2003 BMW 540I SEDAN headlamp

141n
OverviewControlsMaintenanceRepairsDataIndex
Washer fluidsHeadlamp
* and windshield
washer system
Capacity in US quarts (liters).
Windshield washer:
approx. 3.7 (3.5) Ð sedan
approx. 6.3 (6.0) Ð sport wagon
Incl. headlamp washing system:
approx. 6.3 (6.0)
Fill with water and Ñ if required Ñ with a
washer antifreeze (according to manu-
facturer's recommendations).
We recommend that you mix the
washer ßuid before adding it to
the reservoir.< 390de762
Intensive-cleaning washer
reservoir
*
Capacity approx. 1.1 US quarts
(1.0 liter).
Fill with intensive-cleaning washer fluid.
It resists freezing to approx. Ð177
(Ð276) and is available from your BMW
center.
Antifreeze agents or intensive-
cleaning washer fluids for the
washer systems are highly inflammable.
For this reason, keep them away from
sources of flame and store only in orig-
inal containers. Store them so that they
are inaccessible to children. Comply
with the instructions on the con-
tainers.< 390de763

153n
OverviewControlsMaintenanceRepairsDataIndex
Lamps and bulbsThe lamps and bulbs are essential fac-
tors contributing to the safety of your
vehicle. For this reason, you should
follow the instructions below carefully
when replacing a bulb. If you are not
familiar with any of the procedures,
consult your BMW center.
Do not touch the glass portion of a
new bulb with your bare hands
since even small amounts of impurities
burn into the surface and reduce the
service life of the bulb. Use a clean
cloth, paper napkin, or a similar mate-
rial, or hold the bulb by its metallic
base.<
A replacement bulb set is available from
your BMW center.
Whenever working on the elec-
trical system, switch off the elec-
trical accessory you are working on or
disconnect the cable from the negative
terminal of the battery. Failure to do this
could result in short circuits.
To prevent injuries and damage,
comply with any instructions provided
by the bulb manufacturer.<
The right side of the engine compart-
ment.
1 Low beams
2 High beams
For checking and adjusting head-
lamp aim, please contact your
BMW center.< Low and high beamsH7 bulb, 55 watt
The bulb is pressurized. There-
fore, you should always wear
safety glasses and protective gloves.
Failure to observe these precautions
can result in physical injury if the bulb
breaks.< 390de767
1. Turn the bulb holder to the left
(arrow) and remove
2. Remove and replace the bulb.
When cleaning the headlamps,
please observe the following:
>Do not wipe dry (scratches). Never
use abrasives or strong solvents to
clean the covers
>Remove dirt and contamination (such
as insects) by soaking with BMW Car
Shampoo and then rinsing with plenty
of water
>Always use a deicer spray to remove
accumulated ice and snow Ð never
use a scraper.<

155n
OverviewControlsMaintenanceRepairsDataIndex
Lamps and bulbsSide turn signal indicators5 watt bulb
1. Use finger pressure against the rear
end of the lens (arrow) to press it for-
ward for removal
2. Press gently on the bulb and turn it to
the left to remove it.390de768
Front fog lampsH8 bulb, 35 watt
The bulb is pressurized. There-
fore, wear safety glasses and pro-
tective gloves. Failure to observe these
precautions can result in physical injury
if the bulb breaks.<
1. Using a screwdriver, remove the
mounting clips for the air grill (arrow)
and remove the grill by bringing it
toward the front390de671
2. Loosen both screws (arrows)
3. Take off the cover panel next to the
headlamp
4. Turn the headlamp 903 to the left and
remove it by bringing it toward the
front
5. Disconnect the plug
6. Turn the lamp to the left and remove
it.390de672

175n
OverviewControlsMaintenanceRepairsDataIndex
Capacities

Notes
Fuel tank
Reservegal. (liters)
gal. (liters)approx. 18.5 (approx. 70)
approx. 2.0 (approx. 8) Ð BMW 525i, 530i
approx. 2.5 (approx. 10) Ð BMW 540iFuel specification: page 25
Windshield washer system
with headlamp washer system
Intensive cleaning systemquarts (liters)
quarts (liters)
quarts (liters)approx. 3.7 (approx. 3.5)
approx. 6.3 (approx 6.0)
approx. 1.1 (approx 1.0)For details: page 141
Cooling system including
heater circuitquarts (liters) 11.1 (10.5) Ð BMW 525i, 530i
12.7 (12.0) Ð BMW 540iFor details: page 144
Engine oil and filter change quarts (liters) 6.9 (6.5) Ð BMW 525i, 530i
7.9 (7.5) Ð BMW 540i"BMW High Performance
Synthetic Oil."
For details: page 143
Manual transmission, automatic
transmission and differentialÐ Ð Lifetime fluid, no fluid
change required

Everything from A to ZElectrical malfunction
doors33
fuel filler door24
luggage compartment
lid38
sliding/tilt sunroof47
tailgate39
Elements of operation,
cockpit14
Emergency release of
luggage compartment lid
from luggage
compartment's interior41
Energy control83
Engine compartment
essentials140
Engine coolant84, 144
Engine oil142
consumption142
disposal143t
level20
pressure19
specifications143t
viscosity ratings143
Engine specifications170
Estimated time of arrival95
Exterior mirrors57, 58
F
Failure messages85t
Filling the washer
reservoir141t
First-aid kit23
Fittings, tow-starting and
towing165t
Flashlight118
Flat tire135, 158t
Fog lamps104
bulb replacement155t
Fold rear-seat backrest121
Follow me home lamps103
Front ashtray119
Front fog lamps104
Front seat adjustment48
Fuel25
gauge83
quality25
specifications25
tank capacity175
Fuel consumption88, 95
average88, 95
indicator83
Fuel filler door24
electrical malfunction24
manual release24
Fuses162
G
Gasoline25
gauge83
quality25
Glass moonroof47
Glove compartment118
Grilles109
Gross vehicle weight173 H
Handbrake70
Hands-free system119
Hazard warning triangle23
Head restraints50
Headlamp covers,
care153t
Headlamp flasher78
Headlamp washer
system141
Heated seats55
Heated steering wheel56
Heating and
ventilation106, 109
Heating while stopped113
Heavy cargo128
Height adjustment
seats50
steering wheel56
Height of vehicle171
High beams21, 104
bulb replacement153t High Performance Synthetic
Oils143
High-mount brake lamp157
Holder for canned
beverages119
Hood139
release139t
Horn14
Hydraulic Braking Assistant,
refer to DBC20
Hydroplaning133, 135
I
Ice warning82
Identification, tires137
Ignition lock68
Immobilizer function96
activating code96
deactivating code96
selecting code96
Imprint4
Indicator and warning
lamps19
Inflation pressure26t
monitoring101
Inflation pressure,
tires26, 135
INSPECTION84
Instrument
cluster15, 16, 17