1996 FORD EXPLORER battery

Servicing Your Explorer
373
*
[SV33200(ALL)01/95]
RWARNING
Batteries normally produce explosive gases which can
cause personal injury. Therefore, do not allow flames,
sparks or lit tobacco to come near the battery. When
charging or working near a battery, always cover your
face and protect your eyes, and also provide ventilation.
%*
[SV33300(ALL)07/95]
RWARNING
Batteries contain sulfuric acid which burns skin, eyes,
and clothing.
*
[SV33310(ALL)07/95]
If the acid touches someone's skin, eyes, or clothing,
immediately flush the area with water for at least 15 minutes. If
someone swallows the acid, have him or her drink lots of milk
or water first, then Milk of Magnesia, a beaten egg, or vegetable
oil. Call a doctor immediately.
%*
[SV33400(ALL)06/95]
RWARNING
Applying too much pressure on the ends when lifting a
battery could cause acid to spill. Lift the battery with a
carrier or with your hands on the opposite corners.
%*
[SV33500(ALL)01/95]
Automatic Transmission Fluid
*
[SV33601(ALL)06/95]
Under normal driving conditions automatic transmission fluid
should be changed every 30,000 miles (48,000 km) or 21,000
miles (34,000 km) if under severe duty conditions. However, if
the transmission is not working properly, for instance, the
transmission may slip or shift slowly, or you may notice some
sign of fluid leakage, the fluid level should be checked.
*
[SV33701(ALL)05/95]
It is preferable to check the transmission fluid level at normal
operating temperature, after approximately 20 miles (30 km) of
driving. However, if necessary, you can check the fluid level
File:15unsvx.ex
Update:Thu Feb 29 09:20:34 1996

386
[SV41000( X)07/95]
eight pica
chart:0090158-A%*
[SV41300(ALL)06/95]
Power distribution box
*
[SV41400(ALL)10/92]
The high current fuses contained in the Power Distribution Box
protect your vehicle's main electrical systems from overloads;
these fuses provide the connection between the battery and your
vehicle's electrical systems.
*
[SV41500(ALL)10/92]
The high current fuses are coded as follows: 30 amp -light
green, 40 amp - orange, 50 amp - red, 60 amp -blue.
*
[SV41600(ALL)05/95]
RWARNING
Always disconnect the battery before servicing high
current fuses.
*
[SV41610(ALL)07/95]
Ford recommends that high current fuses be replaced by a
qualified technician.
*
[SV41700(ALL)03/93]
RWARNING
Always replace the cover to the Power Distribution Box
before reconnecting the battery or refilling fluid
reservoirs.
*
[SV41800(ALL)04/95]
A blown high current fuse may be replaced but will continue to
blow until the cause of the overload condition is corrected.
File:15unsvx.ex
Update:Thu Feb 29 09:20:34 1996

Servicing Your Explorer
401
*
[SV49800(ALL)02/92]
Never use a metal exhaust collector when you service your
vehicle. If the metal collector contacts any of your vehicle's
plastic trim or bumper parts they could melt or deform.
*
[SV49900(ALL)01/95]
Do not drive your vehicle if it does not operate properly. See
your dealer if the engine runs on for more than five seconds
after you shut it off or if it misfires, surges, stalls, or backfires.
%*
[SV50000(ALL)05/95]
Information about your vehicle's emission control system is on
the Vehicle Emission Control Information decal located on or
near the engine. This decal identifies engine displacement and
gives some tune-up specifications.
%*
[SV51475(ALL)07/95]
Readiness for Inspection/Maintenance Testing
*
[SV51480(ALL)07/95]
In some localities it may become a legal requirement to pass an
Inspection/Maintenance (I/M) test of the On-Board Diagnostic
(OBD) II system. If the vehicle's powertrain system or its battery
has just been serviced, the OBD II system is reset to a not ready
for I/M testing condition. To prepare for I/M testing, the law
specifies a ªneed for additional mixed city and highway driving
to complete the checkº of the OBD II system. As soon as all of
the OBD II system checks are successfully completed, the OBD
II system is set to the ready condition. The amount of driving
required to reach the ready condition varies with individual
driving patterns. To complete this requirement in the minimum
amount of time, refer to the OBD II Drive Cycle defined below.
If the vehicle owner cannot or does not want to do the
additional driving required by law, a service center can perform
this drive cycle as it would any other type of repair work.
*
[SV51485(ALL)09/95]
OBD II Drive Cycle
*
[SV51490(ALL)06/95]
The following steps must be run in the order shown. If any
steps are interrupted, repeat the preceding step. Any safe
driving mode is acceptable between steps.
*
[SV51495(ALL)06/95]
Always drive vehicle in safe manner according to traffic
conditions and obey all traffic laws.
File:15unsvx.ex
Update:Thu Feb 29 09:20:34 1996

410
*
[SV58000(ALL)01/95]
Ford Gas Stabilizer should be added whenever actual or
expected storage periods exceed 60 days. Follow the instructions
on the label. The vehicle should then be operated at idle speed
to circulate the additive throughout the fuel system.
*
[SV58100(ALL)01/95]
A volatile corrosion inhibitor added to the fuel system will
protect the fuel system's inner surfaces from corrosion. Follow
the instructions packaged with the product.
%*
[SV58200(ALL)01/95]
Cooling system
*
[SV58300(ALL)01/95]
n
Protect against freezing temperatures.
%*
[SV58400(ALL)01/95]
Battery
*
[SV58500(ALL)01/95]
n
Check and recharge as necessary.
*
[SV58600(ALL)01/95]
n
Keep connections clean and covered with a light coat of
grease.
%*
[SV58700(ALL)01/95]
Brakes
*
[SV58800(ALL)01/95]
n
Make sure brakes and parking brake are fully released.
%*
[SV58900(ALL)01/95]
Tires
*
[SV59000(ALL)05/95]
n
Maintain recommended air pressure.
*
[SV59100(ALL)01/95]
Miscellaneous
*
[SV59200(ALL)01/95]
n
Make sure all linkages, cables, levers and clevis pins under
vehicle are covered with grease to prevent rust.
*
[SV59300(ALL)03/95]
n
Move vehicles at least 25 feet (8 m) every 15 days to
lubricate working parts and prevent corrosion.
File:15unsvx.ex
Update:Thu Feb 29 09:20:34 1996

422
Anti-theft system (continued)
triggering..................... 167
warning light..................... 88
Appeals (see Dispute settlement board)......... 319
Assistance (see Customer assistance).......... 317
Audio system (see Electronic sound system)....... 207
Autolamp system (see Headlamps).........128, 132
Autolock (see Keyless entry).............. 159
Automatic transaxle, fluid, specification......... 406
Automatic transmission
driving an automatic overdrive............ 248
fluid, adding.................... 375
fluid, checking................... 374
fluid, specification.................. 406
Axle
lubricant specifications................ 406
traction lok...................269, 363
B
Backing up...................... 248
Basic vehicle warranty.................. 3
Battery
acid, treating emergencies..........295, 372±373
battery saver.................... 166
charging system warning light............. 87
disconnecting.................... 298
how to service................... 371
jumping a disabled battery.............. 295
maintenance-free.................. 371
proper disposal, recycling.............. 372
replacement, specifications.............. 405
servicing...................... 371
voltage gauge.................. 87,89
when storing your vehicle.............. 410
File:unixx.ex
Update:Thu Feb 29 09:21:09 1996

427
Index
E
Electrical system
fuses......................381, 388
operating when the engine is off............ 67
power point outlet................. 204
relays....................... 389
Electronic message center (see Message center)....... 96
Electronic sound system
accessory delay.................... 67
antenna...................... 213
atenna....................... 213
radio reception................... 241
tuning the radio...............210, 223, 238
warranty and service information........... 243
Electronic stereo cassette radio (see Electronic
sound system)...............209, 222
Electronic stereo radio (see Electronic sound system) . 209, 222
Emergencies, roadside
assistance...................... 317
battery acid spills................295, 373
fuel........................ 344
jump-starting.................... 295
towing....................... 311
Emergency brake (parking brake)............ 266
Emission control system
catalytic converter.................. 399
emissions warranty................ 3,399
Engine
check engine warning light............... 84
does not start................... 72,74
fuel injected engine, starting............70±71
fuel pump shut-off switch............... 74
preparing to start................... 70
service points.................... 336
File:unixx.ex
Update:Thu Feb 29 09:21:09 1996

430
Fuel cap
removing...................... 339
replacing....................339, 341
Fuel filler door
override, manual.................. 340
remote release................... 339
Fuel filter, specifications................ 405
Fuel gauge....................... 91
Fuel pump shut-off switch
engine does not start................. 74
starting after a collision................ 74
Fuse panels
instrument panel.................. 388
power distribution box............... 386
Fuses
charts.....................381, 388
checking and replacing............... 388
G
Gas cap (see Fuel cap)................. 339
Gas mileage (see Fuel economy).........99,342, 346
Gasoline (see Fuel).................. 339
Gauges, Electronic
engine coolant temperature gauge........... 92
fuel gauge...................... 91
odometer....................... 94
speedometer..................... 93
Gauges, Mechanical
battery voltage gauge................. 89
charging system gauge................ 89
engine coolant temperature gauge........... 92
engine oil pressure gauge............... 90
fuel gauge...................... 91
odometer....................... 94
speedometer..................... 93
tachometer...................... 94
trip odometer..................... 94
File:unixx.ex
Update:Thu Feb 29 09:21:09 1996

439
Index
Snowplowing..................... 294
Snow tires and chains................. 369
Spare tire
changing the tire................299, 304
conventional spare...............299, 301
finding the spare.................. 301
removing the spare tire............... 301
storing the flat tire...............301, 307
temporary spare................... 299
Spark plugs, specifications............... 405
Special driving conditions............... 267
Special notice...................... 4
E-4WD vehicles.................... 4
utility-type vehicles.................. 4
Specification chart, lubricants.............. 406
Speed control
accelerating..................... 144
canceling a set speed................ 146
resetting...................... 144
resuming a set speed................ 146
tap up/tap down.................. 144
when towing a trailer................ 291
Speedometer...................... 93
Starting your vehicle
preparing to start your vehicle............. 70
starting a cold engine................. 71
starting after a collision................ 74
starting a warm engine................ 72
starting your vehicle if the battery is disabled..... 295
Steering, power.................... 255
Steering wheel
horn........................ 140
locking........................ 67
speed controls................... 141
tilting....................... 140
Storage compartments, overhead storage compartment . . 201
File:unixx.ex
Update:Thu Feb 29 09:21:09 1996