1997 DODGE NEON warning

Downloaded from www.Manualslib.com manuals search engine There are two switches used in this system and
they are wired in parallel form. A parking brake
switch located on the parking brake mechanism will
illuminate the lamp if the normally OPEN switch is
CLOSED. This switch is case grounded.
The other switch used is the brake warning lamp
switch. This switch is normally OPEN. When the
brake system pressure is below a predetermined level
the switch CLOSES and completes a path to ground
from the G9 circuit at the cluster, through the
switch, to the left headlamp ground.
ANTI-LOCK WARNING LAMP
The Anti-Lock warning lamp is used to alert the
driver of a problem in the ABS system. When the
ABS controller determines a problem in the system it
grounds the G19 circuit and illuminates the lamp.
HELPFUL INFORMATION
²Check the 5 amp fuse in cavity 11 of the fuse
block.
²Check the 4 amp fuse in cavity 12 of the fuse
block.
²Check the Ignition-Off Draw fuse in the PDC.
²Check for a good ground at the instrument panel
left center support.
²For additional diagnostic tests refer to the
appropriate section of the Service Manual.
PL8W - 40 INSTRUMENT CLUSTER 8W - 40 - 9
DESCRIPTION AND OPERATION (Continued)

Downloaded from www.Manualslib.com manuals search engine 8W-43 AIRBAG SYSTEM
INDEX
page
SCHEMATICS AND DIAGRAMS........................................................... 1
DESCRIPTION AND OPERATION.......................................................... 5
Component Page
Airbag Control Module............8W-43-2, 3, 4
Airbag Warning Lamp.................8W-43-3
Data Link Connector..................8W-43-2
Driver Side Airbag...................8W-43-4
Fuse 12 (FB)........................8W-43-2
Fuse Block.........................8W-43-2Component Page
G202..............................8W-43-2
Instrument Cluster...................8W-43-3
Left Airbag Impact Sensor.............8W-43-3
Passenger Side Airbag.................8W-43-4
Right Airbag Impact Sensor............8W-43-3
8W - 43 - 2 8W - 43 AIRBAG SYSTEMPL

Downloaded from www.Manualslib.com manuals search engine C19
CLUSTER INSTRUMENT
1FRONT
RIGHT
IMPACT
SENSOR SENSORIMPACTRIGHT FRONT
2
SENSOR IMPACT
AIRBAG
RIGHT LEFT
AIRBAG
IMPACT
SENSOR
2LEFT
RIGHT
IMPACT
SENSOR SENSORIMPACTRIGHTLEFT
1
3
LINE 1
LEFT
IMPACT
SENSORAIRBAG
WARNING
LAMP
DRIVER LINE 2
48
LINE 2
SENSORIMPACTRIGHTLINE 1
79
AIRBAG
CONTROL
MODULE
R47
18
DB/LB
R47
18
DB/LB
151678C101
R49
18
LB
R49
18
LB
R46
18
BR/LB
R46
18
BR/LB
R48
18
TN
R48
18
TNR41
18
BK/TN
SENSORIMPACTLEFT RIGHT
IMPACT
SENSOR
AIRBAG
WARNING
LAMP(8W-40-5)
(8W-40-5)
PL-RHD8W-43 AIRBAG SYSTEM 8W - 43 - 3
PLR04302978W-1

Downloaded from www.Manualslib.com manuals search engine 8W-43 AIRBAG SYSTEM
DESCRIPTION AND OPERATION
AIRBAG CONTROL MODULE (ACM)
Two different circuits supply battery voltage from
the fuse block to the Airbag Control Module (ACM),
F15 and F25. The F15 and F25 circuits are connected
to separate bus bars internal to the fuse block. Dif-
ferent circuits from the Power Distribution Center
(PDC) and ignition switch supply battery voltage to
the fuse block bus bars.
The F25 circuit supplies battery voltage to the
ACM only when the ignition switch is in the RUN
position. The F15 circuit powers the ACM when the
ignition switch is in either the START or RUN posi-
tion.
An internal bus bar in the ignition switch connects
the A1 circuit from the PDC to the A21 circuit when
the switch is either the START or RUN position. The
A21 circuit supplies battery voltage to the bus bar in
the fuse block that feeds the F15 circuit. A 30 amp
fuse in the PDC protects the A1 and A21 circuits. A
10 amp fuse in the fuse block, cavity 9, protects the
F15 circuit.
When the ignition switch is in the RUN position, it
connects the A2 circuit from the PDC to the A22 cir-
cuit. The A22 circuit supplies battery voltage to the
fuse block bus bar that feeds the F25 circuit. A 40
amp fuse in the PDC protects the A2 and A22 cir-
cuits. A 10 amp fuse in the fuse block, cavity 5, pro-
tects the F25 circuit.
Circuits D1 and D2 are connected to the CCD Bus
and the ACM. The CCD bus is used to provide com-
munications between modules and the universal data
link connector.
The ACM has a case ground and an external dedi-
cated ground, circuit Z6. The dedicated ground con-
nects to the instrument panel right center support.
AIRBAG IMPACT SENSOR
The Airbag system uses a sensor internal to the
Airbag Control Module (ACM) to detect impact. For
information regarding operation of this sensor, refer
to the appropriate group of the Service Manual.
AIRBAG SQUIB (AIRBAG IGNITER)
DRIVERS SIDE AIRBAG
Two circuits, R43 and R45, connect the ACM to the
drivers side airbag module squib (igniter) after pass-
ing through the clock spring connector. Circuit R43
from cavity 3 of the ACM 4-way connector connects
to the squib. Circuit R45 from cavity 4 of the ACM
4-way connector connects to the squib. R43 and R45
are a twisted pair of wires.
PASSENGERS SIDE AIRBAG
Two circuits, R42 and R44, connect the ACM to the
passengers side airbag module squib (igniter). Circuit
R42 from cavity 1 of the ACM 4-way connector con-
nects to the squib. Circuit R44 from cavity 2 of the
ACM 4- way connector connects to the squib. R42
and R44 are a twisted pair of wires.
Circuits R50 and R51 are connected from the ACM
to the passangers airbag. These circuits are used to
monitor the pressure switch.
AIRBAG WARNING LAMP
The Airbag Warning lamp is used to alert the oper-
ator of a problem with the Airbag system. The lamp
is illuminated when the Airbag Control Module
(ACM) grounds the R41 circuit. Refer to the appro-
priate section of the Service Manual or Diagnostic
Test Procedures Manual to diagnosis this system.
HELPFUL INFORMATION
²Check for blown fuses in the circuit that connect
to the ignition switch and those that connect to the
ACM.
²While the bus bars in the fuse block power the
ACM, they also feed additional components on sepa-
rate fuse protected circuits.
²The ACM has a case ground and an external
dedicated ground. The dedicated ground connects to
the instrument panel right center support.
PL8W - 43 AIRBAG SYSTEM 8W - 43 - 5

Downloaded from www.Manualslib.com manuals search engine AC262
SWITCH IGNITION
SWITCH LAMP
WARNING
BRAKE INSTRUMENT
CLUSTER PARK
BRAKE
SWITCH
S208
G9
20
GY/BKG9
20
GY/BK
G9
22
GY/BK
G9
22
GY/BKG9
22
GY/BK
2C103
(8W-10-5)
(8W-40-5) (8W-40-5)
(8W-40-5)
PL-RHD8W-70 SPLICE INFORMATION 8W - 70 - 3
PLR07002978W-1

Downloaded from www.Manualslib.com manuals search engine 8W-80 CONNECTOR PIN-OUTS
INDEX
page
SCHEMATICS AND DIAGRAMS........................................................... 1
Component Page
A/C Compressor Clutch................8W-80-4
A/C Cycling switch...................8W-80-4
A/C-Heater Blower Motor..............8W-80-4
A/C-Heater Control Switch.............8W-80-4
A/C High Pressure Switch..............8W-80-4
A/C Low Ptressure Switch..............8W-80-5
ABS Hydraulic Modulator..............8W-80-5
ABS Relay Box......................8W-80-5
Airbag Control Module................8W-80-5
Ash Receiver lamp...................8W-80-6
Back-Up Lamp Switch (MTX)...........8W-80-6
Battery Temperature Sensor............8W-80-6
Blower Motor Resister Block............8W-80-6
Brake Warning Lamp Switch...........8W-80-6
C101..............................8W-80-7
C102..............................8W-80-7
C103..............................8W-80-7
C105..............................8W-80-8
C108..............................8W-80-8
C160..............................8W-80-8
C161..............................8W-80-8
C203..............................8W-80-9
C205..............................8W-80-9
C206..............................8W-80-9
C225..............................8W-80-9
C230.............................8W-80-10
C231.............................8W-80-10
C241.............................8W-80-10
C301.............................8W-80-11
C303.............................8W-80-11
C309.............................8W-80-11
C315.............................8W-80-11
C323.............................8W-80-11
C324.............................8W-80-11
C325.............................8W-80-12
C340.............................8W-80-12
C341.............................8W-80-12
Camshaft Position Sensor.............8W-80-12
Clockspring........................8W-80-12
Clutch Pedal Position Switch (MTX).....8W-80-12
Controller Anti-Lock Brake............8W-80-13
Crankshaft Position Sensor............8W-80-14
Data Link Connector.................8W-80-14
Dome Lamp........................8W-80-14
Downstream Heated Oxygen Sensor.....8W-80-15Component Page
Driver Side Airbag..................8W-80-15
Duty Cycle Evap/Purge Solenoid........8W-80-15
EGR Transducer solenoid.............8W-80-15
Engine Coolant Temperature
Sensor (ECT).....................8W-80-15
Engine Oil Pressure Switch............8W-80-16
Front Fog Lamp Switch...............8W-80-16
Fuel Injector No.1...................8W-80-16
Fuel Injector No.2...................8W-80-16
Fuel Injector No.3...................8W-80-16
Fuel Injector No.4...................8W-80-16
Fuel Pump Module..................8W-80-17
Generator.........................8W-80-17
Glove Box Lamp and Switch...........8W-80-17
Headlamp Dimmer and Optical
Horn Switch.....................8W-80-17
Headlamp Leveling Switch............8W-80-17
Headlamp Switch...................8W-80-17
Horn No.1.........................8W-80-18
Horn No.2.........................8W-80-18
(IAT/Map) Sensor...................8W-80-18
Idle Air Control Motor (IAC)...........8W-80-18
Ignition Coil Pack...................8W-80-18
Ignition Switch.....................8W-80-19
Immobilizer Engine Sensor............8W-80-19
Immobilizer Sensor..................8W-80-19
Instument Cluster - C1...............8W-80-19
Instument Cluster - C2...............8W-80-19
Intermittent Wipe/Wash Switch........8W-80-20
Key-In Switch......................8W-80-20
Knock Sensor......................8W-80-20
Left Airbag Impact Sensor.............8W-80-20
Left Back-Up Lamp..................8W-80-20
Left Door Lock Switch................8W-80-21
Left Door Window Motor..............8W-80-21
Left Fog Lamp......................8W-80-21
Left Front Door Lock Motor...........8W-80-21
Left Front Door Speaker..............8W-80-21
Left Front Wheel Speed Sensor.........8W-80-22
Left Headlamp.....................8W-80-22
Left Headlamp Leveling Motor.........8W-80-22
Left Instrument Panel Speaker
(Premium).......................8W-80-22
Left License Lamp...................8W-80-22
Left Park/Turn Signal Lamp...........8W-80-22
8W - 80 - 2 8W - 80 CONNECTOR PIN-OUTSPL

Downloaded from www.Manualslib.com manuals search engine 978W-1
8W - 80 - 5 PL-RHD 8W-80 CONNECTOR PIN-OUTS
PLR08005
CAV CIRCUIT FUNCTION
1 C22 20DB/WT LOW PRESSURE SWITCH OUTPUT
2 C21 20DB/OR A/C CYCLING SWITCH OUTPUT
A/C LOW
PRESSURE SWITCH
BLACK
12
CAV CIRCUIT FUNCTION
1 B142 20BR/YL LEFT FRONT DUMP SOLENOID CONTROL
2 B143 20DG/YL RIGHT FRONT DUMP SOLENOID CONTROL
3 B146 20BR/LB LEFT REAR DUMP SOLENOID CONTROL
4 B148 20DB/LB RIGHT REAR DUMP SOLENOID CONTROL
5 Z1 18BK GROUND
6 Z1 18BK GROUND
BLACK
CAV CIRCUIT FUNCTION
1 F12 18DG/WT ABS RELAY FEED
2 Ð Ð
3 B116 20GY ABS PUMP MOTOR RELAY CONTROL
4 B57 20BR/BK ABS SYSTEM RELAY CONTROL
5 A20 12RD/DG FUSED B(+)
6 B120 12BR/WT ABS PUMP MOTOR RELAY OUTPUT
7 G19 20LG/BR ABS WARNING LAMP DRIVER
8 Ð Ð
9 B47 20RD/LB ABS SYSTEM RELAY OUTPUT
10 Z1 14BK GROUND
DARK
GRAY
ABS HYDRAULIC
MODULATOR 31
64
ABS RELAY BOX 51
10 6
CAV CIRCUIT FUNCTION
1 R45 18DG/LB DRIVER AIRBAG SQUIB LINE 2
2 R43 18BK/LB DRIVER AIRBAG SQUIB LINE 1
3 R47 18DB/LB LEFT IMPACT SENSOR LINE 1
4 R49 18LB LEFT IMPACT SENSOR LINE 2
5 R42 18BK/YL PASSENGER AIRBAG SQUIB LINE 1
6 R44 18DG/YL PASSENGER AIRBAG SQUIB LINE 2
7 R46 18BR/LB RIGHT IMPACT SENSOR LINE 1
8 R48 18TN RIGHT IMPACT SENSOR LINE 2
9 R41 18BK/TN AIRBAG WARNING LAMP DRIVER
10 Z6 18BK/PK GROUND
11 R50 18BR/YL PASSENGER AIRBAG PRESSURE SWTICH SENSE
12 R51 18VT/YL PASSENGER AIRBAG PRESSURE SWITCH GROUND
17 F15 18DB/WT FUSED IGNITION SWITCH OUTPUT (RUN/START)
18 D2 20WT/BK CCD BUS (Ð)
19 D1 20VT/BR CCD BUS (+)
20 F25 18TN/LG FUSED IGNITION SWITCH OUTPUT (RUN)
11 1
22 12
AIRBAG CONTROL
MODULEYELLOW

Downloaded from www.Manualslib.com manuals search engine 978W-1
PL-RHD 8W - 80 - 6 8W-80 CONNECTOR PIN-OUTS
PLR08006
CAV CIRCUIT FUNCTION
1 E2 22OR FUSED PANEL LAMPS DIMMER SWITCH SIGNAL
2 Z3 20BK/OR GROUND BLACK12
ASH
RECEIVER
LAMP
BACK-UP LAMP
SWITCH (MTX)GRAY
CAV CIRCUIT FUNCTION
A L1 20VT/BK REVERSE LAMP SENSE
B F20 20WT FUSED IGNITION SWITCH OUTPUT (RUN)ABAB
CAV CIRCUIT FUNCTION
1 K4 18BK/LB SENSOR GROUND
2 G31 18VT/LG AMBIENT TEMPERATURE SENSOR SIGNAL
2
1 54
3
CAV CIRCUIT FUNCTION
1 C5 14LG M1 BLOWER MOTOR DRIVER
2 C6 14LB M2 BLOWER MOTOR DRIVER
3Ð Ð
4 C7 14BK/TN HIGH BLOWER MOTOR DRIVER
5 C4 14TN LOW BLOWER MOTOR DRIVER
BLOWER MOTOR
RESISTOR
BLOCK
3 25 4
1BLACK
CAV CIRCUIT FUNCTION
1 G9 20GY/BK RED BRAKE WARNING LAMP DRIVER
2 Z1 20BK GROUND
BRAKE WARNING
LAMP SWITCH
BATTERY
TEMPERATURE SENSOR12
BLACK
BLACK
21