2003 CHEVROLET CORVETTE check engine light

How to Check and Add Fluid
Fluid should be added if the ¯uid level is below the step
on the inside of the reservoir. There are additional
instructions on the reservoir cap. Put the rubber seal
and cap back on. See
Engine Compartment Overview
on page 5-12for more information on location.
Engine Coolant
The cooling system in your vehicle is ®lled with
DEX-COOLžengine coolant. This coolant is designed
to remain in your vehicle for 5 years or 150,000 miles
(240 000 km), whichever occurs ®rst, if you add
only DEX-COOL
žextended life coolant.
The following explains your cooling system and how to
add coolant when it is low. If you have a problem
with engine overheating, see
Engine Overheating on
page 5-26.
A 50/50 mixture of clean, drinkable water and
DEX-COOL
žcoolant will:
·Give freezing protection down to-34ÉF (-37ÉC).
·Give boiling protection up to 265ÉF (129ÉC).
·Protect against rust and corrosion.
·Help keep the proper engine temperature.
·Let the warning lights and gages work as they
should.
5-23

Adding Coolant
If you need more coolant, add the proper DEX-COOLž
coolant mixtureat the surge tank,but only when the
engine is cool.
{CAUTION:
You can be burned if you spill coolant on hot
engine parts. Coolant contains ethylene glycol,
and it will burn if the engine parts are hot
enough. Don't spill coolant on a hot engine.
When replacing the pressure cap, make sure it is
hand-tight.
Coolant Surge Tank Pressure Cap
Notice:Your pressure cap is a pressure-type
cap and must be tightly installed to prevent coolant
loss and possible engine damage from overheating.
See ªCapacities and Speci®cationsº for more
information.
See
Engine Compartment Overview on page 5-12for
information on location.
Engine Overheating
You will ®nd an engine coolant temperature gage on the
instrument panel cluster and a COOLANT OVER
TEMP message on the Driver Information Center (DIC).
See
Engine Coolant Temperature Gage on page 3-38andDIC Warnings and Messages on page 3-53.
Overheated Engine Protection
Operating Mode
If an overheated engine condition exists and the
messages COOLANT OVER TEMP and REDUCED
ENGINE POWER are displayed, along with the Check
Engine light, an overheat protection mode which
alternates ®ring groups of cylinders helps prevent engine
damage. In this mode, you will notice a loss in power
and engine performance. This operating mode
allows your vehicle to be driven to a safe place in an
emergency; you may drive up to 50 miles (80 km).
Notice:After driving in the overheated engine
protection operating mode, to avoid engine damage,
allow the engine to cool before attempting any
repair. The engine oil will be severely degraded.
Repair the cause of coolant loss, change the oil
and reset the oil life system. See ªEngine Oilº in
the Index.
5-26

Audio System(s) (cont.)
Understanding Radio Reception.....................3-77
Automatic Transmission Check........................... 6-9
Automatic Transmission Shift Lock Control
System Check.............................................6-10
Automatic Transmission...................................2-21
Fluid..........................................................5-20
Operation...................................................2-24
B
Battery Replacement......................................... 2-8
Battery Run-Down Protection............................3-17
Battery..........................................................5-40
Before Leaving on a Long Trip.........................4-24
Body Lubrication Service................................... 6-9
Brake Fluid....................................................5-37
Brake Wear...................................................5-39
Brake............................................................2-30
Parking......................................................2-30
System Inspection.......................................6-13
System Warning Light..................................3-35
Brakes..........................................................5-37
Braking in Emergencies..................................... 4-8
Braking........................................................... 4-6
Break-In, New Vehicle.....................................2-19
Bulb Replacement...........................................5-47
Back-Up Lamps...........................................5-51
Halogen Bulbs............................................5-47Bulb Replacement (cont.)
Headlamps.................................................5-47
Replacement Bulbs......................................5-51
Taillamps and Turn Signal Lamps..................5-49
Buying New Tires...........................................5-59
C
California Fuel.................................................. 5-5
Canada ± Customer Assistance.......................... 7-4
Canadian Owners................................................ ii
Canadian Roadside Assistance........................... 7-7
Capacities and Speci®cations............................5-92
Carbon Monoxide...................4-27, 4-35, 2-11, 2-35
Care of.........................................................5-77
Safety Belts................................................5-77
Your Cassette Tape Player............................3-78
Your CD Player...........................................3-79
Your CDs ...................................................3-79
Cargo Cover..................................................2-42
Cassette Tape Messages.................................3-66
Cassette Tape Player Service............................. 6-8
CD Adapter Kits.............................................3-66
CD Changer, Trunk-Mounted............................3-71
Center Console Storage Area...........................2-39
Chains, Tires..................................................5-64
Check Engine Light.........................................3-38
Checking Coolant............................................5-25
Checking Engine Oil........................................5-13
2

Checking Things Under the Hood......................5-10
Checking Your Restraint Systems......................1-48
Check...........................................................3-38
Engine Light...............................................3-38
Gages Warning Light...................................3-42
Chemical Paint Spotting...................................5-81
Child Restraints..............................................1-26
Child Restraint Systems...............................1-26
Infants and Young Children...........................1-23
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-31
Older Children.............................................1-21
Securing a Child Restraint Designed for
the LATCH System...................................1-33
Securing a Child Restraint in the Passenger
Seat Position...........................................1-34
Top Strap Anchor Location............................1-31
Top Strap...................................................1-30
Cigarette Lighter.............................................3-21
Cleaning Aluminum Wheels..............................5-80
Cleaning Coated Moldings................................5-76
Cleaning Exterior Lamps/Lenses.......................5-78
Cleaning Fabric/Carpet....................................5-75
Cleaning Glass Surfaces..................................5-77
Cleaning Interior Plastic Components.................5-77
Cleaning Leather............................................5-76
Cleaning Removable Roof Panel.......................5-79
Cleaning the Convertible Top............................5-80
Cleaning the Security Shade and
Convenience Net.........................................5-77Cleaning the Top of the Instrument Panel...........5-76
Cleaning Tires................................................5-80
Cleaning Windshield and Wiper Blades..............5-79
Cleaning........................................................5-81
Fiberglass Springs.......................................5-81
Inside of Your Vehicle..................................5-75
Outside of Your Vehicle................................5-78
Titanium Exhaust System..............................5-81
Underbody Maintenance...............................5-81
Weatherstrips..............................................5-77
Climate Control System...................................3-22
Dual Automatic............................................3-22
Outlet Adjustment........................................3-28
Clutch, Hydraulic.............................................5-22
Compact Disc Messages..........................3-70, 3-75
Competitive Driving Mode................................4-11
Control of a Vehicle.......................................... 4-5
Convenience Net............................................2-42
Convertible Top..............................................2-49
Lowering the Convertible Top........................2-50
Raising the Convertible Top..........................2-53
Coolant.........................................................3-38
Engine Temperature Gage............................3-38
Heater, Engine............................................2-23
Surge Tank Pressure Cap.............................5-26
Cooling System..............................................5-29
Courtesy Lamps.............................................3-16
Cruise Control.................................................. 3-9
Cupholder(s)..................................................2-39
Current and Past Model Order Forms................7-11
3

Electrical System (cont.)
Power Windows and Other Power Options......5-85
Windshield Wiper Fuses...............................5-85
Emergency Trunk Release Handle
(Convertible Only)........................................2-13
Emissions Inspection and Maintenance
Programs...................................................3-40
Engine Accessory Drive Belt Routing.................5-95
Engine Compartment Fuse Block......................5-89
Engine Coolant Level Check.............................. 6-8
Engine Oil Additives........................................5-16
Engine Oil Level Check..................................... 6-8
Engine Oil Scheduled Maintenance..................... 6-5
Engine..........................................................5-18
Air Cleaner/Filter.........................................5-18
Battery.......................................................5-40
Check and Service Engine Soon Light............3-38
Compartment Overview................................5-12
Coolant Heater............................................2-23
Coolant Temperature Gage...........................3-38
Coolant......................................................5-23
Cooling System Inspection............................6-13
Exhaust.....................................................2-35
Oil Pressure Gage.......................................3-41
Oil .............................................................5-13
Overheating................................................5-26
Starting......................................................2-21
Exit/Entry Lighting...........................................3-16
Express-Down Window....................................2-15Extended Mobility Tires....................................5-54
Extender, Safety Belt.......................................1-20
Exterior Lamps...............................................3-12
F
Filter.............................................................5-18
Engine Air Cleaner......................................5-18
Finding a Station....................................3-63, 3-67
Finish Care....................................................5-78
Finish Damage...............................................5-81
Fixed Mast Antenna........................................3-79
Flash-to-Pass................................................... 3-7
Flat Tire........................................................5-68
Floor Mats.....................................................2-40
Fluid.............................................................5-20
Automatic Transmission................................5-20
Manual Transmission....................................5-20
Power Steering...........................................5-35
Windshield Washer......................................5-36
FM ...............................................................3-77
Fog Lamps....................................................3-14
Footnotes........................................................ 6-5
Front Air Dam................................................2-19
Fuel............................................................... 5-4
Additives...................................................... 5-6
California Fuel.............................................. 5-5
Filling a Portable Fuel Container..................... 5-9
Filling Your Tank........................................... 5-7
5

Fuel (cont.)
Fuels in Foreign Countries.............................. 5-6
Gage.........................................................3-42
Gasoline Octane........................................... 5-4
Gasoline Speci®cations.................................. 5-5
System Inspection.......................................6-13
Fuses...........................................................5-86
Fuses and Circuit Breakers...........................5-86
Windshield Wiper.........................................5-85
G
Gage............................................................3-42
Check Gages Warning Light..........................3-42
Engine Coolant Temperature.........................3-38
Engine Oil Pressure.....................................3-41
Fuel..........................................................3-42
Speedometer..............................................3-31
Tachometer.................................................3-31
Voltmeter Gage...........................................3-34
Gasoline......................................................... 5-4
Octane........................................................ 5-4
Speci®cations............................................... 5-5
Glove Box.....................................................2-39
GM Mobility Program for Persons with
Disabilities.................................................... 7-5
H
Hatch/Trunk Lid Release..................................2-12
Hatch/Trunk...................................................2-11
Hazard Warning Flashers................................... 3-4
Headlamp High/Low-Beam Changer.................... 3-7
Headlamp Wiring............................................5-85
Headlamps Doors...........................................3-12
Headlamps on Reminder................................... 3-7
Headlamps....................................................5-47
Bulb Replacement.......................................5-47
Halogen Bulbs............................................5-47
Head-Up Display (HUD)...................................3-17
Highway Hypnosis...........................................4-25
Hill and Mountain Roads..................................4-25
Hood............................................................5-10
Checking Things Under................................5-10
Release.....................................................5-11
Horn............................................................... 3-5
How to Add Coolant to the Coolant
Surge Tank.................................................5-31
How to Add Fluid............................................5-22
How to Check and Add Fluid............................5-23
How to Check Lubricant...................................5-46
How to Check Power Steering Fluid..................5-35
How to Check................................5-20, 5-21, 5-56
How to Remove and Replace the
Floor Mats..................................................2-40
How to Use This Manual...................................... ii
6

How to Wear Safety Belts Properly...................1-12
Hydraulic Clutch.............................................5-22
Hydroplaning..................................................4-21
I
If No Steam Is Coming From Your Engine..........5-28
If Steam Is Coming From Your Engine...............5-27
If the Light Is Flashing.....................................3-39
If the Light Is On Steady.................................3-39
If You Are Stuck in Sand, Mud, Ice or Snow.......4-32
If You're Caught in a Blizzard...........................4-30
Ignition Automatic Transmission
Lock Check................................................6-11
Ignition Positions.............................................2-20
Infants and Young Children, Restraints...............1-23
In¯ation -- Tire Pressure..................................5-56
In¯ator Kit, Tire...............................................5-70
Inspection......................................................6-13
Brake System.............................................6-13
Engine Cooling System................................6-13
Exhaust System..........................................6-12
Fuel System...............................................6-13
Part C - Periodic Maintenance.......................6-12
Steering and Suspension..............................6-12
Tire and Wheel...........................................6-12
Installing the Roof Panel..................................2-47
Instrument Panel Brightness.............................3-15
Instrument Panel Fuse Block............................5-86Instrument Panel.............................................3-30
Cluster.......................................................3-30
Overview..................................................... 3-2
Integrated Windshield and Rear Window
Antennas....................................................3-80
Interior Lamps................................................3-15
J
Jump Starting.................................................5-41
K
Key Lock Cylinders Service................................ 6-9
Keyless Entry System....................................... 2-4
Keys............................................................... 2-3
L
Lamps...........................................................3-12
Exterior......................................................3-12
Interior.......................................................3-15
Lap Belt Cinch Feature....................................1-14
Lap-Shoulder Belt...........................................1-13
LATCH System...............................................1-31
Child Restraints...........................................1-31
Securing a Child Restraint Designed for the
LATCH System........................................1-33
7

LATCH System (cont.)
Latches, Seatback............................................ 1-5
Leaving Your Vehicle With the Engine Running
(Automatic Transmission)..............................2-32
Leaving Your Vehicle.......................................2-10
Lifting From the Front......................................5-66
Lifting From the Rear......................................5-67
Lifting Your Corvette, Tires...............................5-64
Lighted Visor Vanity Mirrors..............................2-15
Light.............................................................3-37
Active Handling System................................3-37
Air Bag Off .................................................3-33
Air Bag Readiness.......................................3-32
Anti-Lock Brake System Warning...................3-36
Brake System Warning.................................3-35
Check Gages Warning.................................3-42
Malfunction Indicator....................................3-38
Safety Belt Reminder...................................3-31
Security.....................................................3-42
TCS Warning Light......................................3-36
Traction Control System (TCS) Warning..........3-36
Limited-Slip Rear Axle.....................................4-11
Loading Your Vehicle.......................................4-33
Lockout Protection..........................................2-10
Locks............................................................. 2-9
Door........................................................... 2-9
Leaving Your Vehicle....................................2-10
Lockout Protection.......................................2-10
Power Door................................................2-10Loss of Control...............................................4-17
Lowering the Convertible Top............................2-50
M
Magnesium Wheel Finish.................................5-81
Magnetic Speed Variable Assist Steering............4-13
Maintenance, Normal Replacement Parts............5-94
Maintenance Schedule...................................... 6-8
At Each Fuel Fill........................................... 6-8
At Least Once a Month.................................. 6-8
At Least Once a Year.................................... 6-9
At Least Twice a Year................................... 6-9
Brake System Inspection..............................6-13
Engine Cooling System Inspection.................6-13
Exhaust System Inspection...........................6-12
Fuel System Inspection................................6-13
How This Section is Organized....................... 6-3
Introduction.................................................. 6-2
Maintenance Requirements............................. 6-2
Part A - Scheduled Maintenance Services......... 6-4
Part B - Owner Checks and Services............... 6-8
Part C - Periodic MaintenanceInspections......6-12
Part D - Recommended Fluids and
Lubricants...............................................6-14
Part E - Maintenance Record........................6-16
Rear Axle Service........................................6-13
Scheduled Maintenance................................. 6-4
Steering and Suspension Inspection...............6-12
8