Page 43 of 2062

Downloaded from www.Manualslib.com manuals search engine MA003−05
MA−4
− MAINTENANCEUNDER HOOD
39 Author: Date:
1996 TOYOTA T100 (RM449U)
UNDER HOOD
GENERAL MAINTENANCE
1. GENERAL NOTES
Maintenance items may vary from country to country. Check the owner’s manual supplement in which
the maintenance schedule is shown.
Every service item in the periodic maintenance schedule must be performed.
Periodic maintenance service must be performed according to whichever interval in the periodic main-
tenance schedule occurs first, the odometer reading (miles) or the time interval (months).
Maintenance service after the last period should be performed at the same interval as before unless
otherwise noted.
Failure to do even one item can cause the engine to run poorly and increase exhaust emissions.
2. WINDSHIELD WASHER FLUID
Check that there is sufficient fluid in the tank.
3. ENGINE COOLANT LEVEL
Check that the coolant level is between the FULL and LOW lines on the see−through reservoir.
4. RADIATOR AND HOSES
(a) Check that the front of the radiator is clean and not blocked with leaves, dirt or bugs.
(b) Check the hoses for cracks, kinks, rot or loose connections.
5. BATTERY ELECTROLYTE LEVEL
Check that the electrolyte level of all battery cells is between the upper and lower level lines on the case.
6. BRAKE AND CLUTCH FLUID LEVELS
Check that the brake and clutch fluid levels are near the upper level line on the see−through reservoirs.
7. ENGINE DRIVE BELTS
Check all drive belts for fraying, cracks, wear or oiliness.
8. ENGINE OIL LEVEL
Check the level on the dipstick with the engine turned off.
9. POWER STEERING FLUID LEVEL
(a) Check the level on the dipstick.
(b) The level should be in the HOT or COLD range depending on the fluid temperature.
10. AUTOMATIC TRANSMISSION FLUID LEVEL
(a) Park the vehicle on a level surface.
(b) With the engine idling and the parking brake applied, shift the selector into all positions from the P to
L, and then shift into the P position.
(c) Pull out the dipstick and wipe off the fluid with a clean rag. Re−insert the dipstick and check that the
fluid level is in the HOT range.
(d) Do this check with the fluid at normal driving temperature (70 − 80°C, 158 − 176°F).
HINT:
Wait until the engine cools down (approx. 30 min.) before checking the fluid level after extended driving at
high speeds, in hot weather, in heavy traffic or pulling a trailer.
11. EXHAUST SYSTEM
(a) Visually inspect for cracks, holes or loose supports.
(b) If any change in the sound of the exhaust or smell of the exhaust fumes is noticed, have the cause
located and corrected.
Page 48 of 2062

Downloaded from www.Manualslib.com manuals search engine B02091
Z04824
A/T
OK if coolOK if hot
Add if coolAdd if hot
B02092
B02093
− MAINTENANCECHASSIS
MA−9
44 Author: Date:
1996 TOYOTA T100 (RM449U)
6. 2WD:
CHECK OIL LEVEL IN MANUAL TRANSMISSION, AU-
TOMATIC TRANSMISSION AND DIFFERENTIAL
(a) Manual transmission:
Remove the filler plug and feel inside the hole with your
finger. Check that the oil comes to within 5 mm (0.20 in.)
of the bottom edge of the hole. If the level is low, add oil
until it begins to run out of the filler hole.
Transmission oil (M/T):
R150: See page MT−5
W59: See page MT−5
(b) Automatic transmission:
Check that the fluid level is in the ”HOT” range at the nor-
mal operating temperature (70 − 80°C or 158 − 176°F)
and add as necessary.
NOTICE:
Do not overfill.
Transmission fluid (A/T): See page
DI−265
(c) Differential:
Remove the filler plug and feel inside the hole with your
finger. Check that the oil comes to within 5 mm (0.20 in.)
of the bottom edge of the hole. If the level is low, add oil
until it begins to run out of the filler hole.
Differential oil: See page SA−154
7. 5VZ−FE (4WD):
CHECK OIL LEVEL IN MANUAL TRANSMISSION, AU-
TOMATIC TRANSMISSION, TRANSFER AND DIFFER-
ENTIAL
(a) Manual transmission:
Remove the filler plug and feel inside the hole with your
finger. Check that the oil comes to within 5 mm (0.20 in.)
of the bottom edge of the hole. If the level is low, add oil
until it begins to run out of the filler hole.
Transmission oil (M/T):
R150F: See page MT−10
Page 49 of 2062

Downloaded from www.Manualslib.com manuals search engine Z04824
A/T
OK if coolOK if hot
Add if coolAdd if hot
B02094
B02095
MA−10
− MAINTENANCECHASSIS
45 Author: Date:
1996 TOYOTA T100 (RM449U)
(b) Automatic transmission:
Check that the fluid level is in the ”HOT” range at the nor-
mal operating temperature (70 − 80°C or 158 − 176°F)
and add as necessary.
NOTICE:
Do not overfill.
Transmission fluid (A/T): See page
DI−265
(c) Transfer:
Remove the filler plug and feel inside the hole with your
finger. Check that the oil comes to within 5 mm (0.20 in.)
of the bottom edge of the hole. If the level is low, add oil
until it begins to run out of the filler hole.
Transfer oil: See page TR−3
(d) Differential:
Remove the filler plug and feel inside the hole with your
finger. Check that the oil comes to within 5 mm (0.20 in.)
of the bottom edge of the hole. If the level is low, add oil
until it begins to run out of the filler hole.
Front differential oil: See page SA−43
Rear differential oil: See page SA−154
8. REPLACE MANUAL TRANSMISSION, TRANSFER
(5VZ−FE: 4WD) AND DIFFERENTIAL OIL
(a) Transfer:
Remove the transfer cover.
(b) Remove the drain plug and drain the oil.
(c) Reinstall drain plug securely.
(d) Add new oil until it begins to run out of the filler hole.
(2WD) Transmission oil (M/T):
R150: See page MT−5
W59: See page MT−5
Page 50 of 2062
Downloaded from www.Manualslib.com manuals search engine B02096
B02097
B02098
2WD
4WD
− MAINTENANCECHASSIS
MA−11
46 Author: Date:
1996 TOYOTA T100 (RM449U)
(5VZ−FE: 4WD) Transmission oil (M/T):
R150F: See page MT−10
Transfer oil: See page
TR−3
Front differential oil: See page SA−43
Rear differential oil: See page SA−154
9. REPLACE AUTOMATIC TRANSMISSION FLUID
(a) Remove the drain plug(s) and drain the fluid.
(b) Reinstall the drain plug(s) securely.
(c) With the engine OFF, add new fluid through the dipstick
tube.
Transmission fluid (A/T): See page DI−265
(d) Start the engine and shift the selector into all positions
from ”P” through ”L” and then shift into ”P”.
(e) With the engine idling, check the fluid level.
Add fluid up to the ”COOL” level on the dipstick.
Page 57 of 2062
Downloaded from www.Manualslib.com manuals search engine − PREPARATIONENGINE MECHANICAL (3RZ−FE)
PP−3
52 Author: Date:
1996 TOYOTA T100 (RM449U)
(09248−05420)Valve Lifter Stopper
09325−20010Transmission Oil Plug
09330−00021Companion Flange Holding ToolCrankshaft pulley
09550−10012Replacer Set ”B”
(09252−10010)No. 1 Replacer Handle−Valve guide busing
09608−30012Front Hub & Drive Pinion Bearing
Tool Set−
(09951−07100)Handle 100Crankshaft rear oil seal
09636−20010Upper Ball Joint Dust Cover
ReplacerCrankshaft timing gear
09816−30010Oil Pressure Switch SocketKnock sensor
09843−18020Diagnosis Check Wire
09950−40010Puller B Set
(09951−04010)Hanger 150
(09952−04010)Slide Arm
Page 92 of 2062
Downloaded from www.Manualslib.com manuals search engine PP01R−01
PP−38
− PREPARATIONLUBRICATION (5VZ−FE)
87 Author: Date:
1996 TOYOTA T100 (RM449U)
LUBRICATION (5VZ−FE)
SST (Special Service Tools)
09032−00100Oil Pan Seal Cutter
09228−07501Oil Filter Wrench
09309−37010Transmission Bearing ReplacerCamshaft front oil seal
09816−30010Oil Pressure Switch Socket
Page 117 of 2062
Downloaded from www.Manualslib.com manuals search engine PP3LR−01
− PREPARATIONMANUAL TRANSMISSION (R150, R150F)
PP−63
11 2 Author: Date:
1996 TOYOTA T100 (RM449U)
MANUAL TRANSMISSION (R150, R150F)
SST (Special Service Tools)
09201−10000Valve Guide Bushing Remover &
Replacer Set2WD:
Speedometer driven gear oil seal
(09201−01080)Valve Guide Bushing Remover &
Replacer 8
09309−35010Transmission Rear Bearing
Replacer2WD:
Output shaft rear bearing
Output shaft center bearing
09316−60011Transmission & Transfer Bearing
Replacer
(09316−00011)Replacer PipeOutput shaft rear bearing
Gear spline piece No.5
(09316−00031)Replacer ”B”5th gear
(09316−00071)Replacer ”F”4WD:
Output shaft rear bearing
Output shaft center bearing
09506−35010Differential Drive Pinion Rear
Bearing ReplacerInput shaft bearing
09921−00010Spring Tension Tool2WD:
Speedometer driven gear oil seal
09950−00020Bearing Remover
09950−60010Replacer Set
(09951−00510)Replacer 51Front bearing retainer oil seal
Page 118 of 2062
Downloaded from www.Manualslib.com manuals search engine PP−64
− PREPARATIONMANUAL TRANSMISSION (R150, R150F)
11 3 Author: Date:
1996 TOYOTA T100 (RM449U)
(09951−00570)Replacer 57Extension housing oil seal
Transfer adaptor oil seal
(09951−00620)Replacer 62Counter rear bearing
09950−70010Handle Set
(09951−07150)Handle 150