1997 FORD AEROSTAR lights

153
Starting
%*
[TO04800(ALL)01/96]
Fuel-Injected Engines
*
[TO04900(ALL)01/96]
When starting a fuel-injected engine,the most
important thing to remember is to avoid
pressing down on the accelerator before or
during starting. Only use the accelerator when
you have problems getting your vehicle started.
SeeStarting Your Enginein this chapter for
details about when to use the accelerator while
you start your vehicle.
*
[TO05150(ALL)01/96]
Starting Your Vehicle
%*
[TO05200(ALL)01/96]
Preparing to Start Your Vehicle
*
[TO05300(ALL)02/96]
RWARNING
Do not start your vehicle in a closed
garage or in other enclosed areas. Exhaust
fumes can be toxic. Always open the
garage door before you start the engine.
*
[TO05400(ALL)01/96]
Before you start your vehicle, do the following:
*
[TO05500(ALL)01/96]
1. Make sure all occupants in the vehicle
buckle their safety belts. SeeSafety Restraints
in the Index for more details.
*
[TO05600(ALL)01/96]
2. Make sure the headlamps and other
accessories are turned off when starting.
*
[TO05750(ALL)01/96]
3. Make sure that the gearshift is in P (Park)
and the parking brake is set before you turn
the key.
*
[TO06015(ALL)02/96]
Before you start your vehicle, you should test
the warning lights on the instrument panel to
make sure that they work. Refer to the
Instrumentationchapter.
File:08cptoa.ex
Update:Thu Jun 6 14:43:40 1996

159
*
[TO08560(ALL)03/96]
If your engine cranks but does not start after a
collision or substantial jolt:
*
[TO08570(ALL)01/96]
1. Turn the ignition key to the OFF position.
*
[TO08580(ALL)03/96]
2. Check under the vehicle for leaking fuel.
*
[TO08590(ALL)01/96]
3. If you do not see or smell fuel, push the red
reset button down. If the button is already
set, you may have a different mechanical
problem.
*
[TO08600(ALL)01/96]
4. Turn the ignition key to the ON position for
a few seconds, then turn it to the OFF
position.
*
[TO08610(ALL)03/96]
5. Check under the vehicle again for leaking
fuel.If you see or smell fuel, do not start
your vehicle again.If you do not see or
smell fuel, you can try to start your vehicle
again.
*
[TO08620(ALL)01/96]
6. Check all vehicle warning lights before
driving the vehicle.
[TO08630(ALL)04/96]
quarter page art:0020107-A
Reset button for fuel pump shut-off switch
*
[TO09200(ALL)02/96]
RWARNING
Do not start your vehicle in a closed
garage or in other enclosed areas. Exhaust
fumes can be toxic. Always open the
garage door before you start the engine.
File:08cptoa.ex
Update:Thu Jun 6 14:43:40 1996

222
*
[ER24200(ALL)01/96]
Also retighten to the specified torque at 500
miles (800 km) of operation after any wheel
change or any time the lug nuts are loosened.
*
[ER24301(ALL)01/96]
RWARNING
Failure to retighten wheel lug nuts at
mileages specified could allow wheels to
come off while the vehicle is in motion.
[ER24315(ALL)01/96]
eight pica chart:0020313-A%*
[ER24400(ALL)02/96]
Jump-Starting Your Vehicle
*
[ER24410(ALL)02/96]
Your vehicle's battery may die if you leave the
lights on or any electrical equipment on after
you turn the engine off. If this happens, you
may be able to jump-start your vehicle with a
booster battery.
*
[ER24420(ALL)02/96]
RWARNING
The gases around the battery can explode
if exposed to flames, sparks, or lit
cigarettes. An explosion could result in
injury or vehicle damage.
*
[ER24430(ALL)02/96]
RWARNING
To protect yourself when charging a
battery, always shield your face and eyes.
Make sure that you can breathe fresh air.
File:10cpera.ex
Update:Thu Jun 6 14:45:00 1996

236
*
[MC07200(ALL)05/96]
one third page art:0060618-C
Oil change intervals
*
[MC07300(ALL)05/96]
Refer to theMaintenance Schedulebooklet for
additional information.
%
*
[MC08000(ALL)05/96]
Brake Fluid
*
[MC08025(ALL)01/96]
Your vehicle is equipped with a brake fluid level
indicator in the master cylinder which lights the
BRAKE warning light on the instrument panel
when the brake fluid level is low.
*
[MC08050(ALL)01/96]
Under normal circumstances, your vehicle
should not use up brake fluid rapidly. However,
expect the level of the brake fluid to slowly fall
as you put more mileage on your vehicle and
the brake pads wear.
*
[MC08075(ALL)01/96]
Check the brake fluid at least once a year. You
can do this by looking at the fluid level in the
plastic brake fluid reservoir on the master
cylinder. The fluid level should be at or near the
MAX mark.
*
[MC08090(ALL)01/96]
RWARNING
Brake fluid is toxic.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996

272authorized service center can perform a detailed
OBD II drive cycle as it would any other type of
repair work.
%
*
[MC44600(ALL)03/96]
Lights and Bulb Replacement
*
[MC44700(ALL)01/96]
It is a good idea to check the operation of the
following lights frequently:
*
[MC44800(ALL)01/96]
q
headlamps
*
[MC44850(ALL)01/96]
q
high-mount brakelamp
*
[MC44900(ALL)01/96]
q
tail lamps
*
[MC45000(ALL)01/96]
q
brakelamps
*
[MC45100(ALL)01/96]
q
hazard flasher
*
[MC45200(ALL)01/96]
q
turn signals
*
[MC45300(ALL)05/96]
q
license plate lamps
%*
[MC45400(ALL)01/96]
The alignment of your headlamps should be
checked if:
*
[MC45500(ALL)01/96]
q
oncoming motorists frequently signal you to
turn off your vehicle's high beams when you
do not have the high beams on
*
[MC45600(ALL)01/96]
q
the headlamps do not seem to give you
enough light to see clearly at night
*
[MC45700(ALL)01/96]
q
the headlamp beams are pointed substantially
away from a position slightly down and to
the right
%*
[MC45800(ALL)01/96]
Headlamp Bulb
*
[MC45900(ALL)03/96]
The headlamps on your vehicle use replaceable
bulbs. When the lamp burns out, simply replace
the bulb, rather than the whole lamp.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996

Index 345
H
Hazard flashers............ 78,199
Headlamps
aiming................ 272
checking alignment.......... 272
cleaning............... 281
daytime running lights......... 72
replacing bulbs............ 272
turning on and off........... 71
warning chime............. 14
Heating
heating and air conditioning system . . . 62
rear seat controls............ 67
standard heater system......... 65
High beams
indicator light............. 14
operation............... 71
High-mount brakelamp, description..... 72
High-mount brakelamp:location...... 72
Hitch................. 194
Hood
latch location............. 231
lubrication specifications........ 296
release lever............. 231
working under the hood....... 230
Hoses, checking............. 243
I
Identification Number, Vehicle (VIN) . . . 300
Idle
relearning..........226, 230, 250
speed................ 156
Ignition
chime................. 14
positions of the ignition......... 74
Indicator lights and chimes (see Lights) . . . 7
Infant seats (see Safety seats).....128, 130
Instrument cluster............. 9
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996

346 Index
Instrument panel............. 59
cleaning............... 282
registers................ 61
Integrated child seat
(see Built-in child seat)........ 141
Interval wipers.............. 76
J
Jack
operation.............216, 219
positioning............216, 219
storage................ 211
Jump-starting your vehicle
attaching cables............ 224
disconnecting cables.......... 226
K
Keys
key in ignition chime.......... 14
positions of the ignition......... 74
stuck in lock position.......... 74
L
Lamps
checking............... 272
daytime running light system...... 72
hazard flashers.......... 78,199
headlamps............... 71
high-mount brakelamp......... 72
illuminated entry system......... 73
interior lamps.............. 71
replacing bulbs............ 272
trailer................ 195
Lane change indicator (see Turn signal) . . . 75
Lap belts................ 116
Lights, warning and indicator
airbag................. 13
brake................. 9
charging system............. 13
check engine.............. 12
door ajar................ 11
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996

Index 347
Lights, warning and indicator (continued)
engine oil pressure........... 16
hazard warning light........ 78,199
high beam............... 14
oil pressure.............. 16
safety belt............... 11
service engine soon........... 12
turn signal indicator.......... 75
Load limits
GAWR................ 179
GVWR................ 179
trailer towing............. 181
Lubricant specifications......... 296
Lug nuts
standard............... 219
tightening sequence........216, 221
Lumbar support, seats.......... 106
Lumbar support pad.......... 106
M
Maintenance schedule and record
(see separate Maintenance Schedule
and Record booklet).......... 3
Maintenance (see Servicing)....... 229
Manual transmission
fluid capacities............ 294
lubricant specifications........ 296
Master cylinder, brakes......... 236
Methanol in fuel............ 265
Mileage, calculating fuel economy.... 268
Mirrors
dual electric remote control....... 91
rearview................ 91
side view mirrors............ 91
side view mirrors (power)........ 91
Motorcraft parts............. 293
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996