2003 ASTON MARTIN DB AR1 Q fuel filter

F - Owner Maintenance
1-F-60
Recommissioning After Storage
Provided that the car has been stored in accordance with the recommended
procedure, the following points only should require attention before using
the car on the road.
Check the tyre pressures, inflate if necessary and lower the car to the ground.
Fully charge and refit the battery. Reset the clock and electric windows.
Drain the engine sump and final drive unit, fit a new engine oil filter element,
then refill with the approved oils. Check the coolant level and if necessary
top up with the correct antifreeze/water solution.
Check all fluid levels and top-up as necessary. Fill the fuel tank
Caution: Starting the engine without sufficient lubrication can cause serious engine
damage. Take care to establish engine oil pressure as directed in the following steps
before allowing the engine to start.
Press and hold the accelerator hard to the floor (kickdown switch actuated).
This will temporarily inhibit the fuel injectors during cranking. Turn on the
ignition. Press and hold the starter button to crank the engine until normal
oil pressure is indicated on the oil pressure gauge. Release the starter button
and the accelerator pedal.
Start the engine normally and check that the oil pressure and ignition
warning lights go out as the engine starts indicating correct oil pressure and
battery charging. Raise the bonnet and check for leaks of fuel, oil and
coolant.
Finally, check the operation of all instruments, lights and accessories.

G - Specifications
1-G-11
Capacities
Europe UK USA
Engine sump (incl. filter) 11 litres (20.0 pints) (11.5 Qts)
Engine sump (excl. filter) 10 litres (18 pints) (10.3 Qts)
Engine cooling system 14.35 litres (25.25 pints) (15.2 Qts)
Screen washer reservoir 2.8 litres (5.0 pints) (3.2 Qts)
Manual gearbox 4.0 litres (7.0 pints) (4.2 Qts)
Automatic gearbox 12.8 litres (22.5 pints) (13.5 Qts)
Final drive 1.6 litres (2.8 pints) (1.7 Qts)
Fuel tank 82 litres (18 galls) (21.5 galls)
Note: Approximately 7 litres of the total fuel capacity specified above is
required to prime the fuel system and is therefore not usable.

2-A-7
A - Service Schedules
Service Schedules
The following service schedules are recommended for DB AR1. The schedules may
be modified if necessary. Please consult your Aston Martin Dealer for details of any
service schedule updates.
Road Test Evaluation
1000mls 7500mls 15000mls
1500km 12000km 24000km
3 months 6 months 12 months
x x x Pre-Maintenance Road Test Evaluation
Fluids Filters and Leaks Checks
1000mls 7500mls 15000mls
1500km 12000km 24000km
3 months 6 months 12 months
x x x Renew the engine oil
x x x Renew the engine oil filter
x x x Check for engine oil leaks
- - x Renew the air cleaner elements
x x x Check auto transmission for leaks
x x x Check man. gearbox for leaks.
Top-up if necessary
- - x Renew rear axle oil
x - - Check / top-up rear axle oil
- x - Check rear axle for leaks, top up if necessary
- - 30000 Renew engine coolant - check S.Gravity
x x x Check/top-up engine coolant
x x x Check cooling and heating systems for leaks
- - 60000 Renew fuel filters
x x x Check for fuel leaks
Every 2 years 30,000 miles Renew brake fluid
x x x Check / top-up brake fluid reservoir
x x x Check / top-up clutch fluid reservoir
x x x Check / top-up power steering reservoir
x x x Check power steering system for leaks
x x x Check brake hoses, pipes and unions for leaks
x x x Check suspension dampers for leaks
x x x Top-up windscreen washer reservoir
x x x Check exhaust system for leaks
x x x Check air conditioning system for leaks