1996 FORD EXPLORER automatic transmission

374without having to drive 20 miles to obtain a normal operating
temperature if outside temperatures are above50ÊF (10ÊC).
*
[SV33801(ALL)01/95]
NOTE: If the vehicle has been operated for an extended
period at high speeds or in city traffic during hot
weather, or pulling a trailer, the vehicle should be
turned off for about 30 minutes to allow the fluid to
cool before checking.
%*
[SV33901(ALL)02/95]
Checking the Automatic Transmission Fluid
*
[SV33910(ALL)06/95]
With the vehicle on a level surface, start the engine and move
the transmission shift selector through all of the gear ranges
allowing sufficient time for each position to engage. Securely
latch the transmission shift selector in the P (Park) position,
fully set the parking brake and leave the engine running.
*
[SV33930(ALL)10/89]
RWARNING
Your vehicle should not be driven if the fluid level is
below the bottom hole on the dipstick and outside
temperatures are above50ÊF (10ÊC).
*
[SV33940(ALL)08/95]
Wipe off the dipstick cap (located on the passenger's side of the
engine), pull the dipstick out and wipe the indicator end clean.
Put the dipstick back into the filler tube and make sure it is
fully seated. Pull the dipstick out and read the fluid level.
*
[SV33950(ALL)03/90]
When checking fluid at normal operating temperature, the fluid
level should be within the crosshatched area on the dipstick.
When the vehicle has not been driven, and outside temperature
is above50ÊF (10ÊC), thefluid level should be between the holes
on the dipstick.
File:15unsvx.ex
Update:Thu Feb 29 09:20:34 1996

Servicing Your Explorer
375
%*
[SV33960(ALL)08/95]
Adding Automatic Transmission Fluid
*
[SV33970(ALL)03/94]
The fluid type is stamped on the dipstick.Before adding any
fluid, be sure that the correct type will be used.
*
[SV33980(ALL)10/89]
Add fluid in 1/2 pint (.25L) increments through the filler tube
to bring the level to the correct area on the dipstick. If an
overfill occurs, excess fluid should be removed by a qualified
technician.
%*
[SV33990(ALL)09/95]
NOTE: Always dispose of used automotive fluids in a
responsible manner. Follow your community's
standards for disposing of these types of fluids. Call
your local recycling center to find out about recycling
automotive fluids.
[SV34000(ALL)04/94]
7-1/2 pica art:0021193-A
Automatic transmission dipstick
File:15unsvx.ex
Update:Thu Feb 29 09:20:34 1996

376
%*
[SV34400(ALL)06/95]
Manual Transmission and Transfer Case
Fluid
*
[SV34600(ALL)01/95]
Checking the Manual Transmission Fluid
*
[SV34700(ALL)12/91]
Clean the filler plug on the side of the case. Remove the filler
plug. The fluid level should be up to the bottom of the filler
plug hole.
*
[SV34800(ALL)03/91]
If additional fluid is required:
*
[SV34900(ALL)01/95]1.
Add enough fluid through the filler plug hole to bring the
level up to the bottom of the hole. Use only fluid certified to
meet Ford Motor Company lubricant specification as listed
underRefill Capacities, Motorcraft Parts, and Lubricant
Specifications, later in this chapter.
*
[SV35000(ALL)03/91]2.
Replace the filler plug in its original position, making sure it
is fully seated.
%*
[SV35100(ALL)02/95]
The Clutch
*
[SV35200(ALL)03/91]
The clutch on your vehicle is automatically self-adjusting and
should not require any routine service.
*
[SV35301(ALL)03/91]
During normal operation the fluid level in the clutch reservoir
will slowly rise. If for any reason the fluid level drops, maintain
the fluid level at the step in the reservoir body.
%*
[SV35400(ALL)03/94]
If it becomes necessary to remove the reservoir cap, thoroughly
clean the reservoir cap before removing it to prevent dirt or
water from entering the reservoir. Remove the internal
diaphragm and then add only a DOT 3 brake fluid such as Ford
High Performance DOT 3 Brake Fluid, meeting Ford
specification ESA-M6C25-A.
File:15unsvx.ex
Update:Thu Feb 29 09:20:34 1996

380
[SV38250(ALL)04/94]
10-1/2 pica
art:0021195-A
Power steering dipstick
[SV38550(ALL)07/95]
10-1/2 pica
art:0090155-A
Power steering dipstick location
*
[SV38800(ALL)07/94]5.
If the power steering fluid is low, add fluid in small
amounts, continuously checking the level, until you reach the
FULL HOT range. Do not overfill.
*
[SV38850(ALL)03/95]6.
When you are finished, put the dipstick back in and make
sure that it fits snugly.
[SV38900(ALL)05/95]
Use only power steering fluid that meets Ford specification such
as MERCONHAutomatic Transmission Fluid (or equivalent).
File:15unsvx.ex
Update:Thu Feb 29 09:20:34 1996

402
*
[SV51500(ALL)07/95]
The engine must be warmed up and at operating temperature
before proceeding with the drive modes of the following OBD II
Drive Cycle.
*
[SV51505(ALL)06/95]1.
Start the engine. Drive or idle (in neutral) the vehicle for 4
minutes.
[SV51510(ALL)05/95]2.
Idle the vehicle in drive (neutral for automatic transmissions)
for 40 seconds.
[SV51515(ALL)05/95]3.
Accelerate the vehicle to 45 mph (72 km/h) (for manual
transmissions upshift from 1st to 5th gear, but hold in 2nd
for at least 5 seconds) at 1/4 to 1/2 throttle for 10 seconds.
*
[SV51520(ALL)05/95]4.
Drive the vehicle with a steady throttle at 45 mph
(72 km/h) (manual transmissions use 5th gear) for 30
seconds.
*
[SV51525(ALL)08/95]5.
Idle the vehicle in drive (neutral for manual transmissions)
for 40 seconds.
*
[SV51530(ALL)05/95]6.
Continue to drive the vehicle in city traffic at speeds
between 25 and 40 mph (40-64 km/h) (manual transmissions
primarily drive vehicles in 3rd and 4th gear when possible)
for 15 minutes. During the 15 minute drive cycle the
following modes must be achieved:
[SV51535(ALL)05/95]
a. at least 5 stop and idle modes at 10 seconds each.
[SV51540(ALL)05/95]
b. acceleration from idles at 1/4 to 1/2 throttle position, and
[SV51545(ALL)05/95]
c. choose three different speeds to do 1.5 minute steady state
throttle drives.
File:15unsvx.ex
Update:Thu Feb 29 09:20:34 1996

422
Anti-theft system (continued)
triggering..................... 167
warning light..................... 88
Appeals (see Dispute settlement board)......... 319
Assistance (see Customer assistance).......... 317
Audio system (see Electronic sound system)....... 207
Autolamp system (see Headlamps).........128, 132
Autolock (see Keyless entry).............. 159
Automatic transaxle, fluid, specification......... 406
Automatic transmission
driving an automatic overdrive............ 248
fluid, adding.................... 375
fluid, checking................... 374
fluid, specification.................. 406
Axle
lubricant specifications................ 406
traction lok...................269, 363
B
Backing up...................... 248
Basic vehicle warranty.................. 3
Battery
acid, treating emergencies..........295, 372±373
battery saver.................... 166
charging system warning light............. 87
disconnecting.................... 298
how to service................... 371
jumping a disabled battery.............. 295
maintenance-free.................. 371
proper disposal, recycling.............. 372
replacement, specifications.............. 405
servicing...................... 371
voltage gauge.................. 87,89
when storing your vehicle.............. 410
File:unixx.ex
Update:Thu Feb 29 09:21:09 1996

426
Convenience kit in cargo area............. 301
Coolant (see Engine coolant)
checking and adding................ 352
drain and flush................... 356
preparing for storage................ 410
refill capacities................... 356
specifications.................... 406
temperature gauge.................. 92
warnings...................... 352
Cooling fan...................... 334
Crankcase emission filter................ 405
Cruise control (see Speed control)............ 141
Customer Assistance Centre, Ford of Canada...... 324
D
Dashboard (see Instrument panel)............ 109
Daytime running light system............. 132
Defects, reporting................... 323
Defrost
rear window.................... 126
windshield..................... 113
Dipstick....................... 349
automatic transmission fluid...........373, 375
engine oil..................... 349
power steering fluid................. 379
Disabled vehicle (see Towing)............. 311
Dispute Settlement Board............... 319
Doors........................ 147
lubricant specifications................ 406
Driveline universal joint and slip yoke......... 377
Driving under special conditions
bad weather.................... 269
heavy load..................... 271
high speed..................... 268
high water..................... 270
slippery roads................... 269
tips for safe driving................. 267
towing a trailer................... 272
File:unixx.ex
Update:Thu Feb 29 09:21:09 1996

435
Index
Manual transmission (continued)
shifting gears.................... 251
shift speeds..................... 253
Master cylinder, brakes................. 377
Message center
low washer fluid.................. 104
system check button................. 100
Methanol in fuel.................... 344
Mileage, calculating fuel economy...........99,346
Mirrors
automatic dimming rearview mirror......... 188
dual electric remote control............. 191
rearview...................... 188
side view mirrors.................. 188
side view mirrors (power).............. 191
vanity mirror.................... 190
vanity mirror, illuminated.............. 190
Moon roof...................... 192
Motorcraft parts.................... 405
N
National Highway Traffic Safety Administration..... 323
New vehicle break-in.................. 5
O
Octane rating..................... 342
Odometer
description...................... 94
trip odometer..................... 94
Off road driving, 4-wheel drive............. 259
Oil filter.....................351, 405
Oil (see Engine oil).................. 348
Oil viscosity...................... 348
On-board diagnostic (OBD II) system.......... 401
File:unixx.ex
Update:Thu Feb 29 09:21:09 1996