2003 CHEVROLET ASTRO window

Vinyl Top of the Instrument Panel
Use warm water and a clean cloth.
Rub with a clean, damp cloth to remove dirt.
You may have to
do this more than once.
0 Things like tar, asphalt and shoe polish will stain if
you don’t get them off quickly. Use a clean cloth
and vinyl/leather cleaner. See your dealer for
this product.
Leather
Use a soft cloth with lukewarm water and a mild soap or
saddle soap and wipe dry with a soft cloth. Then, let
the leather dry naturally.
Do not use heat to dry.
0 For stubborn stains, use a leather cleaner. See your
dealer for this product.
0 Never use oils, varnishes, solvent-based or abrasive
cleaners, furniture polish or shoe polish on leather.
Soiled or stained leather should be cleaned
immediately.
If dirt is allowed to work into the finish,
it can harm the leather. Use only
mild soap and water to clean the top surfaces
of the instrument panel. Sprays containing silicones
or waxes may cause annoying reflections in the
windshield and even make it difficult to see through the
windshield under certain conditions.
Interior Plastic Components
Use only a mild soap and water solution on a soft cloth
or sponge. Commercial cleaners may affect the
surface finish.
Glass Surfaces
Glass should be cleaned often. GM Glass Cleaner
or a liquid household glass cleaner will remove normal
tobacco smoke and dust films on interior glass.
See
GM Vehicle Care/Appearance Materials on
page
5-89.
Notice: Don’t use abrasive cleaners on glass,
because they may cause scratches. Avoid placing
decals on the inside rear window, since they may
have to be scraped
off later. If abrasive cleaners are
used on the inside of the rear window, an electric
defogger element may be damaged. Any temporary
license should not be attached across the
defogger grid.
5-85

Electrical System
Add-on Electrical Equipment
Notice: Don’t add anything electrical to your vehicle
unless you check with your dealer first. Some
electrical equipment can damage your vehicle and
the damage wouldn’t be covered by your warranty.
Some add-on electrical equipment can keep other
components from working
as they should.
Your vehicle has an air bag system. Before attempting to
add anything electrical to your vehicle, see
Servicing
Your Air Bag-Equipped Vehicle on page
1-69.
Headlamp Wiring
The headlamp wiring is protected by a circuit breaker in
the lamp switch. An electrical overload will cause the
lamps to flicker on and
off, or in some cases to remain
off. If this happens, have your headlamp wiring
checked right away.
Windshield Wiper Fuses
The windshield wiper motor is protected by a circuit
breaker and a fuse.
If the motor overheats due to heavy
snow, etc., the wiper will stop until the motor cools.
Although the circuit is protected from electrical overload,
overload due to heavy snow, etc., may cause wiper
linkage damage. Always clear ice and heavy snow
from the windshield before using the windshield wipers.
If the overload
is caused by some electrical problem
and not snow, etc., be sure to get it fixed.
Power Windows and Other
Power Options
Circuit breakers in the fuse panel protect the power
windows and other power accessories. When the
current load is too heavy, the circuit breaker opens and
closes, protecting the circuit until the problem is fixed
or goes away.
5-92

13
14
15
16
Fuse/Circuit Usage Breaker
10 Air Bag System
11 Not Used
12 L, MI, M2 Blower Motor, Rear Air
Conditioning Relay Coil, Front Cont.
Temp. Door Motor, HI Blower Relay.
Defogger Timer Coil
Cigarette Lighter, Door Lock
Switches, Dutch Door Release Module
Cluster Illum, Climate Controls,
Chime Module, Radio Illumination,
Rear Heat Switch Illumination, Rear
Wipermasher Switch Illumination,
Rear Liftgate Switch Illumination,
Remote Cassette Illumination,
Overhead Console, Truck Body
Control Illurnination
Truck Body Module, Headlamp Relay
Front Turn Signals, Rear Turn
Signals, Trailer Turn Signals,
Back-up Lamps, Brake Transmission
Shift Interlock Solenoid 21
22
23
24
A
19
20
FuseKircuit
Usage
Breaker
17 Front Wipers, Front Washer Pump
18 VCM-lgn
3, VCM-Brake, Cruise
Stepper Motor Signal, ATC Module
Instrument Panel Radio: ATC
(Main Feed),
2000 Series (Standby)
PRNDUOdometer, TCC Enable and
PWM Solenoid, Shift A and Shift B
Solenoids, 3-2 Downshift Solenoid, Instrument Panel Cluster, VCM
Module
Powr Adjust Mirrors
Not Used
Rear Wiper, Rear Washer Pump
Not Used
(Circuit Breaker) Power Door Lock
Relay, 6-Way Power Seats
(Circuit Breaker) Power Windows
B
5-95

Fuse/Circuit Usage
Breaker
DIODE-I Air Conditioning
Blank Not Used
Blank
Not Used
Blank Not Used
LIGHTING Courtesy Fuse, Power Adjust
Mirrors Fuse, Truck Body Control
Battery Fuse
Power Accessory Circuit Breaker,
Stop/Hazard Fuse, Auxiliary Power
Fuse, Cigarette Lighter Fuse, Radio
Battery Fuse
BATT
Fuse/Circuit
Breaker
IGN A
IGN
B
ABS
Blank RAP
HTD MIRI
RR DEFOG
Usage
Starter Relay, Ignition Switch
Ignition Switch
Electronic Brake Control Module
Not Used Radio Accessory, Power Windows
Rear Window Defogger,
Climate Control Head
5-98

Daytime Running Lamps (DRL) ...................... 3-14
Defensive Driving
............................................. 4-2
Defogging and Defrosting
................................. 3-1 9
Directing the Airflow
........................................ 3-20
Disabling the Theft-Deterrent Feature
................. 3-49
Doing Your Own Service Work
........................... 5-3
Dome Lamps
.......................................... ~ ~~~ 3-16
Door Front Doors
............................................... 2-8
Locks
.......................................................... 2-7
Power Door Locks
......................................... 2-8
Programmable Automatic Door Locks
............... 2-9
Rear Doors
................................................. 2-13
Sliding Side Door
........................................ 2-10
Position, Safety Belt
..................................... 1-1 8
Driver Information System
................................ 2-42
At Night
..................................................... 4-14
City
........................................................... 4-19
Defensive
..................................................... 4-2
Drunken
....................................................... 4-3
Freeway
..................................................... 4-20
Hill and Mountain Roads
.............................. 4-22
In Rain and on Wet Roads ........................... 4-16
Winter
........................................................ 4-24
Driving On Grades
.......................................... 4-39
Driving on Snow or Ice
.................................... 4-24
Driver
Driving Driving
Through Deep Standing Water
............... 4-18
Driving Through Flowing Water
......................... 4-18
Driving with a Trailer
....................................... 4-37
E
Electrical System
Add-on Equipment
...................................... 5-92
Headlamp Wiring
......................................... 5-92
Fuses and
Circuit Breakers
........................... 5-93
Power Windows and Other Power Options
......... 5-92
Windshield Wiper Fuses
............................... 5-92
Emissions Inspection and
Engine Maintenance Programs
................................. 3-33
Air Cleaner/Filter
......................................... 5-24
Battery
....................................................... 5-46
Check and Service Engine Soon Light
............ 3-30
Coolant
...................................................... 5-28
Coolant Heater
............................................ 2-22
Coolant Temperature Gage
........................... 3-30
Cooling System Inspection
............................ 6-30
Cover
........................................................ 5-20
Engine Compartment Overview
...................... 5-14
Exhaust
..................................................... 2-30
Fan Noise
.................................................. 5-39
Oil
............................................................. 5-15
Starting
...................................................... 2-21
Overheating
................................................ 5-31
4

Engine Coolant Level Check ............................. 6-26
Engine Oil Additives
........................................ 5-18
Entry Lighting
................................................. 3-15
Erasing HomeLink@ Buttons
.............................. 2-37
Except Cargo Vans
................................. 1-38, 1-47
Express-Down Window
.................................... 2-1 7
Extender, Safety Belt
....................................... 1-34
Exterior Lamps
............................................... 3-12
Engine
Oil Level Check
................................... 6-26
Exit Lighting
................................................... 3-15
F
FabricKarpet ................................................. 5-83
Filter Engine Air Cleaner
...................................... 5-24
Finding a Station
.................................... 3-39, 3-41
Finish Care
.................................................... 5-87
Finish Damage
............................................... 5-88
Fixed Mast Antenna
........................................ 3-50
Flash-to-Pass
................. ........................... 3-7
Flat Tire
........................................................ 5-70
Fluid Flat Tire, Changing
......................................... 5-71
Automatic Transmission
................................ 5-25
Power Steering
........................................... 5-40
Windshield Washer
...................................... 5-41
FM
............................................................... 3-50
Following Distance
.......................................... 4-38 Footnotes
..... ................................ 6.7.
6-18
Front Axle
........ ................................... 5-54
Front Doors
..................................................... 2-8
Fuel
............................................................... 5-5
Additives ...................................................... 5-6
California Fuel
.............................................. 5-6
Filling a Portable Fuel Container
.................... 5-10
Filling Your Tank
........................................... 5-8
Fuels in Foreign Countries
.............................. 5-7
Gage
......................................................... 3-36
Gasoline Octane
........................................... 5-5
Gasoline Specifications .................................. 5-5
System Inspection
....................................... 6-30
Fuel Regulator
................................................ 2-21
Fuses Low Warning
Light
....................................... 3-37
Fuses and Circuit Breakers
........................... 5-93
Windshield Wiper
......................................... 5-92
G
Gage
Check Gages Warning Light
.......................... 3-36
Engine Coolant Temperature
......................... 3-30
Fuel
.......................................................... 3-36
Oil Pressure
............................................... 3-34
Speedometer
.............................................. 3-25
Voltmeter Gage
........................................... 3-28
Garage Door Opener
....................................... 2-34
5

Loading Your Vehicle ....................................... 4-29
Locks Door
........................................................... 2-7
Front Doors
.................................................. 2-8
Leaving Your Vehicle
.................................... 2-10
Power Door
.................................................. 2-8
Programmable Automatic Door Locks
............... 2-9
Long Trip/Highway Definition
.............................. 6-6
Long Trip/Highway Intervals
............................... 6-6
Long Trip/Highway Scheduled Maintenance
........ 6-1 8
Loss
of Control ............................................... 4-1 3
Low Fuel Warning Light
................................... 3-37
Lumbar
Luggage
Carrier
.............................................. 2-44
Manual Controls
............................................ 1-3
M
Maintenance. Normal Replacement Parts .......... 5-1 01
Maintenance Schedule At Each Fuel Fill
......................................... 6-26
At Least Once a Month
................................ 6-26
At Least Once a Year
.................................. 6-27
At Least Twice a Year
.................................. 6-26
Brake System Inspection
.............................. 6-31
Engine Cooling System Inspection
................. 6-30
Fuel System Inspection
................................ 6-30
How This Section is Organized
....................... 6-3
Exhaust System
Inspection
........................... 6-30 Maintenance Schedule (cont.)
Introduction
.................................................. 6-2
Long Trip/Highway Scheduled Maintenance
..... 6-18
Maintenance Requirements
............................. 6-2
Part A
. Scheduled Maintenance Services ......... 6-4
Part B
. Owner Checks and Services ............. 6-26
Part C
. Periodic Maintenance Inspections ...... 6-30
Part D
- Recommended Fluids and
Lubricants
............................................... 6-32
Part E
. Maintenance Record ........................ 6-34
Selecting the Right Schedule
.......................... 6-5
Short Trip/City Scheduled Maintenance
............. 6-7
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection
.......................... 6-30
Using Your
................................................... 6-4
Your Vehicle and the Environment
................... 6-2
Maintenance When Trailer Towing
..................... 4-40
Throttle
System Inspection
............................ 6-31
Making Turns
................................................. 4-38
Malfunction Indicator Light
................................ 3-30
Manual Lumbar Controls
.................................... 1-3
Manual Seats
................................................... 1-2
Manual Windows
........................................ 2-16
Mirrors Manual Rearview Mirror
................................ 2-32
Outside Convex Mirror
................................. 2-33
Outside Manual Mirrors
................................ 2-32
Outside Power Mirrors
.................................. 2-32
Model Reference
............................................ vi
8

Matching Transmitter(s) to Your Vehicle ................. 2-5
Mexico, Central America and Caribbean
Islands/Countries (Except Puerto Rico and
U.S. Virgin Islands) ........................................ 7-5
MyGMLink.com
................................................ 7-4
New Vehicle Break-In
...................................... 2-19
Normal Maintenance Replacement Parts
........... 5-101
Odometer
............................................
Off-Road Recovery ................................
Oil
... 3-25
... 4-1 1
Engine ....................................................... 5-1 5
Pressure Gage
............................................ 3-34
Older Children, Restraints
................................ 1-35
Online Owner Center
........................................ 7-4
Operation Tips
................................................ 3-22
Other Warning Devices
...................................... 3-5
Outlet Adjustment
............................................ 3-22
Outside Convex Mirror
............................................. 2-33
Manual Mirrors
............................................ 2-32
Power Mirrors
............................................. 2-32
Overhead Console
.......................................... 2-39
Owners, Canadian
............................................... ii
Owner’s Information
........................................ 7-1 2
P
Park (P)
Shifting Into
............................. ........ 2-27
Shifting Out
of ......................... ............ 2-29
Brake
..................................................... 2-26
Parking
Over Things That Burn
................................. 2-30
Park (P) Mechanism Check
........................... 6-29
Parking Brake
and Automatic Transmission
Parking on Hills
........................................ 4-39 -39
Part A
- Scheduled Maintenance Services ............... 6-4
Part B
- Owner Checks and Services ................... 6-26
Part D
- Recommended Fluids and Lubricants ....... 6-32
Part
E - Maintenance Record ............................. 6-34
Passing
................................................. 4-12, 4-38
Passlock@
...................................................... 2-18
Payload
......................................................... 4-31
Plan Ahead When Possible
................................ 7-8
Playing the Radio
................................... 3-39, 3-41
Power
Accessory Outlets
........................................ 3-16
Door Locks
.................................................. 2-8
Electrical System
......................................... 5-92
Seat
............................................................ 1-3
Windows .................................................... 2-17
Part
C - Periodic
Maintenance Inspections ............ 6-30
Playing a Compact Disc
................................... 3-43
Steering Fluid
............................................. 5-40 9