1997 FORD AEROSTAR coolant temperature

17 %
*
[IS09500(ALL)05/96]
Fuel Gauge
*
[IS09700(ALL)01/96]
The fuel gauge displays approximately how
much fuel is in the fuel tank only when the
ignition switch is ON.
*
[IS09850(ALL)01/96]
For a proper fuel gauge indication after adding
fuel, the ignition switch should be in the OFF
position while the vehicle is being refueled.
*
[IS09900(ALL)01/96]
The fuel gauge indicator may vary slightly while
the vehicle is in motion. This is the result of fuel
movement within the tank. An accurate reading
may be obtained with the vehicle on smooth,
level ground.
[IS10000(ALL)01/96]
one inch art:0020061-C
Fuel gauge
%*
[IS11100(ALL)03/96]
Engine Coolant Temperature Gauge
*
[IS11201(ALL)02/96]
This gauge indicates the temperature of the
engine coolant, not the coolant level. If the
coolant is not at its proper level or mixture, the
gauge indication will not be accurate.
*
[IS11301(ALL)05/96]
The pointer moves from the C (cold) mark into
the NORMAL band as the engine coolant warms
up. It is acceptable for the pointer to fluctuate
within the NORMAL band under normal driving
conditions. Under certain driving conditions,
such as heavy stop and go traffic or driving up
hills in hot weather, the pointer may move to
the top of the NORMAL band.
*
[IS11401(ALL)04/96]
If, under any circumstances, the pointer moves
above the NORMAL band, the engine is
overheating and continued operation may cause
engine damage.
File:03cpisa.ex
Update:Fri Jun 7 14:23:36 1996

18
*
[IS11501(ALL)03/96]
If your engine overheats:
*
[IS11601(ALL)03/96]
1. Pull off the road as soon as it is safely
possible.
*
[IS11701(ALL)01/96]
2. Turn off the engine.
*
[IS11801(ALL)03/96]
3. Let the engine cool.DO NOT REMOVE
COOLANT SYSTEM FILL CAP UNTIL
THE ENGINE IS COOL.
*
[IS11901(ALL)01/96]
4. Check the coolant level following the
instructions on checking and adding coolant
to your engine. Refer toEngine coolantin the
Index. If you do not follow these
instructions, you or others could be injured.
[IS12325(ALL)01/96]
quarter page art:0020541-B
Engine coolant temperature gauge
%*
[IS12601(ALL)03/96]
Speedometer
*
[IS12700(ALL)03/96]
The speedometer tells you how many miles
(kilometers) per hour your vehicle is moving.
*
[IS12750(ALL)03/96]
Your vehicle contains a speedometer which
receives its input from the Anti-Lock brake
sensor. The speedometer is also used to provide
a speed signal for correct operation of the
vehicle's Powertrain Control Module (PCM),
electronic transmission, and speed control (if so
equipped). Because of this, it is very
IMPORTANT to change the speedometer's
internal conversion constant if the size of the
tires on the vehicle is changed. Changing the
conversion constant to the proper value when
File:03cpisa.ex
Update:Fri Jun 7 14:23:36 1996

157
*
[TO07450(ALL)01/96]
RWARNING
Do not park, idle, or drive your vehicle in
dry grass or other dry ground cover. The
emission system heats up the engine
compartment and exhaust system, which
can start a fire.
*
[TO07500(ALL)01/96]
If you consistently start your vehicle in subzero
temperatures, use an engine block heater (if
your vehicle has this option).
%*
[TO07600(ALL)01/96]
Engine Block Heater (If equipped)
*
[TO07700(ALL)01/96]
Engine block heaters are strongly recommended
if you live in a region where temperatures reach
-10ÊF (-23ÊC) orbelow. An engine block heater
warms the engine coolant, which improves
starting, warms up the engine faster, and allows
the heater-defrost system to respond quickly.
*
[TO08000(ALL)01/96]
RWARNING
To prevent electrical shock, do not use
your heater with ungrounded electrical
systems or two-pronged (cheater) adapters.
*
[TO08100(ALL)01/96]
For best results, plug the heater in at least three
hours before you start your vehicle. Using the
heater for longer than three hours will not
damage the engine, so you can plug it in at
night to start your vehicle the following
morning.
*
[TO08150(ALL)01/96]
NOTE: Be sure to disconnect the engine block
heater before driving your vehicle.
File:08cptoa.ex
Update:Thu Jun 6 14:43:40 1996

243
*
[MC08835(ALL)05/96]
Always dispose of used automotive fluids in a
responsible manner. Follow your community's
regulations and standards for recycling and
disposing of automotive fluids.
*
[MC08840(ALL)05/96]
Coolant refill capacity
*
[MC08845(ALL)05/96]
To find out how much fluid your vehicle's
cooling system can hold, refer toRefill capacities
in theCapacities and specificationschapter.
*
[MC08850(ALL)05/96]
Have your dealer check the engine cooling
system for leaks if you have to add more than a
quart (liter) of engine coolant per month.
*
[MC08855(ALL)05/96]
Severe winter climate
[MC08860(ALL)01/96]
If you drive in extremely cold climates (less than
S34ÊF (S38ÊC), it may be necessary to increase
the coolant concentration above 50%. Refer to
the chart on the coolant container to ensure the
coolant concentration in your vehicle is such that
the coolant will not freeze at the temperature
level in which you drive during winter months.
Never increase the engine coolant concentration
above 60%. Leave a 50/50 mixture of engine
coolant and water in your vehicle year-round in
non-extreme climates.
%*
[MC08865(ALL)01/96]
Checking Hoses
*
[MC08870(ALL)01/96]
Inspect all engine and heater system hoses for
deterioration, leaks and loose clamps before
adding or replacing engine coolant. Make
whatever repairs or replacements that are
necessary using Motorcraft parts or their
equivalents.
%*
[MC08875(ALL)05/96]
Engine Coolant Drain and Flush
[MC08915(ALL)05/96]
Proper procedures for flushing the cooling
system can be found in theService Manual,or
you can see a qualified technician.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996

244 [MC08970(ALL)04/96]NOTE: Due to air being trapped in the 4.0L
engine cooling system, it is not
unusual to experiencea4to7ounce
(120 to 210 ml) coolant loss up to 7,500
miles (12,000 km) after initial system
fill.
%
*
[MC09000(ALL)01/96]
Power Steering Fluid
*
[MC09020(ALL)01/96]
Check the level of the power steering fluid at
least twice a year (i.e., every Spring and Fall).
%*
[MC09030(ALL)01/96]
Checking and Adding Power Steering
Fluid
*
[MC09035(ALL)04/96]
1. Start the engine and let it run until the
power steering fluid reaches normal
operating temperature. The power steering
fluid will be at the right temperature when
the engine coolant temperature gauge in the
instrument cluster is near the center of the
NORMAL operating temperature range.
*
[MC09040(ALL)01/96]
2. While the engine idles, turn the steering
wheel back and forth several times. Make
sure that the cap assembly is installed at this
time.
*
[MC09045(ALL)01/96]
3. Turn the engine off.
%*
[MC09050(ALL)01/96]
4. Check the fluid level on the dipstick (which
is highlighted in yellow in your vehicle). The
fluid level should be between the arrows in
the FULL HOT range, which is marked on
the side of the dipstick, opposite the side
marked FULL COLD. Do not add fluid if the
level is within the FULL HOT range.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996

Index 339
Cleaning your vehicle (continued)
plastic parts............. 281
polishing............... 280
rear windows............. 70
rustproofing............. 280
safety belts.............. 283
tail lamps.............. 281
upholstery and interior trim...... 282
washing............... 280
waxing............... 280
wheels................ 281
windows................ 70
Climate control system
air conditioning............ 62
heating................ 62
heating only system........... 65
Clock................ 28,44
Cold engine starting........... 154
Combination lap and shoulder belts . 108, 110
Compact disc player
(see Electronic sound system).... 22,29
Compact disc radio
(see Electronic sound system)...... 22
Console, description............ 92
Controls, mirrors............. 91
Convenience kit in cargo area...... 211
Coolant (see Engine coolant)
checking and adding......... 240
drain and flush............ 243
preparing for storage......... 285
refill capacities............ 294
specifications............. 296
temperature gauge........... 17
warnings............... 240
Cooling fan............... 230
Crankcase emission filter......... 293
Customer Assistance Center, Ford (U.S.). . 305
Customer Assistance Centre,
Ford of Canada..........305, 310
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996

Index 341
Emergency brake (parking brake)..... 165
Emission control system
catalytic converter.......... 269
emissions warranty......... 3,269
Engine
check engine warning light....... 12
does not start............ 158
fuel injected engine, starting...... 153
fuel pump shut-off switch....... 158
preparing to start........... 153
refill capacities............ 294
service points............ 297
starting............... 154
starting after a collision........ 158
storing your vehicle.......... 283
Engine block heater........... 157
Engine coolant
checking and adding......... 240
checking hoses............ 243
disposal.............230, 248
drain and flush............ 243
preparing for storage......... 285
proper solution..........230, 248
recovery reservoir........240, 297
refill capacities............ 294
specifications............. 296
temperature gauge........... 17
Engine coolant temperature gauge
description............... 17
mechanical............... 17
Engine coolant temperature
gauge:electronic............. 17
Engine fan............... 230
Engine:idle speed control........ 156
Engine knocking............ 264
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996

344 Index
G
Gas cap (see Fuel cap).......... 260
Gas mileage (see Fuel economy) . . . 264, 268
Gasohol................ 265
Gasoline (see Fuel)............ 260
Gauges, Mechanical
battery voltage gauge.......... 15
charging system gauge......... 15
engine coolant temperature gauge.... 17
engine oil pressure gauge........ 16
fuel gauge............... 17
odometer................ 20
speedometer.............. 18
trip odometer.............. 20
GAWR (Gross Axle Weight Rating)
calculating.............. 187
definition.............179, 185
driving with a heavy load....... 179
location............... 185
Gearshift
automatic operation.......... 170
column-mounted........... 170
gearshift override.........155, 171
locking the gearshift........... 74
positions............... 170
shifting the gears........... 170
shift-lock.............155, 171
Gearshift:shifting the gears........ 170
GVWR (Gross Vehicle Weight Rating)
calculating.............. 187
definition.............179, 184
driving with a heavy load....... 179
location............... 185
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996