1999 GMC C-SERIES check oil

yellowblue
6-46 Automatic Ether Injection System (Option)
If your diesel engine vehicle
has this feature, the ether
cylinder is on the upper
right rear side of the engine
compartment.
To change an empty ether cylinder, follow these steps.
1. Loosen the 5/16 inch screw head on the
cylinder
-to-bracket clamp.
2. Spread the clamp apart.3. Clean any dirt from the neck of the cylinder and the
top of the valve before you take out the cylinder.
4. Check the inside of the valve for any foreign matter.
Clean the valve as necessary.
5. Cover the valve to protect it from dirt and take out
the cylinder.
6. Install a new gasket whenever you take out the
cylinder. Use only one gasket and spread a light film
of clean oil on it before installation.
7. Put in the new cylinder. Turn it clockwise until it just
starts to contact the gasket.
8. Tighten the cylinder another half turn (180 degrees).
Don't over
-tighten.
9. Retighten the cylinder clamp.
ProCarManuals.com

yellowblue
6-47 Front Wheel Bearings with Oil-Filled Hubs
If your vehicle has oil-filled
hubs, occasionally check to
see if they have enough oil.
You can tell by looking into
the sight glass to see if there
is oil there.
If there isn't, clean the rubber fill plug in the center of
the glass, and then remove it. Be careful not to allow
any dirt or water to get into the oil. Add enough of the
recommended oil to bring it up to the level mark that
you'll see on the glass.
Refer to your Maintenance Schedule for the proper oil
to use.
When you fill the hub, check the glass again after
driving a short distance. It takes a while for the oil to
flow through the system, and you may find that you
have to add a little more to fill it to the proper level.
Air Conditioning System
Every now and then, have your dealership check your
air conditioning system to be sure it has not lost any
cooling ability. If you think the system is not working
properly, have your GM Truck dealer check it out as
soon as possible.
The air conditioning won't work when the temperature
outside is below 40
F (4
C).
NOTICE:
If your vehicle is equipped with factory air
conditioning, the system is charged with the
R
-134a refrigerant. Servicing of the air
conditioning system should be performed by a
trained service technician.
ProCarManuals.com

yellowblue
6-75
Extending the recommended oil change interval requires
the use of an infrared oil analysis program which shows
the condition of the oil and its additives. For more
information, consult your GM Truck dealer, who is an
authorized Caterpillar

engine dealer.
Transmission Capacity
Capacities (volumes) shown are approximate. For
manual transmissions, the correct oil level is to the
bottom of the fluid fill plug opening. The oil capacity
will vary, due to the angle of the transmission, with the
vehicle. For automatic transmissions, see the Allison
Automatic Transmission Operator's Manual for oil
check and maintenance information.
Manual Transmission Pints (Liters)
RT6609 12.0 (5.7). . . . . . . . . . . . . . . . . . . . . . . . . . . . .
RT6610 12.0 (5.8). . . . . . . . . . . . . . . . . . . . . . . . . . . . .
RTO6610 12.0 (5.8). . . . . . . . . . . . . . . . . . . . . . . . . . . RT6613 16.0 (7.5). . . . . . . . . . . . . . . . . . . . . . . . . . . . .
RT7608LL 19.5 (9.3). . . . . . . . . . . . . . . . . . . . . . . . . .
RT8609 15.0 (7.0). . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FS4205A, FS4205B, FS4205C 12.5 (5.9). . . . . . . . . .
5205A, FS5205C 12.5 (5.9). . . . . . . . . . . . . . . . . . . . .
FS5306 18.0 (8.5). . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FS6305A, FS6305B 19.0 (9.0). . . . . . . . . . . . . . . . . . .
FS6306 19.5 (9.2). . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FS7206 20.0 (9.5). . . . . . . . . . . . . . . . . . . . . . . . . . . . .
T8607B 36.0 (17.0). . . . . . . . . . . . . . . . . . . . . . . . . . .
Automatic Transmission Pints (Liters)
AT542 (for oil pan filter change) 30.0 (14.0)*. . . . . . .
AT545 (for oil pan filter change) 40.0 (19.0)*. . . . . . .
MT643 (for oil pan filter change) 13.0 (24.5)*. . . . . .
MT653 (for oil pan filter change) 36.0 (17.0)*. . . . . .
*Add two pints (one liter) when changing spin
-on filter.
ProCarManuals.com

yellowblue
7-5
Scheduled Maintenance
The services shown in this schedule up to 100,000 miles
(166 000 km) should be performed after 100,000 miles
(166 000 km) at the same intervals. The services shown
after 100,000 miles (166 000 km) should be performed
at those same intervals.
This vehicle has a computer that lets you know when to
change your engine oil. This is not based on mileage,
but on engine revolutions and engine operating
temperature. When the computer has calculated that the
oil needs changing, the Oil Life Indicator will indicate
that a change is necessary.
See ªFootnotesº at the end of this Maintenance Schedule
for further explanation of maintenance services and
Caterpillar

diesel application.
100 Miles (160 km)
Wheel stud nut service. (45)
500 Miles (800 km)
Wheel stud nut service. (45)
1,000 Miles (1 600 km)
Wheel stud nut service. (45)(46)
3,000 Miles (5 000 km)
Engine oil and filter service. (3)(9)
Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)
Clutch pedal free travel service. (10)
Rear axle air shift motor service. (11)
6,000 Miles (10 000 km)
Engine oil and filter service. (3)(9)
Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)
Chassis lubrication service (or every 6 months,
whichever occurs first). (12)
Lubricate door hinge pins and rollers with engine oil.
Wheels and tires service. (15)
Hydraulic brake service (or every 6 months,
whichever occurs first). (7)
Hydraulic parking brake service (or every 6 months,
whichever occurs first). (8)
Clutch pedal free travel service. (10)
9,000 Miles (15 000 km)
Engine oil and filter service. (3)(9)
Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)
ProCarManuals.com

yellowblue
7-6 12,000 Miles (20 000 km)

Engine oil and filter service. (3)(9)

Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)

Chassis lubrication service (or every 6 months,
whichever occurs first). (12)

Lubricate door hinge pins and rollers with engine oil.

Wheels and tires service. (15)

Hydraulic brake service (or every 6 months,
whichever occurs first). (7)

Hydraulic parking brake service (or every 6 months,
whichever occurs first). (8)

Engine drive belts service (or every 12 months,
whichever occurs first). (18)

Clutch pedal free travel service. (10)

Throttle linkage service. (19)

Thermostatically controlled engine cooling
fan service. (4)(20)

Shields and underhood insulation service. (4)(5)(21)

Check air brake relay valve operation and check for
leaks (or every month, or every 300 hours,
whichever occurs first).
15,000 Miles (25 000 km)

Engine oil and filter service. (3)(9)

Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)

Steering system service. (13)

Front and rear suspension service. (14)

Spring
-to-axle U-bolts and shackle bolts service. (16)

Exhaust system service (or every 6 months,
whichever occurs first). (3)(4)(17)

Air brake service (or every 6 months, whichever
occurs first). (39)
18,000 Miles (30 000 km)

Engine oil and filter service. (3)(9)

Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)

Chassis lubrication service (or every 6 months,
whichever occurs first). (12)

Inspect door hinge pins and bushings and replace as
necessary. Lubricate door hinge pins and rollers with
engine oil.
ProCarManuals.com

yellowblue
7-7

Replace air conditioning filter dryer (or every
18 months, whichever occurs first, and whenever
refrigerant charge is lost for any reason).

Wheels and tires service. (15)

Hydraulic brake service (or every 6 months,
whichever occurs first). (7)

Hydraulic brake caliper service (or every 6 months,
whichever occurs first). (22)

Hydraulic parking brake service (or every 6 months,
whichever occurs first). (8)

Clutch pedal free travel service. (10)

Clean air brake application valve (or every 3 months,
or every 300 hours, whichever occurs first);
lubricate linkage.
21,000 Miles (35 000 km)

Engine oil and filter service. (3)(9)

Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)
24,000 Miles (40 000 km)

Engine oil and filter service. (3)(9)

Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)
Chassis lubrication service (or every 6 months,
whichever occurs first). (12)

Lubricate door hinge pins and rollers with engine oil.

Wheel bearing (grease type) service (or every
24 months, whichever occurs first, and whenever
hubs are removed). (23)

Wheels and tires service. (15)

Hydraulic brake service (or every 6 months,
whichever occurs first). (7)

Hydraulic parking brake service (or every 6 months,
whichever occurs first). (8)

Engine drive belts service (or every 12 months,
whichever occurs first). (18)

Clutch pedal free travel service. (10)

Throttle linkage service. (19)

Thermostatically controlled engine cooling
fan service. (4)(20)

Shields and underhood insulation service. (4)(5)(21)

Air intake system service (or every 24 months,
whichever occurs first). (4)(5)(24)

Thermostatically controlled air cleaner service
(or every 24 months, whichever occurs first).
(3)(4)(25)

(Continued)
ProCarManuals.com

yellowblue
7-8 24,000 Miles (40 000 km) (Continued)

Evaporative Control System service (if equipped) (or
every 24 months, whichever occurs first). (3)(26)

Rear axle air shift motor service. (11)
Check air brake relay valve operation and check for
leaks (or every month, or every 300 hours,
whichever occurs first).
Air brake chamber service (or every 2 months,
whichever occurs first). (41)
Trailer brake hand control valve service (or every
3 months, or 900 hours, whichever occurs first). (42)
27,000 Miles (45 000 km)
Engine oil and filter service. (3)(9)
Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)
30,000 Miles (50 000 km)
Engine oil and filter service. (3)(9)
Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)
Chassis lubrication service (or every 6 months,
whichever occurs first). (12)
Replace fuel filter(s) (or every 12 months, whichever
occurs first). (3)Air cleaner filter replacement service (or every
24 months, whichever occurs first). (3)(4)(27)
Steering system service. (13)
Front and rear suspension service. (14)
Spring
-to-axle U-bolts and shackle bolts service. (16)
Exhaust system service (or every 6 months,
whichever occurs first). (3)(4)(17)
Air brake service (or every 6 months, whichever
occurs first). (39)
Lubricate door hinge pins and rollers with engine oil.
Wheels and tires service. (15)
Hydraulic brake service (or every 6 months,
whichever occurs first). (7)
Hydraulic parking brake service (or every 6 months,
whichever occurs first). (8)
Clutch pedal free travel service. (10)
Air brake automatic slack adjuster service (or every
500 hours, whichever occurs first). (40)
33,000 Miles (55 000 km)
Engine oil and filter service. (3)(9)
Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)
ProCarManuals.com

yellowblue
7-9 36,000 Miles (60 000 km)

Engine oil and filter service. (3)(9)

Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)

Chassis lubrication service (or every 6 months,
whichever occurs first). (12)

Inspect door hinge pins and bushings and replace as
necessary. Lubricate door hinge pins and rollers with
engine oil.

Replace air conditioning filter dryer (or every
18 months, whichever occurs first, and whenever
refrigerant charge is lost for any reason).

Wheels and tires service. (15)

Hydraulic brake service (or every 6 months,
whichever occurs first). (7)

Hydraulic brake caliper service (or every 6 months,
whichever occurs first). (22)

Hydraulic parking brake service (or every 6 months,
whichever occurs first). (8)

Engine drive belts service (or every 12 months,
whichever occurs first). (18)

Clutch pedal free travel service. (10)

Throttle linkage service. (19)

Thermostatically controlled engine cooling
fan service. (4)(20)
Shields and underhood insulation service. (4)(5)(21)

Check air brake relay valve operation and check for
leaks (or every month, or every 300 hours,
whichever occurs first).

Clean air brake application valve (or every 3 months,
or every 300 hours, whichever occurs first);
lubricate linkage.
39,000 Miles (65 000 km)

Engine oil and filter service. (3)(9)

Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)
42,000 Miles (70 000 km)

Engine oil and filter service. (3)(9)

Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)

Chassis lubrication service (or every 6 months,
whichever occurs first). (12)

Lubricate door hinge pins and rollers with engine oil.

Wheels and tires service. (15)

Hydraulic brake service (or every 6 months,
whichever occurs first). (7)

Hydraulic parking brake service (or every 6 months,
whichever occurs first). (8)

Clutch pedal free travel service. (10)
ProCarManuals.com