1999 SUZUKI GRAND VITARA tow

[x] Cancel search: tow

Page 9 of 656

SUZUKI GRAND VITARA 1999 2.G Owners Manual 0A-4 GENERAL INFORMATION
WARNING:
SDM
 During service procedures, be very careful when handling a Sensing and Diagnostic Module (SDM).
Never strike or jar the SDM.
Never power up the air bag system w

Page 17 of 656

SUZUKI GRAND VITARA 1999 2.G Owners Manual 0B-4 MAINTENANCE AND LUBRICATION
Maintenance Recommended under Severe Driving Conditions
If the vehicle is usually used under the conditions corresponding to any severe condition code given below, it

Page 180 of 656

SUZUKI GRAND VITARA 1999 2.G Owners Manual ENGINE GENERAL INFORMATION AND DIAGNOSIS (H27 ENGINE) 6-1-19
P0133HO2S circuit slow response
(Bank 1 - Sensor 1)Response time of HO2S-1 output volt-
age between rich and lean is longer 
than specifica

Page 181 of 656

SUZUKI GRAND VITARA 1999 2.G Owners Manual 6-1-20 ENGINE GENERAL INFORMATION AND DIAGNOSIS (H27 ENGINE)
P0174 Fuel system too lean (Bank 2)Short term fuel trim or total fuel trim 
(short and long terms added) is larger 
than specification for

Page 290 of 656

SUZUKI GRAND VITARA 1999 2.G Owners Manual ENGINE MECHANICAL (H27 ENGINE) 6A2-3
REMOVAL
1) Release fuel pressure in fuel feed line by referring to Section
6.
2) Disconnect negative (–) cable at battery.
3) Drain coolant.
4) Remove strut towe

Page 295 of 656

SUZUKI GRAND VITARA 1999 2.G Owners Manual 6A2-8 ENGINE MECHANICAL (H27 ENGINE)
16) Connect water hoses (3) to throttle body.
17) Connect accelerator cable (1) and A/T throttle cable (2) (for
A/T vehicle) to throttle body.
18) Install surge ta

Page 304 of 656

SUZUKI GRAND VITARA 1999 2.G Owners Manual ENGINE MECHANICAL (H27 ENGINE) 6A2-17
Valves and Cylinder Heads
1. Cylinder block 6. Exhaust valve 11. Valve stem oil seal 16. Cylinder head bolt 
(hex hole bolt)
2. RH bank cylinder head 7. Intake va

Page 305 of 656

SUZUKI GRAND VITARA 1999 2.G Owners Manual 6A2-18 ENGINE MECHANICAL (H27 ENGINE)
INSPECTION
Valve guides
Using a micrometer and bore gauge, take diameter readings on
valve stems and guides to check stem-to-guide clearance. Be
sure to take read
Page:   1-8 9-16 17-24 next >