1996 VOLVO 850 wheel

1996 Volvo 850
Evaporative control system

The car is equipped with a gas evaporative control system, which prevent\
s gasoline fumes from being
released into the atmosphere. The system is comprised of an expansion ch\
amber in the fuel tank, a roll-
over valve on the cross member in front of the fuel tank and a charcoal \
canister with a built-in vacuum
valve under the left-front wheel housing. The components are interconnec\
ted by hoses which channel
fuel vapor from the gas tank to the charcoal filter, where it is stored \
until the engine is started and then
drawn into the engine's air intake system.


Crankcase ventilation

The engine is provided with positive crankcase ventilation which prevent\
s crankcase gases from being
released into the atmosphere. Instead, the crankcase gases are admitted \
to the intake manifold and
cylinders.

PCV system

The orifice nipple in the intake manifold and the filter at the end of t\
he PCV hose in the air cleaner
should be inspected every 60,000 miles (96,000 km). Check/replace rubb\
er hoses at the same time. pg. 8:9 Lubrication
file:///K|/ownersdocs/1996/1996_850/96850_806.htm (5 of 11)12/30/2006 \
9:59:52 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
Turbo: Champion RC7GYC (or equivalent)
Spark plug gap 0.028" (0.7 mm)
Tightening torque 18.4 ft. lbs. +/- 3.7 ft. lbs. (25 Nm +/- 5 Nm)

Front suspension

Spring strut suspension with integrated shock absorbers and control arm \
linked to the support frame.
Power-assisted rack and pinion steering. Safety type steering column.
The alignment specifications apply to an unladen car but include fuel, c\
oolant, and spare wheel.

Toe-in measured on the wheel rims: 2.4 mm +/- 0.7 mm
Toe-in measured on tire sides: 2.9 +/- 0.9 mm

Rear Suspension

Delta-link individual rear-wheel suspension with longitudinal support ar\
ms, double link arms and track
rods.

Toe-in measured on the tire sides: 4° +/- 10°

All specifications are subject to change without notice. pg. 9:5 Specifications (cont.)
Power transmission

Manual transmission: M 56 H
Single-disc dry plate clutch. All-synchromesh on all gears including rev\
erse; integrated final drive.
Operation via a floor mounted gear lever.

Final drive ratio 4.00:1
Reduction ratios
file:///K|/ownersdocs/1996/1996_850/96850_901.htm (5 of 7)12/30/2006 9\
:59:55 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

Length (sedan) 183.5 in. (466 cm)
(wagon) 185.4 in. (471 cm)
Width 69.3 in. (176 cm)
Height (sedan) 55.7 in. (141 cm)
(wagon) 56.9 in. (145 cm)
Wheelbase 104.9 in. (266 cm)
Track, front 59.8 in. (152 cm)
Track, rear 57.9 in. (147 cm)
Turning circle (between
curbs) 33.5 ft. (10.2 m)
Cargo capacity
Sedan (seat up) 14.7 cu. ft. (0.44 m³)
Wagon (seat up) 37.1 cu. ft. (1.1 m³)
Sedan (seat down) 33.2 cu. ft. (0.99 m³)
Wagon (seat down) 67.0 cu. ft. (2.0 m³)
WARNING! When adding accessories, equipment, luggage and other cargo to \
your vehicle, the total
loaded weight capacity of the vehicle must not be exceeded.

Gross vehicle weight (GVW) USA Canada
850 (sedan) 4180 lbs (1896 kg) 1900 kg
850 (wagon) 4340 lbs (1969 kg) 1970 kg
850 Turbo (sedan) 4250 lbs (1928 kg) 1930 kg
850 Turbo (wagon) 4340 lbs (1969 kg) 1970 kg

Capacity Weight *
850 (sedan) 920 lbs (417 kg) 415 kg
850 (wagon) 1005 lbs (456 kg) 460 kg
850 Turbo (sedan) 920 lbs (417 kg) 415 kg
850 Turbo (wagon) 950 lbs (431 kg) 430 kg
850 R Turbo (sedan) 880 lbs (399 kg) 400 kg
850 R Turbo (wagon) 880 lbs (399 kg) 400 kg

Curb weight USA Canada
850 sedan 3120-3250 lbs (1415-1519 kg) 1385-1520 kg
850 wagon 3230-3460 lbs (1465-1569 kg) 1465-1570 kg

Permissible axle weight, front
file:///K|/ownersdocs/1996/1996_850/96850_906.htm (3 of 9)12/30/2006 9\
:59:57 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
7- Springs Shock Absorbers and Wheels; 8- Body and Interior.

A Literature Catalog Request Card was placed in the car prior to deliver\
y from the retailer to you.
Complete ordering information is provided.


Volvo supports Voluntary Mechanic Certification by the A.S.E. Certified \
mechanics have demonstrated
a high degree of competence in specific areas. Besides passing exams eac\
h mechanic must also have
worked in the field for two or more years before a certificate is issued\
. These professional mechanics are
fully able to analyze vehicle problems and perform the necessary service\
procedures to keep your Volvo
at peak operating condition.

NOTE: The above pertains to the USA only.


Your new Volvo comes with a four year road assistance program named ON-C\
ALL. Additional
information, features, and benefits are described in a separate informat\
ion package in your glove
compartment.
file:///K|/ownersdocs/1996/1996_850/96850_906.htm (5 of 9)12/30/2006 9\
:59:57 AMClassic Cars & Cycles www.ClassicCycles.org