2002 HONDA S2000 service

For very short distances, such as
freeing the car, you can use the
detachable towing hook that mounts
on the anchors in the front and rear
bumpers.Remove the cover f rom the
bumper.
To use the towing hook: Remove the towing hook, hook
extension, and wheel wrench f rom
the tool box.
Using the wheel wrench, f asten
the extension into the bolt hole in
the anchor.
If your car gets stuck in sand, mud,
or snow, call a towing service to pull
it out (see page ).
1.2. 3.
247
CONT INUED
If Your Car Gets Stuck
T aking Care of t he Unexpect ed
245

µ
µ
If your car needs to be towed, call a
prof essional towing service or, if you
belong to one, an organization that
provides roadside assistance. Never
tow your car behind another vehicle
with just a rope or chain. It is very
dangerous.
There are three popular types of
prof essional towing equipment. The tow
truck uses two pivoting arms that go
under the tires (f ront or rear) and lif t
them of f the ground. The other two
tires remain on the ground. Because
the S2000 sits so low, the body could
come in contact with the ground and
be damaged.
The operator
loads your vehicle on the back of a
truck.
When you contact the towing agency,
inf orm them that you have an S2000
and that a f lat-bed is required.Wheel L if t Equipment
Flat -bed Equipment
T his method of
towing is unacceptable.
T his is the only way your
S2000 should be transported.
Emergency T owing
T aking Care of t he Unexpect ed 247

µ
The treadwear grade is a compara-
tive rating based on the wear rate of
the tire when tested under controlled
conditions on a specif ied government
test course. For example, a tire
graded 150 would wear one and one-
half (1 1/2) times as well on the
government course as a tire graded
100. The relative perf ormance of
tires depends upon the actual condi-
tions of their use, however, and may
depart signif icantly f rom the norm
due to variations in driving habits,
service practices and dif f erences in
road characteristics and climate.
The tires on your vehicle meet all
U.S. Federal Saf ety Requirements.
All tires are also graded f or
treadwear, traction, and temperature
perf ormance according to
Department of Transportation
(DOT) standards. The f ollowing
explains these gradings.
Quality grades can be f ound where
applicable on the tire sidewall
between the tread shoulder and the
maximum section width. For
example:
The traction grades, f rom highest to
lowest, are AA, A, B, and C. These
grades represent the tire’s ability to
stop on wet pavement as measured
under controlled conditions on
specif ied government test surf aces
of asphalt and concrete. A tire
marked C may have poor traction
perf ormance.
Warning: The traction grade
assignedtothistireisbasedon
straight-ahead braking traction tests,
and does not include acceleration,
cornering, hydroplaning, or peak
traction characteristics.
All passenger car tires must conf orm
to Federal Saf ety Requirements in
addition to these grades.
T echnical Inf ormation
DOT T ire Quality Grading (U.S. Vehicles)
T readwear
Unif orm T ire Quality Grading T readwear 200
Traction AA
Temperature A Traction AA, A, B, C
254

Some conventional gasolines are
being blended with alcohol or an
ether compound. These gasolines
are collectively ref erred to as
oxygenated f uels. To meet clean air
standards, some areas of the United
States and Canada use oxygenated
f uels to help reduce emissions.
If you use an oxygenated f uel, be
sure it is unleaded and meets the
minimum octane rating requirement.
Bef ore using an oxygenated f uel, try
to conf irm the f uel’s contents. Some
states/provinces require this
informationtobepostedonthepump.The f ollowing are the U.S. EPA and
Canadian CGSB approved
percentages of oxygenates:
(methyl or wood
alcohol)
Your vehicle was not designed to use
fuel that contains methanol.
Methanol can corrode metal parts in
the fuel system, and also damage
plastic and rubber components. This
damage would not be covered by
your warranties.
(Methyl Tertiary Butyl
Ether)
You may use gasoline containing up
to 15 percent MTBE by volume. (ethyl or grain alcohol)
You may use gasoline containing up
to 10 percent ethanol by volume.
Gasoline containing ethanol may be
marketed under the name ‘‘Gasohol.’’
If you notice any undesirable
operating symptoms, try another
service station or switch to another
brand of gasoline.
Fuel system damage or perf ormance
problems resulting f rom the use of
an oxygenated f uel containing more
than the percentages of oxygenates
given above are not covered under
warranty.
Oxygenated Fuels
T echnical Inf ormation MET HA NOL
MT BE
ET HA NOL
256

Honda dealership personnel are
trained prof essionals. They should
be able to answer all your questions.
If you encounter a problem that your
dealership does not solve to your
satisf action, please discuss it with
the dealership’s management. The
Service Manager or General
Manager can help. Almost all
problems are solved in this way.
If you are dissatisf ied with the
decision made by the dealership’s
management, contact your Honda
Customer Relations Of f ice.U.S. Owners: In Puerto Rico and the U.S. Virgin
Islands:
When you call or write, please give
us this inf ormation:
Vehicle Identif ication Number
(see page )
Name and address of the dealer
who services your vehicle
Date of purchase
Mileage on your vehicle
Your name, address, and tele-
phone number
A detailed description of the
problem
Name of the dealer who sold the
vehicle to you
Canadian Owners:
250
Cust omer Relat ions Inf ormat ion
Warrant y and Cust omer Relat ions
264 CUSTOMER RELATIONS
RELATIONS AVEC LA CLIENTÉLE
Bella International
P.O. Box 190816
San Juan, Puerto Rico 00919-0816
(787) 250-4318
American Honda Motor Co.
Honda Consumer Affairs
Department
Mail stop 500-2N-7D 1919 Torrance Blvd
Torrance, CA 90501-2746
telephone: (800) 993-1009
Honda Canada Inc.
715 Milner Avenue
Toronto, ON
M1B 2K8
Tel: 1-888-9-HONDA-9
Fax: Toll-free 1-877-939-0909 Toronto (416) 287-4776

ÎÎ
Î
µ
Î
   $#
The f ollowing publications covering the operation and
servicingof yourcarcanbeobtainedfromHelm
Incorporated, either by f illing out the attached f orm or,
f or credit card holders, calling the toll-f ree phone number
on the f orm. For manuals prior to the year shown below,
contact Helm Incorporated, P.O. Box 07280, Detroit,
Michigan 48207, or call 1-800-782-4356.
Valid only f or sales within the U.S. Canadian owners shouldcontact their authorized Honda dealer.
Authorized Manuals
Purchasing Factory Authorized Manuals
(U.S. only)
267
ORDER TOLL FREE: 1-800-782-4356
OR
(NOTE: For Credit Card Holder Orders Only)
MINIMUM CREDIT CARD PURCHASE $10.00
Publication
Form Number 61S2A01
61S2A01EL 61S2A30
31S2A610
HON-R From Description
2000-2002 Honda S2000 Service Manual
2000-2002 Honda S2000
Electrical Troubleshooting Manual 2000-2002 Honda S2000Body Repair Manual2002 Honda S2000 Owner’s Manual
Order Form for Previous Years-
Indicate Year and Model Desired Price
Each
$68.00 $48.00$42.00$32.00
FREE PUBLICATION NUMBER
VEHICLE MODEL
Name Year Qty
Price
Each Total
Price
GRAND TOTAL
HANDLING CHARGE
Mich. Purchases
Add 6% Sales Tax
TOTAL MATERIAL
$6.00
Prices are subject to change without notice and without incurring
obligation. Monday-Friday 8:00 A.M. 6:00 P.M. EST
By completing this form you can order the materials desired. You can
pay by check or money order, or charge to your credit card. Mail to
Helm Incorporated at the address shown on the back of the order form.
Prices are subject to change without
notice and without incurring obligation.
Orders are mailed within 10 days. Please
allow adequate time for delivery.

µµ
µ
( % ) $
%."#)
This manual describes the procedures involved in the
replacement of damaged body parts.
This manual covers maintenance and recommended
procedures f or repair to engine and chassis components.
It is written f or the Journeyman mechanic, but is simple
enough f or most mechanically-inclined owners to under-
stand.
This manual complements the Service Manual by
providing in-depth troubleshooting inf ormation f or each
electrical circuit in your car.
Authorized Manuals
Service Manual:
Electrical T roubleshooting Manual:
Body Repair Manual:
268 NOTE: Dealers and Companies please provide dealer or company name,
and also the name of the person to whose attention the shipment should
be sent. For purchases outside U.S.A. please write to the address shown
below for a quotation.
P.O. BOX 07280·DETROIT, MICHIGAN 48207·1-800-782-4356
Customer Name
Attention
Apartment Number
State & Zip Code
City
Daytime Telephone Number
Check or money order enclosed payable to Helm Inc U.S. funds only.
Do not send cash
Master
Card VISA Check here if your billing address is different
from the shipping address shown above.
Account Number Expiration: Mo. Yr.
CUSTOMER SIGNATURE DATE
Street Address No P.O. Box Number
()
These Publications cannot be returned for credit without receiving advance authorization within 14
days of delivery. On returns, a restocking fee may be applied against the original order.

Recovery Vehicle, Emergency.......................................
Towing . 247
.............................
Reminder Lights . 43
.......................
Remote Transmitter . 61
Replacement Inf ormation
................................
Air Cleaner . 178
..........................
Engine Coolant . 169
................
Engine Oil and Filter . 165
..........................................
Fuses . 241
................................
Light Bulbs . 200
....................................
Schedule . 152
................................
Spark Plugs . 180
...........................................
Tires . 195
.............................
Wiper Blades . 186
Replacing Seat Belts Af ter a
............................................
Crash . 34
...............................
Restraint, Child . 19
................................
Rotation, Tire . 194
........................................
Saf ety Belts . 8
............
Safety Defects, Reporting . 268
.............
Saf ety Labels, Location of . 40
...............................
Saf ety Messages . ii ...........................................
Seat Belts . 8
...............
Additional Information . 33
.....
Advice f or Pregnant Women . 17
.....................................
Cleaning . 214
......................
Lap/Shoulder Belt . 33
................................
Maintenance . 34
......
Reminder Light and Beeper . 44
...................
System Components . 33
...............
Use During Pregnancy . 17
........................
Seats, Adjusting the . 67
...............................
Serial Number . 250
...........................
Service Intervals . 152
.............................
Service Manual . 269
.........
Service Station Procedures . 123
Shif ting
The 6-speed Manual .........................
Transmission . 139
Side Marker Lights, Bulb .........................
Replacement in . 202
...............................
Signaling Turns . 53
6-speed Manual Transmission
...............
Checking Fluid Level . 174
................................
Shif ting the . 139
.....................................
Snow Tires . 197
...................
Solvent-type Cleaners . 210
..................................
Sound System . 92 Spare Tire
......................................
Inf lating . 220
............................
Specif ications . 253
................
Spark Plugs, Replacing . 180
....................
Specif ications Charts . 252
..................................
Speed Control . 55
...................................
Speedometer . 47
..........
SRS, Additional Inf ormation . 35
...
Additional Safety Precautions . 38
How the Automatic Seat Belt
....................
Tensioners Work . 37
How the SRS Indicator .......................................
Works . 37
...........
How Your Airbags Work . 35
........................
SRS Components . 35
..................................
SRS Service . 38
..................
SRS Indicator Light . 37, 45
.......................
Starting the Engine . 137
In Cold Weather at High ..................................
Altitude . 138
................
With a Dead Battery . 228
..............
State Emissions Testing . 261
........
Steam Coming f rom Engine . 231
Steering Wheel
.............
Anti-theft Column Lock . 58
.....................
Stereo Sound System . 92
Index
S
VI