Page 2910 of 5127
Fig. 349: Using A Dial Indicator Measure The Direct Clutch Piston Stroke While Applying
Compressed Air
Courtesy of GENERAL MOTORS CORP.
11. Install the direct clutch on the oil pump.
12. Using a dial indicator, measure the direct clutch piston stroke while applying and releasing 392 kPa (57
psi) of compressed air.
Specifications: The piston stroke is 0.4-0.8 mm (0.016-0.031 in).
If the piston stroke is less than the limit of piston stroke, parts may have been assembled
incorrectly, so check and reassemble again.
NOTE: Refer to Compressed Air Should Not Exceed 98 kPa (14 psi) Notice .
2006 Chevrolet Aveo
2006 TRANSMISSION Automatic Transaxle - Aisin (81-40LE) - Introduction (2 Of 2) - Aveo
Microsoft
Thursday, July 16, 2009 1:17:29 PMPage 361 © 2005 Mitchell Repair Information Company, LLC.
Page 4294 of 5127

2005 ACCESSORIES & EQUIPMENT
Instrument Panel, Gages, & Console - Aveo
SPECIFICATIONS
FASTENER TIGHTENING SPECIFICATIONS
Fastener Tightening Specifications
BULB USAGE SPECIFICATIONS
Bulb Usage Specifications
Application
Specification
MetricEnglish
Chime Module Screws3.5 N.m31 lb in
Clock Screws2.5 N.m22 lb in
Cupholder Screws2.5 N.m22 lb in
Floor Console Screws4 N.m35 lb in
HVAC Controls Screws4 N.m35 lb in
Instrument Cluster Screws4 N.m35 lb in
Instrument Cluster Trim Panel Screws4 N.m35 lb in
Instrument Panel Bolts Behind the HVAC Controls4 N.m35 lb in
Instrument Panel End Bolts4 N.m35 lb in
Instrument Panel Bolts20 N.m15 lb ft
Indicator LampColorBulb
ABS WiringAmber14 V 1.4 W
Air Bag WarningRed14 V 1.4 W
Battery Charge IndicatorRed14 V 1.4 W
Check EngineAmber14 V 1.4 W
Door Open WarningRed14 V 1.4 W
Engine OverheatRed14 V 1.4 W
Fasten Seat Belt WarningRed14 V 1.4 W
High Beam IndicatorBlue14 V 1.4 W
Low Fuel Level WarningAmber14 V 1.4 W
Oil Pressure WarningRed14 V 1.4 W
Parking Brake Indicator and Brake
Fluid WarningRed14 V 1.4 W
Service Engine Soon WarningAmber14 V 1.4 W
Transaxle Power Mode IndicatorAmber14 V 1.4 W
Turn Signal IndictorsGreen14 V 1.4 W
2005 Chevrolet Aveo
2005 ACCESSORIES & EQUIPMENT Instrument Panel, Gages, & Console - Aveo
2005 Chevrolet Aveo
2005 ACCESSORIES & EQUIPMENT Instrument Panel, Gages, & Console - Aveo
Microsoft
Friday, July 31, 2009 1:07:02 PMPage 1 © 2005 Mitchell Repair Information Company, LLC.
Microsoft
Friday, July 31, 2009 1:07:07 PMPage 1 © 2005 Mitchell Repair Information Company, LLC.
Page 4306 of 5127

DIAGNOSTIC INFORMATION AND PROCEDURES
DIAGNOSTIC STARTING POINT - INSTRUMENT PANEL, GAGES AND CONSOLE
Begin the system diagnosis by reviewing the Symptoms
- Instrument Panel, Gages and Console . Reviewing
the symptom information will help you determine the correct symptom diagnostic procedure when a
malfunction exists.
DIAGNOSTIC SYSTEM CHECK - INSTRUMENT CLUSTER
Test Description
The numbers below refer to the step numbers on the diagnostic table.
1: Lack of communication may be due to a malfunction of the serial data circuits. The specified
procedure will determine the particular condition.
3: The presence of DTCs may be related to an engine electrical condition. The specified procedure will
compile all the available information before tests are performed.
Diagnostic System Check - Instrument Cluster
DIAGNOSTIC TROUBLE CODE (DTC) LIST
Diagnostic Trouble Code (DTC) List
Connector Part Information
AK 32104
1-Way F Metri-Pack 150 Series Sealed (BK)
PinWire ColorCircuit No.Function
1D-GN/WH31Oil Pressure Indicator Control
StepActionYesNo
1
Install a scan tool.
Does the scan tool power up?
Go to Step 2
Go to Scan Tool
Does Not Power Up
in Data Link
Communications
2
1. Turn ON the ignition, with the engine OFF.
2. Attempt to establish communication with the
engine control module (ECM).
Does the scan tool communicate with the ECM?
Go to Step 3
Go to Scan Tool
Does Not
Communicate with
Componentin Data
Link
Communications
3
Select the Display DTCs function for the ECM.
Does the scan tool display DTC P0461, P0462, P0463
or P0464?Go to Diagnostic
Trouble Code
(DTC) List
Go to Symptoms -
Instrument Panel,
Gages and Console
DTCDiagnostic ProcedureModules
2005 Chevrolet Aveo
2005 ACCESSORIES & EQUIPMENT Instrument Panel, Gages, & Console - Aveo
Microsoft
Friday, July 31, 2009 1:07:02 PMPage 13 © 2005 Mitchell Repair Information Company, LLC.