1998 CHEVROLET VENTURE wheel torque

10. Lower the vehicle by attaching the folding wheel
wrench
to the jack and rotating the wrench to the
left. Lower the jack completely.
L
a CAUTION:
11. Tighten the wheel nuts
firmly in a criss-cross
sequence,
as shown.
Incorrect wheel nuts or improperly tightened
wheel nuts can cause the wheel to become loose
and even come off. This could lead to an accident.
Be sure to use the correct wheel nuts.
If you have
to replace them, be sure to get new
GM original
equipment wheel nuts.
Stop somewhere as
soon as you can and have the
nuts tightened with a torque wrench to
100 lb-ft
(140 Nom).
ProCarManuals.com

NOTICE:
Improperly tightened wheel nuts can lead to
brake pulsation and rotor damage.
To avoid
expensive brake repairs, evenly tighten the wheel
nuts in the proper sequence and to the proper
torque specification.
Don’t try to put a wheel cover
on the compact spare tire.
It won’t fit. Store the wheel cover securely in the rear
of
the vehicle until you have the flat tire repaired or
replaced.
I NOTICE:
Wheel covers won’t fit on your compact spare. If
you try to put a wheel cover on your compact
spare, you could damage the cover or the spare.
Storing a Flat or 5are Tire and Tools
A CAUTION:
Storing a jack, a tire or other equipment in the
passenger compartment
of the vehicle could
cause injury.
In a sudden stop or collision, loose
equipment could strike someone. Store all these
in the proper place.
Lay
the tire near the rear of the vehicle with the valve
stem down. Slide the cable retainer through the center
of
the wheel and start to raise the tire. When the tire is
almost in the stored position, turn the tire so the valve is
towards the rear
of the vehicle. This will help when you
check and maintain tire pressure in the spare.
Keep raising the wheel until you hear the hoist
mechanism click twice. This means the wheel
is firmly
stored against the underside
of the vehicle. Push
against the wheel to be sure
it does not move and is
stored securely.
5-33
ProCarManuals.com

Brake Wear
Your vehicle has front disc brakes and rear drum brakes.
Disc brake pads have built-in wear indicators that
make a high-pitched warning sound when the brake
pads are
worn and new pads are needed. The sound
may come and
go or be heard all the time your vehicle
is moving (except when you are pushing on the brake
pedal firmly).
A CAUTION:
The brake wear warning sound means that soon
your brakes won’t work well. That could lead to
an accident. When you hear the brake wear
warning sound, have your vehicle serviced.
NOTICE:
Continuing to drive with worn-out brake pads
could result in costly brake repair.
Some driving conditions or climates may cause a
brake squeal when the brakes are first applied or lightly
applied. This does not mean something is wrong with
your brakes.
Properly torqued wheel nuts are necessary
to help
prevent brake pulsation. When tires are rotated, inspect
brake pads for wear and evenly torque wheel nuts
in the
proper sequence
to GM specifications.
Your rear drum brakes don’t have wear indicators, but
if you ever hear a rear brake rubbing noise, have the
rear brake linings inspected immediately. Also, the rear
brake drums should be removed and inspected each time
the tires are removed
for rotation or changing. When
you have the front brake pads replaced, have the rear
brakes inspected,
too.
Brake linings should always be replaced as complete
axle sets.
See “Brake System Inspection” in Section 7 of this
manual under
Part C “Periodic Maintenance
Inspections.”
6-29
ProCarManuals.com

Tire Inspection and Rotation
Tires should be rotated every 6,000 to 8,000 miles
(10 000 to 13 000 Ism). Any time you notice unusual
wear, rotate your tires as soon as possible and check
wheel alignment. Also check for damaged tires or
wheels. See “When It’s Time for New Tires” and
“Wheel Replacement” later in this section for
more information.
The purpose
of regular rotation is to achieve more
uniform wear for
all tires on the vehicle. The first
rotation is the most important. See “Scheduled Maintenance Services” in the Index for scheduled
rotation intervals. Don’t include the compact spare tire
in your
tire rotation.
After the tires have been rotated, adjust the front and rear inflation pressures as shown on the
Certificatioflire label. Make certain that all wheel
nuts are properly tightened. See “Wheel Nut Torque”
in the Index.
I
Rust or dirt on a wheel, or on the parts to which
it is fastened, can make wheel nuts become loose
after a time. The wheel could come
off and cause
an accident. When you change
a wheel, remove
1 any rust or dirt from places where the wheel
attaches to the vehicle. In an emergency, you can
use
a cloth or a paper towel to do this; but be
sure to use
a scraper or wire brush later, if you
need to, to get all the rust or dirt
off. (See
“Changing a Flat Tire” in the Index.)
When rotating your tires, always use
the correct rotation
pattern shown here.
I 6-42
ProCarManuals.com

Fuses
RR HVAC
SWC ACCY
HAZARD
RR PWR SCKT
DRL
LH TLP
RR DEFOG
FRT PWR SCKT
SIR
FRT HVAC
LOWMED BLWR
MALL/RADIO/DIC Rear Blower Motor,
Rear
Heater-NC
Control,
and Temperature Door
Actuator (Rear)
Steering Wheel Radio
Control Switches
Turn Signal Switch
Rear Electric Accessory
Plug Housing
DRL Control Module
Not Used
Rear Window Defogger Relay
Front Electric Accessory
Plug Housing
Inflatable Restraint
Control Module
Heater-A/C Control
BCM, Driver Information
Display, Radio
and Radio Rear
Speaker Amplifier
Fuses
STOP LAMP
ABS MOD BATT
CAN VENT
SOL
ELC
CTSY LAMP
IGN 1
SUNROOF
Stoplamp Switch to Stoplamps
Electronic Brake Control
ModuleElectronic Brake
Traction Control Module
(EBCMEBTCM)
Evaporative Emissions (EVAP)
Canister Vent Solonoid Valve
Electronic Level Control (ELC)
Air Compressor and ELC
Relay, Trailer Harness
BCM
ALC Sensor, BCM, Electronic
Brake Control Indicator Lamp
Driver Module, Instrument
Panel Cluster, Rear Window
Wipermasher and
Multifunction Switch (Fog Lamp SwitcWTraction Control Switch) and Stoplamp/Torque
Converter Clutch (TCC) Switch
Sunroof Control Module
6-60
ProCarManuals.com

Capacities and Specifications
The following approximate capacities are given in
English and metric conversions.
Please refer to “Recommended Fluids and Lubricants”
in the Index for more information.
Automatic Transaxle
Pan Removal and Replacement ..... 8 quarts (7.5 L)
Cooling System
With A/C .................... 9.6 quarts (9.1 L)
With Rear Climate Control or
Engine Crankcase - Oil and
Fuel Capacity
Rear Heater ................ 11.9 quarts (11.3 L)
Filter Change ............... 4.5 quarts (4.3 L)
StandardRegular .............. .20 gallons (76 L)
OptionaVExtended ............. .25 gallons (95 L)
Refrigerant, Air Conditioning* . . See Refrigerant
Label under the hood.
Tire Pressures, Sizes ........... See Tire-Loading
Information label
on driver’s door.
Wheel Nut Torque .......... 100 lb-ft (140 N-m)
Windshield Washer Fluid ....... 1 gallon (0.37 L)
*See Air Conditioning Refrigerants later in
this section.
NOTE: All capacities are approximate. When
adding,
be sure to fill to the appropriate level, as
recommended in
this manual.
Engine Specifications
Engine VIN Code ........................... E
Firing Order ...................... 1-2-3-4-5-6
EngineType
.............................. V6
Horsepower ............................. 180
Thermostat
Temperature
Specification
................... 195 “F (91 “C)
6-65
ProCarManuals.com

Taillamp Bulb Replacement ...................... 6-37
TapePlayerCare
............................... 3-30
Temperature Knob. Climate Control System
........... 3-2
Theft
......................................... 2-22
Theft-Deterrent Feature. CD Player
................ 3-26
THEFTLOCK
................................. 3-26
Thermostat
.................................... 6-24
Third Gear
.................................... 2-32
Third Row Solid Bench Seat
...................... 1 - 13
Adjusting ................................... 1-13
Folding the Seatback
.......................... 1 - 13
Removing
................................... 1-14
Replacing
................................... 1 - 16
Tilt Steering Wheel
............................. 2-52
Time. Setting the
................................ 3-9
Tirechains
.................................... 6-47
Tire Loading
................................... 4-30
Tire-Loading Information Label
................... 4-30
Tires
......................................... 6-40
Alignment and Balance
........................ 6-46
BuyingNew
................................. 6-43
Chains
..................................... 6-47
ChangingaFlat
.............................. 5-24
Cleaning
.................................... 6-53
Compact Spare ............................... 5-34
Inflation
.................................... 6-41
Inflation Check ............................... 7-29
Inspection and Rotation
........................ 6-42
Loading
.................................... 4-30
Pressure
.................................... 6-41
Storing
a Flat or Spare ......................... 5-33
TemDerature ................................. 6-45 Treadwe ar
................................... 6-45
Uniform Quality Grading
....................... 6-44
Used Wheel Replacement
...................... 6-47
Wear Indicators
.............................. 6-43
Wheel Replacement
........................... 6-46
When It’s Time for New
....................... 6-43
TopStrap
..................................... 1-88
TorqueLock ................................... 2-37
Torque, Wheel Nut
......................... 5-32, 6-65
Towing a Trailer
................................ 4-33
Towing Your Vehicle
............................. 5-8
Traction Control System .......................... 4-9
Traction Control System Warning Light
........ 2-90, 4-10
Trailer Brakes
..................................... 4-37
Driving on Grades
............................ 4-40
Drivingwith
................................. 4-37
Hitches
..................................... 4-36
Maintenance When Towing
..................... 4-41
ParkingonHills
.............................. 4-40
Safety Chains
................................ 4-37
Tongue Weight
............................... 4-35
Total Weight on Tires
.......................... 4-36
Turnsignals
................................. 4-39
Weight
..................................... 4-34
Towing
..................................... 4-33
Transaxle Fluid, Automatic
....................... 6-18
Transmitters, Keyless Entry
........................ 2-8
Transportation, Courtesy
.......................... 8-8
Trip Computer ................................ 2- 100
Trip Odometer ................................. 2-85
TTYUsers ..................................... 8-4
Turn Signal and Lane Change Signals ............... 2-53 Traciion .................................... 6-45 . 1 .
9-11
_. .
ProCarManuals.com

Turn Signal Reminder Chime ..................... 2-54
Turn SignaVMultifunction Lever ................... 2-53
Turn Signals When Towing a Trailer ................ 4-39
Underbody Flushing Service ..................... 7-32
Underbody Maintenance ......................... 6-54
Underhood Fuse and Relay Center ................. 6-61
Underhood Lamp ............................... 6-11
Vehicle
Control
...................................... 4-6
Damage Warnings .............................. vii
Dimensions
................................. 6-66
Identification Number ......................... 6-56
Loading .................................... 4-30
Storage ..................................... 6-30
Ventilation System ............................... 3-8
Ventilation Tips ................................. 3-9
Visor Vanity Mirrors ............................ 2-78
Visors. Sun .................................... 2-78
warning Devices ............................... 5-2
Warning Lights. Gages and Indicators ............... 2-86
Washer Fluid. Windshield ........................ 6-25
Washing Your Vehicle ........................... 6-52
Weatherstrips .................................. 6-51
Wheel
Alignment
.................................. 6-46
Nut Torque ............................. 5.32. 6.65
Replacement ................................. 6-46
Used Replacement ............................ 6-47
Wrench ..................................... 5-27
Windows ..................................... 2-50
Power ...................................... 2-51
Power Rear Quarter ........................... 2-52
Rear Side Panels .............................. 2-52
SideLatches ................................. 2-51
Windshield Washer ............................. 2-55
Fluid .................................. 2-55. 6-25
Fluid Level Check ............................ 7-29
Rear ....................................... 2-56
Windshield Wiper .............................. 2-54
Rear ....................................... 2-56
Blade Replacement ........................... 6-39
Fuses ...................................... 6-57
Winter Driving ................................. 4-26
Wiper Blade Check ............................. 7-30
Wiring. Headlamp .............................. 6-57
Wrench. Wheel ................................. 5-27
9-12
.. ..
ProCarManuals.com