1997 ASTON MARTIN DB7 warning

Introduction
/^r"^^^^^3^
'"'P ?
Safety Precautions L —^ ^^—^
Safety Precautions "
All service workshops are a source of potential danger and repair work should only be performed by technically
trained staff following the procedures in this manual. A safety conscious approach to the performance of all service
procedures must be observed at all times. Statutory requirements governing all aspects of health and safety at work
including directives for the proper use of materials and equipment must be implemented.
The following contains a list of particular safety precautions which should be observed; it is not intended to be
exhaustive.
Air Conditioning System
Do not disconnect any air conditioning refrigerant system pipes unless trained and instructed to do
so.
The refrigerant
used can cause blindness if allowed to contact your eyes.
Chemical Handling and Storage
Chemicalsusedintheservicingofmotorvehiclesincludeacids,adhesives, antifreeze, brake fluids, coolants, grease,

oil,
paint, resin and solvents. Exposure to certain chemicals through direct contact or inhalation can be
fatal.

Potential hazards may also be present through the incorrect use, storage and handling of chemicals causing a fire
risk. The following precautions should be observed.

1.
Strictly adhere to handling and safety information found on containers and labels.

2.
Do not store chemicals in unlabelled or incorrectly labelled containers.
3. Containers used for storing chemicals should not be left
open;
there is a risk of
spilling,
or evaporation of fumes
which may be inflammable or toxic.

4.
Do not mix chemicals unless instructed to do so following manufacturers guidelines.
5. Do not inhale chemical materials to determine identity, they may be toxic.
6. Do not use petrol, kerosene, diesel
fuel,
gas oil, thinners or solvents for washing
skin.

7. Containers whose capacity is over 25 litres (5 gallons) require a bund wall in order to contain spillages.
8. Chemicals based on solvents such as paint should not be sprayed in a confined space; work areas used for
such operations should be well ventilated and fume extraction equipment should be utilised.
9. Ensure that adequate ventilation is provided when volatile de-greasing agents are being used.
WARNING: Fume extraction equipment must be in operation when
solvents
are
used
e.g.
trichloroethane, white
spirit, SBP3, methylene chloride, perchlorethylene.
WARNING: Do not smoke in the vicinity of volatile de-greasing agents.

10.
Avoid splashing the
skin,
eyes and clothing.

11.
Clean chemicals from the skin and clothing as soon as possible after soiling.

12.
Wear protective clothing such as goggles, non porous gloves and apron when hand
I
ing battery acid and other
corrosive and toxic substances.
iv April 1997

//—-^
^^^^5~^
' -^ ^ Introduction
Safety Precautions
Safety Precautions (continued)
Electrical Equipment

1.
Ensure that electrical equipment is in safe working order before use.

2.
Inspect power leads of all mains electrical equipment for damage and security, and check that it is properly

earthed.

3. Ensure that electrical equipment is protected by a fuse of the correct current rating.

4.
Disconnect the battery before commencing repair operations to the electrical system, fuel system and engine
or when working beneath the vehicle.
Exhaust Fumes
Engines should not be run in confined spaces, exhaust fumes contain harmful and toxic substances including carbon
monoxide which can prove fatal if inhaled. Engines must only be run where there is fume extraction equipment in
operation or where there is adequate ventilation.
Fire Precautions

1.
Ensure that a suitable form of fire extinguisher is conveniently located near the work area.

2.
Keep oils, solvents and combustible materials away from naked flames and other sources of ignition.
3. Ensure that NO SMOKING signs are posted around areas where combustible materials and vapour may be
present and ensure that the warnings are strictly observed.

4.
Ensure that dry sand is available to soak up any spillage of fuel or other flammable solutions.
5. Fume extraction equipment must be available and in full working order to remove combustible and toxic
vapours.
6. All personnel should be aware of the fire drill procedures and precautions.
Jacking and Lifting

1.
The recommended procedures for lifting, jacking and towing are included latefin this seetion-and must be
strictly observed to ensure personal safety.

2.
Always use a vehicle hoist, ramp or pit for working beneath the car in preferencetd^&^cking
3. Never rely on a jack to support a car independently, use axle stands or blocks carefully pJaQed at the jacking
points to provide rigid support.

4.
When working beneath a vehicle, chock the wheels as well as applying the handbrake.
5. Ensure that the vehicle is standing on firm level ground before jacking or lifting.
5. Check any lifting equipment used has adequate capacity for the load being lifted and is ih"fdll working order.
Tools and Equipment

1.
Do not leave tools, equipment, spilt oil, etc. around or on the work area.

2.
Ensure that tools and equipment used are in good condition; do not use damaged or defective tools or
equipment.
3. Do not apply heat in an attempt to free stiff nuts or fittings; as well as causing damage to protective coatings,
there is a risk of damage to electronic equipment and brake lines from stray heat.

4.
Use the recommended service tool where instructed to do so.
April 1997 v

Em3^^^

Electrics
Ignition Switch / Instrument Panel - Removal Procedures
6.5.03 Ignition Switch 6.5.04 Instrument Panel
Procedure

1.
Disconnect the battery.

2.
Remove three screws and the steering column
lower cover.
Procedure

1.
Disconnect the battery.

2.
Remove the four screws from the instrument pane!
surround and remove the surround.
Figure 7. Ignition Switch
3.

4.

Loosen thegrub screw securing the switch and ease
the switch from its location.
Disconnect the switch multi-plug and remove the

switch.

Figure 1. Instrument Panel Removal
3. Remove two screws from the top edge of the
instrument panel and withdraw the panel.

4.
Detach the three electrical connectors and remove
the instrument panel.
5. Panel warning lamps are 1.2W bayonet fit. The
larger panel illumination lamps are also 1.2W
bayonet fit.
May 1996 6-7

Electrics
Electrical Component Location Index - Up to 97 MY
Component Name
ABS ECU
Air Con Compressor Clutch
Air Con Fan Motor - LH
Air Con Fan Motor - RH
Air Conditioning Trinary Switch
Air Conditioning Unit
Air Pump
Air Temperature Sensor
Alarm Override Switch
Alarm Siren
Alternator
Ambient Temperature Sensor
Barometric Pressure Sensor
Boot Lamp
Boot Lamp
Boot Lock Actuator
Boot Release Switch
Brake Accumulator Pump
Bulb Fail Unit - Front Side Lights
Camshaft Sensor
Central Locking Unit
Cigar Lighter
Column Switchgear
Crankshaft Position Sensor
Cruise Control Brake Switch
Cruise Control Clutch Switch (LHD)
Cruise Control ECU
Cruise Control On/Off Switch
Cruise Control Pump
Cruise Control Set Switch
Cruise Control Inhibit Switch
Diagnostic Socket - Transmission
Dimmer Module
Door Lock Actuator
Door Mirror- LHD
Door Mirror- RHD
Door Mirror Switch LH
Door Mirror Switch RH
Door Speaker -LH
Door Speaker - RH
EDIS Coil Pack
EDIS Amplifier Module
Engine Diagnostic Socket
Engine ECU
Exhaust Temperature/Speed Warning
Fan Fuses
Fan Motor 1
Fan Motor 2
Fan Run-on Switch
Flasher Module
Fog Lamp - RH Front
Fog Lamp - LH Front
Location
Reference
15-1
3-20
8-2
8-6
10-6
8-3
8-4
3-13
1-8
11-7
3-2
1-12
11-1
5-2
5-2
13-8
2-10
7-4/8
4-6
3-10
9-4
8-1
13-3
3-3
11-8
12-9
6-3
12-7
1-2
12-8
10-8
10-7
4-16
12-12
2-4
2-8
2-3
2-9
6-4
6-9
3-1
1-10
10-5
7-3
4-3
1-21
7-6
7-7
7-5
4-13
14-10
14-9
Wiring Diag.
Reference
28-A1
5-D2
8-A5
13-C4
5-D3
11-82
1-C2
5-C3
1-C5
1-B3
5-D3
1-A2
4-A4
24-A5
24-C4
27-A5

l-i-C3

28-84
9-C2
6-C3
8-D1
19-D3
12-C5
5-D2
12-85
2-D4
20-A2
20-C3
2-A3
20-D3
21-D3
12-A4
13-A4
17/18-B1
17-A3
17-A5
17-D5
18-D5
17-C5
18-C5
5-D5
6-B2
6-D4
6-C5
11-C5
3-A3
3-A2
3-B2
5-A2
13-C2
1-A1
1-C1

Rep.
Op. Notes
Reference

5.1.11.1

8.1.07.3

8.2.09.1
8.2.08.1
8.1.11.1
8.2.01.1

2.3.01.2
2.2.06.1
6.1.06.1
6.2.03.1
6.3.01.1

8.2.07.1

3.3.08.2

6.9.04.1
6.9.04.1
6.9.06.1
6.5.09.1

5.1.08.1

6.4.01.1
2.5.06.1
6.7.03.1
6.5.10.1
6.5.02.1
2.5.06.3
6.4.02.1
6.1.08.1 Manual only
6.6.09.1
6.5.07.1
6.1.09.2
6.5.07.2

3.3.08.6

6.4.03.1
6.4.04.1
6.7.10.1
6.7.08.1
6.8.01.1
6.7.08.2
6.8.01.2
6.7.09.1
6.8.02.1
6.2.05.1
6.2.05.3
6.4.05.1
6.4.06.1
6.4.07.1 Multi-functio
6.2.06.1

1.7.17.1

1.7.17.2

1.7.16.4

6.4.08.1
6.1.04.1
6.1.04.2
May 1996 6-19

Electrics
Electrical Component Location Index •
Component Name
Fuel Filler Flap Solenoid
Fuel Pump 1
Fuel Pump 2
Fuel Tank Sender Unit
Gear Selector Illumination
Gear Shift Interlock Solenoid
Gearbox Connector (Auto)
Gearbox ECU
Gearshift Interlock Module
Handbrake Switch
Headlamp Control Module
Head/Side Lamp - LH Front
Head/Side Lamp - RH Front
Heated Front Screen Controller
Heated Front Screen Fuse - 40A
Heated Front Screen
Heated Front Screen
Heated Rear Screen
Heated Washer Jet
Heated Washer Jet
High Level Stop Lamp
Horn - LH
Horn - RH
Idle Speed Control Valve
Ignition Switch
Indicator/Side Lamp - LH Front
Indicator/Side Lamp - RH Front
Inertia Switch
Injector 1
Injector 2
Injector 3
Injector 4
Injector 5
Injector 6
Input Speed Sensor (Auto)
Instrument Panel Illumination Control
Instrument Panel
Interior Light - Rear LH
Interior Light - Rear RH
Key Solenoid
Key-In Warning Switch
Kickdown Switch
Lambda Sensor A
Lambda Sensor B
Logic Earth
Low Coolant Probe
Low Level Sensor
Lumbar Pump
Map Reading Light
Microswitch - Glass Drop LH
Microswitch - Glass Drop RH
Up to 97 MY
Location
Reference
2-1
15-13
15-14
15-12
9-3
13-6
7-11
11-2
13-7
8-8
1-3
14-7
14-12
11-4
11-5
7-10
7-1
9-8
1-11
1-11
9-1
11-6
11-6
3-17
8-7
14-8
14-11
7-2
3-6
3-7
3-8
3-9
3-n
3-12
11-11
2-7
2-6
5-4
5-4
11-10
11-9
8-5
3-18
3-19
9-2
13-5
4-1
9-5
5-1
12-2
12-2
Wiring Diag.
Reference
24-A3
25-A1
25-A2
24-C5
19-D4
21-C4
7-B4
4-B3
21-A2
24-A1
2-A2
1-D2
1-A2
9-A2
9-B2
8-B5
14-B2
24-A2
5-A3
5-B3
24-B2
3-C1
3-81
5-C5
12-D2
1-C1
1-A1
8-D2
5-A2
5-C2
5-A3
5-C2
5-A4
5-C4
7-B2
13-D5
11-C5
24-A2
24-D2
12-B2
12-B2
14-A5
6-B5
6-B5
10-D4
8-C3
3-C1
22-D2
13-C4
17-A2
18-A2
Ini^'

IL-^^'^

Rep.
Op.
Reference

6.9.07.1

2.6.02.1
2.6.02.1
2.6.06.1

6.5.11.1

3.3.01.1

6.6.10.1
6.5.12.1
6.1.10.1
6.1.01.1

6.1.01.2

6.4.09.1

6.4.09.2

6.4.09.3
6.4.09.3

6.6.11.1
6.4.10.1
6.4.10.1
6.6.12.1
6.1.11.1
6.1.11.1

2.2.05.1

6.5.13.1
6.1.03.1
6.1.03.1
6.5.14.1
6.3.04.1
6.3.04.1
6.3.04.1
6.3.04.1
6.3.04.1
6.3.04.1

3.4.02.1

6.5.04.2

6.5.04.1
6.6.02.1
6.6.02.1
6.5.14.1

5.4.01.1

6.3.05.1
6.3.05.1
6.5.15.1

1.7.14.1

6.6.01.1
6.1.13.1
6.1.13.1

W3^y
Notes
Auto only
Auto only
Auto only
Auto only
Auto only
Auto only
Auto only
6-20 May 1996

[n:m3^y

Component Name
Microwave Sensor
Mode Switch
Multifunction Module
Number Plate Lamp - LH
Number Plate Lamp - RH
Oil Pressure Warning Light Transducer
Output Speed Sensor (Auto)
Park Switch (Auto)
Purge Valve 1
Purge Valve 2
Radio Aerial
Radio Telephone Connector
Radio Tweeter
Radio Tweeter
Radio
Rear & Number Plate Bulb Fail Unit
Rear Fog Lamp LH
Rear Fog Lamp RH
Rear Lamp - LH
Rear Lamp - RH
Recline Motor Potentiometer
Relay - ABS Pump
Relay - Air conditioning clutch
Relay - Air Pump
Relay - Auxiliary Load
Relay - Boot Release
Relay - Courtesy Lights
Relay - Cruise Control On/Off
Relay - Drivers Seat Heater
Relay - Fan 1
Relay - Fan 2
Relay - Fan Run On
Relay - Front Fog Lamps
Relay - Fuel Pump 1
Relay - Fuel Pump 2
Relay - Gearbox Failure Warning
Relay - Headlamp Dipped Beam
Relay - Headlamps
Relay - Heated Rear Window
Relay - Horns
Relay - Ignition Load
Relay - Main
)
Location
Reference
12-1
7-9
4-2
5-3
5-3
3-17
11-12
10-1
10-3
10-4
15-4
15-3
6-7
6-5
6-6
15-11
14-2
14-5
14-1
14-6
9-7
4-8
1-17
4-14
4-4
15-9
4-11
6-1
12-3
1-20
1-19
1-18
1-6
15-7
15-8
4-9
1-5
1-7
4-15
1-16
4-10
4-12
Relays - Drivers/Passengers Seat Heaters 12-3
Relay - Rear Fog Lamps
Relay - Reverse Lamps
Relay - Sidelamps
Relay - Starter Solenoid
Relay - Stop Lamps
Reversing Lamp Switch (Man)
Reversing Light Switch (Auto)
Screen Wash Pump
4-17
15-6
1-9
1-15
15-5
11-3
10-2
1-13
Electrics
Electrical Component Location Index - Up to 97 MY
Wiring Diag.
Reference
24-C2
4-A3
8-C4
27-84
27-B6
5-C5
7-B3
21-B1
5-A4
5-A5
24-D2
25-B2
8-C3
14-C4
10-A2
25-C3
17-D2
18-D2
24-A5
24-C4
22-81
9-C4
3-A3
13-A5
9-D1
26-D3
13-A2
20-B1
16-D3
3-B6
3-B6
3-A5
1-B5
26-A2
26-A3
13-A1
1-B5
1-84
13-A4
3-A4
13-A2
13-A3
15-D3
13-A5
25-A4
1-B4
3-A4
25-A5
7-C5
21-C2
3-D1

Rep.
Op. Notes
Reference

6.6.14.2

6.5.07.4

6.4.12.1
6.9.03.1
6.9.03.1

1.5.08.1

3.4.02.2
Auto only

6.5.13.1
Auto only

6.1.14.1

6.1.14.2

6.9.08.1
6.9.09.1
6.5.17.1
6.5.17.1
6.5.05.1
6.9.10.1
6.7.02.1
6.6.07.1

5.1.15.1

6.2.06.1
6.4.13.1
6.4.14.1
6.9.11.1
6.4.15.1
6.5.18.1
6.6.15.1

1.7.16.3
1.7.16.3

1.7.16.4

6.1.04.3

6.9.12.1
6.9.12.1
6.4.16.1
Auto only

6.1.15.1
6.1.16.1
6.4.17.1
6.2.07.1
6.4.18.1
6.4.19.1

6.6.15.2

6.4.20.1
6.9.13.1
6.1.17.1
6.2.08.1
6.9.14.1
6.2.09.1

6.2.09.2

6.3.06.1

May 1996 6-21

NO COLOUR 14
WU
17
GW
51
RO
es
UB
83
WK
86
BK
94
RY
95
U
96
UW
97
GY
109
LGB
121
WR
131
YR
136
UB
138
RN
163
BK
172
G
174
KB
175
PY
198
GN
207 HB 209
OK
222 OS 226 BH 248
NS
250 WS 253 UG 255
G
258
KB
262 BLG 322 RU 325
GU
324 Y 325 LG 528 RN 330 YG 331
YU 351
m
354
W
355 *B
362
RW
368 OS 569 OU 577 BC 578 BS 580 PG 381 BP 582
WB
384 WP 386 GO 387 BW 388 PS 401 BY 416 LGG 417 LGN 418 LOW 420 LGR 421
LG
422
LGP
423
BS
437 LG 438 W 439 W 449 WK 451 LG 453 GP 461
P
477 BW 478
BK
480 RK 485 LGN 484 RIN 486 RN 488 BRD 489 UIN
AREA B5 A4-I09 05 C5 A4-I06 C5 B5 AS-III B5 B5 65 B5 B5 B5 B5 D4 D4 04 05 B2 B5 BS B5 B5 05 C5 C5 C5 05 C2 02 02 C5 C5 C5 C5 C5 05 A4-II0 C5
A4-I0I C5 C5 C5 05 C5 CS 05 C5 C5 05 C5 C5 05 C5 05 05 05 05 05 D5 05 05 D5 B2 02 B6 B6 B6 B4-I02 B6 66 66 B6 ef
NO COLOUR 491
R
492
YW 493 KB 495 OR 496 OU 497 SLG 500 KB 502 RU 505 GW 504
BW
512 WY
514
RB
515
W
516
BLG
517 LGY
520 U
521
YU
525
RW
524
6
526
BK
527
BK
536 B
537
W
540 NR
542 GB
551
8
532
B 554 WY 555
W
565 BU 565 B 566 NY
574
WK
584 GR
586
LGO
587
WY
588
WS 595 BY 600 GB
603 NR 604
NB
608 0
615
BU
616
P
617
PW 618
8
622
KB
630 NR 646 GR 649 P 662 N 663 P 664
WK 668 WO
682 R
687 NY
688 OG 690 OW 695 P 699 NK 705
WK
712
W
716
PW
717
OU

AREA A4-II0 D2 C5 B6
86 C2
66
86
66
A3-I09I B6 66 A4-II0 66 66 86 C2 66 86 66 B6 B2 B2 B2 B2 02 B5 C5 C5
C5
C5 05 C6 C6 06 06 C6 06 D6 06 06 D6 66 86 B6 86 86 66 B6 66 66 66 66 66 06 06 C6 06 C6
C6 C6
A4-II0
C6 C6
NO COLOUR 529 N 530 N 531
N
532 N 533 N 534 H 535 N
AREA A5-I07
86
A3-I06 A3-I05
06 06 «

^fl
""••• '^^

AIR CON UNIT

NO COLOUR
PIN
536 8 451 LG 198 GN 557
W
538 PN 559 RW 540 NR
1 2 3 4 5 6 7
e
9 10 l( 'i
AREA 61 CI Al 81
64-10'
A4-I0I 61
GEAR SELECT NO COLOUR 145 BG 497 SLG 521
YU
541 YR 542
GB
543 PN 544 G 545
YH
546 YB 647 6 262 6LG
PIN 1 2 3 4 5 6 7 8 9 10 II 12
15

AREA 85 Al Al C6 81
64-10' 64-10;
C6 06 C6 61
6
^ Q-

SPL 108 SPL 109 SPL
110
SPL
III

SHEET
8
AREA
CI

NO COLOUR
PIN

548 RG 549 GR 322 RU 325
GU
463 GP 550
RW

551
B

492 YW

2 5 4 5 6
7 8 9 10 II 12 15 14
15 l«

ift^A

C6 CG 61 61 CI
A4-I0I

Bl
01

EXHAUST TEMP/ SPEED WARNING NO COLOUR 552 B 553 PS 388 PS 384 WP 554 WY
JJM...

-pi!r 1 2 3 4 5
.&_
AREA
61 06 CI CI 61 Bl

c

n:

r

1
TO- •

IDffl

Dl
ID

llli=i,
ID¥|

miD
(DID

Oltix

IQI
ID
ID 9
16

C
I
f
DID

OIDJ
IDID

Djcx

OHO
DID
DD

Di=r

DD
DD
DD

9 16

M aimviw
169
S
170
BS

171
NR

172
G

165
RK
173
GB

174
KB

175
PY
176
KU
163
BK
1 2 3
4 5 6 7 8
9
10 II 12
13 14 15 If

AREA
65 65 85 A5
CI
85 A5
Al
Al 65 Al

BINNACLE HARNESS

NO
COLOUR
495 K6 556
PK
557
PR
558
U
559
Y
560 RK 51
RO

561
PK
562
G
563 BU 564 RW 565
6

401 BY 566 NY 567 RN 382
W6
568 R
Tifr
1 2 3 4 5 6
7 8
9 10 II 12
13 14
15 16 IT 18
19
Z9

mk
Al C6 06
A4-I0!
06
64-102
Al

64-10'
64-103
Bl
A4-I0I
81
CI Bl 06 CI C6
SHEET 12 AREA I

NO COLOUR 14
WU
65
UB
86
BK
94
RY
96
UW
97
GY
109 LGB 121
WR
131
YR
134 GW 136
U8
138 RN 145 BG 169
S
170
BS
171
NR
175
Gfl
176 KU 207
NB
209
OK
222 OS 226 6N 248
NS
250
WS
255
UG
2SS
G
258
KB
324
Y
525
LG
528
RN
550 YG 331
YU
351 WU 555
WR

568 OS 569 OU 577
BG
378 BS 380 PG 381
BP
586 GO 587 BW 416 IGG 417 LOW 418 ION 420 LGR 421
LG
422
LGP
425 BS 457 LG 438 W 459 W "?»fK
AREA Al Al «
Al Al
Al Al Al
Al
A4-I0!
Al
Al C2 D4 04 D4 D4 04 Al 61 81 Bl Bl Bl ei 81 Bl 81 61 61 61 61 61 61
81 61 61 CI CI CI CI a CI CI CI a a a a Cl CI a P
NO COLOUR 461
P
477
8W
478 6 483 LGK 464 RIN 486 RN 488 6R0 489 UIN 495 OR 496 OU 500 KB 502
RU
503 6W 512 WY 514
R6
516 6LG 517 LGY 520 U 523
RW
524
6
526
BK
527 eK 530 N 533 N 554 N 535
N
541
YR
545
YH
546 YB 547 6 548 RG 549 GR 553
PS
556
BK
557
PR
559
Y
567 RN 568 R 569 U 570
U
572 U 574
WK
576
W
584
GR
586 LGO 587
WY
588
WS
593 GW 595 BY 600 66 603 NR 604 NB 608 0 610 W
iiin CI CI CI a u a 01 Dl Al Al Al Al Al Al Al Al Al Al Al Al Al Al A2 A2 A2 A2 C2 02 C2 C2 02 02 65 C5 05 C5 05 05 A5-III A4-I0E A4-I0t Bl A4-II0 81 61 61 61 A4-I09 61 61 61 61 Bl A4-II0
NO COLOUR 613 W 615
BU
616
P
617 PW 618
8
622 K8 629 RK 630 NR 643 GW 646 GR 649 P 655
H
657
W
659
H
660 H 661
N
662
N
663 P 664
WK
668 WO 670 N 671
N
673
N
674 PH 675
N
680 G 681
N
682 R 687 NY 688 00 690 OW 695 P 699 NU 705
WK
711
RW
713
W
716 PW 717
OU

AltfA A4-IID 81 a CI CI CI 64-102 CI A4-I09 CI CI A3-I0S A4-II0 A3-I07 A3-I0r A5-I05 CI CI CI CI *3-IO( A3-I0e A3-I07
64-10'
A3-I07
64-lO;
A3-I0!
CI CI CI CI CI CI CI 64-101 A4-II0 a CI
Wiring Diagram
Model
-
Aston Martin DB7 Coupe
Harness Title
-
Bulkhead RHD
- 4

Part No.-83
7-81306

Revision
- 0
Sheet 11 of 29
-
Up to 97 MY

14 65 86
94 96 97 109 121 l}l 134 136 I3B 145 169 170 171 173 176 207 209 222 226
248
250 255 255
258 324
325
328 330 331
351 355

COLOUR
VfU
UB
BK
RY UW 61 LCB m YR GW UB RN BO S BS NR 6B KU NB OK OS BN NS WS UG G KB Y LG RN YG YU WU
WR

368 OS 369 OU
377 BC
378
BS
380 PG
381
BP
386 GO
387 BW
416 LGG
417
LOW
4IS
LGN
420 LGR
421
LG
422 LGP
423 BS 437 LG
438*
439 W
449WK
461
P
477 BW
478
B
483LGK
484 RIN 486 RN 488 BRO 489 UIN 495 OR 496 OU 500 KB
502
RU 503 BW 5P2
WY
514
RB
516
BLG
517
LCY
520 U
523
RW 524
B
526 BK 527 BK 530
N
533
H
534
N 535
N
541
YR
545 YN
546
YB 547 B
548 RG
549
GR 553 PS 556 BK

AREA
B3-I14 C5
A6
B3-II3
C2 A6 A6 A6 A6 B6 B6 86 86 86 86 86
D3 C2 C3 C3 C3 B3
B6 C2
D3
86 86 66 86
85-121
86 B6
D3
B6
03 03 86 86 CI
84-120 03 C3-1I5
05 05 05
C5
84-119
C5 66 C5 B6 86 B3
82
Be
86 03 02
85-121
C2 C2
86 C6 C6
82-112 C3-II5 83-116
C2 03
B4-II8
B5
C6 C6 C6 C5
84-II7 02 02
C6
C5 B2 82
C6 C6
ce
C2
NO
COLOUR
557 PR 559 Y 567 RN 568 R 569 U
570 U
572
U
574
WK
576
W
584 GR
586 LGO
597
WY
568 WS
593
BW
595 GY 600 GB
603 NR
604
OB
608 0 610
W
613 W
615 eu
616
P
617
PW
618
B
622 KB
629 RK
630 NR 643 GW 646 GR 649 P 655 N 657 W
659 N
660 N 661
N
662 N 665 P 664 WK 668 WO
670 N
671
N
673 N
674 PN 675 N 680 G ESI
N
682
R
687 NY 688 08 690 OW 695 P 699 NU 705
WK
711
RW
713
W
716
PW
717
OU

AREA
C6
ce
85-121
II
A2 A2 A2 02 02 C2 C2 C3 C3 03 D5
C5 C5 C5 05 06 06 06 06 06
AG
AG
AG AG
B6 B6 B6 B6
Be B6 B6 66 66
B6 B6 66
66
ce ce
C6 C6 C6
ce ce
C6
ce
C6
NO coLOuit
PIN
inti 569 U
U Al
570
U
W Al

I H>^ 1

NO COLOUR
Pm
AREA 571
RY U
B5-1I5 572
U
W Al

I M>^ 1

NO COLOUlt
Pl((
577
GR
1
578 GY
2
982 GU
5
583 GN
4

AREA
62 82 62 62
DIAGNOSTICS
SOCKET

1HH41

SHEET
II
AREA
6
<4
«

SPL
116 SPL 117

KEY SOLENOID
r-|

KEY-IN WARNING SWITCH
NO
COLOUR
PIN
iS5EA^
580 PG
I Bl
573 B
2 C6

449 WK
I
461
P 2
226
6N 5
577 GR
4
578 GY
5
6 579 B
7
580 6
581
RW
982 GU 583 GH
NO COLOUF 207
NB
914
R6
96
UW
584 GR 585 SW 176
KU
553 PS 222
OS
209 OK 986 LGO 587 WY
250 WS 489 UIN 484 RIN mm

NN
1 2 5 4 5 6 7 8 9 10 II 12 13 14 15
If

AREA
Al CI Al Al 06 Al Dl Al Al Al Al
Bl CI CI
P
_..
NO COLOUR
PIN
588 WS
U
483 LGK
W
589 LGK
W

AREA
Al CI
Bi
L
120 SPL 121
SPL
119

^VWv-
NO
COLOUR
PIN
AREA"
920
U
A CI
iSM
B C5

DE
ilD
OKD

NO tdliVK t>IN 541
YR
1
599 LGY
2
600 GB
3
601
B 4

AREA
01
84-18
Al
??
INSTRUMENT PACK GREEN
IGNITION SWITCH NO COLOUR
PIN
534
N
1
574 WK
2
575 WY
3
57GW
4

AREA
01 Al
A3-II6
Al

NO COLbUR t>IN 590 BS 591
RY
589 LGK 592
RU
593
GW
586 GO 551
WU
594
6W
253
UG
516
BLG
595 BY 173
66
596 OU 569 OU 597 OS 368 OS

1 2 3 4 9 6 7 8 9 10 II 12 15 14 15
,,.,lf
AREA
C6
B3-II3
C5
62-112
Al 61 Bl
C3-II5
61 01 Al Al
ce
61 C6 61

-2.
4

J
12

CRUISE DISABLE
AND
STOP LIGHT SWITCH

Qli
All
Oil

ID
cm;

ii

[[(Dfl)

IDO
Dlczr'

COLUMN SWITCHOEAR
N6
COLOUt
602 6 527
BK
603 NR 604 NB 998 U 65
UB
605 GW 457 LG 606 GR 422
LOR
607 LC 420 LCP
418
LGH
417
LGW
608 0 416
LGG
609 RW 140
PB

PIN 1 2 3 4 9 6 7
n
9 10 II 12 15 14 19 16 17 18 19

AREA
C6 Dl Al Al 69 Al C6 CI C6 CI
B4-II9
Bl
61
61 Al D6 66
NO
COLOUR
86
eK
97
GY
109
LGB
121
WR
131
YR
134
NT
136
UB
138
RN
140
PB
144
WY
149
BG 169 S
170
BS
171
NR
248 NS 295
G
258 KB
324 Y 325 IG 330 YO 331
YU
355
WR 377 BG
378
BS
423 BS 436 W 439 W 477 BW
478 B
495 OU 496 KB 500 BS 523
RW
924
B
926
BK
533 N 535 N 547 8 548 RC 549 GR
556 BK 557 PR 599 Y 968 R 973 B 579 B 580
6
581
RW
585 SW
590 66
596 OU
597 OS
601 6 602 6
605 GW 606 GR 609 RW
610
W
613
W
615
BU
616
P
617
PW

AREA
Al Al Al Al Al Al Al Al D9
B3-II6
Al Al Al Al
61 61 61 61 Bl Bl Bl 61
Al Al C2 B2 B2 82 C3 D3 05 D5 C9 C5 C5 C5 D5 Bl 81
NO
COLOUR
618
B
622 KB 629
RK 630 NR 654 RN 659 RU 645 GW 646 GR 649 P 655 N 657 W 658 LCY 659 N 660 N 661
N
662 N
G65P
664 WK 667 LG 668 WO 670 N 671
N
673 N
674
PN 675 N
678
WU
680 G 681
N
682 R 685 N 685 N 687 NY 688 OG 690 OW 699 P 699 NU 700 BP 701
RN
704
BP
709
WK 711
RW
715
W
716
PW
717
OU

AREA
61 Bl Bl
81
B9-I2I B2-II2
Bl Bl Bl Bl Bl
B4-II8
81 Bl Bl Bl

B3-II4
61 Bl 61 Bl Bl Bl
B4-II4
CI
CI CI
B4-II7
62-117
CI CI CI CI CI A9-I20 89-121 A5-I20 CI CI CI CI CI

I^:M^'^2?
Wiring Diagram
Model
-
Aston Martin
DB7
Coupe
Harness Title
-
Bulkhead
RHD
-
5

Part No.-837-81307
Revision
-
0
Sheet
12 of 29
-
Up to 97 MY