2002 BMW MOTORRAD R 1150 RT oil

i
2
Introduction
General information and con-
trols
General view, left side ........... 4
General view, right side ......... 5
Cockpit ................................. 6
Telltale and warning lights ..... 7
Ignition switch and steering
lock .................................... 8-9
Left handlebar fitting ........... 10
Right handlebar fitting ......... 11
Seats ............................. 12-13
System case .................. 14-15
Adjusting the windshield ..... 16
Hazard warning flashers ...... 17Safety check
Checklist ........................ 18-19
Engine oil ....................... 20-21
Fuel ................................ 22-23
Handlebar levers ............ 24-25
Brake system
- general ........................ 26-27
- with BMW Integral
ABS ............................ 28-31
Clutch ................................. 32
Lights ............................. 33-35
Shock absorbers ................ 36
Suspension spring
preload ............................... 37
Wheels ........................... 38-39
Loads............................. 40-41
Contents
10r22bkg3.book Seite 2 Freitag, 27. Januar 2006 12:43 12

4
General information and controls
1
General view, left side
1Storage compartment
2 Reservoir for clutch fluid
3 Engine oil filler (
b 21)
4 Power socket, 12 V
Provision for connecting
additional equipment –
max. load 5 A
5 Lifting handle (
b 48-49)
6 Dual seat lock (
b 12) 7
Suspension strut,
shock absorber adjustment
(
b 36)
8 Primary spark plug, left
9 Secondary spark plug,
only R 1150 RT
10 Oil level sight glass, engine
(
b 21)
( ) Figure in bracketsbpage number for
description
543216
78910
10r22bkg3.book Seite 4 Freitag, 27. Januar 2006 12:43 12

7
General information and controls
1
321
10
8
9
5*467
Telltale and warning lights
1Left turn indicator repeater
green
s
2 Warning light battery charge
red
r (b 56)
3 Warning light Tank capac-
ity/when app. 4 litres
remain in tank orange
m
(b 23, 56)
4 Neutral indicator (gearbox)
green
k (b 53)
5 Warning light ABS red
l
(
b 56, 68)
( ) Figure in bracketsbpage number for
description
6 Warning light, general
red
e\b(b 56, 68)
7 Warning light engine oil
pressure red
p\b(b 56)
8 Telltale light Right turn indi-
cator repeater green
t
9 Telltale light fog lamp green
t
10 High-beam headlight telltale
blue
q
*n depending on national-market
specification
10r22bkg3.book Seite 7 Freitag, 27. Januar 2006 12:43 12

2
19
Safety check
For this reason, check the
details in the following sections
before you start the journey:
–Fuel level
– Positions of the handlebar-
lever fittings
– Brake fluid level
– Clutch fluid level
– Brakes
– Warning lights and telltale
lights
– Lights
– shock absorber settings
and spring preload
– condition of wheels and tyres,
tread depth and tyre pres-
sures
– Load, gross weight –
Check at regular intervals as
described in the following
sections
(each time you stop for refuel-
ling):
– Engine oil level
(every second or third time
you stop for refuelling):
– Brake pads
If you encounter any problems
or difficulties, it is always best to
contact your authorised BMW
Motorrad dealer.
He will provide the necessary
advice and assistance.
Checklist
10r22bkg3.book Seite 19 Freitag, 27. Januar 2006 12:43 12

2
20
Safety check
Engine oil
Checking oil levelCheck oil level regularly each
time you stop to refuel.
Only check the engine oil when
the engine is at normal operat-
ing temperature as the oil level
can vary by up to 10 mm
(0.39 in) in a hot engine or a
cold engine at extreme outside
temperatures (-10°C).
Wait at least five minutes after
switching off the hot engine for
the oil to collect in the sump. Checking the oil level after the
engine has only been used for a
short time or is only just warm
could lead to wrong interpretati-
ons and thereby to an incorrect
oil fill because the cold, more
viscous oil takes longer to flow
back into the sump. This can
take up to 12 hours at extreme
temperatures (-10
°C).
e Attention:
To avoid damage to the engine:
– Never exceed the maximum
oil level.
Always keep the oil level above
the minimum mark.
Always check the oil level with
the motorcycle standing up-
right.
 Check the oil when the engine
is at normal operating tem-
perature
 Read the oil level at least five
minutes after switching off the
engine
 Make sure that the motorcy-
cle is upright
– ensure that the surface is
level and firm!
10r22bkg3.book Seite 20 Freitag, 27. Januar 2006 12:43 12

2
21
Safety check
1
MAXMIN
2
Engine oil

Check oil level at sight glass:
MAX Upper edge
Ring marking
MIN Lower edge
Ring marking
– The difference between the
two marks is approx. 0.5 litres
(0.88 Imp. pints)
 If necessary, unscrew the oil
filler screw 2 and top up the
engine oil through the engine
oil filler 1
 Then retighten the oil filler
screw 2
e Attention:
Warning light, engine oil pres-
sure red
p\b(b 7)\bindicates no
(or very little) oil pressure in
the lube-oil system; this light
m u s t n o t b e r e g a r d e d a s a n o i l
level check. Oil pressure
builds up after 1-2 seconds
and the warning light goes out
– the redengine oil pressure
warning light
p should re-
main off while the engine is
running
BMW recommends Castrol
10r22bkg3.book Seite 21 Freitag, 27. Januar 2006 12:43 12

3
57
Starting – Riding – Parking
5
Engine oil pressureWarning light 5 goes out above
idle speed.
e Attention:
If warning light 5 comes on dur-
ing the journey, take the follow-
ing action as soon as traffic
conditions permit:
 Declutch
 Operate the kill switch
 Bring the motorcycle safely to
a halt
check engine oil level (b 21)
e Attention:
If the warning light comes on
even though the oil level is cor-
rect, you must consult a spe-
cialist workshop, preferably an
authorised
BMW motorcycle dealer.
Telltale and warning lights
10r22bkg3.book Seite 57 Freitag, 27. Januar 2006 12:43 12

3
58
Starting – Riding – Parking
The Rider Information Display
only operates when the ignition
is switched on.
Engine oil temperature
display 1
A= engine oil is overheating (red )
e Attention:
Stop the engine, wait 10 min-
utes and then check the oil level
(
b 20). If the oil level is correct,
always consult a specialist
workshop without delay, prefer-
ably a BMW Motorrad dealer.
Avoid high engine speeds until
the problem has been dealt
with.
B = engine oil at regular
operating temperature
C = engine oil cold ( blue)
Rider Information Display (RID)
1
A
B
C
10r22bkg3.book Seite 58 Freitag, 27. Januar 2006 12:43 12