1996 FORD AEROSTAR transmission

333
driving to complete the checkº of the OBD II
system. As soon as all of the OBD II system
checks are successfully completed, the OBD II
system is set to the ready condition. The amount
of driving required to reach the ready condition
varies with individual driving patterns. To
complete this requirement in the minimum
amount of time, refer to the OBD II Drive Cycle
defined below. If the vehicle owner cannot or
does not want to do the additional driving
required by law, a service center can perform
this drive cycle as it would any other type of
repair work.
*
[SV50030(ALL)07/95]
OBD II Drive Cycle
*
[SV50040(ALL)06/95]
The following steps must be run in the order
shown. If any steps are interrupted, repeat the
preceding step. Any safe driving mode is
acceptable between steps.
*
[SV50050(ALL)06/95]
Always drive vehicle in safe manner according
to traffic conditions and obey all traffic laws.
[SV50055(ALL)08/95]
NOTE: When instructions read ªin drive,º use
the standard Overdrive gear. It is not
necessary to turn Overdrive off with
the OVERDRIVE OFF button. For more
information on Overdrive, refer to the
Automatic Overdrive Transmission
section of theDriving Your Aerostar
chapter.
*
[SV50060(ALL)07/95]
The engine must be warmed up and at
operating temperature before proceeding with
the drive modes of the following OBD II Drive
Cycle.
*
[SV50070(ALL)06/95]
1. Start the engine. Drive or idle (in neutral)
the vehicle for 4 minutes.
*
[SV50080(ALL)06/95]
2. Idle the vehicle in drive for 40 seconds.
*
[SV50090(ALL)07/95]
3. Accelerate the vehicle to 45 mph (70 km/h)
at 1/4 to 1/2 throttle for 10 seconds.
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

360 Index
Automatic transmission
driving an automatic overdrive..... 188
fluid, adding............. 308
fluid, checking............ 307
fluid, refill capacities......... 335
fluid, specification........... 338
Axle
lubricant specifications......... 338
refill capacities............ 335
traction lok............201, 297
B
Backing up............... 188
Basic vehicle warranty........... 4
Battery................. 304
acid, treating emergencies.....225, 305
charging system warning light...... 81
disconnecting............. 228
how to service............ 304
jumping a disabled battery....... 225
maintenance-free........... 304
proper disposal, recycling....... 305
replacement, specifications....... 337
servicing............... 304
voltage gauge.............. 82
when storing your vehicle....... 344
Brake fluid............... 309
brake warning light........... 75
checking and adding......... 309
description.............. 309
specifications...........310, 338
Brakelamp, high-mount......... 106
Brakes................. 193
adjustment.............. 193
anti-lock............... 193
applying the brakes.......... 196
brake warning light........... 75
File:cpixa.ex
Update:Tue Aug 29 17:47:05 1995

364 Index
Customer Assistance Center,
Ford (U.S.).............. 247
Customer Assistance Centre,
Ford of Canada..........247, 253
D
Dashboard (see Instrument panel)...... 89
Daytime running light system...... 104
Defects, reporting............ 252
Defrost, rear window........... 99
Dipstick
automatic transmission fluid....306, 308
engine oil.............. 283
power steering fluid.......... 311
Disabled vehicle (see Towing)...... 243
Dispute Settlement Board........ 248
Doors................. 121
door ajar warning light......... 77
lubricant specifications......... 338
Driving under special conditions..... 198
bad weather............. 200
heavy load.............. 202
high speed.............. 199
high water.............. 201
slippery roads............ 200
tips for safe driving.......... 198
E
Electrical system
circuit breakers............ 322
fuses................. 313
operating when the engine is off..... 61
Electronic radio with cassette
(see Electronic sound system)..... 163
Electronic sound system
radio reception............ 182
tuning the radio.......151, 164, 175
warranty and service information.... 184
File:cpixa.ex
Update:Tue Aug 29 17:47:05 1995

Index 377
Trailer towing
calculating maximum trailer weight . . 211
safety chains............. 219
trailer brakes............. 219
trailer lamps............. 219
Transmission
automatic operation.......... 186
fluid, checking and adding
(automatic)............ 307
fluid, refill capacities......... 335
lubricant specifications........ 338
Transmission control switch....... 188
Trip odometer.............. 88
Tune-up specifications (VECI)...... 332
Turn signal............... 109
indicator lights............ 109
lever................ 109
U
Used engine oil, disposal........ 266
V
Variable interval wipers......... 110
VECI (Vehicle Emission Control Information)
decal................ 332
Vehicle Identification Number (VIN).... 5
Vehicle loading............. 205
calculating the load.......... 211
understanding loading information . . . 207
Vehicle storage............. 342
Ventilating your vehicle
(see Climate control).......... 91
Viscosity (see Engine oil)........ 282
Voltmeter (see Battery voltage gauge).... 82
File:cpixa.ex
Update:Tue Aug 29 17:47:05 1995