2002 BMW MOTORRAD R 1150 GS Adventure warning light

2
31
Safety check
1
MAXMIN2
 Check the oil level at the sight glass:
MAX Top edge
of marking ring
MIN Bottom edge
of marking ring
– The difference between the
two marks is approx. 0.5 litre
(0.88 pint)
 If necessary, remove oil filler plug 2 and top up the engine
oil through engine oil filler 1.
 Reinstall oil filler plug 2e Attention:
Warning light, engine oil pres-
sure red
p (b 9) indicates no
(or very little) oil pressure in
the lube-oil system; this light
m u s t n o t b e r e g a r d e d a s a n o i l
level check. Oil pressure
builds up after 1-2 seconds
and the warning light goes out
– the redengine oil pressure
warning light
p should remain
off while the engine is running.
Engine oil
BMW recommends Castrol
10geBKg6.book Seite 31 Dienstag, 19. November 2002 1:11 13

2
33
Safety check1
2
Refuel
– Always use super (premium) unleaded fuel to DIN 51607 or
equivalent standard,
minimum octane number
95 (RON) or 85 (MON)
 Close the fuel filler cap
Capacity
L Note:
The fuel gauge and RID do not
operate unless the ignition is
switched on.
OEOptional extra
– Usable tank capacitiy 22 litres (5.5 gal)
– Usable tank capacitiy 30 litres (5.5 gal)
OE (GS Adventure only)
– When the reserve fuel level (approx. 4 litres/0.9 gal) is
reached, this is indicated by
orange warning light 1
Fuel level indicator 2 in
RIDOE (b 75)
L Note:
If only two bars are visible,
approx. 4 litres (0.9 Imp. gal) of
fuel remain in the tank (also indi-
cated by orange warning light 1).
Fuel
10geBKg6.book Seite 33 Dienstag, 19. November 2002 1:11 13

2
46
Safety check
Lights
Checking lights
e Attention:
Check that all lights are opera-
tional at the start of each
journey.
L Note:
If turn indicator telltale light
flashes at twice the usual
speed: defective flasher bulb.
BMW Integral ABS
OE:
General warning light ON (
b 9):
Check brake light or tail light.
If the tail light is defective the
brake light is dimmed and acts
as a tail light. When you apply
the brakes the brake light
shines at full brightness.
OEOptional extra
L Note:
To change bulbs in parking
lights, headlight (dipped and
main beams), rear, brake and
indicator lights:
(
b Maintenance Instructions,
Chapter 2)
Headlight setting, RHD/
LHD traffic
For trips in countries where the
traffic drives on the opposite
side of the road:
Adjust the headlight accord-
ingly (Maintenance Instructions
bChapter 2).
When necessary, you can
resort to the assistance of a
specialist workshop,
preferably your authorised
BMW motorcycle dealer.
10geBKg6.book Seite 46 Dienstag, 19. November 2002 1:11 13

3
67
Starting – Riding – Parking
Running in
Running in new brake
pads
d Warning:
New brake pads must “bed
down” and therefore do not
achieve their optimum friction
levels during the first 500 km
(300 miles).
This slight initial reduction in
braking efficiency can be
compensated for by exerting
greater pressure on the lever.
Try to avoid all unnecessary
hard braking during this initial
period.
e Attention:
Comply with the notes on
BMW Integral ABS
OE
(b 80- 89).
OEOptional extra
Running in new tyres
d Warning:
New tyres have a smooth sur-
face. This must be roughened
by riding in a restrained man-
ner at various heel angles
until the tyres are run in.
This running in procedure is
essential if the tyres are to
achieve maximum grip.
10geBKg6.book Seite 67 Dienstag, 19. November 2002 1:11 13

3
72
Starting – Riding – Parking
12*
43
Battery charge currentWarning light1 goes out above
idle speed.
e Attention:
If warning light 1 comes on dur-
ing the journey:
consult a specialist workshop,
preferably an authorised BMW
motorcycle dealer.
OEOptional extra
ABS warning lightOE
The ABS warning light 2 lights
up if the BMW Integral ABS
develops a fault (
b 84)
Warning light, general General warning light 3 lights
up if a fault develops in the
BMW Integral ABS
OE (b 84), or
if the tail light or brake light is
defective.
Low fuel levelWhen warning light 4 comes
on, there are still approx.
4 litres (0.9 gal) of fuel in the
tank.
*n depending on national-market
specification
Warning lights
10geBKg6.book Seite 72 Dienstag, 19. November 2002 1:11 13

3
73
Starting – Riding – Parking
5
Engine oil pressureWarning light5 goes out above
idle speed.
e Attention:
If warning light 5 comes on dur-
ing the journey, take the follow-
ing action as soon as traffic
conditions permit:
Declutch
 Operate the kill switch
 Bring the motorcycle safely to a halt
 Check engine oil level
(b 31)
e Attention:
If the warning light comes on
even though the oil level is cor-
rect, you must consult a spe-
cialist workshop, preferably an
authorised
BMW motorcycle dealer.
Warning lights
10geBKg6.book Seite 73 Dienstag, 19. November 2002 1:11 13

3
75
Starting – Riding – Parking
2
3
4
65
Rider Information Display
OE (RID)
Fuel gauge 2
L Note:
If only two bars are displayed,
about 4 litres (0.9 Imp. gal) of
fuel remain in the tank (the or-
ange warning light also comes
on (
b 72)).
Gear indicator 31 - 0 - 2 - 3 - 4 - 5 - 6
Clock 4 To adjust, press with a ball- point pen or similar object at
point 5 (minutes) or point 6
(hours)
OEOptional extra
10geBKg6.book Seite 75 Dienstag, 19. November 2002 1:11 13

3
84
Starting – Riding – Parking
21*
Self-diagnosis with pull-
away test
The BMW Integral ABS per-
forms self-diagnosis and a pull-
away test to ensure its
operability.
Self-diagnosis is performed
automatically when you switch
on the ignition.
d Warning:
Self-diagnosis is not per-
formed unless both brake le-
vers are in their fully released
positions.
Only the RESIDUAL BRAKING
FUNCTION is available until
self-diagnosis is completed
(b 83) .  Release the brake levers, if
necessary
 Switch on the ignition
Initially:
– ABS warning light 1:
flashes at 4 Hz
– General warning light 2:
ON
bSelf-diagnosis is in
progress
Then:
– ABS warning light 1:
flashes at 1 Hz
– General warning light 2:
OFF
bSelf-diagnosis successfully
completed
OEOptional extra
*
n depending on national-market
specification
Brake system - with BMW Integral ABSOE
10geBKg6.book Seite 84 Dienstag, 19. November 2002 1:11 13