1998 CHEVROLET CORVETTE automatic transmission

Downloaded from www.Manualslib.com manuals search engine Wheel Nuts
Wheel Nut Torque .......... 100 lb-ft (140 N-m)
Capacities (Approximate)
The following approximate capacities are given in
United States and metric conversions.
Air Conditioning ... See the refrigerant information
label under the hood.
Automatic Transmission
Drain and Refill ................ 5 quarts (4.7 L)
Overhaul
................. 10.8 quarts (10.2 L)
Coolant System
LS 1 (with M30
automatic transmission)
...... 12.6 quarts (1 1.9 L)
LS 1 (with "6
manual transmission)
....... 12.9 quarts ( 12.2 L)
Crankcase
With Filter Change ........... 6.5 quarts (6.1 L)
Fuel Tank ................. 19.1 gallons (72.3 L)
Manual Transmission
Rear Axle (Overhaul)
................ 4.1
quarts (3.8 1 L)
Lubricant
.................. 1.5 quarts (1 -42 L)
Limited Slip Additive ......... 4 ounces (1 18 ml)
Tire Pressures ...... See Tire-Loading Information
label on rear edge of driver's door.
NOTE: All capacities are approximate. When adding,
be sure to fill to the appropriate level, as recommended
in this manual. Recheck fluid level after filling.
Vehicle Dimensions
Wheelbase .............. 104.5 inches (265.4 cm)
Tread
Front .................. 62.1 inches (157.7 cm)
Rear
.................... .62 inches (157.4 cm)
Length ................. 179.7 inches (456.4 cm)
Width ................... 73.6 inches (1 86.9 cm)
Height .................. 47.7 inches (1 21.1 cm)
6-71

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
40,000 Miles (64 000 km)
0 Check the Engine Oil Life Monitor. If engine oil and filter are changed, reset
the Engine Oil Life Monitor. See “Engine Oil” in the Index.
An Emission Control Service. (See footnote *.)
if necessary.
An Emission Control Service. (See footnote “f)
Inspect air cleaner filter if you are driving in dusty conditions. Replace filter
50,000 Miles (80 000 km)
0
0
Check the Engine Oil Life Monitor. If engine oil and filter are changed, reset
the Engine Oil Life Monitor.
See “Engine Oil” in the Index.
An Emission Control Service. (See footnote *.)
Inspect air cleaner filter if you are driving in dusty conditions. Replace filter
if necessary.
An Emission Control Service. (See footnote “f)
Change automatic transmission fluid and filter if the vehicle is mainly driven
under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly reaches 90°F
- In hilly or mountainous terrain.
- Uses such as high performance operation.
If you do not use your vehicle under any of these conditions, change the fluid
and filter at
100,000 miles (166 000 km). Manual transmission fluid doesn’t
require change.
(32 O C) or higher.
I DATE I
DATE
SERVICED
BY
7-7

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
100,000 Miles (160 000 km) (Continued)
0 Change automatic transmission fluid and filter if the vehicle is mainly driven
under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly reaches 90°F
(32 O C) or higher.
- In hilly or mountainous terrain.
- Uses such as high performance operation.
Manual transmission fluid doesn’t require change.
0 If you haven’t used your vehicle under severe conditions listed previously and,
therefore, haven’t changed your automatic transmission fluid, change
both the
fluid and the filter. Manual transmission fluid doesn’t require change.
150,000 Miles (240 000 km)
0 Drain, flush and refill the cooling system (or every 60 months since last
service, whichever occurs first). See “Engine Coolant” in the Index for
what to use.
An Emission Control Sewice.
DATE I
MILEAGE
7-10
I

Downloaded from www.Manualslib.com manuals search engine At Least Twice a Year Automatic Transmission Inspection
Restraint System Check
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages are
working properly. Look for any other loose or damaged
safety belt system parts. If you see anything that might
keep a safety belt system from doing its job, have it
repaired. Have any torn or frayed safety belts replaced.
Also look for any opened or broken
air bag coverings,
and have them repaired or’replaced. (The air bag system
does not need regular maintenance.)
Wiper Blade Check
Inspect wiper blades for wear or cracking. Replace blade
inserts that appear
worn or damaged or that streak or
miss areas of the windshield. Also see “Wiper Blades.
Cleaning” in the Index.
Manual Transmission Check
Check the transmission fluid level; add if needed. See
“Manual Transmission” in the Index. Check for leaks.
A fluid loss may indicate a problem. Have the system
inspected and repaired
if needed. It is
not necessary to check the transmission fluid level.
A transmission fluid leak is the only reason for fluid
loss. Check for leaks.
If a leak occurs, take the vehicle to
your
GM dealership Service Department and have it
repaired as
soon as possible.
At Least Once a Year
Key Lock Cylinders Service
Lubricate the key lock cylinders with the lubricant
specified in Part D.
Body Lubrication Service
Lubricate all body door hinges. Also lubricate all hinges
and latches, including those for the hood, rear
compartment, console door and any folding seat
hardware.
Part D tells you what to use. More frequent
lubrication may be required when exposed to a
corrosive environment.

Downloaded from www.Manualslib.com manuals search engine Starter Switch Check
-
I A CAUTION:
Brake-Transmission Shift Interlock (BTSI) Check (Automatic Transmission)
When you are doing this check, the vehicle could
move suddenly.
If it does, you or others could be
injured. Follow the steps below.
1. Before you start, be sure you have enough room
2. Firmly apply both the parking brake (see “Parking
around the vehicle.
Brake” in the Index if necessary) and the
regular brake.
NOTE:
Do not use the accelerator pedal, and be
ready to turn off the engine immediately if it starts.
3. On automatic transmission vehicles, try to start the
engine in each gear. The starter should work only in
PARK (P) or NEUTRAL (N). If the starter works in
any other position, your vehicle needs service.
On manual transmission vehicles, put the shift lever
in NEUTRAL (N), push the clutch down halfway
and try to start the engine. The starter should work
only when the clutch is pushed down all the way to
the floor.
If the starter works when the clutch isn’t
pushed all the way down, your vehicle needs service.
I A CAUTION:
I
When you are doing this check, the vehicle could
move suddenly.
If it does, you or others could be
injured. Follow the steps below.
1. Before you start, be sure you have enough
room around the vehicle. It should be parked
on a level surface.
2. Firmly apply the parking brake (see “Parking Brake”
in the Index if necessary).
NOTE: Be ready to apply the regular brake
immediately if the vehicle begins to move.
3. With the engine off, turn the key to the ON position,
but don’t start the engine. Without applying the
regular brake, try to move the shift lever out of
PARK (P) with normal
effort. If the shift lever
moves out of PARK (P), your vehicle’s BTSI
needs service.
7-13

Downloaded from www.Manualslib.com manuals search engine Ignition Automatic Transmission Lock Check
While parked, and with the parking brake set, try to turn
the ignition key to
OFF in each shift lever position. The
key should turn to
OFF only when the shift lever is in
PARK (P).
On all vehicles, the key should come out only in
OFF.
Parking Brake and Automatic Transmission
PARK
(P) Mechanism Check
When you are doing this check, your vehicle
could begin to move. You
or others could be
injured and property could be damaged. Make sure there
is room in front of your vehicle in case
it begins to roll. Be ready to apply the regular
brake
at once should the vehicle begin to move. Park on
a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake,
set the parking brake.
0 To check the parking brake’s holding ability: With
the engine running and transmission in
NEUTRAL (N), slowly remove foot pressure from
the regular brake pedal.
Do this until the vehicle is
held by the parking brake only.
To check the PARK (P) mechanism’s holding ability:
With the engine running, shift to PARK (P). Then
release all brakes.
Underbody Flushing Service
At least every spring, use plain water to
flush any
corrosive materials from the underbody. Take care to
clean thoroughly any areas where mud and other debris
can collect.

Downloaded from www.Manualslib.com manuals search engine Part D: Recommended Fluids and
Lubricants
NOTE: Fluids and lubricants identified below by name,
part number
or specification may be obtained from
your dealer.
USAGE
Engine Oil
FLUIDLUBRICANT
The engine requires a special
Engine Oil meeting GM Standard
GM4718M. Oils meeting this
Standard may be identified as
synthetic, and should
also be
identified with the American
Petroleum Institute Certified For Gasoline Engines “Starburst” symbol. However, not all
Synthetic API oils with the
Starburst symbol will meet this
GM Standard. You should look for
and use only an oil that meets GM
Standard GM47 18M. For the
proper viscosity, see “Engine Oil”
in the Index.
USAGE ~~
Engine Coolant
Hydraulic Brake
System
Hydraulic Clutch System
~
Power Steering System
Manual Transmission
Automatic Transmission
FLUIDLUBRICANT
50/50 mixture of clean water
(preferably distilled) and use only
GM Goodwrench@ DEX-COOL@
or Havoline@ DEX-COOL@
Coolant. See “Engine Coolant” in
the Index.
Delco Supreme
11 @ Brake Fluid
(GM Part No. 12377967
or
equivalent DOT-3 Brake Fluid).
Hydraulic Clutch Fluid (GM Part
No. 12345347 or equivalent
DOT-3 Brake Fluid).
GM Synthetic Power Steering
Fluid
(GM Part No. 12345866 or
12345867 or equivalent).
DEXRON@-I11 Automatic
Transmission Fluid. DEXRON@
-111 Automatic
Transmission Fluid.

Downloaded from www.Manualslib.com manuals search engine Section 9 Index
Accessory Outlet .............................. 2-59
Accessory Power Plug
........................... 6-63
Adding Equipment to the Outside of Your Vehicle
...... 6-3
AirBag
....................................... 1-18
How Does it Restrain
.......................... 1-23
How it Works ................................ 1-20
Location
............................... 1.20. 1-21
Servicing
................................... 1-24
What Makes it Inflate
.......................... 1-22
What Will
You See After it Inflates ............... 1-23
When Should it Inflate
......................... 1-22
Air Bag Readiness Light
.................... 1.20. 2.78
AirBagSystem
................................ 1-18
Aircleaner
.................................... 6-16
Air Conditioning
....................... 3.3. 3.7. 3.10
Alignment and Balance. Tire
...................... 6-48
Aluminum Wheels. Cleaning
...................... 6-58
Antenna Integrated
................................... 3-30
PowerMast ................................. 3-29
Antifreeze
..................................... 6-22
Anti-Lock Brakes
...................................... 4-7
Brake System Warning Light
................ 2.78. 4.7
Anti-Lock Brake System Warning Light
............. 2-80
Anti-Theft Radio
............................... 3-25
Appearance Care
............................... 6-52
Appearance Care Materials
....................... 6-6 1
Arbitration Program
.............................. 8-9 Ashtray
....................................... 2-58
Audio Equipment. Adding ........................ 3-27
Automatic
Audio Systems
................................. 3-12
Electronic Dual Climate Control System
............ 3-4
Overdrive
................................... 2-28
Transmission Check
........................... 7-12
Transmission Fluid ............................ 6-18
Transmission. Operation
....................... 2-26
Transmission. Park Mechanism Check
............ 7-14
Transmission. Shifting
......................... 2-26
Transmission. Starting Your Engine
.............. 2-22
Axle. Limited-Slip Rear
......................... 2-39
Axle. Rear
.................................... 6-21
Back-up Lamp Bulb Replacement
................. 6-37
Battery
....................................... 6-32
Jump Starting
................................. 5-3
Replacement. Remote Function Actuation (RFA) System
...................... 2-12
Warnings
................................ 5-3. 5-5
BBB Auto Line ................................. 8-9
Belt. Engine Accessory
.......................... 6-72
Better Business Bureau Mediation
................... 8-9
Blizzard
...................................... 4-26
Brake
Adjustment
.................................. 6-31
Fluid
....................................... 6-29
9-1