Page 112 of 328
yellowblue
2-70 Filterminder Gage (Diesel Engine)
This optional gage is in the
lower center of the
instrument panel. It
monitors the engine
air filter.
As the filter gets dirty, the yellow indicator will begin to
rise. When it reaches 25 inches of vacuum on the scale,
the filter should be replaced.
After replacing the filter, reset the gage by pressing in
the yellow reset pin at the bottom of the gage.
If you have a diesel engine, also see your Caterpillar
Operation & Maintenance Manual.
Hourmeter Gage (If Equipped)
If your vehicle has this
gage, it will be to the lower
left of the steering column,
mounted on a bracket either
above or below the fuse
block. It shows the total
engine operating time.
ProCarManuals.com
Page 199 of 328

6-
yellowblue
6-1
Section 6 Service and Appearance Care
Here you will find information about the care of your vehicle. This section begins with service and fuel information,
and then it shows how to check important fluid and lubricant levels. There is also technical information about your
vehicle, and a part devoted to its appearance care.
6
-2 Service
6
-4 Fuel (Gasoline Engine)
6
-5 Diesel Fuel Requirements and Fuel System
6
-6 Fuels in Foreign Countries (Gasoline Engines)
6
-7 Filling Your Tank
6
-8 Filling a Portable Fuel Container
6
-9 Checking Things Under the Hood
6
-11 Noise Control System
6
-13 Engine Oil (Gasoline Engine)
6
-17 Engine Oil (Caterpillar Diesel Engine)
6
-17 Engine Air Cleaner/Filter
6
-18 Automatic Transmission Fluid
6
-19 Manual Transmission Fluid
6
-20 Rear Axle
6
-20 Rear Axle Shift Motor (Option)
6
-21 Radiator Pressure Cap (Gasoline Engines)
6
-22 Surge Tank Pressure Cap (Diesel Engines)
6
-22 Thermostat6
-23 Engine Coolant (Gasoline Engine)
6
-27 Engine Coolant (Caterpillar Diesel Engine)
6
-28 Power Steering Fluid
6
-29 Windshield Washer Fluid
6
-30 Brakes
6
-36 Electric/Hydraulic Parking Brake Fluid
6
-42 Battery
6
-44 Other Service Items
6
-48 Tires
6
-59 Appearance Care
6
-59 Cleaning the Inside of Your Vehicle
6
-63 Cleaning the Outside Your Vehicle
6
-66 GM Vehicle Care/Appearance Materials
6
-67 Vehicle Identification Number (VIN)
6
-67 Service Parts Identification Label
6
-68 Electrical System
6
-74 Capacities and Specifications
6
-77 Air Conditioning Refrigerants
ProCarManuals.com
Page 215 of 328
yellowblue
6-17
Engine Oil
(Caterpillar Diesel Engines)
See your Caterpillar Operation & Maintenance Manual
for information on oil quality and viscosities as well as
the temperature range chart.
Air Filter Restriction Indicator
Your engine has an indicator that lets you know when
the air filter is dirty and needs to be serviced. It is in the
air intake tube below the air cleaner on the passenger's
side of the engine.
When the yellow indicator
reaches the red ring in the
sight glass, it's time to
service the air filter.After the air filter is properly serviced, the indicator can
be reset by pushing the button on top of the indicator.
Engine Air Cleaner/Filter
Your GM Maintenance Schedule says when to replace
the air filter.
Gasoline Engine Caterpillar Diesel
Engine
ProCarManuals.com
Page 216 of 328

yellowblue
6-18
CAUTION:
Gasoline Engines Only: Operating the engine
with the air cleaner/filter off can cause you or
others to be burned. The air cleaner not only
cleans the air, it stops flame if the engine
backfires. If it isn't there, and the engine
backfires, you could be burned. Don't drive with
it off, and be careful working on the engine with
the air cleaner/filter off.
NOTICE:
Gasoline Engines Only: If the air cleaner/filter is
off, a backfire can cause a damaging engine fire.
And, dirt can easily get into your engine, which
will damage it. Always have the air cleaner/filter
in place when you're driving.
Your vehicle may also be equipped with an optional
Filterminder gage. See ªWarning Lights, Gages and
Indicatorsº in the Index.
Automatic Transmission Fluid
When to Check
A good time to have it checked is when the engine oil is
checked. See your Allison Automatic Transmission
Operator's Manual to find out when to change your
transmission fluid and filters.
How to Check and What to Use
The Allison Automatic Transmission Operator's Manual
that came with the vehicle shows how to check the
automatic transmission fluid and what fluid to use.
NOTICE:
Too much or too little fluid can damage your
transmission. Too much can mean that some of
the fluid could come out and fall on hot engine
parts or exhaust system parts, starting a fire. Be
sure to get an accurate reading if you check your
transmission fluid.
ProCarManuals.com
Page 232 of 328
yellowblue
6-34 Air Dryer (Option)
If your vehicle has air brakes, it may have an air dryer.
This collects and removes dirt, moisture or other foreign
matter from the air prior to entering the brake system. It
is mounted on the left frame rail.
If your dryer is a
Bendix
-Westinghouse, it
has a filter that you need to
change at intervals. See
your Maintenance Schedule
for more about servicing
this filter.
Alcohol Injector (Option)
If your vehicle has air brakes, it may have an alcohol
injector. It is on the frame or crossmember at the right
front corner of the vehicle.
The alcohol injector helps prevent moisture in the air
brake system from freezing. Use it only in cold weather,
32F (0C) or below.
ProCarManuals.com
Page 242 of 328
yellowblue
6-44
Other Service Items
Component Box
Your vehicle has a component box along the left frame rail.
What is in the box depends on what options are on your
vehicle. Normally, the fuel filter, air dryer, Luberfiner oil
filter, emission canister or other components are in there.
To get into the box, you first have to remove the top
cover. To do that, remove the two 8 mm bolts on top and
the single 8 mm bolt at the top front. Then, pull the
cover toward you and lift it off.You can then remove the front cover if you need to, by
removing the two 8 mm bolts and pulling it off.
When you're through, be sure to put the front cover on,
before you put on the top cover.
Fuel Filter (Gasoline Engines)
The steel fuel filter is located inside the component box
at the rear. See your Maintenance Schedule for
recommended service intervals.
If your vehicle is equipped with the optional Davco
spin
-on type filter, it is also located in the component box.
ProCarManuals.com
Page 269 of 328
yellowblue
6-71
Name Circuits Protected
CHAS Exhaust Brake, Air Suspension
Dump Valve, Air Dryer, HYD
ABS ECHU
PARK LP Auxiliary Wiring, Air Conditioner
Controls, Parking Lamps, Turn
Signals, Taillamps, Stoplamps,
Marker Lamps, Trailer Running
Lamps, Lighted Mirrors, Radio
Receiver, Mirror Clearance Lamps
HORN Horn/Diagnostic Connector
PRK BRK Parking Brake Module
FUEL Heated Fuel Filter (Diesel
Engines) or Fuel Pump
(Gasoline Engines)
AXLE Heated Mirrors, Radiator Shutters,
Tw o
-Speed Axle Motor,
Tw o
-Speed Axle Switch
MRKR LP Roof Marker Lamps,
Trailer Marker Lamps,
Marker Lamp RelayName Circuits Protected
CIG/AUX Cigarette Lighter,
Auxiliary Power Jacks
AUX Auxiliary Wiring Relay
IGN RLY/VIN Vehicle Interface Module
(Diesel Engines) or Generator,
Coil, Injectors (Gasoline Engines)
WDO Power Windows
CRNK Starter Relay
IGN SW Instrument Panel Cluster Telltales
AUX Auxiliary Wiring
RDO Radio, Auxiliary Wiring
DR LK Power Door Locks
ProCarManuals.com
Page 275 of 328

yellowblue
6-77
Air Conditioning Refrigerants
Not all air conditioning refrigerants are the same.
If the air conditioning system in your vehicle needs
refrigerant, be sure the proper refrigerant is used.
If you're not sure, ask your dealer.
Air Conditioning Refrigerant Capacity
Refrigerant R-134a 2.5 lbs. (1.134 kg). . . . . . . . . . . .
This capacity (volume) is approximate.
Normal Maintenance Replacement
Parts
Allison Transmission External Filters
Engine GM (AC) Part Number
7.2L 25011122 (PF897). . . . . . . . . . . . . . . . . . . . . . .
7.4L 25011122 (PF897). . . . . . . . . . . . . . . . . . . . . . .
Air Compressor Filter
Air Compressor GM Part Number
Bendix Tu
-Flo
550 (13.2 CFM)2467368
Service Replacement Part and
Filter Recommendations
Engine 7.2L 7.4L
RPO LG5 LP4/L21
Spark Plug Ð AC Type R41
-932
ÐGap Ð 0.060 inch
(1.52 mm)
ÐTorque Ð 22.0 lb. ft.
(30.0 Nm)
Oil Filter CAT
2P4004 AC Type PF-932
PCV Valve Ð AC Type CV
-774C
Air Cleaner* Donaldson
P522606Donaldson
P533355
Fuel Filter AC
-TP-915 Pri-
mary**AC Type GF-481
Pressure Caps RC
-54 Ð
*Optional Davco (K28) D350921 spin
-on type filter
located in component box.
**Optional Cold Weather (KUK) Racor B6484GM
spin
-on type located in component box. Optional Davco
heated fuel water separator mounted on the side of the
diesel engine.
ProCarManuals.com