1998 TOYOTA 4RUNNER catalytic converter

4RUNNER (1998)
Part 2
INFORMATION
BEFORE DRIVING
YOUR TOYOTA
Off- road vehicle precautions
Break- in period
Fuel
Operation in foreign countries
Three- way catalytic converter
Engine exhaust cautions
Facts about engine oil
consumption
Twin ground electrode spark plugs
Brake system
Brake pad wear limit
indicators
Luggage stowage precautions
Your Toyota's identification
Theft prevention labels
Suspension and chassis
Types of tires
InformationOff- road vehicle precaution

4RUNNER (1998)
Fuel
FUEL TYPE
Your new vehicle must use only un-
leaded gasoline.
To help prevent gas station mixups,
your Toyota has a new smaller fuel
tank opening. The special nozzle on
pumps with unleaded fuel will fit it,
but the larger standard nozzle on
pumps with leaded gas will not.
At a minimum, the gasoline you use
should meet the specifications of
ASTM D4814 in the U.S.A. and CGSB
3.5- M93 in Canada.
NOTICE
Do not use leaded gasoline. Use of leaded gasoline will cause thethree- way catalytic converter to
lose its effectiveness and the
emission control system to func-tion improperly. Also, this can in-crease maintenance costs.
OCTANE RATING
Select Octane Rating 87 (Research
Octane Number 91) or higher.
Use of unleaded gasoline with an oc-
tane rating or research octane number
lower than stated above will cause
persistent heavy knocking. If it is se-
vere, this will lead to engine damage.
If your engine knocks...
If you detect heavy knocking even
when using the recommended fuel, or
if you hear steady knocking while
holding a steady speed on level
roads, consult your Toyota dealer.
However, now and then, you may no-
tice light knocking for a short time
while accelerating or driving up hills.
This is no need of concern.
GASOLINES CONTAINING DETER-
GENT ADDITIVES
Toyota recommends use of gaso-
lines that contain detergent addi-
tives to avoid build- up of engine
deposits.
For further details, ask your Toyota
dealer or a local gasoline retailer. IMPROVED GASOLINES
The American Automobile Manufac-
turers Association (AAMA) has de-
veloped a specification of improved
gasolines. The AAMA specification
offers optimal fuel information for
better vehicle performance and bet-
ter protection of your engine.
Toyota recommends the use of gaso-
lines that meet the AAMA specifica-
tion, if available, for improved drive-
ability and emission control system.
GASOLINES CONTAINING MTBE
Gasolines that contain MTBE (Meth-
yl Tertiary- Butyl Ether) are available
in the market. If you use a gasoline
mixed with MTBE, make certain that
it does not contain more than 15%
of MTBE.
If the use of gasolines containing
MTBE causes poor driveability and/or
poor fuel economy, you should discon-
tinue the use of fuels containingMTBE.

4RUNNER (1998)
Three- way catalytic convert- er
The three- way catalytic converter is
an emission control device installed
in the exhaust system.
The purpose is to reduce pollutants in
the exhaust gas.
CAUTION
Keep people and combustible
materials away from the exhaust
pipe while the engine is run-
ning. The exhaust gas is very
hot.
Do not drive, idle or park your
vehicle over anything that might
burn easily such as grass,
leaves, paper or rags.

4RUNNER (1998)
NOTICE
A large amount of unburned
gases flowing into the three- waycatalytic converter may cause itto overheat and create a fire haz-
ard. To prevent this and otherdamage, observe the followingprecautions:
Use only unleaded gasoline.
Do not drive with an extremely
low fuel level; running out offuel could cause the engine to misfire, creating an excessive
load on the three- way catalyticconverter.
Do not allow the engine to runat idle speed for more than 20 minutes.
Avoid racing the engine.
Do not push- start or pull- start
your vehicle.
Do not turn off the ignitionwhile the vehicle is moving.
Keep your engine in good run-
ning order. Malfunctions in theengine electrical system, elec-tronic ignition system/distribu-
tor ignition system or fuel sys-tems could cause an extremelyhigh three- way catalytic con-
verter temperature.
If the engine becomes difficultto start or stalls frequently,
take your vehicle in for acheck- up as soon as possible.
Remember, your Toyota dealer
knows your vehicle and itsthree- way catalytic converter
system best.
To ensure that the three- waycatalytic converter and the en-
tire emission control system op-erate properly, your vehiclemust receive the periodic in-
spections required by the Toyo-ta Maintenance Schedule. For scheduled maintenance informa-
tion, refer to the separateºOwner 's Manual Supplement/Maintenance Scheduleº.
Engine exhaust cautions
CAUTION
Avoid inhaling the engine ex-
haust. It contains carbon mon-
oxide, which is a colorless and
odorless gas. It can cause un-
consciousness or even death.
Make sure the exhaust system
has no holes or loose connec-
tions. The system should be
checked from time to time. If
you hit something, or notice a
change in the sound of the ex-
haust, have the system checked
immediately.
Do not run the engine in a ga-
rage or enclosed area except
for the time needed to drive the
vehicle in or out. The exhaust
gases cannot escape, making
this a particularly dangerous
situation.
Do not remain for a long time
in a parked vehicle with the en-
gine running. If it is unavoid-
able, however, do so only in an
unconfined area and adjust the
heating or cooling system to
force outside air into the ve-
hicle.

4RUNNER (1998)
Part 4
IN CASE OF AN
EMERGENCY
If your vehicle will not start
If your engine stalls while
driving
If your vehicle overheats
If you have a flat tire
If your vehicle needs to be
towed
If you cannot shift automatic
transmission selector lever
If you lose your keys
Before making these checks, make
sure you have followed the correct
starting procedure given in ºHow to
start the engineº in Part 3 and that
you have sufficient fuel.
If the engine is not turning over or
is turning over too slowlyÐ
1. Check that the battery terminals are tight and clean.
2. If the battery terminals are O.K., switch on the interior light.
3. If the light is out, dim or goes out when the starter is cranked, the
battery is discharged. You may try
jump starting. See º(c) Jump start-
ingº for further instructions.
If the light is O.K., but the engine still
will not start, it needs adjustment or
repair. Call a Toyota dealer or quali-
fied repair shop.
NOTICE
Do not pull- or push- start the ve- hicle. It may damage the vehicleor cause a collision when the en-
gine starts. Also the three- way
catalytic converter may overheatand become a fire hazard.
If the engine turns over at its nor-
mal speed but will not startÐ
1. Check that all the push- on connec- tors are tight. (For example, con-
nections at the spark plugs, ignition
coil and/or distributor)
2. If the connectors are O.K., the en- gine may be flooded because of
repeated cranking. See º(b) Start-
ing a flooded engineº for further
instructions.
If your vehicle will not start
Ð
(a) Simple checks