1996 FORD MUSTANG check engine

296may be liable if their emission control device is
removed or is prevented from working.
*
[SV53500( ALL)02/92]
Never use a metal exhaust collector when you
service your vehicle. If the metal collector
contacts any of your vehicle's plastic trim or
bumper parts they could melt or deform.
*
[SV53600( ALL)01/95]
Do not drive your vehicle if it does not operate
properly. See your dealer if the engine runs on
for more than five seconds after you shut it off
or if it misfires, surges, stalls, or backfires.
%*
[SV53700( ALL)05/95]
Information about your vehicle's emission
control system is on the Vehicle Emission
Control Information decal located on or near the
engine. This decal identifies engine displacement
and gives some tune-up specifications.
%*
[SV53702( ALL)07/95]
Readiness for Inspection/Maintenance
Testing
*
[SV53715( ALL)07/95]
In some localities it may become a legal
requirement to pass an
Inspection/Maintenance (I/M) test of the
On-Board Diagnostic (OBD) II system. If the
vehicle's powertrain system or its battery has
just been serviced, the OBD II system is reset to
a not ready for I/M testing condition. To
prepare for I/M testing, the law specifies a
ªneed for additional mixed city and highway
driving to complete the checkº of the OBD II
system. As soon as all of the OBD II system
checks are successfully completed, the OBD II
system is set to the ready condition. The amount
of driving required to reach the ready condition
varies with individual driving patterns. To
complete this requirement in the minimum
amount of time, refer to the OBD II Drive Cycle
defined below. If the vehicle owner cannot or
does not want to do the additional driving
required by law, a service center can perform
this drive cycle as it would any other type of
repair work.
File:15rcsvm.ex
Update:Thu Mar 28 14:48:54 1996

300
*
[SV54550( ALL)09/95]
NOTE: Rear axle lube quantities must be
replaced every 100,000 miles
(160,000 km) or if the axle has been
submerged in water. Otherwise, the
lube should not be checked or changed
unless a leak is suspected or repair
required.
%*
[SV54600( ALL)10/95]
Motorcraft Parts
[SV54700(M )03/95]
fourteen pica chart:0010451-M[SV55000( ALL)09/94]
If a spark plug is removed for examination, it
must be reinstalled in the same cylinder.
[SV55025(MBC )05/94]
For 3.8L engines:
[SV55050(MBC )03/95]
Cylinders #1, #2, #3 have an EG suffix.
[SV55075(MBC )03/95]
Cylinders #4, #5, #6 have an E suffix.
[SV55100( ALL)05/95]
For 4.6L (2V) engines:
[SV55125( ALL)05/95]
Cylinders #1, #2, #3, #4 have a PG suffix.
[SV55150( ALL)05/95]
Cylinders #5, #6, #7, #8 have a P suffix.
[SV55200( ALL)03/95]
If a spark plug needs to be replaced, use only
spark plugs with the service number suffix letter
as shown on the engine decal.
File:15rcsvm.ex
Update:Thu Mar 28 14:48:54 1996

322 Index
Controls
instrument panel............ 79
mirrors................ 125
steering column............. 91
Convertible
cleaning............... 138
installation of the boot......... 134
lowering the convertible top...... 132
raising the convertible top....... 137
Coolant (see Engine coolant)
checking and adding......... 252
drain and flush............ 257
preparing for storage......... 303
proper solution............ 255
refill capacities............ 298
specifications............. 300
temperature gauge........... 73
warnings............... 252
Cooling fan............... 236
Crankcase emission filter......... 299
Cruise control (see Speed control)...... 97
Customer Assistance Center, Ford (U.S.) . . 217
Customer Assistance Centre,
Ford of Canada..........217, 223
D
Dashboard (see Instrument panel)...... 79
Daytime running light system....... 84
Defects, reporting............ 222
Defrost
rear window.............. 83
windshield............... 82
Dipstick
automatic transmission fluid....269, 271
engine oil.............. 249
power steering fluid.......... 274
Disabled vehicle (see Towing)...... 213
Dispute Settlement Board........ 218
File:rcixm.ex
Update:Wed Mar 27 09:41:15 1996

Index 323
Doors................. 103
lubricant specifications........ 300
Driving under special conditions
bad weather............. 190
heavy load.............. 192
high water.............. 191
slippery roads............ 190
tips for safe driving.......... 190
towing a trailer............ 194
E
Electrical system
circuit breakers............ 287
fuses..............278, 286
operating when the engine is off..... 49
power point outlet.......... 130
Electronic sound system
radio reception............ 173
tuning the radio.........142, 163
warranty and service information . . . 175
Electronic stereo cassette radio
(see Electronic sound system)..... 142
Emergencies, roadside
assistance.............. 215
battery acid spills........... 199
fuel................. 245
jump-starting............. 199
towing................ 213
Emergency brake (parking brake) . . . 187±188
Emission control system
catalytic converter.......... 293
emissions warranty......... 4,293
Engine
check engine warning light....... 70
does not start........... 54,57
fuel injected engine, starting..... 51,53
fuel pump shut-off switch........ 57
preparing to start..........51±52
refill capacities............ 298
service points............ 239
File:rcixm.ex
Update:Wed Mar 27 09:41:15 1996

324 Index
Engine (continued)
starting............... 49,53
starting after a collision......... 57
storing your vehicle........301±302
Engine block heater............ 55
Engine coolant
checking and adding......... 252
checking hoses............ 254
disposal.........236, 251, 256, 271
drain and flush............ 257
low coolant warning light........ 68
preparing for storage......... 303
proper solution............ 255
recovery reservoir.........239, 252
refill capacities............ 298
specifications............. 300
temperature gauge........... 73
Engine coolant temperature gauge
description............... 73
mechanical.............73±74
Engine fan............... 236
Engine knocking............. 244
Engine oil
changing oil and oil filter.....249, 251
checking and adding......... 249
dipstick............... 249
disposal.........236, 251, 256, 271
engine oil pressure gauge........ 77
filter, specifications.......... 299
low oil warning light.......... 65
refill capacities............ 298
specifications...........248, 300
synthetic oil...........248±249
ªbreak-inº oils............. 5
viscosity.............248±249
Entry system, remote.......... 110
Exhaust fumes.............. 56
Extended Service Plan, Ford........ 4
File:rcixm.ex
Update:Wed Mar 27 09:41:15 1996

326 Index
Fuel pump shut-off switch
engine does not start.......... 57
starting after a collision......... 57
Fuse panels
engine compartment.......... 282
high current fuse panel........ 283
instrument panel.........278, 286
Fuses
charts..............280, 286
checking and replacing........ 286
circuit breakers............ 287
G
Gas cap (see Fuel cap).......... 242
Gas mileage (see Fuel economy)..... 243
Gasohol................ 244
Gasoline (see Fuel)............ 242
Gauges, Mechanical
engine coolant temperature gauge.... 73
engine oil pressure gauge........ 77
fuel gauge............... 72
odometer................ 75
speedometer.............. 75
tachometer............... 76
trip odometer.............. 75
GAWR (Gross Axle Weight Rating)
calculating.............. 192
definition............... 192
driving with a heavy load....... 192
location............... 192
Gearshift
automatic operation.......... 177
console-mounted........... 179
downshifting............. 185
File:rcixm.ex
Update:Wed Mar 27 09:41:15 1996

Index 329
K
Keys
key in ignition chime.......... 51
positions of the ignition......... 49
removing from the ignition....... 50
stuck in lock position........ 49,51
L
Lamps
bulb replacement specifications chart . . 292
checking............... 288
daytime running light system...... 84
dome lamps............87±88
flashing the lamps........... 92
fog lamps............... 86
hazard flashers............. 94
headlamps............... 85
high beams.............. 92
illuminated mirrors.......... 128
instrument panel, dimming....... 87
interior lamps........... 84,87
map lamps............... 88
replacing bulbs............ 288
trailer................ 197
Lane change indicator (see Turn signal) . . . 91
Lights, warning and indicator
airbag................. 67
anti-lock brakes (ABS).......... 65
anti-theft................ 72
brake................. 64
charging system............ 68
check engine.............. 70
engine oil pressure........... 77
hazard warning light.......... 94
high beam............... 70
low coolant.............. 68
lowoil................. 65
oil pressure.............. 77
overdrive off.............. 69
File:rcixm.ex
Update:Wed Mar 27 09:41:15 1996

330 Index
Lights, warning and indicator (continued)
safety belt............... 66
service engine soon........... 70
theft system.............. 72
turn signal indicator......... 72,91
Load limits
GAWR................ 192
GVWR................ 192
trailer towing............. 194
Lubricant specifications......... 300
Luggage compartment.......... 131
Lug nuts
anti-theft............... 212
standard............... 209
tightening sequence.......... 211
M
Maintenance schedule and record
(see separate Maintenance
Schedule and Record booklet)...... 3
Maintenance (see Servicing)....... 235
Manual transmission
backing up (reverse).......... 183
clutch..............182, 272
driving................ 182
fluid, checking and adding....... 272
fluid capacities............ 298
lubricant specifications......... 300
shifting gears............. 183
shift speeds.............. 184
Map pockets.............. 131
Master cylinder, brakes......... 272
Methanol in fuel............. 244
File:rcixm.ex
Update:Wed Mar 27 09:41:15 1996