Page 198 of 353
217
*
[DR33645(ALL)06/94]
Automatic Transmissions
[DR33650(ALL)08/95]
thirty-four pica chart:0095069-AFile:10cpdra.ex
Update:Tue Aug 29 17:45:28 1995
Page 201 of 353
![FORD AEROSTAR 1996 1.G Owners Manual 220
*
[DR38500(ALL)06/95]
Driving while you tow
*
[DR38520(ALL)05/95]
Be especially careful when driving while you
tow a trailer. Never drive faster than 45 mph
(70 km/h) when you tow in hilly country FORD AEROSTAR 1996 1.G Owners Manual 220
*
[DR38500(ALL)06/95]
Driving while you tow
*
[DR38520(ALL)05/95]
Be especially careful when driving while you
tow a trailer. Never drive faster than 45 mph
(70 km/h) when you tow in hilly country](/manual-img/11/4751/w960_4751-200.png)
220
*
[DR38500(ALL)06/95]
Driving while you tow
*
[DR38520(ALL)05/95]
Be especially careful when driving while you
tow a trailer. Never drive faster than 45 mph
(70 km/h) when you tow in hilly country on
hot days. Also, anticipate stops so that you can
brake gradually.
%*
[DR38540(ALL)01/95]
If you use the speed control while you are
towing on very long, steep grades, the speed
control may shut off.
[DR38600(ALL)08/95]
When towing a trailer in hilly terrain, with a
vehicle equipped with an automatic overdrive
transmission, you may wish to operate in Drive
(by cancelling Overdrive with OVERDRIVE OFF
button) rather than
k(Overdrive). This will
eliminate excessive downshifting and upshifting
to maintain speed. Switch back to Overdrive
whenever practical for optimum powertrain
cooling. This can be accomplished by pushing in
the switch located on the end of the indicator
lever.
*
[DR38800(ALL)06/95]
When descending a steep grade with a trailer,
operate in Drive rather than Overdrive. If
additional braking is needed, shift the automatic
transmission gearshift into 2 (Second) gear or 1
(Low).
[DR38925(ALL)08/95]
Servicing your vehicle if you tow
*
[DR38950(ALL)08/93]
If you tow a trailer for a long distance, your
vehicle will need to be serviced more frequently
than usual. Refer to theMaintenance Schedule and
Recordbooklet for additional information.
File:10cpdra.ex
Update:Tue Aug 29 17:45:28 1995
Page 204 of 353
![FORD AEROSTAR 1996 1.G Owners Manual 223
*
[DR40600(ALL)01/93]
To start, after being parked on a grade:
*
[DR40700(ALL)05/95]
q
Apply the brake pedal and hold.
*
[DR40800(ALL)08/95]
q
Start the engine.
*
[DR40900(ALL)08/95]
q
Shift trans FORD AEROSTAR 1996 1.G Owners Manual 223
*
[DR40600(ALL)01/93]
To start, after being parked on a grade:
*
[DR40700(ALL)05/95]
q
Apply the brake pedal and hold.
*
[DR40800(ALL)08/95]
q
Start the engine.
*
[DR40900(ALL)08/95]
q
Shift trans](/manual-img/11/4751/w960_4751-203.png)
223
*
[DR40600(ALL)01/93]
To start, after being parked on a grade:
*
[DR40700(ALL)05/95]
q
Apply the brake pedal and hold.
*
[DR40800(ALL)08/95]
q
Start the engine.
*
[DR40900(ALL)08/95]
q
Shift transmission into gear and release the
parking brake.
*
[DR41000(ALL)08/95]
q
Release the brake pedal and move the vehicle
uphill to free the wheel chocks.
*
[DR41100(ALL)05/95]
q
Apply the brake pedal and hold while
another person retrieves the chocks.
[DR41200(ALL)08/95]
Luggage Rack (If equipped)
[DR41300(ALL)08/95]
Always distribute your luggage load evenly. Do
not load more than 100 pounds (45 kg) onto
rack or cause the vehicle to exceed the Gross
Vehicle Weight Rating (GVWR).
[DR41400(ALL)08/95]
The crossbars and cross slats are adjustable.
Loosen the adjustment screws, slide the bars and
slats as necessary, and retighten the screws.
[DR41500(ALL)08/95]
RWARNING
Be sure that items on the roof rack are
securely fastened.
[DR41600(ALL)08/95]
Use caution to avoid scratching the paint. Drive
carefully and avoid sudden starts and stops.
File:10cpdra.ex
Update:Tue Aug 29 17:45:28 1995
Page 217 of 353
![FORD AEROSTAR 1996 1.G Owners Manual 237
*
[RE15100(ALL)05/95]
RWARNING
Make sure the spare tire and jacking
equipment are stowed and secured in the
proper storage location.
%*
[RE15200(ALL)03/95]
Preparing to Change the Tire
*
[RE15250( FORD AEROSTAR 1996 1.G Owners Manual 237
*
[RE15100(ALL)05/95]
RWARNING
Make sure the spare tire and jacking
equipment are stowed and secured in the
proper storage location.
%*
[RE15200(ALL)03/95]
Preparing to Change the Tire
*
[RE15250(](/manual-img/11/4751/w960_4751-216.png)
237
*
[RE15100(ALL)05/95]
RWARNING
Make sure the spare tire and jacking
equipment are stowed and secured in the
proper storage location.
%*
[RE15200(ALL)03/95]
Preparing to Change the Tire
*
[RE15250(ALL)12/91]
NOTE: To lift your vehicle by other than the
front or rear jacking points, be sure to
use only hoist adapters with a wide
contact surface.
*
[RE15325(ALL)03/95]
1. Make sure that your vehicle will not move
or roll. Put the gearshift in P (Park). Set the
parking brake and block the wheel that is
diagonally opposite the tire that you are
changing.
*
[RE15335(ALL)12/91]
NOTE: Make sure the ignition is in the OFF
position.
*
[RE15420(ALL)06/95]
When one of the back wheels is off the ground,
the transmission alone will not prevent the
vehicle from moving or slipping off the jack,
even if the vehicle is in P (Park). To prevent the
vehicle from moving when you change a tire, be
sure the parking brake is set, then block the
wheel (both directions) that is diagonally
opposite (other side and end of the vehicle) to
the tire being changed.
*
[RE15430(ALL)05/95]
RWARNING
If the vehicle slips off the jack, you or
someone else could be seriously injured.
File:12cprea.ex
Update:Tue Aug 29 17:46:27 1995
Page 223 of 353
![FORD AEROSTAR 1996 1.G Owners Manual 243
*
[RE24375(ALL)03/95]
If the Engine Cranks But Does
Not Start or Does Not Start After
a Collision
*
[RE24400(ALL)07/95]
The Fuel Pump Shut-off Switch
*
[RE24500(ALL)07/95]
If the engine cranks but FORD AEROSTAR 1996 1.G Owners Manual 243
*
[RE24375(ALL)03/95]
If the Engine Cranks But Does
Not Start or Does Not Start After
a Collision
*
[RE24400(ALL)07/95]
The Fuel Pump Shut-off Switch
*
[RE24500(ALL)07/95]
If the engine cranks but](/manual-img/11/4751/w960_4751-222.png)
243
*
[RE24375(ALL)03/95]
If the Engine Cranks But Does
Not Start or Does Not Start After
a Collision
*
[RE24400(ALL)07/95]
The Fuel Pump Shut-off Switch
*
[RE24500(ALL)07/95]
If the engine cranks but does not start or if you
have had a collision, the fuel pump shut-off
switch may have been triggered. The shut-off
switch is a device that stops the fuel pump
when your vehicle has been involved in a
substantial jolt.
*
[RE24600(ALL)07/95]
For information on how to check and reset the
fuel pump shut-off switch, seeFuel pump shut-off
switchin the Index.
%
*
[RE24700(ALL)05/95]
Towing Your Vehicle
[RE24750(ALL)08/95]
The recommended method to tow your Aerostar
is with flatbed or wheel lift equipment.
However, slingbelt towing is acceptable. On
vehicles equipped with an under-vehicle spare
tire carrier, remove the tire assembly from the
carrier and store it in a secure area before
towing. For E-4WD vehicles, the 4-wheel drive
system must be disabled prior to towing. The
transmission must be in N (Neutral) and the
ignition switch must be in the OFF position to
disable the Electronic 4-Wheel Drive System.
File:12cprea.ex
Update:Tue Aug 29 17:46:27 1995
Page 284 of 353
![FORD AEROSTAR 1996 1.G Owners Manual 306
*
[SV33200(ALL)01/95]
RWARNING
Batteries normally produce explosive gases
which can cause personal injury.
Therefore, do not allow flames, sparks or
lit tobacco to come near the battery. When
char FORD AEROSTAR 1996 1.G Owners Manual 306
*
[SV33200(ALL)01/95]
RWARNING
Batteries normally produce explosive gases
which can cause personal injury.
Therefore, do not allow flames, sparks or
lit tobacco to come near the battery. When
char](/manual-img/11/4751/w960_4751-283.png)
306
*
[SV33200(ALL)01/95]
RWARNING
Batteries normally produce explosive gases
which can cause personal injury.
Therefore, do not allow flames, sparks or
lit tobacco to come near the battery. When
charging or working near a battery, always
cover your face and protect your eyes, and
also provide ventilation.
%*
[SV33300(ALL)07/95]
RWARNING
Batteries contain sulfuric acid which burns
skin, eyes, and clothing.
*
[SV33310(ALL)07/95]
If the acid touches someone's skin, eyes, or
clothing, immediately flush the area with water
for at least 15 minutes. If someone swallows the
acid, have him or her drink lots of milk or water
first, then Milk of Magnesia, a beaten egg, or
vegetable oil. Call a doctor immediately.
%*
[SV33400(ALL)06/95]
RWARNING
Applying too much pressure on the ends
when lifting a battery could cause acid to
spill. Lift the battery with a carrier or
with your hands on the opposite corners.
%
*
[SV33500(ALL)01/95]
Automatic Transmission Fluid
*
[SV33601(ALL)06/95]
Under normal driving conditions automatic
transmission fluid should be changed every
30,000 miles (48,000 km) or 21,000 miles
(34,000 km) if under severe duty conditions.
However, if the transmission is not working
properly, for instance, the transmission may slip
or shift slowly, or you may notice some sign of
fluid leakage, the fluid level should be checked.
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995
Page 285 of 353
![FORD AEROSTAR 1996 1.G Owners Manual 307
*
[SV33701(ALL)05/95]
It is preferable to check the transmission fluid
level at normal operating temperature, after
approximately 20 miles (30 km) of driving.
However, if necessary, you can check FORD AEROSTAR 1996 1.G Owners Manual 307
*
[SV33701(ALL)05/95]
It is preferable to check the transmission fluid
level at normal operating temperature, after
approximately 20 miles (30 km) of driving.
However, if necessary, you can check](/manual-img/11/4751/w960_4751-284.png)
307
*
[SV33701(ALL)05/95]
It is preferable to check the transmission fluid
level at normal operating temperature, after
approximately 20 miles (30 km) of driving.
However, if necessary, you can check the fluid
level without having to drive 20 miles to obtain
a normal operating temperature if outside
temperatures are above50ÊF (10ÊC).
*
[SV33801(ALL)01/95]
NOTE: If the vehicle has been operated for an
extended period at high speeds or in
city traffic during hot weather, or
pulling a trailer, the vehicle should be
turned off for about 30 minutes to
allow the fluid to cool before checking.
%*
[SV33901(ALL)02/95]
Checking the Automatic Transmission
Fluid
*
[SV33910(ALL)06/95]
With the vehicle on a level surface, start the
engine and move the transmission shift selector
through all of the gear ranges allowing sufficient
time for each position to engage. Securely latch
the transmission shift selector in the P (Park)
position, fully set the parking brake and leave
the engine running.
*
[SV33930(ALL)10/89]
RWARNING
Your vehicle should not be driven if the
fluid level is below the bottom hole on
the dipstick and outside temperatures are
above50ÊF (10ÊC).
*
[SV33940(ALL)02/95]
Wipe off the dipstick cap (located toward the
passenger's side of the engine), pull the dipstick
out and wipe the indicator end clean. Put the
dipstick back into the filler tube and make sure
it is fully seated. Pull the dipstick out and read
the fluid level.
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995
Page 286 of 353
![FORD AEROSTAR 1996 1.G Owners Manual 308
*
[SV33950(ALL)03/90]
When checking fluid at normal operating
temperature, the fluid level should be within the
crosshatched area on the dipstick. When the
vehicle has not been driven, and outside FORD AEROSTAR 1996 1.G Owners Manual 308
*
[SV33950(ALL)03/90]
When checking fluid at normal operating
temperature, the fluid level should be within the
crosshatched area on the dipstick. When the
vehicle has not been driven, and outside](/manual-img/11/4751/w960_4751-285.png)
308
*
[SV33950(ALL)03/90]
When checking fluid at normal operating
temperature, the fluid level should be within the
crosshatched area on the dipstick. When the
vehicle has not been driven, and outside
temperature is above50ÊF (10ÊC), thefluid level
should be between the holes on the dipstick.
%*
[SV33960(ALL)08/95]
Adding Automatic Transmission Fluid
*
[SV33970(ALL)03/94]
The fluid type is stamped on the dipstick.
Before adding any fluid, be sure that the
correct type will be used.
*
[SV33980(ALL)10/89]
Add fluid in 1/2 pint (.25L) increments through
the filler tube to bring the level to the correct
area on the dipstick. If an overfill occurs, excess
fluid should be removed by a qualified
technician.
%*
[SV33990(ALL)04/95]
NOTE: Always dispose of used automotive
fluids in a responsible manner. Follow
your community's standards for
disposing of these types of fluids. Call
your local recycling center to find out
about recycling automotive fluids.
*
[SV34000(ALL)06/92]
quarter page art:0020372-E
Automatic transmission dipstick
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995