2002 MAZDA MODEL PROTÉGÉ engine

8-21
Maintenance and Care
Owner Maintenance
Form No. 8Q36-EA-01F
All moving points of the body, such as
door and hood hinges and locks, should
be lubricated each time the engine oil is
changed. Use a nonfreezing lubricant on
locks during cold weather.
Make sure the engine hood’s secondary
latch keeps the hood from opening when
the primary latch is released.A viscous paper air filter fits inside the air
cleaner housing, as shown. It’s been
specially treated and should not be
cleaned and reused. Replace it when
necessary.

Replacing the Air Filter
1. Unfasten the clamps.
Body LubricationAir Filter
Don’t drive without an air filter. This
could result in excessive engine wear.
NOTE
If the vehicle is operated in very dusty
or sandy areas, replace the filter more
often than recommended intervals.
CAUTION
Clamp
J39L(02MY).book Page 21 Thursday, November 1, 2001 10:49 AM

8-41
Maintenance and Care
Owner Maintenance
Form No. 8Q36-EA-01F

Fuse Panel Description
Fuse block (Engine compartment)
DESCRIPTIONFUSE
RATINGPROTECTED
COMPONENT
1 HEATER 40 A Heater
2 (ABS) 60 AAntilock brake
system, For
protection of
various circuits
3 IG KEY 60 AFor protection of
various circuits
4 (PTC) 30 A—
5 (GLOW) 40 A—
6—— —
7COOLING
FA N30 A Cooling fan
8 BTN 40 AInterior lights,
Power door lock
9 (AD FAN) 30 AAdditional
cooling fan for air
conditioner
10INJ OR
FIP30 AEngine control
unit
11 (A/C) 10 A Air conditionerDESCRIPTIONFUSE
RATINGPROTECTED
COMPONENT
12 (ST.SIG) 10 A Starter signal
13 HORN 15 A Horn
14 HAZARD 15 AHazard warning
flashers
15 TAIL 15 A Taillights
16(HEAD
C/U)7.5 AFor protection of
various circuits
17 (FOG) 15 A—
18 (FOG) 15 A Fog lights
19 STOP 15 A Brake lights
20 HEAD-R 15 A Headlight-right
21 HEAD-L 15 A Headlight-left
22—— —
23 HEAD HI 15 A—
24 MAIN 100 AFor protection of
all circuits
J39L(02MY).book Page 41 Thursday, November 1, 2001 10:49 AM

8-42
Maintenance and Care
Owner Maintenance
Form No. 8Q36-EA-01F
Fuse panel (Driver’s side)
DESCRIPTIONFUSE
RATINGPROTECTED
COMPONENT
1(S/WRM) 15 AFor protection of
various circuits
2 (H/CLN) 20 AFor protection of
various circuits
3 (RADIO) 15 A Audio system
4 (A/C) 15 A Air conditioner
5 (R.WIPER) 10 AFor protection of
various circuits
6—— —
7—— —
8 ROOM 10 AInterior lights,
Trunk light,
Luggage
compartment light
9(MIRR
DEF)10 A—
10—— —
11(DOOR
LOCK)30 A Power door lock
12 (P/WIND) 30 A—DESCRIPTIONFUSE
RATINGPROTECTED
COMPONENT
13 WIPER 20 AWindshield wiper
and washer
14 ENGINE 10 AEngine control
unit
15 METER 10 A Instrument cluster
16—— —
17 (P/WIND) 30 A Power windows
J39L(02MY).book Page 42 Thursday, November 1, 2001 10:49 AM

9-9
Customer Information
Wa r r a n t y
Form No. 8Q36-EA-01F
Government regulations in the United States and Canada require that automobiles meet
specific emission regulations and safety standards. Therefore, vehicles built for use in the
United States, its territories, and Canada may differ from those sold in other countries.
The differences may make it difficult or even impossible for your vehicle to receive
satisfactory servicing in other countries. We strongly recommend that you NOT take your
Mazda outside these areas.
You may have these problems if you do:
•Recommended fuel may be unavailable. Any kind of leaded fuel or low-octane fuel will
affect vehicle performance and damage the emission controls and engine.
•Proper repair facilities, tools, testing equipment, and replacement parts may not be
available.
The Mazda warranty applies only to Mazda vehicles registered and normally operated in
the United States, its territories, and Canada.
Outside the United States and Canada
J39L(02MY).book Page 9 Thursday, November 1, 2001 10:49 AM

9-10
Customer Information
Wa r r a n t y
Form No. 8Q36-EA-01F
Non-genuine parts and accessories for Mazda vehicles can be found in stores.
These may fit your vehicle, but they are not approved by the Mazda for use with Mazda
vehicles. When you install non-genuine parts or accessories, they could affect your
vehicle’s performance or safety system; the Mazda warranty doesn’t cover this. Before you
install any non-genuine parts or accessories, consult an Authorized Mazda Dealer.
Mazda assumes no responsibility for death, injury, or expenses that may result from the
installation of add-on non-genuine parts or accessories.
Add-On Non-Genuine Parts and Accessories
Installation of Non-Genuine Parts or Accessories:
Installation of non-genuine parts or accessories is dangerous. Improperly designed
parts or accessories could seriously affect your vehicle’s performance or safety
system. This could cause you to have an accident or increase your chances of injuries
in an accident. Always consult an Authorized Mazda Dealer before you install non-
genuine parts or accessories.
Add-On Electrical and Electronic Equipment:
Incorrectly choosing or installing improper add-on equipment or choosing an
improper installer is dangerous. Essential systems could damaged, causing engine
stalling, air-bag (SRS) activation, ABS inactivation, or a fire in the vehicle.
Be very careful in choosing and installing add-on electrical equipment, such as
mobile telephones, two-way radios, stereo systems, and car alarm systems.
WARNING
J39L(02MY).book Page 10 Thursday, November 1, 2001 10:49 AM

10-3
Identification Numbers
Form No. 8Q36-EA-01F

Engine Number
Front 1.6-liter engine
1.8 and 2.0-liter engines
Front
J39L(02MY).book Page 3 Thursday, November 1, 2001 10:49 AM

10-4
Form No. 8Q36-EA-01F
Specifications

Engine

Electrical System

Lubricant Quality
*Refer to the recommended SAE viscosity numbers on page 8-11.
Specifications
ItemModel
1.6-liter engine 1.8-liter engine 2.0-liter engine
Type DOHC-16V in-line, 4-cylinder
Bore×Stroke78.0×83.6 mm
(3.07×3.29 in) 83.0×85.0 mm
(3.27×3.35 in) 83.0×92.0 mm
(3.27×3.62 in)
Displacement1,598 ml
(1,598 cc, 97.5 cu in) 1,840 ml
(1,840 cc, 112.2 cu in) 1,991 ml
(1,991 cc, 121.5 cu in)
Compression ratio 9.0 9.1
ItemModel
1.6-liter engine 1.8 and 2.0-liter engines
Battery12V-40AH/5HR 12V-40AH/5HR
12V-48AH/5HR 12V-52AH/5HR
Alternator 12V-70A 12V-80A
Starter 12V-0.8 kW 12V-1.0 kW
Spark-plug numberMAZDA—BP13 18 110, BP14 18 110
NGK ZFR5F-11, ZFR6F-11 BKR5E-11, BKR6E-11
DENSO KJ16CR11, KJ20CR11 K16PR-U11, K20PR-U11
CHAMPION—RC8YC4, RC10YC4
Spark-plug gap 1.0—1.1 mm (0.040—0.043 in)
LubricantClassification
API Service ILSAC
Engine oil
*
SG (Energy Conserving II) —
SH (Energy Conserving II) GF-I
SJ GF-II
SL GF-III
Lubricant Classification
Manual transaxle oilAny temperatureAPI Service GL-4 or GL-5
SAE 75W-90
Above 10°C (50°F) API Service GL-4 or GL-5
SAE 80W-90
Automatic transaxle fluid ATF M-V
Power steering fluid ATF M-III or equivalent (e.g. Dexron® III)
Brake/Clutch fluid SAEJ1703 or FMVSS116 DOT-3
J39L(02MY).book Page 4 Thursday, November 1, 2001 10:49 AM

10-5
Specifications
Form No. 8Q36-EA-01F

Capacities
(Approximate Quantities)
Check oil and fluid levels with dipsticks or reservoir gauges.

Dimensions
ItemUnit
L US qt Imp qt
Engine oil1.6-liter engineWith oil filter replacement 3.2 3.4 2.8
Without oil filter
replacement3.0 3.2 2.6
1.8 and 2.0-liter
enginesWith oil filter replacement 3.5 3.7 3.1
Without oil filter
replacement3.3 3.5 2.9
Coolant1.6-liter engineWith heater 6.0 6.3 5.3
Without heater 5.5 5.8 4.8
1.8 and 2.0-liter
enginesWith heater 7.5 7.9 6.6
Without heater 6.9 7.3 6.1
Transaxle oilManual transaxle 2.7 2.9 2.4
Automatic transaxle 7.2 7.6 6.3
Fuel tank1.6-liter engine 50 13.2 (US gal) 11.0 (Imp gal)
1.8 and 2.0-liter engines 55 14.5 (US gal) 12.1 (Imp gal)
ItemModel
Sedan Hatchback
Overall length 4,450 mm (175.2 in) 4,331 mm (170.5 in)
Overall width 1,705 mm (67.1 in) 1,705 mm (67.1 in)
Overall height 1,410 mm (55.5 in) 1,410 mm (55.5 in)
Front tread 1,470 mm (57.9 in) 1,465 mm (57.7 in)
Rear tread 1,470 mm (57.9 in) 1,470 mm (57.9 in)
Wheelbase 2,610 mm (102.8 in) 2,610 mm (102.8 in)
J39L(02MY).book Page 5 Thursday, November 1, 2001 10:49 AM