1997 DODGE NEON fuse

Downloaded from www.Manualslib.com manuals search engine 41
3
5 252
3
14 34
20A
FUSE
14
RUN-ACC A31
F10
18
YL/RD
F10
18
YL/RDF10
18
YL/RD
S313
431
6
Q41
18
WTQ46
18
ORQ42
18
LBQ43
18
VTZ8
18
BK/VT
S314
Z8
18
BK/VT
Z8
14
BK/VT
6C225
G203
5
Z8
18
BK/VT
BLOCK FUSE
Q45 18PK/BK
12
2 CLOSE
1 OPEN
SWITCH
SLIDE
SUNROOF SUNROOF
VENT
SWITCH
1 OPEN
2 CLOSE
2 1
12
3 4
Z8
18
BK/VT
CONTROL HEATER
A/C
1Z8 18BK/VT
4 VENT OPEN
3 VENT CLOSE
2 CLOSE
1 OPEN
MOTOR
SUNROOF
POWER
14
F10
18
YL/RD
5C225
SWITCH
(8W-11-12)
(8W 15 6)
(8W-10-12)
(8W-11-2)
(8W-42-3)
M
8W - 64 - 2 8W-64 POWER SUNROOFPL-RHD
PL8W - 64 POWER SUNROOF 8W - 64 - 3
DESCRIPTION AND OPERATION (Continued)

Downloaded from www.Manualslib.com manuals search engine 8W-64 POWER SUNROOF
DESCRIPTION AND OPERATION
POWER SUNROOF
Power for the tilt and slide switches is supplied on
circuit F10. This circuit is HOT in the ACCESSORY
and RUN position only, and protected by a 20 amp
fuse located in the fuse block, cavity 14.
Power for the fuse is supplied by circuit A31. This
circuit connects from the ignition switch to the fuse
block.
Feed for the A31 circuit is supplied on circuit A1.
This circuit is protected by a 30 amp fuse located in
the Power Distribution Center (PDC).
SUNROOF OPEN/CLOSE
When the operator selects sunroof OPEN the
switch connects the feed circuit F10 to circuit Q41.
The Q41 circuit connects from the switch to the
OPEN side of the motor.
Ground for the motor is supplied on circuit Q42
from the motor back to the CLOSE side of the open/
close switch. The ground is passed through the bus
bar in the switch to circuit Q45. Circuit Q45 connects
from the open/close switch to the tilt switch.
The ground is passed through the switch to circuit
Z8 and finally to ground.
When the operator selects the CLOSE function,
power and ground are reversed.
TILT OPEN/CLOSE
When the operator selects tilt OPEN circuit F10 is
connected to circuit Q43. Circuit Q43 connects from
the switch to the CLOSED vent limit switch in the
sunroof module.
The voltage is passed through the switch to circuit
Q46. The Q46 circuit connects from the limit switch
to the slide switch OPEN side.
Power is passed through the switch to the Q41 cir-
cuit, then to the power sunroof motor.
Ground is provided on circuit Q42 from the motor
to the slide switch CLOSE side. The ground is passed
through the bus bar in the switch to circuit Q45. The
Q45 circuit connects from the slide switch to the tilt
switch CLOSE side.
Ground is passed through the switch to the Z8 cir-
cuit and to ground.
When the operator selects the VENT CLOSE func-
tion, power and ground are reversed.
PL8W - 64 POWER SUNROOF 8W - 64 - 3

Downloaded from www.Manualslib.com manuals search engine Component Page
Left Power Mirror...................8W-80-23
Left Power Window Switch............8W-80-23
Left Rear Door Lock Motor............8W-80-23
Left Rear Fog Lamp.................8W-80-23
Left Rear Speaker...................8W-80-23
Left Rear Wheel Speed Sensor.........8W-80-23
Left Repeater Lamp.................8W-80-24
Left Tail/Stop Lamp.................8W-80-24
Left Turn Signal Lamp...............8W-80-24
Map/Reading Lamps.................8W-80-24
Master Power Window Switch..........8W-80-24Component Page
Park/Neutral Position Switch (ATX).....8W-80-25
Passenger Side Airbag................8W-80-25
Power Folding Mirror Relay...........8W-80-25
Power Mirror Fuse Holder............8W-80-25
Power Mirror Switch - C1.............8W-80-25
Power Mirror Switch - C2.............8W-80-26
Power Steering Pressure Switch........8W-80-26
Power Sunroof Motor.................8W-80-26
Powertrain Control Module - C1........8W-80-26
Powertrain Control Module - C2........8W-80-27
PRNDL Lamp......................8W-80-28
Radiator Fan Motor..................8W-80-28
Radio - C1.........................8W-80-28
Radio - C2.........................8W-80-29
Rear Fog Lamp Switch...............8W-80-29
Rear Window Defogger Switch.........8W-80-29
Right Airbag Impact Sensor...........8W-80-29
Right Back-Up Lamp.................8W-80-29
Right Door Lock Switch...............8W-80-30
Right Door Window Motor.............8W-80-30
Right Fog Lamp....................8W-80-30
Right Front Door Lock Motor..........8W-80-30
Right Front Door Speaker.............8W-80-30
Right Front Wheel Speed Sensor........8W-80-31
Right Headlamp....................8W-80-31
Right Headlamp Leveling Motor........8W-80-31
PL8W - 80 CONNECTOR PIN-OUTS 8W - 80 - 3
DESCRIPTION AND OPERATION (Continued)

Downloaded from www.Manualslib.com manuals search engine 978W-1
PL-RHD 8W - 80 - 4 8W-80 CONNECTOR PIN-OUTS
PLR08004
CAV CIRCUIT FUNCTION
1 C3 18DB/BK A/C COMPRESSOR CLUTCH RELAY OUTPUT
2 Z1 20BK GROUND
CAV CIRCUIT FUNCTION
1 C21 22DB/OR A/C CYCLING SWITCH OUTPUT
2 F20 22WT FUSED IGNITION SWITCH OUTPUT (RUN)
3 C2 22DB/YL MODE SWITCH OUTPUT
BLACK
A/C CYCLING
SWITCH
31
BLACK
71
CAV CIRCUIT FUNCTION
1Z8 14BK/VT GROUND
Z8 18BK/VT GROUND
2 C7 14BK/TN HIGH BLOWER MOTOR DRIVER
3 C6 14LB M2 BLOWER MOTOR DRIVER
4 C5 14LG M1 BLOWER MOTOR DRIVER
5 C4 14TN LOW BLOWER MOTOR DRIVER
6 C2 22DB/YL*MODE SWITCH OUTPUT
7 E2 22OR FUSED PANEL LAMPS DIMMER SWITCH SIGNAL
7 E2 22OR FUSED PANEL LAMPS DIMMER SWITCH SIGNAL
*WITH A/C A/C-HEATER
CONTROL
SWITCH
CAV CIRCUIT FUNCTION
1 C20 20BR/OR A/C SWITCH SENSE
2 C22 20DB/WT LOW PRESSURE SWITCH OUTPUT BLACK21
A/C HIGH
PRESSURE
SWITCH
1
A/C COMPRESSOR
CLUTCH
BLACK
2
2
1
A/C-HEATER
BLOWER MOTOR (WITH A/C)
BLACK
CAV CIRCUIT FUNCTION
1 C1 14DG FUSED IGNITION SWITCH OUTPUT (RUN)
2 C7 14BK/TN HIGH BLOWER MOTOR DRIVER

Downloaded from www.Manualslib.com manuals search engine 978W-1
8W - 80 - 5 PL-RHD 8W-80 CONNECTOR PIN-OUTS
PLR08005
CAV CIRCUIT FUNCTION
1 C22 20DB/WT LOW PRESSURE SWITCH OUTPUT
2 C21 20DB/OR A/C CYCLING SWITCH OUTPUT
A/C LOW
PRESSURE SWITCH
BLACK
12
CAV CIRCUIT FUNCTION
1 B142 20BR/YL LEFT FRONT DUMP SOLENOID CONTROL
2 B143 20DG/YL RIGHT FRONT DUMP SOLENOID CONTROL
3 B146 20BR/LB LEFT REAR DUMP SOLENOID CONTROL
4 B148 20DB/LB RIGHT REAR DUMP SOLENOID CONTROL
5 Z1 18BK GROUND
6 Z1 18BK GROUND
BLACK
CAV CIRCUIT FUNCTION
1 F12 18DG/WT ABS RELAY FEED
2 Ð Ð
3 B116 20GY ABS PUMP MOTOR RELAY CONTROL
4 B57 20BR/BK ABS SYSTEM RELAY CONTROL
5 A20 12RD/DG FUSED B(+)
6 B120 12BR/WT ABS PUMP MOTOR RELAY OUTPUT
7 G19 20LG/BR ABS WARNING LAMP DRIVER
8 Ð Ð
9 B47 20RD/LB ABS SYSTEM RELAY OUTPUT
10 Z1 14BK GROUND
DARK
GRAY
ABS HYDRAULIC
MODULATOR 31
64
ABS RELAY BOX 51
10 6
CAV CIRCUIT FUNCTION
1 R45 18DG/LB DRIVER AIRBAG SQUIB LINE 2
2 R43 18BK/LB DRIVER AIRBAG SQUIB LINE 1
3 R47 18DB/LB LEFT IMPACT SENSOR LINE 1
4 R49 18LB LEFT IMPACT SENSOR LINE 2
5 R42 18BK/YL PASSENGER AIRBAG SQUIB LINE 1
6 R44 18DG/YL PASSENGER AIRBAG SQUIB LINE 2
7 R46 18BR/LB RIGHT IMPACT SENSOR LINE 1
8 R48 18TN RIGHT IMPACT SENSOR LINE 2
9 R41 18BK/TN AIRBAG WARNING LAMP DRIVER
10 Z6 18BK/PK GROUND
11 R50 18BR/YL PASSENGER AIRBAG PRESSURE SWTICH SENSE
12 R51 18VT/YL PASSENGER AIRBAG PRESSURE SWITCH GROUND
17 F15 18DB/WT FUSED IGNITION SWITCH OUTPUT (RUN/START)
18 D2 20WT/BK CCD BUS (Ð)
19 D1 20VT/BR CCD BUS (+)
20 F25 18TN/LG FUSED IGNITION SWITCH OUTPUT (RUN)
11 1
22 12
AIRBAG CONTROL
MODULEYELLOW

Downloaded from www.Manualslib.com manuals search engine 978W-1
PL-RHD 8W - 80 - 6 8W-80 CONNECTOR PIN-OUTS
PLR08006
CAV CIRCUIT FUNCTION
1 E2 22OR FUSED PANEL LAMPS DIMMER SWITCH SIGNAL
2 Z3 20BK/OR GROUND BLACK12
ASH
RECEIVER
LAMP
BACK-UP LAMP
SWITCH (MTX)GRAY
CAV CIRCUIT FUNCTION
A L1 20VT/BK REVERSE LAMP SENSE
B F20 20WT FUSED IGNITION SWITCH OUTPUT (RUN)ABAB
CAV CIRCUIT FUNCTION
1 K4 18BK/LB SENSOR GROUND
2 G31 18VT/LG AMBIENT TEMPERATURE SENSOR SIGNAL
2
1 54
3
CAV CIRCUIT FUNCTION
1 C5 14LG M1 BLOWER MOTOR DRIVER
2 C6 14LB M2 BLOWER MOTOR DRIVER
3Ð Ð
4 C7 14BK/TN HIGH BLOWER MOTOR DRIVER
5 C4 14TN LOW BLOWER MOTOR DRIVER
BLOWER MOTOR
RESISTOR
BLOCK
3 25 4
1BLACK
CAV CIRCUIT FUNCTION
1 G9 20GY/BK RED BRAKE WARNING LAMP DRIVER
2 Z1 20BK GROUND
BRAKE WARNING
LAMP SWITCH
BATTERY
TEMPERATURE SENSOR12
BLACK
BLACK
21

Downloaded from www.Manualslib.com manuals search engine 978W-1
PL-RHD 8W - 80 - 14 8W-80 CONNECTOR PIN-OUTS
PLR08014
(CONTINUED)
CAV CIRCUIT FUNCTION
51 D21 20PK SCI TRANSMIT
52 Ð Ð
53 Ð Ð
54 Ð Ð
55 Ð Ð
56 Ð Ð
57 B57 20BR/BK ABS SYSTEM RELAY CONTROL
58 Ð Ð
59 Ð Ð
60 F12 20DG/WT ABS MODULE FEED
CAV CIRCUIT FUNCTION
1 K7 20OR 8 VOLT SUPPLY
2 K4 20BK/LB SENSOR GROUND
3 K24 20GY/BK CRANKSHAFT POSITION SENSOR SIGNAL
CRANKSHAFT
POSITION
(CKP) SENSOR
CAV CIRCUIT FUNCTION
1 Ð Ð
2 Ð Ð
3 D1 20VT/BR CCD BUS (+)
4 Z12 22BK/TN GROUND
5 Z12 22BK/TN GROUND
6 D20 20LG SCI RECEIVE
7 D21 20PK SCI TRANSMIT
8 Ð Ð
9 Ð Ð
10 Ð Ð
11 D2 20WT/BK CCD BUS (Ð)
12 Ð Ð
13 Ð Ð
14 Ð Ð
15 Ð Ð
16 A14 16RD/WT FUSED B(+)
BLACK
DATA LINK
CONNECTOR 18
916
CAV CIRCUIT FUNCTION
1 M1 22PK FUSED B(+)
2Ð Ð
3 M2 20YL DOME LAMP FEED
DOME LAMP1 3
BLACK
31
BLACK

Downloaded from www.Manualslib.com manuals search engine 978W-1
8W - 80 - 15 PL-RHD 8W-80 CONNECTOR PIN-OUTS
PLR08015
CAV CIRCUIT FUNCTION
1 A142 18DG/OR AUTOMATIC SHUTDOWN RELAY OUTPUT
2 Z1 18BK GROUND
3 K4 20BK/LB SENSOR GROUND
4 K141 20TN/WT DOWNSTREAM HEATED OXYGEN SENSOR SIGNAL
CAV CIRCUIT FUNCTION
1 R45 18DG/LB DRIVER AIRBAG SQUIB LINE 2
2 R43 18BK/LB DRIVER AIRBAG SQUIB LINE 1
YELLOW
DRIVER SIDE
AIRBAG 2 1
CAV CIRCUIT FUNCTION
1 K52 20PK/BK DUTY CYCLE EVAP/PURGE SOLENOID CONTROL
2 F12 20DG/WT FUSED IGNITION SWITCH OUTPUT (RUN/START) BLACK2 1
DUTY CYCLE
EVAP/PURGE
SOLENOID
CAV CIRCUIT FUNCTION
A K4 20BK/LB*SENSOR GROUND
A K4 20BK/RDlSENSOR GROUND
B K2 20TN/DB*ENGINE COOLANT TEMPERATURE SENSOR SIGNAL
B K2 20TN/BKlENGINE COOLANT TEMPERATURE SENSOR SIGNAL
C G20 20VT/YL ENGINE COOLANT TEMPERATURE GAUGE SIGNAL
BLACK
ENGINE COOLANT
TEMPERATURE (ECT)
SENSOR
BA
CB A
C
*2.0L SOHC ENGINEl2.0L DOHC ENGINE
BLACK
2
4
1
3
DOWNSTREAM HEATED
OXYGEN SENSOR
CAV CIRCUIT FUNCTION
1 K35 20GY/YL EXHAUST GAS RECIRCULATION SOLENOID CONTROL
2 F12 18DB/WT FUSED IGNITION SWITCH RELAY OUTPUT BLACK
21
(EGR)
TRANSDUCER
SOLENOID