1999 CHEVROLET VENTURE engine overheat

yellowblue
6-21
3. After adding fluid, recheck the fluid level as
described under ªHow to Check.º
4. When the correct fluid level is obtained, push the
dipstick back in all the way.
Radiator Pressure Cap
NOTICE:
Your radiator cap is a 15 psi (105 kPa)
pressure
-type cap and must be tightly installed to
prevent coolant loss and possible engine damage
from overheating. Be sure the arrows on the cap
line up with the overflow tube on the radiator
filler neck.
When you replace your radiator pressure cap, a GM cap
is recommended.
Thermostat
Engine coolant temperature is controlled by a thermostat
in the engine coolant system. The thermostat stops the
flow of coolant through the radiator until the coolant
reaches a preset temperature.
When you replace your thermostat, a GM thermostat
is recommended.
Engine Coolant
The cooling system in your vehicle is filled with
DEX
-COOL
engine coolant. This coolant is designed
to remain in your vehicle for 5 years or 150,000 miles
(240 000 km), whichever occurs first, if you add only
DEX
-COOL
extended life coolant.
The following explains your cooling system and how to
add coolant when it is low. If you have a problem with
engine overheating, see ªEngine Overheatingº in
the Index.

yellowblue
6-22
A 50/50 mixture of clean, drinkable water and
DEX
-COOL
coolant will:

Give freezing protection down to
-34F (-37C).

Give boiling protection up to 265F (129C).

Protect against rust and corrosion.

Help keep the proper engine temperature.

Let the warning lights and gages work as
they should.
NOTICE:
When adding coolant, it is important that you use
only DEX
-COOL (silicate-free) coolant.
If coolant other than DEX-COOL is added to the
system, premature engine, heater core or
radiator corrosion may result. In addition, the
engine coolant will require change sooner
-- at
30,000 miles (50 000 km) or 24 months,
whichever occurs first. Damage caused by the use
of coolant other than DEX
-COOL is not
covered by your new vehicle warranty.
What to Use
Use a mixture of one-half clean, drinkable water and
one
-half DEX-COOL coolant which won't damage
aluminum parts. If you use this coolant mixture, you
don't need to add anything else.
CAUTION:
Adding only plain water to your cooling system
can be dangerous. Plain water, or some other
liquid like alcohol, can boil before the proper
coolant mixture will. Your vehicle's coolant
warning system is set for the proper coolant
mixture. With plain water or the wrong mixture,
your engine could get too hot but you wouldn't
get the overheat warning. Your engine could
catch fire and you or others could be burned. Use
a 50/50 mixture of clean, drinkable water and
DEX
-COOL coolant.

yellowblue
6-23
NOTICE:
If you use an improper coolant mixture, your
engine could overheat and be badly damaged.
The repair cost wouldn't be covered by your
warranty. Too much water in the mixture can
freeze and crack the engine, radiator, heater core
and other parts.
If you have to add coolant more than four times a year,
have your dealer check your cooling system.
NOTICE:
If you use the proper coolant, you don't have to
add extra inhibitors or additives which claim to
improve the system. These can be harmful.
Checking Coolant
The engine coolant reservoir is located on the driver's
side of the vehicle, above the engine air cleaner/filter.
The vehicle must be on a level surface. When your
engine is cold, the coolant level should be at the FULL
COLD mark, or a little higher. When your engine is
warm, the level should be above the FULL COLD mark
or a little higher.

yellowblue
9-4
Dome Lamp 2-66 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Door
Locks 2
-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power Sliding 2-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sliding 2-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Door Ajar Light 2-100 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Driver Information Center (DIC) 2-102 . . . . . . . . . . . . . . . . . .
Driver Position 1-28 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Driver's Four-Way Manual Seat 1-2 . . . . . . . . . . . . . . . . . . . .
Driving
City 4
-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Defensive 4-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Drunken 4-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Freeway 4-21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
In a Blizzard 4-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
In Foreign Countries 6-5 . . . . . . . . . . . . . . . . . . . . . . . . . . .
In the Rain 4-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Night 4-16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
On Curves 4-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
On Grades While Towing a Trailer 4-38 . . . . . . . . . . . . . . .
On Hill and Mountain Roads 4-23 . . . . . . . . . . . . . . . . . . . .
On Snow and Ice 4-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Through Water 4-19 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wet Roads 4-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Winter 4-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
With a Trailer 4-36 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Drunken Driving 4-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Electrical Equipment, Adding 2-41, 3-29 . . . . . . . . . . . . . . .
Electrical System 6-57 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Electronic Level Control 4-31 . . . . . . . . . . . . . . . . . . . . . . . . .
Engine 6-10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Cleaner/Filter 6-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Coolant 6-21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Coolant Heater 2
-41 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Coolant Level Check 7-30 . . . . . . . . . . . . . . . . . . . . . . . . . .
Coolant Temperature Gage 2-94 . . . . . . . . . . . . . . . . . . . . .
Exhaust 2-52, 4-28, 4-36 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Identification 6-56 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil Level Check 7-30 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Overheated Protection Operating Mode 5-10 . . . . . . . . . . .
Overheating 5-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Running While Parked 2-52 . . . . . . . . . . . . . . . . . . . . . . . . .
Specifications 6-65 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Starting Your 2-40 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Oil 2-99, 6-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Additives 6-14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking 6-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Used 6-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
What Kind to Use 6-13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
When to Add 6-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
When to Change 6-14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Equipment, Adding to the Outside of Your Vehicle 6-3 . . . . . .
Exhaust, Engine 2-52, 4-28, 4-36 . . . . . . . . . . . . . . . . . . . . . .
Exit Lighting 2-65 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fabric Cleaning 6-49 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Filling a Portable Fuel Container 6-7 . . . . . . . . . . . . . . . . . . . .
Filling Your Tank 6-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Filter
Air 6
-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Passenger Compartment Replacement 6-16 . . . . . . . . . . . . .
Finish
Care 6
-53 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Damage 6-54 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FIRST (1) Gear 2-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Flashers, Hazard Warning 5-2 . . . . . . . . . . . . . . . . . . . . . . . . .
Flat Tire, Changing 5-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

yellowblue
9-8
Net, Cargo 2-73 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
NEUTRAL (N) 2-44 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
New Vehicle ªBreak-Inº 2-37 . . . . . . . . . . . . . . . . . . . . . . . . .
Night Vision 4-16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Normal Replacement Parts Maintenance 6-65 . . . . . . . . . . . . .
Odometer 2-87 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Odometer, Trip 2-87 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Off-Road Recovery 4-13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil, Engine 2-102, 6-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil Pressure Light 2-98 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
OnStar System
2-80 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Overhead Console 2-69 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Overhead Console Switchbank 2-12 . . . . . . . . . . . . . . . . . . . .
Overheated Engine Protection 5-10 . . . . . . . . . . . . . . . . . . . . .
Overheating Engine 5-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Owner Checks and Services 7-30 . . . . . . . . . . . . . . . . . . . . . . .
Owner Publications, Ordering 8-12 . . . . . . . . . . . . . . . . . . . . .
Paint Spotting, Chemical 6-54 . . . . . . . . . . . . . . . . . . . . . . . .
PARK (P)
Automatic Transaxle 2
-43 . . . . . . . . . . . . . . . . . . . . . . . . . .
Shifting Into 2-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Shifting Out of 2-50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parking
At Night 2
-33 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake 2-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake Mechanism Check 7-33 . . . . . . . . . . . . . . . . . . . . . . .
Lots 2-33 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Over Things That Burn 2-51 . . . . . . . . . . . . . . . . . . . . . . . .
With a Trailer 4-39 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Passenger Compartment Air Filter Replacement 6-16 . . . . . . . Passing 4
-13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PASS-Key
III 2-35 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PASS-Key
III Security Light 2-100 . . . . . . . . . . . . . . . . . . .
Payload 4-31 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Periodic Maintenance Inspections 7-34 . . . . . . . . . . . . . . . . . .
Portable Fuel Container, Filling a 6-7 . . . . . . . . . . . . . . . . . . .
Power
Accessory Outlets 2
-83 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Door Locks 2-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Option Fuses 6-57 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Remote Control Mirrors 2-67 . . . . . . . . . . . . . . . . . . . . . . . .
Seat 1-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Steering 4-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Windows 2-53 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power Sliding Door Light 2-99 . . . . . . . . . . . . . . . . . . . . . . . .
Power Steering Fluid 6-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
How to Check 6-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
What to Use 6-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
When to Check 6-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pregnancy, Use of Safety Belts 1-36 . . . . . . . . . . . . . . . . . . . .
Pretensioners, Safety Belts 1-46 . . . . . . . . . . . . . . . . . . . . . . . .
Problems on the Road 5-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Publications, Service and Owner 8-12 . . . . . . . . . . . . . . . . . . .
Radiator 5-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radiator Pressure Cap 6-21 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radio Reception 3-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radios 3-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rain, Driving In 4-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Reading Lamps 2-65 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear
Air Vents 3
-7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cargo Lamp 2-66 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Climate Control 3-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .