1996 VOLVO 850 lock

1996 Volvo 850

1 - Plastic cover, 2 - Bulb HB4/9006
3 - Bulb HB3/9005, 4 - Connector

Headlight bulb replacement

1. Turn the plastic cover counter-clockwise and remove it.
2. Turn the bulb and connector (one unit) 1/4 turn counter-clockwise a\
nd remove.
3. Disconnect the wiring from the bulb unit.
4. Connect a new bulb unit into the wiring without touching the bulb its\
elf.
5. Re-insert the bulb into the headlight housing and turn 1/4 turn clock\
wise until the unit seats properly.
The unit has three guide lugs to ensure proper seating.
6. Reinstall the plastic cover.

Headlight adjustment

The height of the headlight beams can be adjusted according to vehicle l\
oad. The headlights should be re-
aimed if heavy loads are carried in the trunk/cargo area or rear seat, o\
r when towing a trailer.
To adjust the headlights:
l Park the car on a level surface and open the hood.
l The headlights are equipped with a level which can be seen by looking th\
rough the clear "window" on
the top of the headlight lens.
l Turn the height adjustment knob (A) until the bubble in the level alig\
ns with the "0" marks or within
the dark marking lines.
file:///K|/ownersdocs/1996/1996_850/96850_605.htm (2 of 13)12/30/2006 \
9:59:43 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

Location of bulbs in holder

All the bulbs in the tail light unit are replaced from inside the trunk \
as follows:

1. Turn the two plastic screws and open the cover over the rear lamp uni\
t.
2. Loosen and remove the bulb holder.
3. Let the connector with its wires remain attached to the bulb holder. \

4. Remove the bulb by pressing in and turning counter-clockwise.
5. Insert a new bulb into the holder and reinstall the holder into the t\
ail light assembly.
6. Close the cover.


Bulbs 1, 4:
5W/4 cp BA 15 s


Bulbs 2, 3, 5, 6:
21W/32 cp BA 15 s
pg. 6:8 Replacing bulbs
file:///K|/ownersdocs/1996/1996_850/96850_605.htm (4 of 13)12/30/2006 \
9:59:43 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
2. Brake light
3. Tail light
4. Back-up light
5. Tail light / Rear fog light (left side only)

All the bulbs in the tail light unit are replaced from inside the cargo \
space as follows:
l Turn the ignition key to position 0 and switch off the lights.
l Remove the upper panel of the tail light unit by using a screwdriver and\
/or the lower panel by first
removing the side floor cover and then the panel.
l Press in the plastic catches (A or B) and take out the bulb holder.
l Remove the speaker (optional) from the upper section of the tail light\
unit.
l Leave the connector and cables connected to the bulb holder.
l Remove the bulb by pressing it inwards and turning it slightly counter-c\
lockwise.
l Insert a new bulb into the bulb holder and reinstall the holder in the t\
ail light assembly.
l Check that the bulb works. Reinstall the cover.
pg. 6:9 Replacing bulbs Depress the catches (sedans)

Press sides and pull out/down (wagons)

file:///K|/ownersdocs/1996/1996_850/96850_605.htm (6 of 13)12/30/2006 \
9:59:43 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

Press in the springs (sedans) Remove the cover (wagons)

High-mounted brake light

Sedans:
l Turn off the ignition.
l Press in the springs on both sides of the holder.
l Pull the cover towards you.
l Depress the catches on both sides of the reflector and withdraw it from \
the holder.
l Replace the bulb.
l Reinstall the reflector.
l Press the cover into place.

Wagons:
l Turn off the ignition.
l Press the sides of the cover using both hands and pull it out and down. \
l Remove the inner protective cover from the bulb.
l Remove the bulb by pressing in and turning slightly counter-clockwise.
l Replace the bulb.
l Reinstall the protective cover over the bulb.
l Press the cover into place.
pg. 6:10 Replacing bulbs
file:///K|/ownersdocs/1996/1996_850/96850_605.htm (7 of 13)12/30/2006 \
9:59:43 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
l Turn the plastic cover counter-clockwise to remove it.
l Press the spring toward the lamp unit to release it and move it to the s\
ide.
l Replace the bulb.
l Reinstall in reverse order.




Contents | Top of Page
file:///K|/ownersdocs/1996/1996_850/96850_605.htm (13 of 13)12/30/2006\
9:59:43 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
examine the curved metal wire to see if it is broken. If so, put in a ne\
w fuse of the same color and
amperage (written on the fuse). Spare fuses are stored in a compartmen\
t in the fuse box.

If fuses burn out repeatedly, have the electrical system tested at a Vol\
vo retailer.

If you find it difficult to remove a fuse, you will find a special fuse \
tool clipped in the fuse box. pg. 6:14 Fuses
Location * Amperage

1 Fuel injection, distributor ignition system, automatic gearbox 15A
2 Fuel pump 15A
3 Interior courtesy lights 10A
4 –
5 ECC blower (speed 4) 30A
6 Central locking system 25A
7 Audio system 15A
8 –
9 ABS 30A
10 Electrically heated rear seat 15A
11 Electrically heated rear window and side-door mirrors 30A
12 Brake lights 10A
13 Hazard warning flashers, headlight flashers 15A
14 ABS 30A
15 OBD socket, courtesy lights, open door warning lights,
remote operated central locking system 10A
16 Power antenna, electrical connector for trailer, accessories 30A
17 Key reminder, seat belt reminder 10A
18 Front fog lights 15A
19 Left high beam 15A
20 Right high beam, high beam indicator light 15A
21 Left low beam 15A
22 Right low beam 15A
23 Left parking lights, license plate lights 10A
24 Right parking lights 10A
25 Rear fog light, rear fog light indicator light 10A
26 Heated front/rear seats, power side-view mirrors 25A
27 Backup lights, direction indicators 15A
file:///K|/ownersdocs/1996/1996_850/96850_613.htm (2 of 8)12/30/2006 9\
:59:46 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
28 Cruise control, heated rear windows, seat belt reminder light,
bulb failure warning sensor, shiftlock 10A
29 ABS 15A
30 Cigarette lighter 10A
31 ECC blower (speeds 1-3), ECC, AC-compressor 25A
32 Audio system, remote controlled central locking 10A

Location * Amperage
33 Rear window wiper/washer (wagons) 15A
34 Windshield/headlight wipers/washers, horn 25A
35 Instrument panel lights, power sun roof 10A
36 –
37 Power windows, power sun roof AUT/CB **
38 –
39 Power seat (driver's side) AUT/CB **
40 Power seat (passenger's side) AUT/CB **
* Some of the equipment/systems listed may be available on certain model\
s only.
** This is an automatic circuit breaker located in the fuse box and does\
not normally need to be
replaced.

For more detailed information concerning function and location of relays\
, fuses, etc., refer to the Volvo
Service Manuals. These can be purchased directly using the Service Liter\
ature Brochure/Order Form or
through your Volvo retailer. pg. 6:15 Installation of accessories
file:///K|/ownersdocs/1996/1996_850/96850_613.htm (3 of 8)12/30/2006 9\
:59:46 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

Shiftlock release (automatic transmission only)

The gear selector is locked in the (P)ark position. To manually releas\
e the shiftlock:
l Turn the starting (ignition) key to position I
l Press firmly on the "SHIFTLOCK OVERRIDE" button located to the right of \
the base of the gear
selector
l While holding the override button down, press the button on the front of\
the gear selector
l Move the selector from the ( P )ark position.


Fuel tank cover does not open

Faulty motor in fuel tank cover
(Sedans):
Open the cover panel on the right tail light unit and pull on the hook. \

The fuel tank cover can then be opened.
(Wagons):
file:///K|/ownersdocs/1996/1996_850/96850_613.htm (7 of 8)12/30/2006 9\
:59:46 AMClassic Cars & Cycles www.ClassicCycles.org