2002 BMW MOTORRAD R 1150 GS Adventure fuel

i
2
Introduction
12
General information and
controls
General view, left side
R 1150 GS ............................ 4
General view, right side
R 1150 GS ............................ 5
General view, left side
R 1150 GS Adventure ........... 6
General view, right side
R 1150 GS Adventure ........... 7
Cockpit ................................. 8
Telltale and warning lights ..... 9
Ignition switch and steering
lock ................................ 10-11
Hazard warning lights .......... 12
Power socket ...................... 13
Left handlebar fitting ........... 14
Right handlebar fitting ......... 15
Dualseat R 1150 GS ..... 16-18
Seat
R 1150 GS Adventure .... 19-20
System case .................. 21-23
Aluminium case .............. 24-26
Adjusting the windscreen .... 27Safety check
Checklist ........................ 28-29
Engine oil ....................... 30-31
Fuel ................................ 32-33
Handlebar levers ............ 34-35
Brake system - general .. 36-37
Brake system - without
BMW Integral ABS ......... 38-40
Brake system - with
BMW Integral ABS ......... 41-44
Clutch ................................. 45
Lights ............................. 46-49
Suspension spring
preload .......................... 50-51
Shock absorber .................. 52
Wheels ........................... 53-55
Accessories and tyres......... 56
Accessories and loads ... 56-57
Contents
10geBKg6.book Seite 2 Dienstag, 19. November 2002 1:11 13

111
5
General information and controls
1312
192016
1514
1817
12Stowage compartment for
toolkit (supplied)
13 Fuse box
14 Brake fluid reservoir, front
brake (
b39)
15 Fuel cap (
b32)
( ) Figure in bracketsbpage number for
description
16 Type plate/vehicle identifi-
cation number
17 Primary spark plug, right
18 Secondary spark plug, right
19 Brake fluid reservoir for rear
brake (
b40)
20 Helmet holder
General view, right side
10ge01g6.fm Seite 5 Montag, 7. Juni 2004 10:12 10

11
6
General information and controls
1235764
8910
R 1150 GS Adventure1 Headlight guardOA
not allowed on
public roads
2 Fog lamp with guard
OA
3Power socket
4 Hand protectors
OAOptional accessories
5Fuel tankOE capacity 30 l
(6.6 gal)
6 Case carrier
OA
7Mounting plate for
topcaseOA
8Primary spark plug, left
9 Secondary spark plug, left
10 Crash bar
OE
OEOptional extra
General view, left side
10ge01g6.fm Seite 6 Montag, 7. Juni 2004 10:13 10

111
9
General information and controls
1Telltale light, left turn
indicator repeater green
s
2 Warning light, battery
charge current red
r
3 Warning light, fuel tank
content approx. 4 litres
(0.9 gal) orange
m (b33)
4 Telltale light, neutral green
k (b69)
5 Warning light,
ABS
l red OE
OEOptional extra
6Warning light, engine oil
pressure red
p
7Telltale light, right turn
indicator repeater green
t
8 Warning light, general
red
e (b 84-89)
9 Telltale light, high (main)
beam blue
q
( ) Figures in brackets bpage number
for description
*
n depending on national-market
specification
Telltale and warning lights
124637
9
5*
8
10geBKg6.book Seite 9 Dienstag, 19. November 2002 1:11 13

2
29
Safety check
Checklist
For this reason, check the
details in the following sections
before you start the journey:
– Fuel level
– Positions of the handlebar-lever fittings
–Brakes
– Brake fluid level
– Clutch fluid level
– Warning lights and telltale lights
–Lights
– Shock absorber settings and spring preload
– Wheel rim and tyre condition,
tread depth and tyre
pressures
– Load, gross weight – Check regularly (every time
you stop for fuel),
on the basis of the following
section:
– Engine oil level
(every second/third stop for
fuel):
– brake pads
If you encounter any problems
or difficulties, it is always best to
contact your authorised BMW
motorcycle dealer. He will pro-
vide the necessary advice and
assistance.
10geBKg6.book Seite 29 Dienstag, 19. November 2002 1:11 13

2
32
Safety check
Fuel
Refuelling
d Warning:
Fuel is flammable and explo-
sive. Do not smoke. Never
bring a naked flame near the
fuel tank.
The fuel expands when hot
(for instance if the fuel tank is
in the sun). For this reason,
only fill as far as the lower
edge of the filler neck.
e Attention:
Leaded fuel will destroy the cat-
alytic converter.
Do not run the fuel tank dry or
you may damage the engine or
the catalytic converter.
Wipe off plastic parts immedi-
ately if they are wetted with fuel.
 Place motorcycle on centre stand
– Make sure the ground is level and firm.
 Open fuel filler cap
10geBKg6.book Seite 32 Dienstag, 19. November 2002 1:11 13

2
33
Safety check1
2
Refuel
– Always use super (premium) unleaded fuel to DIN 51607 or
equivalent standard,
minimum octane number
95 (RON) or 85 (MON)
 Close the fuel filler cap
Capacity
L Note:
The fuel gauge and RID do not
operate unless the ignition is
switched on.
OEOptional extra
– Usable tank capacitiy 22 litres (5.5 gal)
– Usable tank capacitiy 30 litres (5.5 gal)
OE (GS Adventure only)
– When the reserve fuel level (approx. 4 litres/0.9 gal) is
reached, this is indicated by
orange warning light 1
Fuel level indicator 2 in
RIDOE (b 75)
L Note:
If only two bars are visible,
approx. 4 litres (0.9 Imp. gal) of
fuel remain in the tank (also indi-
cated by orange warning light 1).
Fuel
10geBKg6.book Seite 33 Dienstag, 19. November 2002 1:11 13

3
61
Starting – Riding – Parking
Important notes
Catalytic converter
e Attention:
To avoid damage to the cata-
lytic converter:
 Do not run the fuel tank dry
 Push-start only when the
engine is cold
 Do not run the engine with a
spark plug lead disconnected
 Do not exceed the engine- speed limits marked on the
revolution counter
 Comply with all specified
maintenance intervals
 Stop the engine at once if it
misfires
 In the event of misfiring or a severe drop in engine power,
consult a specialist work-
shop, preferably an author-
ised BMW motorcycle dealer
If misfiring or malfunction of the
fuel-air mixture preparation sys-
tem causes unburned fuel to
reach the catalytic converter,
there is a risk of it overheating
and being damaged.
Risk of fireHigh temperatures occur at the
exhaust system, particularly if a
catalytic converter is installed.
d Warning:
Make sure that whether riding
or standing still or when the
motorcycle is parked, no eas-
ily flammable material
(for example hay, grass,
leaves, clothing or luggage
etc.) can come into contact
with the hot exhaust system.
Do not allow the engine to
idle unnecessarily or for pro-
longed periods
– Risk of overheating or fire.
Ride away immediately after
starting the engine.
10geBKg6.book Seite 61 Dienstag, 19. November 2002 1:11 13