1996 FORD E SERIES checking oil

76 [LG07001( E M)03/93]
quarter page art:0020863-BBattery voltage gauge
*
[LG07500( ALL)05/94]
Engine Oil Pressure Gauge
*
[LG07601( ALL)06/93]
This gauge indicates the engine's oil pressure,
not the oil level. However, if your engine's oil
level is low, it could affect the oil pressure. With
the engine running, the pointer should move
into the NORMAL band. If the pointer drops
below the NORMAL band while the engine is
running, you have lost oil pressure and
continued operation will cause severe engine
damage.
*
[LG07701( ALL)03/95]
If you lose engine oil pressure:
*
[LG07801( ALL)01/95]
1. Pull off the road as soon as safely possible.
*
[LG07901( ALL)04/95]
2. Shut off the engine immediately or severe
engine damage could result.
*
[LG08001( ALL)02/95]
3. Check the engine's oil level, following the
instructions on checking and adding engine
oil. Refer toEngine oilin the Index. If you
do not follow these instructions, you or
others could be injured. To assure an
accurate reading, your vehicle should be on
level ground.
*
[LG08051( ALL)03/93]
4. If the level is low, add only as much oil as
necessary before you start the engine again.
Do not overfill. Do not operate the engine if
the pointer is below the NORMAL band,
regardless of the oil level. Contact your
nearest dealer for further service actions.
File:05ltlge.ex
Update:Wed Apr 17 08:49:15 1996

298
*
[SV13730( EF )01/93]
For vehicles with 4.9L, 5.0L or 7.5L engines
[SV13740( ALL)04/95]
Engine oils with anSAE 10W-30viscosity are
PREFERREDfor your vehicle which provide the
best engine protection for all climates down to
-5ÊF (-20ÊC). SAE5W-30 enigne oils may also be
used down to-15ÊF (-25ÊC).
[SV13745( ALL)02/95]
Synthetic engine oils which are CERTIFIED and
of the preferred viscosity may be used in your
engine. The engine oil and oil filter must still be
changed according to the maintenance schedule.
*
[SV13775( ALL)01/95]
Checking and Adding Engine Oil
*
[SV13800( ALL)03/95]
Since the proper amount of engine oil is
important for safe engine operation, check the oil
using the dipstick each time you put fuel in
your vehicle. Remember the engine must be off,
the oil must be warm and the vehicle must be
parked on level ground.
*
[SV13900( ALL)03/95]
Checking the engine oil level:
*
[SV14000( ALL)02/95]
1. Turn the engine off after it has warmed up
and allow a few minutes for the engine oil
to drain back into the oil pan.
*
[SV14075( E M)03/95]
2. Set the parking brake, making sure the
gearshift is securely latched in P (Park).
*
[SV14100( ALL)02/95]
3. Open the hood. Protect yourself from engine
heat.
*
[SV14200( ALL)03/95]
4. Locate the engine oil dipstick (highlighted in
yellow) and carefully pull it out of the
engine.
*
[SV14300( ALL)01/95]
5. Wipe the dipstick clean and put it back into
position, making sure it is fully seated.
File:14ltsve.ex
Update:Wed Apr 17 08:40:13 1996

301
*
[SV16700( EF )06/93]
If your vehicle is over 8500 GVWR and the
above conditions do not apply, change the
engine oil and oil filter every 6 months or 5,000
miles (8,000 km), whichever comes first.
*
[SV16800( ALL)06/95]
Refer to theMaintenance Schedule and Record
booklet for additional information.
*
[SV16900( EF )03/94]
NOTE: Refer to thePower Stroke Diesel Engine
Owner's Guide Supplementfor oil
viscosity, filter application and oil and
filter change intervals.
%*
[SV17250( ALL)04/95]
NOTE: Always dispose of used automotive
fluids in a responsible manner. Follow
your community's standards for
disposing of these types of fluids. Call
your local recycling center to find out
about recycling automotive fluids.
*
[SV17275( ALL)06/95]
RWARNING
Continuous contact with USED motor oil
has caused cancer in laboratory mice.
*
[SV17280( ALL)06/95]
Protect your skin by washing with soap and
water.
*
[SV17300( ALL)03/95]
Engine Coolant
*
[SV17400( ALL)02/95]
Checking the engine coolant
*
[SV17700( ALL)10/89]
Your vehicle's engine coolant protects the engine
from overheating in the summer and from
freezing in the winter. Check the level of the
engine coolant at least once a month, but
preferably each time you stop for fuel. Simply
look at the engine coolant recovery reservoir
located in the engine compartment. To locate
this reservoir, see the diagram of your vehicle's
engine underEngine typesin this chapter.
File:14ltsve.ex
Update:Wed Apr 17 08:40:13 1996

319
*
[SV31700(BEF )01/95]
q
Drive slowly. If you can hear the chains rub
or bang against your vehicle, stop the vehicle
and tighten the chains. If you continue to
hear the chains rub or bang against your
vehicle, remove the chains to prevent damage
to your vehicle.
*
[SV31800(BEF )10/94]
q
Avoid fully loading your vehicle if possible.
*
[SV31900(BEF )05/94]
q
Remove tire chains at the first opportunity
after using them on snow and ice. Do not use
the chains on dry roads.
*
[SV31950(BEF )05/91]
q
Make sure your suspension insulation and
bumpers are not missing or worn to avoid
damage to your vehicle.
%*
[SV31975(BEF )04/95]
Cleaning the Wheels
*
[SV31980(BEF )05/95]
Wash the wheels with the same detergent you
use to wash your vehicle's body. Do not use
acid-based wheel cleaners, steel wool, abrasives,
fuel, or strong detergents. These substances will
damage protective coatings. Use tar and road oil
remover to remove grease and tar.
*
[SV31985(BEF )04/95]
NOTE: Before going to a car wash, find out if
the brushes are abrasive.
*
[SV32100( ALL)03/95]
Battery
*
[SV32200( ALL)02/95]
Your vehicle may have a Motorcraft
maintenance-free battery. When the original
equipment battery is replaced under warranty, it
may be replaced by a Motorcraft
Low-Maintenance Battery.
*
[SV32500( ALL)06/95]
The Low-Maintenance Battery has removable
vent caps for checking the electrolyte level and
for adding water, if necessary. The electrolyte
level should be checked at least every 24 months
or 24,000 miles (40,000 km) in temperatures up
to 90ÊF (32ÊC) andmore often in temperatures
File:14ltsve.ex
Update:Wed Apr 17 08:40:13 1996

384 Index
Engine fan............... 280
Engine knocking............. 290
Engine oil
changing oil and oil filter....... 300
checking and adding......... 298
dipstick............... 298
disposal...........301, 304, 324
engine oil pressure gauge........ 76
filter, specifications.......... 356
refill capacities............ 353
specifications............. 297
synthetic oil............. 297
ªbreak-inº oils............. 8
viscosity............... 297
Entry system
illuminated.............. 120
remote................ 116
Exhaust fumes.............. 65
Extended Service Plan, Ford........ 4
F
Fan, engine fan, avoiding injury..... 280
Federal Communications Commission . . . 192
Federal Highway Administration
Regulation............... 7
Flashers, hazard............. 103
Flashing the lights............ 101
Flat tire................. 247
Fluid refill capacities........... 353
Ford Customer Assistance Center..... 261
Ford Dispute Settlement Board...... 262
Ford Extended Service Plan........ 4
Ford Motor Company of Canada..... 268
Ford of Canada Customer
Assistance Centre........... 268
Foreign registration........... 267
Four-Wheel Drive vehicles, special notice . . 5
French owner guides, how to obtain.... 3
File:ltixe.ex
Update:Wed Apr 17 08:36:26 1996

386 Index
Gauges, Mechanical
battery voltage gauge.......... 75
charging system gauge......... 75
engine coolant temperature gauge.... 78
engine oil pressure gauge........ 76
fuel gauge............... 77
speedometer.............. 79
GAWR (Gross Axle Weight Rating)
calculating.............. 225
definition.............218, 223
driving with a heavy load....... 218
Gearshift
automatic operation........195, 200
column-mounted.........195, 200
locking the gearshift........... 55
positions.............195, 200
shifting the gears.........195, 200
shift-lock........... 60,196, 202
Gearshift:shifting the gears......195, 200
GVWR (Gross Vehicle Weight Rating)
calculating.............. 225
definition.............218, 223
driving with a heavy load....... 218
H
Hazard flashers............. 103
Headlamps
aiming................ 340
checking alignment.......... 340
cleaning................ 93
daytime running lights......... 93
flashing............... 101
high beam.............. 100
replacing bulbs..........340±341
turning on and off........... 92
warning chime............. 77
Heating
heating and air conditioning system . . . 87
File:ltixe.ex
Update:Wed Apr 17 08:36:26 1996

388 Index
Jump-starting your vehicle
attaching cables............ 245
disconnecting cables.......... 247
K
Keys
key in ignition chime.......... 56
positions of the ignition......... 55
removing from the ignition....... 56
stuck in lock position........55±56
L
Lamps
cargo lamps.............. 94
checking............... 340
courtesy lamps............. 94
daytime running light system...... 93
dome lamps.............. 94
flashing the lamps........... 101
hazard flashers............ 103
headlamps............... 92
high beams.............. 100
high-mount brakelamp...... 96,343
illuminated entry system........ 120
illuminated mirrors.......... 143
instrument panel, dimming....... 94
interior lamps............ 92,94
replacing bulbs............ 340
Lane change indicator (see Turn signal) . . . 99
Lap belts................. 22
Lights, warning and indicator
airbag................. 74
anti-lock brakes (ABS).......... 70
anti-theft................ 75
brake................. 69
charging system............. 74
check engine.............. 71
engine oil pressure........... 76
hazard warning light......... 103
File:ltixe.ex
Update:Wed Apr 17 08:36:26 1996

390 Index
N
National Highway Traffic Safety
Administration............ 266
New vehicle break-in........... 8
O
Octane rating.............. 290
Odometer................. 80
Oil filter..............300, 356
Oil (see Engine oil)........... 297
Oil viscosity.............. 297
On-board diagnostic (OBD II) system . . . 351
Order forms, service information..... 152
Overdrive................ 203
Overseas offices............. 267
P
Panic alarm feature, remote entry system . 117
Parking brake
operation............... 212
warning light.............. 69
Parts (see Motorcraft Parts)........ 356
PCV valve, specifications......... 356
Power door locks............ 116
Power features
door locks.............. 116
lumbar support............ 141
mirrors..............143, 146
seats................. 140
windows.............123±124
Power point electrical outlet....... 148
Power steering
dipstick............... 328
driving with power steering...... 206
fluid, checking and adding....... 328
fluid, refill capacity.......... 353
fluid, specifications.......... 329
servicing............... 206
Prop rod, hood............. 281
File:ltixe.ex
Update:Wed Apr 17 08:36:26 1996