2002 HONDA S2000 fuel cap

Removethefuelfillcapslowly.
You may hear a hissing sound as
pressure inside the tank escapes.
Place the cap in the holder on the
fuel fill door.
Because the f uel f ill cap is on the
driver’s side of the car, park with
that side closest to the service
station pumps.
Open the f uel f ill door by pulling
on the knob on the driver’s door
jamb.
1. 2.
3.
CONT INUED
Filling the Fuel Tank
Service Station Procedures
Bef ore Driving
123
PPuullll
FFUUEELLFFIILLLLCCAAPP
Gasoline is highly flammable
and explosive. You can be
burned or seriously injured
when handling fuel.
Stop the engine and keep
heat, sparks, and flame away.
Handle fuel only outdoors.
Wipe up spills immediately.

Check the level in the windshield
washer reservoir at least monthly
during normal usage. In bad weather,
when you use the washers of ten,
check the level every time you stop
for fuel.Fill the reservoir with a good-quality
windshield washer f luid. This
increases the cleaning capability and
prevents f reezing in cold weather.
The windshield washer reservoir is
located in the rear of the engine
compartment on the passenger’s side. Check the reservoir’s f luid level by
removing the cap and looking at the
level gauge attached to the cap.
When you ref ill the reservoir, clean
the edges of the windshield wiper
blades with windshield washer fluid
on a clean cloth. This will help to
condition the blade edges.
Windshield Washers
Maint enance173
RREESSEERRVVOOIIRRCCAAPP
Do not use engine antif reeze or a
vinegar/water solution in the
windshield washer reservoir.
Antif reeze can damage your car’s paint,
while a vinegar/water solution can
damage the windshield washer pump.
Use only commercially-available
windshield washer f luid.

This indicator comes on f or a f ew
seconds when you turn the ignition
switch ON (II). If it comes on at any
other time, it indicates one of the
engine’s emissions control systems
may have a problem. Even though
you may f eel no dif f erence in your
car’s perf ormance, it can reduce
your f uel economy and cause your
car to put out excessive emissions.
Continued operation may cause
serious damage.If you have recently ref ueled your
car, the cause of this indicator
coming on could be a loose or
missing f uel f ill cap. Check the cap
and tighten it until it clicks several
times. Replace the fuel fill cap if it is
missing. Tightening the cap will not
make the indicator turn of f
immediately; it takes three driving
trips.
If the indicator remains on past three
driving trips, or the f uel cap was not
loose or missing, have the car
checked by the dealer as soon as
possible. Drive moderately until the
dealer has inspected the problem.
Avoid full-throttle acceleration and
driving at high speed.
Youshouldalsohavethedealer
inspect your car if this indicator
comes on repeatedly, even though it
may turn of f as you continue driving.
Malf unction Indicator L amp
T aking Care of t he Unexpect ed
236
MMAALLFFUUNNCCTTIIOONNIINNDDIICCAATTOORRLLAAMMPP
If you keep driving with the
malf unction indicator lamp on, you can
damage your car’s emissions controls
and engine. Those repairs may not be
covered by your car’s warranties.

Thediagramsinthissectiongive
you the dimensions and capacities of
your Honda, and the locations of the
identif ication numbers. It also
includes inf ormation you should
know about your vehicle’s tires and
emissions control systems.................
Identif ication Numbers . 250
................................
Specif ications . 252
DOT Tire Quality Grading
......................
(U.S. Vehicles) . 254
.................................
Treadwear . 254
......................................
Traction . 254
.............................
Temperature . 255 .........................
Oxygenated Fuels . 256
......
Driving in Foreign Countries . 257
.......................
Emissions Controls . 258
.....................
The Clean Air Act . 258
Crankcase Emissions Control
....................................
System . 258
Evaporative Emissions Control ....................................
System . 258
...
Exhaust Emissions Controls . 259
....................
PGM-FI System . 259
Ignition Timing Control
................................
System . 259
Secondary Air Injection ................................
System . 259
Three Way Catalytic
...........................
Converter . 259
....................
Replacement Parts . 259
..
Three Way Catalytic Converter . 260
................
State Emission Testing . 261
T echnical Inf ormat ion
T echnical Inf ormation 249

Î ÎÎ Î
T echnical Inf ormation
Specif ications
252 Engine
Dimensions
Weights
Capacities
162.0 in (4,115 mm)
68.9 in (1,750 mm)
50.6 in (1,285 mm)
94.5 in (2,400 mm)
57.9 in (1,470 mm)
59.4 in (1,510 mm) 13.2 US gal (50
, 11.0 Imp gal)
Water cooled 4-stroke DOHC
VTEC 4-cylinder gasoline engine
Type
BorexStroke
Displacement
Compression ratio
Spark plugs 121.8 cu-in (1,997 cm
)
11.0 : 1 1.72 US gal (6.5
, 1.43 Imp gal)
2.01 US gal (7.6, 1.67 Imp gal)
Length
Width
Height
Wheelbase
Track
Gross vehicle weight rating See the certification label attached
to the driver’s doorjamb. Fuel tank
Engine coolant
Engine oil Manual
transmission
fluid
Differential
oil
Windshield
washer
reservoir5.1 US qt (4.8
, 4.2 Imp qt)
4.8 US qt (4.5, 4.0 Imp qt)
5.9 US qt (5.6, 4.9 Imp qt)
1.6 US qt (1.5, 1.3 Imp qt)
1.7 US qt (1.6, 1.4 Imp qt)
0.78 US qt (0.74
,0.65Impqt)
0.81 US qt (0.77,0.68Impqt)
2.7 US qt (2.6, 2.3 Imp qt)
4.4 US qt (4.2, 3.7 Imp qt)
Including the coolant in the reserve tank and that remaining in the
engine.
Reserve tank capacity:
0.16 US gal (0.6
, 0.13 Imp gal)
Excluding the oil remaining in the engine.
3.43 x 3.31 in (87.0 x 84.0 mm)
See the spark plug maintenance
section, page 181 .
FrontRear
1: 2:Change Total
Change Total
ChangeTotal
Change Total
U.S. Cars
Canadian Cars
1 2
Including filter
Without filter

CONT INUED
...
Closing the Convertible Top . 239
.....
Low Oil Pressure Indicator . 234
...
Malf unction Indicator Lamp . 236
..................
Overheated Engine . 231
...........................
Emergency Brake . 79
......................
Emergency Flashers . 78
............
Emergency Trunk Opener . 65
.......................
Emissions Controls . 258
.............
Emissions Testing, State . 261 Engine
...........
Check Engine Light . 45, 236
Compartment, Checking
......................................
in the . 124
.......................................
Coolant . 126
....
Coolant Temperature Gauge . 47
...................................
Drive Belt . 190
Malf unction Indicator
................................
Lamp . 45, 236
........
Oil Pressure Indicator . 44, 234
..............
Oil, What Kind to Use . 163
...............................
Overheating . 231
............................
Specif ications . 252
............................
Speed Limiter . 140
.......................................
Starting . 137
.........
Engine Cover, Opening the . 124
......................
Ethanol in Gasoline . 256 ...
Evaporative Emission Controls . 258
...............................
Exhaust Fumes . 39
Expectant Mothers, Use of Seat
........................................
Belts by . 17
..................
Exterior, Cleaning the . 210
..........................................
Gasohol . 256
.........................................
Gasoline . 122
...............
Fuel Reserve Indicator . 46
...........................................
Gauge . 48
................
Octane Requirement . 122
.....................
Oxygenated Fuels . 256
........................
Tank, Filling the . 123
............................
Fabric, Cleaning . 214
.....................................
Fan, Interior . 84
Features, Comfort and
................................
Convenience . 83
....................
Filling the Fuel Tank . 123
Filters
...............................................
Oil . 165
.............
Flashers, Hazard Warning . 78
...................
Flat Tire, Changing a . 221
Fluids
..........................................
Brake . 176
.........................................
Clutch . 177
..............
Manual Transmission . 174
..................
Windshield Washer . 173
........
FM Stereo Radio Reception . 101
.....
Foreign Countries, Driving in . 257
..........................
Four-way Flashers . 78 .................................................
Fuel . 122
......................
Fill Door and Cap . 123
...........................................
Gauge . 48
................
Octane Requirement . 122
...............................
Oxygenated . 256
........................
Reserve Indicator . 46
........................
Tank, Filling the . 123
..............
Fuel Mileage, Improving . 127
..............
Fuel Station Procedures . 123
.....................
Fuses, Checking the . 241
Index
F
G
III

Service Inf ormat ion Summary
Gasoline:Tire Pressure (measured cold):
Brake Fluid:
6-speed Manual Transmission Fluid:
SpareTirePressure:
Recommended Engine Oil:
Fuel Tank Capacity: Honda Manual Transmission
Fluid preferred, or an API service
SG, SH or SJ, SAE 10W-30 or
10W-40 motor oil as a temporary
replacement (see page ).
Capacity:
1.6 US qt (1.5
, 1.3 Imp qt)
Honda Heavy Duty Brake Fluid
DOT 3 preferred, or a DOT 3 or
DOT 4 brake fluid as a temporary
replacement (see page ). Front:
Front:
Rear:
60 psi (420 kPa , 4.2 kgf/cm)
32 psi (220 kPa , 2.2 kgf/cm
)
32 psi (220 kPa , 2.2 kgf/cm
)
Premium unleaded gasoline,
pump octane number of 91 or
higher.
API premium grade 10W-30
detergent oil (see page ).
Oil change capacity (including
filter):
5.1 US qt (4.8
, 4.2 Imp qt) 164 174 176
13.2 US gal (50
, 11.0 Imp gal)