1996 FORD RANGER transmission fluid

302
%*
[SV34400(ALL)06/95]
Manual Transmission and Transfer Case
Fluid
*
[SV34600(ALL)01/95]
Checking the Manual Transmission Fluid
*
[SV34700(ALL)12/91]
Clean the filler plug on the side of the case. Remove the filler
plug. The fluid level should be up to the bottom of the filler
plug hole.
*
[SV34800(ALL)03/91]
If additional fluid is required:
*
[SV34900(ALL)01/95]1.
Add enough fluid through the filler plug hole to bring the
level up to the bottom of the hole. Use only fluid certified to
meet Ford Motor Company lubricant specification as listed
underRefill Capacities, Motorcraft Parts, and Lubricant
Specifications,later in this chapter.
*
[SV35000(ALL)03/91]2.
Replace the filler plug in its original position, making sure it
is fully seated.
%*
[SV35100(ALL)02/95]
The Clutch
*
[SV35200(ALL)03/91]
The clutch on your vehicle is automatically self-adjusting and
should not require any routine service.
*
[SV35301(ALL)03/91]
During normal operation the fluid level in the clutch reservoir
will slowly rise. If for any reason the fluid level drops, maintain
the fluid level at the step in the reservoir body.
%*
[SV35400(ALL)03/94]
If it becomes necessary to remove the reservoir cap, thoroughly
clean the reservoir cap before removing it to prevent dirt or
water from entering the reservoir. Remove the internal
diaphragm and then add only a DOT 3 brake fluid such as Ford
High Performance DOT 3 Brake Fluid, meeting Ford
specification ESA-M6C25-A.
File:15unsvr.ex
Update:Wed May 1 13:56:18 1996

Servicing Your Ranger
307
[SV38501(R )04/94]
10-1/2 pica
art:0020383-C
Power steering reservoir
[SV38550(ALL)07/95]
10-1/2 pica
art:0090155-A
Power steering dipstick location
*
[SV38800(ALL)07/94]5.
If the power steering fluid is low, add fluid in small
amounts, continuously checking the level, until you reach the
FULL HOT range. Do not overfill.
*
[SV38850(ALL)03/95]6.
When you are finished, put the dipstick back in and make
sure that it fits snugly.
[SV38900(ALL)05/95]
Use only power steering fluid that meets Ford specification such
as MERCONHAutomatic Transmission Fluid (or equivalent).
File:15unsvr.ex
Update:Wed May 1 13:56:18 1996

350
Audio system (see Electronic sound system)....... 127
Autolamp system (see Headlamps)............ 82
Automatic transmission
driving an automatic overdrive............ 158
fluid, adding.................... 301
fluid, checking................... 300
fluid, specification.................. 331
Axle
lubricant specifications................ 331
traction lok...................186, 289
B
Backing up...................... 157
Basic vehicle warranty.................. 3
Battery
acid, treating emergencies............219, 298
battery saver.................... 107
charging system warning light............. 62
disconnecting.................... 222
how to service................... 297
jumping a disabled battery.............. 219
maintenance-free.................. 297
proper disposal, recycling.............. 298
replacement, specifications.............. 330
servicing...................... 297
voltage gauge.................. 62,64
when storing your vehicle.............. 336
Brake fluid
brake warning light.................. 56
checking and adding................ 304
description..................... 304
specifications.................... 331
Brakes
adjustment..................... 177
anti-lock...................... 177
applying the brakes................. 182
brake warning light.................. 56
File:unixr.ex
Update:Wed May 1 13:58:05 1996

354
D
Dashboard (see Instrument panel)............. 73
Daytime running light system.............. 82
Defects, reporting................... 247
Defrost, windshield................. 77,80
Dipstick
automatic transmission fluid...........299, 301
engine oil..................... 276
power steering fluid................. 305
Disabled vehicle (see Towing)............. 234
Dispute Settlement Board............... 243
Doors......................... 99
lubricant specifications................ 331
Driveline universal joint and slip yoke......... 303
Driving under special conditions
bad weather.................... 185
heavy load..................... 188
high speed..................... 185
high water..................... 187
slippery roads................... 185
tips for safe driving................. 184
towing a trailer................... 191
E
Electrical system
fuses......................308, 314
operating when the engine is off............ 41
power point outlet................. 126
relays....................... 315
Electronic sound system
accessory delay.................... 41
radio reception................... 152
tuning the radio................130, 146
warranty and service information........... 154
Electronic stereo cassette radio (see Electronic
sound system)................. 129
Electronic stereo radio (see Electronic sound system) . . . 129
File:unixr.ex
Update:Wed May 1 13:58:05 1996

362
M
Maintenance schedule and record (see separate
Maintenance Schedule and Record booklet)..... 3
Maintenance (see Servicing).............. 257
Manual transmission
clutch.....................161, 302
fluid, checking and adding.............. 302
lubricant specifications................ 331
shifting gears.................... 162
shift speeds..................... 164
Master cylinder, brakes................ 304
Methanol in fuel................... 271
Mileage, calculating fuel economy............ 273
Mirrors
dual electric remote control............. 122
rearview...................... 122
side view mirrors.................. 122
side view mirrors (power).............. 122
Motorcraft parts.................... 330
N
National Highway Traffic Safety Administration..... 247
New vehicle break-in.................. 5
O
Octane rating..................... 269
Odometer
description...................... 70
trip odometer..................... 71
Off road driving, 4-wheel drive............. 174
Oil filter.....................277, 330
Oil (see Engine oil).................. 275
Oil viscosity..................... 275
File:unixr.ex
Update:Wed May 1 13:58:05 1996

368
Transfer case
fluid checking................... 302
lever operated................... 167
Transmission
automatic operation................. 156
fluid, checking and adding (automatic)........ 300
fluid, checking and adding (manual)......... 302
lubricant specifications................ 331
Transmission control switch.............. 158
Transmitter (see Remote entry)............. 103
Trip odometer..................... 71
Tune-up specifications (VECI)............. 325
Turn signal
indicator lights.................... 87
lever......................... 87
U
Used engine oil, disposal............258, 278, 301
V
Variable interval wipers................. 88
VECI (Vehicle Emission Control Information) decal.... 325
Vehicle Identification Number (VIN).......... 242
Vehicle loading.................... 192
calculating the load................. 198
understanding loading information.......... 188
Vehicle storage.................... 334
Ventilating your vehicle (see Climate control)....... 74
Viscosity (see Engine oil)................ 275
Voltmeter (see Battery voltage gauge)......... 62,64
File:unixr.ex
Update:Wed May 1 13:58:05 1996