1996 FORD WINDSTAR battery

Roadside Emergencies
265
[RE02750(ALL)04/95]
24 pica art:0050259-B
Jumper Cable Placement (3.0L)
[RE02800(ALL)02/95]
After you connect the jumper cables to the batteries:
*
[RE02900(ALL)03/95]1.
Make sure that the jumper cables are not in the way of
moving engine parts, then start the vehicle that has the
booster battery. Run the engine at a moderate speed.
File:wnres.ex
Update:Tue Mar 19 08:18:21 1996

266
[RE03000(ALL)02/95]2.
Let the dead battery charge for a few minutes and then start
the vehicle that has the dead battery. If the starter does not
crank, check for good, solid jumper cable clamp attachments.
It may take a couple of tries before your vehicle starts. If
your vehicle does not start after several attempts, you may
have a different mechanical problem.
*
[RE03100(ALL)03/95]3.
When both vehicles are running, let them idle for a few
minutes to charge the dead battery.
% [RE03200(ALL)02/95]
Take the jumper cables off in the following order:
[RE03300(ALL)02/95]1.
Remove the negative (s) end of the jumper cable from the
metallic surface in the engine compartment of the vehicle
that needed a jump-start.
*
[RE03400(ALL)03/95]2.
Remove the other end of the negative (s) cable from the
booster battery.
*
[RE03500(ALL)03/95]3.
Remove the positive (+) cable from the booster battery.
*
[RE03600(ALL)03/95]4.
Remove the other end of the positive (+) cable from the
vehicle that needed a jump-start.
% [RE03700(ALL)02/95]
After your vehicle is started, let it idle for a while to let the
engine ªrelearnº its idle conditions and drive it around for a
little while with all electrical accessories turned off, to let the
battery recharge.You may need to use a battery charger to
fully recharge the battery.
File:wnres.ex
Update:Tue Mar 19 08:18:21 1996

283
Customer Assistance
%*
[HS00205(ALL)06/94]
Roadside Assistance
*
[HS00210(ALL)05/95]
Ford Motor Company has set up a 24-hour, seven-day-a-week
hotline with trained operators that put you in touch with the
help you need if you experience a problem with your vehicle.
This complimentary service is provided to you throughout your
warranty period of 3 years or 36,000 miles (3 years or
60,000 km), whichever comes first. To purchase Roadside
Assistance coverages beyond this period, through Ford Auto
Club, contact your Ford or Lincoln-Mercury dealer (not
available in Canada).
*
[HS00215(ALL)06/94]
Roadside Assistance will cover the following:
*
[HS00220(ALL)06/94]
n
Mount your spare if you have a flat tire.
*
[HS00225(ALL)06/94]
n
Jump-start your battery if it is dead.
*
[HS00230(ALL)06/94]
n
Unlock your vehicle if you are locked out.
*
[HS00235(ALL)06/94]
n
Bring you fuel if you run out.
*
[HS00240(ALL)06/94]
n
Tow your vehicle if you are stranded. Even non-warranty
related tows, like accidents or getting stuck in mud or snow,
are covered (some exclusions apply, such as impound towing
and repossession).
*
[HS00245(ALL)06/94]
How to use Roadside Assistance
*
[HS00250(ALL)06/94]
Your Roadside Assistance identification card can be found in the
Owner Guide portfolio in your glove compartment. Complete
the card and place it in your wallet for quick reference.
*
[HS00255(ALL)04/95]
To receive roadside assistance in the United States call
1-800-241-FORD (in Canada call 1-800-665-2006).
*
[HS00260(ALL)04/95]
Should you need to arrange for roadside assistance yourself,
Ford Motor Company will reimburse the reasonable cost. To
obtain information about reimbursement call 1-800-241-FORD
(in Canada call 1-800-665-2006).
File:wnhss.ex
Update:Tue Mar 19 08:17:31 1996

302
*
[SV02700(ALL)01/95]
n
Never get under a vehicle while it is supported by a jack
only. If you must work under a vehicle, use safety stands.
*
[SV02800(ALL)01/95]
n
Keep all lit cigarettes and other smoking materials away
from the battery and all fuel-related parts.
*
[SV02900(ALL)03/95]
Working Under the Hood
[SV03000(ALL)02/95]
Before you open the hood, read this section carefully.
*
[SV03100(ALL)02/95]
If you plan to work under the hood while the engine is
off:
*
[SV03200(ALL)01/93]
RWARNING
Set the parking brake and make sure the gearshift is
securely latched in P (Park). This will prevent your
vehicle from moving unexpectedly.
*
[SV03300(ALL)01/93]
RWARNING
Always remove the key from the ignition after you turn
off the engine.
*
[SV03400(ALL)03/95]
If you must work under the hood while the engine is
on:
[SV03500(ALL)05/95]
RWARNING
Set the parking brake and make sure that the gearshift is
securely latched in P (Park). This will prevent your
vehicle from moving unexpectedly.
*
[SV03600(ALL)03/95]
RWARNING
Do not wear loose clothing or jewelry that can get caught
in the moving parts.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996

Servicing Your Windstar
323
*
[SV20800(ALL)01/93]
To find out how much engine coolant mixture your vehicle's
coolant system can hold, seeRefill Capacitieslater in this chapter.
[SV20900(ALL)02/95]
You may add water by itself only in an emergency, but you
should replace it with a 50/50 mixture of water and coolant as
soon as possible.
*
[SV21000(ALL)02/95]
Have your dealer check the engine cooling system for leaks if
you have to add engine coolant more than once a month, or
you have to add more than a quart (liter) at a time.
%*
[SV21100(ALL)11/94]
Checking hoses
*
[SV21200(ALL)01/93]
Inspect all engine and heater system hoses for deterioration,
leaks and loose clamps before adding or replacing engine
coolant. Make whatever repairs or replacements are necessary
using Motorcraft parts or their equivalents.
%*
[SV21300(ALL)05/95]
Engine coolant drain and flush
[SV21400(ALL)11/93]
To drain and flush your engine coolant, youMUSTsee your
Ford dealer or refer to the procedure in the service manual.
Failing to do so could result in engine damage.
%*
[SV21505(ALL)05/95]
Battery
*
[SV21510(ALL)02/95]
The Motorcraft maintenance-free battery does not require
additional water during its life of service. The vents are part of
the cover and cannot be removed. For longer, trouble-free
operation, keep the top of the battery clean and dry. Also, make
certain the battery cables are tightly fastened to the battery
terminals.
*
[SV21515(ALL)02/95]
If you see any corrosion on the battery cables or terminals,
remove the cables from the terminal and clean them both with a
wire brush. You can neutralize the acid with a solution of
baking soda and water. Reinstall the cables when you are done
cleaning them, and apply a small quantity of grease to the top
of each battery terminal to help prevent corrosion.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996

324
*
[SV21520(ALL)06/95]
Battery Replacement
*
[SV21525(ALL)02/95]
If your original equipment battery requires replacement while
under warranty, it may, in some cases, be replaced by a
Motorcraft low-maintenance battery. The low-maintenance
battery has removable vent caps for checking the electrolyte
level and for adding water, if needed.
*
[SV21530(ALL)02/95]
Check your battery's electrolyte level, at least every 12 months
or 12,000 miles (20,000 km), in temperatures up to90ÊF (32ÊC).
Keep the electrolyte in each cell up to the ªlevelº indicator. Do
not overfill the battery cell.
*
[SV21535(ALL)05/95]
If the electrolyte level in your battery gets low, you can add
plain tap water to the battery, as long as you do not use hard
water (water with a high mineral or alkali content). If possible,
however, try to only fill the battery cell with distilled water. If
the battery needs water often, have the charging system
checked.
%*
[SV21540(ALL)03/95]
Help Us Protect Our Environment
*
[SV21545(ALL)04/95]
Ford Motor Company strongly recommends that used lead-acid
batteries be returned to an authorized recycling facility for
disposal.
*
[SV21550(ALL)02/95]
7-1/2 pica art:0040201-A
Battery recycling symbol
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996

Servicing Your Windstar
325
*
[SV21555(ALL)02/95]
RWARNING
The gases around the battery can explode if exposed to
flames, sparks, or lit cigarettes. An explosion could result
in injury or vehicle damage.
%*
[SV21560(ALL)05/95]
RWARNING
Batteries contain sulfuric acid which burns skin, eyes,
and clothing.
*
[SV21562(ALL)05/95]
If the acid touches someone's skin, eyes, or clothing,
immediately flush the area with water for at least 15 minutes. If
someone swallows the acid, have him or her drink lots of milk
or water first, then Milk of Magnesia, a beaten egg, or vegetable
oil. Call a doctor immediately.
%*
[SV21570(ALL)05/95]
RWARNING
Applying too much pressure on the ends when lifting a
battery could cause acid to spill. Lift the battery with a
carrier or with your hands on the opposite corners.
%*
[SV21580(ALL)03/95]
Windshield Washer Fluid and Wipers
%*
[SV21600(ALL)03/95]
Washer Fluid
[SV21700(ALL)02/95]
Check the level of the windshield washer fluid every time you
stop for fuel. The reservoir for washer fluid is located on the
front, passenger side of the engine compartment. This reservoir
contains the fluid for both the windshield and liftgate washers.
*
[SV21900(ALL)05/95]
RWARNING
Do not put windshield washer fluid in the container for
the engine coolant.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996

350
*
[SV37500(ALL)05/95]
RWARNING
Always disconnect the battery before servicing high
current fuses.
*
[SV37520(ALL)05/95]
Ford recommends that high current fuses be replaced by a
qualified technician.
*
[SV37600(ALL)03/93]
RWARNING
Always replace the cover to the Power Distribution Box
before reconnecting the battery or refilling fluid
reservoirs.
[SV37700(ALL)12/93]
A blown maxi-fuse may be replaced but will continue to blow
until the cause of the overload condition is corrected.
*
[SV37800(ALL)05/95]
RWARNING
Always replace a fuse with one that has the specified
amperage rating. Using a fuse with a higher amperage
rating can cause severe wire damage and could start a
fire.
%*
[SV38400(ALL)10/94]
Relays
% [SV38500(ALL)03/94]
Relays are devices which receive signals from components or
systems. After receiving signals, relays transfer these signals to
activate or deactivate other components or systems. One relay
box is located with the maxi-fuses near the battery and one is
located with the fuse panel under the instrument panel.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996