2002 Peugeot 306 Break brake

MAINTENANCE OF YOUR 30631
Power steering reservoir
Open the reservoir, with the engine cold, at outside temperature, the levelshould always be above the MINImark, close to the MAXI mark.
Windscreen and headlamp wash reservoir* For best quality cleaning and for your
safety, we recommend that you useproducts approved by PEUGEOT(capacity 4,4 litres or 6 litres withheadlight wash). Battery
At the start of winter, have your battery checked by a PEUGEOT
dealer. Air filter Regular replacement of the filter element is essential. If you drive invery dusty conditions, change it twiceas often. Brake pads Brake pad wear depends on the style of driving, in particular for vehicleswhich are used in town or for shortjourneys or which are driven in a
sporty manner, it may be necessaryto check the thickness of the padseven between services. Manual gearbox This does not need an oil change. Check the level according to the
manufacturerÕs service schedule. Autoadaptive automatic gearbox This does not need an oil change: have the level checked by a
PEUGEOT dealer according to the
manufacturerÕs service schedule.
Only use products appro-
ved by Automobiles
PEUGEOT.
To ensure best perfor-
mance from components as impor- tant as the power steering and thebraking system, PEUGEOT selectsand offers quite specific products.
Fuel supply cut-off* In a serious collision, a system pre- vents fuel from reaching the engine.
To re-establish the fuel supply, press the switch on the angle of the front
left-hand suspension assembly, underthe bonnet.
* According to specification.

MAINTENANCE OF YOUR 30633
For your safety, always change the wheel:
- on level, stabIe and non-slippe- ry ground,
- with the handbrake applied,
- with first gear or reverse enga- ged (position Pfor the automa-
tic gearbox).
Never go underneath a vehicle which is supported only by a jack.(Use a ramp).
To fit the wheel After positioning the wheel, pre- tighten the bolts using the wheel-brace. Lower the jack and remove it.Fully tighten the wheel bolts using the wheelbrace. Fit the wheel trim starting with the section by the valve and press intoplace using the palm of the hand.
Removing the wheel Park the vehicle on level, stable and non-slippery ground. Apply the handbrake, engage first gear or reverse (position Pfor the
automatic gearbox). Remove the wheel trim by using the wheelbrace and pulling next to thevalve.
Warning: your wheel trims are fitted
with dummy nuts. Do not use them to remove your wheel trims.4-door: Use the jack storage box to
chock the wheel diagonally opposite the wheel to be changed. Loosen the wheel bolts.Place the jack in the location designed for it, as close as possible to thewheel to be changed. Ensure that the whole of the base of the jack is in contact with the ground. Extend the jack, fully loosen the wheel bolts and remove the wheel. Refitting the wheel in the carrier
Raise the wheel, then the carrier, and resecure it on the hook. Do not forget to fully tighten the spare wheel carrier securing bolt. After changing the wheel:
- have the tightening of the bolts
and the tyre pressure checked by a PEUGEOT dealer as soonas possible,
- have the punctured wheel repaired and refit it to thevehicle as soon as possible.

MAINTENANCE OF YOUR 30637
Rear lights 3 and 5 door
1 Brake lights/side lights P21/5W.
2 Side lights P21/5W.
3 Rear fog lamp P21W.
4 Reversing lights P21W.
5 Amber direction indicator lights PY21W.
Rear lights 3, 4 and 5 door
- Unscrew the two wing nuts inside
the boot.
- Remove the plastic cover.
- Disconnect the connector Aby
pressing the metal bar.
- Disconnect the connector Bby
releasing the tab.
- Release the light unit.
- Pinch the tabs and remove the bulb holder C.
- Change the faulty bulb.
Rear lights 4 door
1 Amber direction indicator lights PY21W.
2 Rear fog lamp P21W.
3 Reversing lights P21W.
4 Brake lights/side lights P21/5W.
5 Side lights P21/5W.
12
54
3
A
B1
452
3
When refitting, ensure that the seal is clean, inorder to prevent water
entry.
CC

MAINTENANCE OF YOUR 306
38
Rear lights (estate)
- Open the storage compartment
inside the boot.
- Open the access flap.
- Unscrew the wing bolt on the inside.
- Unscrew the second wing bolt outside the vehicle.
Use the wheelbrace to make it easier to unscrew the bolts. Warning:never
use it for refitting.
- Release the light unit.
- Disconnect the connector by pres- sing the metal bar.
- Pinch the tabs and remove the bulb holder.
- Change the faulty bulb.
Fog lamp P21W
This is located in the bumper.Additional brake light 5 bulbs W5WRemove the plastic protector by pres- sing the notches
A.
Squeeze the tabs Bto release the
lamp holder. Change the faulty bulb.
1 Amber direction indicator lights
PY21W.
2 Reversing lights P21W.
3 Brake lights/side lights P21/5W.
AA
BB
1
2
3The bulbs must be repla- ced by bulbs of identical
specification and colour.

MAINTENANCE OF YOUR 30647
Driving advice Distribution of loads: distribute the load in the trailer so that the heaviestloads are as close as possible to theaxle and the nose weight is close tothe maximum authorised without,
however, exceeding it. Cooling:
towing a trailer on a slope
increases the coolant temperature. As the fan is electrically controlled, itscooling capacity is not dependent onthe engine speed.
On the contrary, use a high gear to lower the engine speed, and reduceyour speed. The maximum towing load on a long slope depends on the gradient andthe outside temperature. In all cases, pay attention to the coolant temperature. If the warning light comes on, stop the
vehicle and switch off the engine assoon as possible.
TOWING A TRAILER,
CARAVAN, BOAT ETC.
Only use original PEUGEOT towbars which have been tested and approvedfrom the design stage of your vehicle. The towbar must be fitted by a
PEUGEOT dealer.
Your vehicle is mainly designed for transporting people and luggage but it
may also be used to tow a trailer. Driving with a trailer subjects the towing vehicle to more significantforces and requires particular atten-
tion on the part of the driver. Air density decreases with altitude, thus also reducing engine perfor-
mance. Above 1000 metres, reducethe maximum towing load by 10 %and so on for each additional 1000 metres.
For use in arduous conditions(towed load at the limit of the Permis-
sible Gross Train Weight, in Summeron a long hill)
certain engines (1.9 l
Diesel) must be equipped with a
more resistant cooling system.
Consult a PEUGEOT dealer who, depending on your vehicle and what it
is used for, will be able to advise youabout suitable equipment. Pay attention to the coolant tempera- ture at all times. If the alarm warning light comes on,
stop the vehicle and switch off theengine as soon as possible.
Tyres: check the tyre pressures of the
towing vehicle and the trailer, obser- ving the recommended pressures. Brakes: towing increases the braking
distance. Drive at a moderate speed,
change down early, brake graduallyand avoid jerky braking. Lighting: adjust your headlamps so
as not to dazzle other road users. Check the electrical signalling on the
trailer. Side wind: sensitivity to side wind is
increased. Drive smoothly and at a moderate speed.

MAINTENANCE OF YOUR 306
48
BODYWORK MAINTENANCE
To preserve the paintwork and the plastic trim on your vehicle, we rec-ommend that you wash them regu-
larly,
- by hand, there are no specific pre-cautions to take;
- however repeated use of poorly maintained automatic car-washes can lead to the appearance ofmicro-scopic scratches which givethe paintwork a matt appearance(especially visible on dark colours);
- using a high pressure washer, always following the recommen-dations on the equipment (pres-sure and spraying distance). If there are areas of damage on the vehicle (painted bumpers, or head-lamps), it is not recommended todirect the high pressure jet ontothem: wash the areas of damageby hand. Also avoid the entry of water into the locks. Waxing:
the regular use of wax
added to the washing water orapplied separately is strongly recom-mended, it protects the upper coats ofpaintwork against external attack. For all questions relating to the main- tenance of your vehicle, contact anapproved dealer who can advise youon quality products selected by ourdepartments. - Clean off, as soon as
possible, bird droppings,resinous deposits, tarstains and grease
marks ; (as these all containsubstances which can causeserious damage to the paint-work).
- Brake briefly several times to expel any dampness from thebrake pads, when you are set-ting off after washing your vehi-cle.
- Do not use a dry or abrasive cloth, or detergent or solventproducts to clean the doublelens, complex surface head-lamps as they are fitted withpolycarbonate glass covered ina protective finish.
- Do not use petrol, oil or cloth stain removers to clean thebodywork and plastic parts ofyour vehicle.
- To prevent the development of bodywork corrosion as a resultof accidental damage (stonechips, scratches etc.) have them
repaired swiftly.

116
TECHNICAL DATA
* The speed of a towing vehicle is limited to 60 mph (100 Km/h).
TOWING WEIGHTS AND LOADS (IN KG)
Engines
1.4 litre 1.6 litre 1.6 litre 1.8 litre 2 l 16 V 2 l 16 V 1.9 l D 2 l HDI
Gearbox Manual Manual
Auto.Manual Manual Auto.Manual Manual
Model codes : 7CÉ KFW N F T N F T LFY/L6A RFV R F V W J Y R H Y
¥
Kerb weight1 013 1 071 1 108 1 096 1 160 1 208 1 100 1 142
¥ Gross vehicle weight (GVW) 1 460 1 535 1 550 1 560 1 625 1 650 1 530 1 585 ¥
Gross Train weight (GTW)*2 360 2 435 2 450 2 560 2 625 2 650 2 480 2 585
¥ Unbraked trailer 540 570 575 580 610 630 570 600¥
Braked trailer (within GTW)1 200 1 200 1 200 1 200 1 200 1 200 1 200 1 200
Engines 1.4 litre 1.6 litre 1.6 litre 1.8 litre 1.8 l 16 V 2 l 16 V 2 l 16 V 1.9 l D 2 l HDI
Gearbox Manual Manual
Auto.Manual Manual Manual Auto.Manual Manual
Model codes : 7AÉ KFW
NFT NFT LFY/L6A
FYE/FYT RFV
RFV WJY RHY
¥
Kerb weight1 043 1 106 1 125 1 116 1 116 1 194 1 242 1 118 1 213
¥ Gross vehicle weight (GVW) 1 480 1 580 1 600 1 600 1 670 1 640 1 650 1 580 1 630 ¥
Gross Train weight (GTW)*2 380 2 480 2 500 2 600 2 670 2 640 2 650 2 530 2 630
¥ Unbraked trailer 550 580 585 590 625 620 640 580 610¥
Braked trailer (within GTW)1 200 1 200 1 200 1 200 1 200 1 200 1 200 1 200 1 200
5 DOOR
Engines 1.4 litre 1.9 l D1.8 l 16 V1.9 l D
Gearbox Manual Manual Manual Manual
Model codes : 7SÉ / 7TÉ KFW WJY FYE/FYT WJZ
¥
Kerb weight1 013 1 100 1 096 1 118
¥ Gross vehicle weight (GVW) 1 460 1 530 1 670 1 580 ¥
Gross Train weight (GTW)*2 360 2 480 2 670 2 530
¥ Unbraked trailer Ñ Ñ Ð Ð¥
Braked trailer (within GTW)1 200 1 200 1 200 1 200
3 DOOR VAN 7S... 5 DOOR VAN 7T...
3 DOOR

117
TECHNICAL DATA
* The speed of a towing vehicle is limited to 60 mph (100 Km/h).
TOWING WEIGHTS AND LOADS (IN KG)
Engines
1.4 litre 1.6 litre 1.6 litre 1.8 litre 1.8 l 16 V 2 l 16 V 2 l 16 V 1.9 l D 2 l HDI
Gearbox Manual Manual
Auto.Manual Manual Manual Auto.Manual Manual
Model codes : 7BÉ KFW N F T N F T LFY/L6AFYE/FYT
RFV RFV WJY RHY
¥
Kerb weight1 042 1 117 1 180 1 162 1 162 1 198 1 225 1 227 1 225
¥ Gross vehicle weight (GVW) 1 515 1 575 1 610 1 615 1 695 1 635 1 660 1 590 1 635 ¥
Gross Train weight (GTW)*2 415 2 475 2 510 2 615 2 695 2 635 2 660 2 540 2 635
¥ Unbraked trailer 555 585 605 600 640 630 650 590 620¥
Braked trailer (within GTW)1 200 1 200 1 200 1 200 1 200 1 200 1 200 1 200 1 200
4 DOOR
Engines 1.4 litre 1.6 litre 1.6 litre 1.8 litre 1.8 l 16 V 2 l 16 V 2 l 16 V 1.9 l D 2 l HDI
Gearbox Manual Manual
Auto.Manual Manual Manual Auto.Manual Manual
Model codes : 7BÉ KFW N F T N F T LFY/L6AFYE/FYT
RFV RFV WJY RHY
¥
Kerb weight1 088 1 150 1 165 1 185 1 185 1 195 1 225 1 172 1 260
¥ Gross vehicle weight (GVW) 1 550 1 605 1 635 1 645 1 725 1 665 1 675 1 625 1 655 ¥
Gross Train weight (GTW)*2 450 2 505 2 535 2 645 2 725 2 665 2 675 2 575 2 655
¥ Unbraked trailer 570 590 620 630 675 640 650 600 635¥
Braked trailer (within GTW)1 000 1 000 1 000 1 000 1 000 1 000 1 000 1 000 1 000
ESTATE