1996 FORD RANGER engine coolant

282
[SV20475(ALL)09/95]
Severe winter climate
[SV20490(ALL)09/95]
If you drive in extremely cold climates (less than-34ÊF [-36ÊC]),
it may be necessary to increase the coolant concentration above
50%. Refer to the chart on the coolant container to ensure the
coolant concentration in your vehicle is such that the coolant
will not freeze at the temperature level in which you drive
during winter months. Never increase the engine coolant
concentration above 60%. Leave a 50/50 mixture of engine
coolant and water in your vehicle year-round in non-extreme
climates.
%*
[SV20500(ALL)08/95]
Checking Hoses
*
[SV20600(ALL)10/89]
Inspect all engine and heater system hoses for deterioration,
leaks and loose clamps before adding or replacing engine
coolant. Make whatever repairs or replacements that are
necessary using Motorcraft parts or their equivalents.
%*
[SV20700(ALL)08/95]
Engine Coolant Drain and Flush
*
[SV20800(ALL)10/89]
To drain your vehicle's engine coolant:
*
[SV20900(ALL)03/94]1.
Turn off the engine and let it cool. Fully depressurize the
engine cooling system by covering the radiator cap with a
thick cloth and turning it slowly counterclockwise to the first
stop. Step back while the pressure releases.
*
[SV20950(ALL)05/90]2.
Remove the cap.
*
[SV21000(ALL)05/90]3.
Attach a small hose to the drain tube at the bottom of the
radiator.
*
[SV21200(ALL)05/90]4.
Let the engine coolant drain into a suitable container.
Disconnect the lower radiator hose at the radiator connector
and drain any remaining engine coolant into a container.
*
[SV21250(ALL)05/95]
Proper procedures for flushing the cooling system can be found
in theService Manual.
File:15unsvr.ex
Update:Wed May 1 13:56:18 1996

Servicing Your Ranger
283
%*
[SV21300(ALL)08/95]
Engine coolant refill procedure
*
[SV21400(ALL)10/89]
After you have drained the engine cooling system:
[SV21700(ALL)10/89]1.
When cold, fill the radiator to a level 1 to 1 1/2 inches
(38 mm) below the filler neck seat.
*
[SV21900(ALL)03/94]2.
Replace the radiator cap to its fully installed position, then
back off to the first stop. This will prevent high pressure
from building up in the cooling system during this part of
the fill procedure.
*
[SV22100(ALL)10/89]3.
Start and idle the engine until the thermostat opens and the
radiator upper hose becomes warm.
*
[SV22200(ALL)05/95]4.
Shut off the engine and allow the engine to cool. Cover the
radiator cap with a thick cloth and cautiously remove it. Step
back while the pressure releases.
*
[SV22500(ALL)10/89]5.
Finally, check the radiator and add more engine coolant if
needed, following the procedures noted above. Reinstall the
radiator cap securely, when finished.
*
[SV22525(ALL)05/90]6.
If more engine coolant is necessary, fill the overflow
reservoir to the appropriate level marked on the bottle.
%*
[SV22700(ALL)03/95]
Windshield Washer Fluid and Wipers
%*
[SV22800(ALL)03/95]
Washer Fluid
*
[SV22900(ALL)01/95]
Check the level of the windshield washer fluid every time you
stop for fuel. The reservoir for washer fluid is located on the
passenger's side of the engine compartment. Visual inspection
can determine if the washer fluid is adequate. Do not operate
the washer when the reservoir is empty.
*
[SV23300(ALL)05/95]
RWARNING
Do not put windshield washer fluid in the container for
the engine coolant.
File:15unsvr.ex
Update:Wed May 1 13:56:18 1996

Servicing Your Ranger
305
*
[SV37000(ALL)01/95]
Do not fill the reservoir above the MAX line.
*
[SV37100(ALL)01/95]
If you find that the fluid level is excessively low Ð below the
seam or ridge on the outside of the plastic reservoir Ð have the
brake system inspected.
*
[SV37200(ALL)01/95]
RWARNING
Do not let the reservoir for the master cylinder run dry.
This may cause the brakes to fail.
[SV37500(ALL)04/94]
7-1/2 pica art:0020382-C
Brake master cylinder
%*
[SV37600(ALL)03/95]
Power Steering Fluid
*
[SV37700(ALL)01/95]
Check the level of the power steering fluid at least twice a
year (i.e., every Spring and Fall).
%*
[SV37800(ALL)03/95]
Checking and Adding Power Steering Fluid
*
[SV37900(ALL)02/95]1.
Start the engine and let it run until the power steering fluid
reaches normal operating temperature. The power steering
fluid will be at the right temperature when the engine
coolant temperature gauge in the instrument cluster is near
the center of the NORMAL operating temperature range.
*
[SV38000(ALL)01/95]2.
While the engine idles, turn the steering wheel back and
forth several times. Make sure that the cap assembly is
installed at this time.
*
[SV38100(ALL)05/95]3.
Turn the engine off.
File:15unsvr.ex
Update:Wed May 1 13:56:18 1996

Index
349
A
Accessory position on the ignition............. 41
Accessory power source, power point outlet....... 126
Additives, engine oil.................. 275
Air bag supplemental restraint system
and child safety seats................. 36
description.................... 25,30
disposal....................... 34
driver air bag................... 25,30
indicator light..................... 58
operation....................... 30
passenger air bag................... 30
proper seating.................... 27
service and information labels............. 30
tone generator.................. 31,34
wearing safety belts.................. 26
Air cleaner filter
location...................... 262
specifications.................... 330
Alarm, activating remote personal............ 104
Antenna, radio (see Electronic sound system).....127, 152
Antifreeze (see Engine coolant)............. 278
Anti-lock brake system (ABS)
description..................... 177
noise........................ 179
see also Brake.................... 177
Anti-theft system
arming the system.................. 107
description..................... 107
disarming an untriggered system........... 108
disarming a triggered system............. 108
triggering...................... 107
Appeals (see Dispute settlement board)......... 243
Assistance (see Customer assistance)........... 241
File:unixr.ex
Update:Wed May 1 13:58:05 1996

353
Index
Clutch
adjusting...................... 302
fluid........................ 302
fluid reservoir................... 302
operation while driving............... 161
recommended shift speeds.............. 164
shifting the gears.................. 162
specifications.................... 331
Cold engine starting................... 46
Combination lap and shoulder belts...........9,11
Controls
instrument panel................... 73
mirrors....................... 122
power seat..................... 120
steering column.................... 87
Convenience kit in cargo area.............. 225
Coolant (see Engine coolant)
checking and adding................ 278
drain and flush................... 282
preparing for storage................ 335
refill capacities................... 283
specifications.................... 331
temperature gauge.................. 68
warnings...................... 278
Cooling fan...................... 258
Crankcase emission filter................ 330
Cruise control (see Speed control)............. 93
Customer Assistance Centre, Ford of Canada....... 248
File:unixr.ex
Update:Wed May 1 13:58:05 1996

355
Index
Emergencies, roadside
assistance...................... 241
battery acid spills................219, 299
fuel........................ 271
jump-starting.................... 219
towing....................... 234
Emergency brake (parking brake)............ 181
Emission control system................ 323
catalytic converter.................. 323
emissions warranty................ 3,323
Engine
check engine warning light............... 60
does not start................... 46,48
fuel injected engine, starting.............. 44
fuel pump shut-off switch............... 48
preparing to start................... 44
service points.................... 262
starting...................... 41,45
starting after a collision................ 48
storing your vehicle................. 334
Engine block heater................... 47
Engine coolant
checking and adding................ 278
checking hoses................... 282
disposal..................258, 278, 301
drain and flush................... 282
preparing for storage................ 335
recovery reservoir.................. 262
refill procedure................... 283
specifications.................... 331
temperature gauge.................. 68
Engine coolant temperature gauge
description...................... 68
mechanical...................... 68
Engine fan...................... 258
File:unixr.ex
Update:Wed May 1 13:58:05 1996

358
G
Gas cap (see Fuel cap)................. 266
Gas mileage (see Fuel economy)..........269, 273
Gasoline (see Fuel).................. 266
Gauges, Electronic
engine coolant temperature gauge........... 68
fuel gauge...................... 67
odometer....................... 70
speedometer..................... 70
Gauges, Mechanical
battery voltage gauge................. 64
charging system gauge................ 64
engine coolant temperature gauge........... 68
engine oil pressure gauge............... 65
fuel gauge...................... 67
odometer....................... 70
speedometer..................... 70
tachometer...................... 71
trip odometer..................... 71
GAWR (Gross Axle Weight Rating)
calculating..................... 198
definition....................188, 196
driving with a heavy load.............. 188
location....................188, 196
Gearshift
automatic operation................. 156
column-mounted.................. 156
floor-mounted................... 162
gearshift override.................. 157
locking the gearshift.................. 41
positions....................156, 162
shifting the gears................156, 162
shift-lock...................... 157
File:unixr.ex
Update:Wed May 1 13:58:05 1996