1997 FORD AEROSTAR lock

267
*
[MC36800(ALL)01/96]
To fill the fuel tank properly:
*
[MC36900(ALL)01/96]
NOTE: Extinguish all lit cigarettes, other
smoking materials, and any open
flames before fueling your vehicle.
*
[MC37000(ALL)01/96]
1. Remove the fuel cap by following the
instructions above underRemoving the Fuel
Capin this chapter. Proceed to add fuel to
the tank only if your vehicle is on level
ground.
*
[MC37010(ALL)01/96]
2. Make sure that you pump unleaded fuel and
put the nozzle all the way inside the fuel
filler pipe.
*
[MC37020(ALL)01/96]
3. If you spill any fuel on the body of your
vehicle, clean it off immediately. The fuel
may dull or soften the paint if you do not
wash it off.
[MC37030(ALL)05/96]
4. Replace the fuel cap completely when you
are finished. Turn it clockwise until it is fully
tight. It will click when it is fully tightened.
*
[MC37040(ALL)01/96]
You may occasionally hear and/or feel a slight
thump occurring one or two seconds after a
gentle stop. This is normal and generally occurs
with the fuel tank 3/4 full. It is caused by the
wave action of the fuel within the tank.
%*
[MC37050(ALL)01/96]
Running Out of Fuel
*
[MC37060(ALL)01/96]
If your vehicle runs out of fuel, try to stop on
level ground away from traffic. Add at least two
gallons (8 liters) of fuel to start your vehicle
again. If your vehicle is not on level ground,
you may need as much as five gallons (20 liters)
of fuel to start it.
*
[MC37070(ALL)08/95]
NOTE: Avoid running out of fuel because this
situation may have an adverse effect on
modern powertrain components.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996

282
*
[MC50320(ALL)01/96]
q
Extreme care must be used if a power washer
is used to clean the engine. The high pressure
fluid could penetrate sealed parts and
assemblies causing damage or malfunctions.
[MC50330(ALL)01/96]
q
In order to avoid possible cracking of the
engine block, do not spray a hot engine with
cold water.
[MC50340(ALL)01/96]
q
The alternator and air intake must be
covered. Covering these components will help
prevent water damage.
*
[MC50350(ALL)01/96]
q
Never wash or rinse the engine while it is
running. Water getting into the engine may
cause internal damage.
*
[MC50400(ALL)02/96]
Cleaning the Instrument Panel Lens
*
[MC50410(ALL)01/96]
Clean the instrument panel lens with a soft cloth
and a glass cleaner, such as Ford Ultra-Clear
Spray Glass Cleaner, or equivalent. Do not use
paper towel or an abrasive cleaner to clean the
lens as these may cause scratches.
%*
[MC50475(ALL)02/96]
Cleaning the Interior Lamps
*
[MC50490(ALL)02/96]
Your interior dome lamps and map lamps are
plastic and should be cleaned with a mild
detergent diluted in water. Rinse them with clear
water.
%*
[MC50500(ALL)03/96]
Cleaning the Seats
*
[MC50520(ALL)01/96]
Vinyl
*
[MC50530(ALL)01/96]
For routine cleaning, wipe the surface with a
soft, damp cloth. For more thorough cleaning,
wipe the surface with a leather and vinyl cleaner
or a mild soap.
%*
[MC50550(ALL)05/96]
Fabric
*
[MC50560(ALL)05/96]
Remove dust and loose dirt with a whisk broom
or a vacuum cleaner. Remove fresh spots
immediately. Follow the directions that come
with the cleaner.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996

300
%*
[CS55000(ALL)01/96]
Your Vehicle Identification
Number (VIN)
*
[CS55100(ALL)04/96]
You should include your Vehicle Identification
Number (VIN) any time you write to Ford
Motor Company about your vehicle.
*
[CS55200(ALL)03/96]
The Vehicle Identification Number is attached to
your vehicle in the following places:
*
[CS55300(ALL)03/96]
q
on the metal tag attached to the top of the
instrument panel on the driver's side Ð you
can see the tag by looking through the
windshield from outside your vehicle.
*
[CS55400(ALL)03/96]
one inch art:0010558-A
Vehicle Identification Number (VIN/Serial Number)
%*
[CS55500(ALL)03/96]
q
on the Safety Compliance Certification Label
Ðthis label is attached to the left front door
lock facing or the door latch post pillar. It is
required by the National Highway Traffic
Safety Administration and is made of special
material. If someone tampers with it, it will
be destroyed and/or a destruction pattern
will appear.
*
[CS55600(ALL)01/96]
The label contains the name of the manufacturer,
the month and year of manufacture, the
certification statement and the Vehicle
Identification Number. The label also contains
Gross Vehicle Weight Rating and Gross Axle
Weight Ratings, wheel and tire data and
information codes for additional vehicle data.
For further information about the Safety
Compliance Certification Label and the
information contained on it, refer to the Index.
File:12cpcsa.ex
Update:Thu Jun 6 14:45:39 1996

303
Customer Assistance
%*
[HS00205(ALL)05/96]
Roadside Assistance
*
[HS00210(ALL)11/95]
Ford Motor Company has set up a 24-hour,
seven-day-a-week hotline with trained operators
who put you in touch with the help you need if
you experience a problem with your vehicle.
This complimentary service is provided to you
throughout your warranty period of 3 years or
36,000 miles (60,000 km), whichever comes first.
To purchase Roadside Assistance coverages
beyond this period (available through Ford Auto
Club in the United States or Ford and
Lincoln-Mercury dealers in Canada), contact
your Ford or Lincoln-Mercury dealer. Additional
Roadside Assistance coverage is unavailable in
Puerto Rico and the Virgin Islands.
*
[HS00215(ALL)06/94]
Roadside Assistance will cover the following:
*
[HS00220(ALL)06/94]
q
Mount your spare if you have a flat tire.
*
[HS00225(ALL)06/94]
q
Jump-start your battery if it is dead.
*
[HS00230(ALL)06/94]
q
Unlock your vehicle if you are locked out.
*
[HS00235(ALL)06/94]
q
Bring you fuel if you run out.
*
[HS00240(ALL)06/94]
q
Tow your vehicle if you are stranded. Even
non-warranty related tows, like accidents or
getting stuck in mud or snow, are covered
(some exclusions apply, such as impound
towing and repossession).
File:14cphsa.ex
Update:Thu Jun 6 14:45:58 1996

336 Index
Autolamp system (see Headlamps)..... 72
Automatic transmission
fluid, adding............. 248
fluid, checking............ 247
fluid, refill capacities......... 294
fluid, specification........... 296
Axle
lubricant specifications......... 296
refill capacities............ 294
traction lok............177, 254
B
Basic vehicle warranty........... 3
Battery
acid, treating emergencies.....223, 250
charging system warning light...... 13
disconnecting............. 226
how to service............ 249
jumping a disabled battery....... 222
maintenance-free........... 249
proper disposal, recycling....... 250
replacement, specifications....... 293
servicing............... 249
voltage gauge............ 13,15
when storing your vehicle....... 285
Brake fluid
brake warning light........... 9
checking and adding......... 236
description.............. 236
specifications...........237, 296
Brakelamp, high-mount brakelamp..... 72
Brakes
adjustment.............. 163
anti-lock............... 163
applying the brakes.......... 166
brake warning light........... 9
fluid, checking and adding....... 236
fluid, refill capacities.......236, 294
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996

Index 337
Brakes (continued)
fluid, specifications........237, 296
front disc.............. 163
if brakes do not grip well.....164, 166
master cylinder............ 236
new brake linings............ 5
noise..............163, 165
parking............... 166
power braking............ 163
rear anti-lock............. 164
servicing.............164, 236
stopping distances.......... 165
trailer................ 195
when storing your vehicle....... 285
Brake-shift interlock.........155, 171
Break-in period.............. 5
Brights (high beams)........... 14
Built-in child seat
cleaning............... 283
operation.............. 141
Bulbs, replacing
halogen............... 272
headlamps.............. 272
C
Canada, customer assistance....... 310
Canada, warranty information....... 3
Canadian Motor Vehicle Arbitration Plan
(CAMVAP).............. 311
Capacities for refilling fluids....... 294
Carbon monoxide in exhaust....... 160
Car seats for children (see Child safety seats) 130
Cassette tape player (see Electronic sound
system).............. 35,49
Catalytic converter........... 269
CD player (see Electronic sound system) . . 29
Chains, tires.............. 259
Changing a tire............. 209
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996

338 Index
Charging system gauge.......... 15
Charging system warning light....... 13
Child safety restraints
built-in child seat........... 141
child safety belts........... 150
child safety seats........... 130
Child safety seats
and air bags............. 130
attaching with tether straps...... 139
automatic locking mode (retractor) . 112, 130
built-in child seat........... 141
in front seat............. 130
in rear outboard seat......... 130
in rear seat.............. 130
tether anchorage hardware....... 139
Chime
headlamps on.............. 14
key in ignition............. 14
safety belt............... 11
Circuit breakers
checking and replacing........ 209
see also fuses............. 200
Cleaning your vehicle
built-in child seat........... 283
CD player and discs........... 32
chrome and aluminum parts...... 280
engine compartment.......... 281
exterior............... 280
exterior lamps............ 281
fabric................ 282
headlamps.............. 281
instrument panel......... 61,281
instrument panel lens......... 282
interior................ 282
interior lamps............. 282
mirrors................. 91
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996

Index 339
Cleaning your vehicle (continued)
plastic parts............. 281
polishing............... 280
rear windows............. 70
rustproofing............. 280
safety belts.............. 283
tail lamps.............. 281
upholstery and interior trim...... 282
washing............... 280
waxing............... 280
wheels................ 281
windows................ 70
Climate control system
air conditioning............ 62
heating................ 62
heating only system........... 65
Clock................ 28,44
Cold engine starting........... 154
Combination lap and shoulder belts . 108, 110
Compact disc player
(see Electronic sound system).... 22,29
Compact disc radio
(see Electronic sound system)...... 22
Console, description............ 92
Controls, mirrors............. 91
Convenience kit in cargo area...... 211
Coolant (see Engine coolant)
checking and adding......... 240
drain and flush............ 243
preparing for storage......... 285
refill capacities............ 294
specifications............. 296
temperature gauge........... 17
warnings............... 240
Cooling fan............... 230
Crankcase emission filter......... 293
Customer Assistance Center, Ford (U.S.). . 305
Customer Assistance Centre,
Ford of Canada..........305, 310
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996