger
Seat Position...........................................1-34
Top Strap Anchor Location............................1-31
Top Strap...................................................1-30
Cigarette Lighter.............................................3-21
Cleaning Aluminum Wheels..............................5-80
Cleaning Coated Moldings................................5-76
Cleaning Exterior Lamps/Lenses.......................5-78
Cleaning Fabric/Carpet....................................5-75
Cleaning Glass Surfaces..................................5-77
Cleaning Interior Plastic Components.................5-77
Cleaning Leather............................................5-76
Cleaning Removable Roof Panel.......................5-79
Cleaning the Convertible Top............................5-80
Cleaning the Security Shade and
Convenience Net.........................................5-77Cleaning the Top of the Instrument Panel...........5-76
Cleaning Tires................................................5-80
Cleaning Windshield and Wiper Blades..............5-79
Cleaning........................................................5-81
Fiberglass Springs.......................................5-81
Inside of Your Vehicle..................................5-75
Outside of Your Vehicle................................5-78
Titanium Exhaust System..............................5-81
Underbody Maintenance...............................5-81
Weatherstrips..............................................5-77
Climate Control System...................................3-22
Dual Automatic............................................3-22
Outlet Adjustment........................................3-28
Clutch, Hydraulic.............................................5-22
Compact Disc Messages..........................3-70, 3-75
Competitive Driving Mode................................4-11
Control of a Vehicle.......................................... 4-5
Convenience Net............................................2-42
Convertible Top..............................................2-49
Lowering the Convertible Top........................2-50
Raising the Convertible Top..........................2-53
Coolant.........................................................3-38
Engine Temperature Gage............................3-38
Heater, Engine............................................2-23
Surge Tank Pressure Cap.............................5-26
Cooling System..............................................5-29
Courtesy Lamps.............................................3-16
Cruise Control.................................................. 3-9
Cupholder(s)..................................................2-39
Current and Past Model Order Forms................7-11
3