1994 MAZDA MX-5 timing belt

WATER PUMP WATER PUMP REMOVAL I INSTALLATION 1. Disconnect the negative battery cable. 2. Drain the engine coolant. (Refer to page E-5 for WARNING and procedure) 3. Remove in the order shown in the figure, referring to Removal Note. 4. Install in the reverse order of removal. 1. Timing belt 4. Water pump Service . . . . . . . . . . . . . . . . . . . . . Section B Inspect for cracks, damaged mounting sur- 2. PIS oil pump face, bearing condition, and leakage. Removal Note . . . . . . . . . . . . . . page E-1 1 If the water pump is damage, replace it. 3. Water hose Do not repair it. 5. Water inlet pipe Gartner Banana

ENGINE TUNE-UP - TIMING LIGHT - 45UOFX422 GND Irnr Air Cleaner Element Inspection 1. Check the air cleaner element for excessive dirt and for oil and damage. Caution Cleaning the element with compressed air will re- duce the element's ability to filter the air. Don't use compressed air to clean the element. 2. Replace the element if necessary. ADJUSTMENT Preparation 1. Warm up the engine to normal operating temperature. 2. Turn all electric loads OFF. Headlight switch Blower switch Rear window defroster switch 3. Connect the SST to the data link connector. 4. Connect a timing light to the engine. 5. Connect a tachometer to the data link connector terminal IG- as shown. Ignition Timing 1. Perform Preparation. (Refer to above.) 2. Verify that the idle speed is within the specification; if not, adjust it. Idle speed 4 (Neutral): 800-900 (850 + 50) rpm [MT] (P range): 750-850 (800 & 50) rpm [AT] 3. Set switch A to position 1. 4. Set test switch to SELF TEST. 5. If the SST is not used, connect a jumper wire between the TEN terminal and the GND terminal of the data link connector. 6. Verify that the idle speed is within the specification. ldle speed (Ground the terminal TEN): 650-975 rpm 7. Verify that the timing mark (white) on the crankshaft pulley and the mark on the timing belt cover are aligned. lgnition timing: BTDC 9"-11" (10" & lo) Gartner Banana

Before beginning any service procedure. refer to section T of this manual for air bag system service warnings and audio antitheft system alarm conditions . ENGINE ELECTRICAL SYSTEM INDEX ....................................... G- 2 OUTLINE ..................................... G- 3 SPECIFICATIONS ........................... G- 3 TROUBLESHOOTING GUIDE .................. G- 4 CHARGING SYSTEM .......................... G- 6 PREPARATION ............................. G- 6 CIRCUIT DIAGRAM ......................... G- 6 TROUBLESHOOTING ....................... G- 7 BATTERY .................................. G- 8 ALTERNATOR .............................. G-10 DRIVE BELT ................................ G-13 IGNITION SYSTEM ............................ G-15 PREPARATION ............................. G-15 CIRCUIT DIAGRAM ......................... G-15 TROUBLESHOOTING ....................... G-16 IGNITION TIMING ........................... G-17 SPARK PLUG ............................... G-18 IGNITION COIL ............................. G-19 IGNITER ................................... G-19 HIGH-TENSION LEAD ....................... G-20 STARTING SYSTEM ........................... G-21 CIRCUIT DIAGRAM ......................... G-21 TROUBLESHOOTING ....................... G-21 STARTER .................................. G-22 STARTER INTERLOCK SWITCH (MT) ......... G-28 45UOGX401 Gartner Banana

OUTLINE OUTLINE SPECIFICATIONS (i.e. powertrain control module (engine), audio, etc.) *2 With System Selector (49 B019 9AO) test switch at SELF TEST. - Engine Item Starter Ignition system Cylinder Arrangement Battery BP DOHC MT I AT 12, Negative ground S46A24L(S) (32 Ah) Maintenance-free 20.0 A.C. I REAR Voltage V Type and capacity (5-hour rate) 12-65 -. 1 2-70 Drive belt deflection mm {in} Dark current" m A Transistorized (built-in voltage regulator) 14.3-1 4.9 21.5 I0.846) 8 (0.31 1 Ignition timing** BTDC ("CA)lrpm U Alternator 'I Dark current is the constant flow of current while the ignition switch is OFF. 45UoGX-003 New Used 101850 Ignition coil Spark plug FRONT 55-7.0 (0.22-0.27) 6.0-7.5 (0.2H.29) 101800 TY pe Primary coil winding n Secondary coil winding kR Type Plug gap mm {in) Firing order Type Output V-A Regulator type Regulated voltage V TY pe Output V-kW Molded (with igniter) - 8.7-1 2.9 (20°C (68°F)) NGK : BKR5E-11 BKR6E-11 (Standard ... MT) NIPPONDENSO : K16PR-U11 K20PR-U11 (Standard ... MT, AT) 1 .O-1.1 IO.040-0.043) 1-3-4--2 Brush length mm {in) Direct 124.95 17.0 i0.67) 11.5 I0.45) Brush length mm {in} Standard Minimum Coaxial reduction 12-1.4 17.5 i0.69) 12.0 i0.47) Standard Minimum Electronic spark advance (ESA) Powertrain control module (engine) controls spark advance Type Spark advance control Gartner Banana

TD TECHNICAL DATA A. MEASUREMENTS I Item I Measurements I B. ENGINE Overall length mm {in) Overall width mm (in) Overall height mm {in) Wheelbase mm {in) 3,948 (1 55.4) 1,676 i65.9) 1,224 I48.2) 2,266 I89.2) 1,410 (55.5) 1,428 (56.2) Tread - ltem Tvoe u Front mm (in) Rear mm {in) BP DOHC Gasoline. 4-cvcle . In-line, 4-cylinders Pentroof DOHC, belt-driven 16 valves 83.0 x 85.0 {3.27 x 3.35) 1,840 (1,840, 11 2) 9.0 1,255 {I 2.8, 1823-300 883 (9.0, 1281-300 196 {2.0, 28) s. Cylinder arrangement and number Combustion chamber Valve system Bore x Stroke mm {in] Total piston displacement ml {cc, cu in) Compression ratio Valve timing Compression pressure kPa (kgflcm2. psil-r~m I Valve and valve auide I Standard Minimum Maximum difference between each cvlinder - - IN openz (BTDCO) Close (ABDCO) Open (BBDCO) EX close (ATDC") Valve clearance mm {in) Cylinder head 5 48 56 14 IN 133.8-1 34.0 i5.268-5.275) 0.1 0 {0.004) max. 0.10 {0.004) max. 0.02G0.066 {0.0010-0,0025) 0.18 {0.0071) Height mm (in) Distortion mm {in) Grinding mm {in) - 0: Maintenance-free Cylinder head-to-HLA clearance mm (in} Valve head diameter mm Iin) Valve head margin thickness mm {in} Valve face angle I Valve seat 1 u Standard Maximum Valve length mm {in) EX IN EX IN EX IN EX Standard Minimum Standard Minimum IN EX IN EX 5.99--6.03 iO.2359--0.2374) 0.005--0.060 (0.0002-0.0023) 0.01 b0.065 (0.0004-0,0025) 0.20 {0.008} 18.3-1 8.9 {0.7214.744) 18.3-1 8.9 (0.721-0.744) Guide inner diameter mm (in) 0: Maintenance-free 32.9-33.1 {I .296--1.303) 27.85-28.15 {I .097-1 .I 08) 0.9 {0.035) 1 .O (0.039) 45" 45" 101.89 {4.0114} 100.39 {3.9524) 101.99 (4.0153) 100.49 (3,9563) 5.970-5.985 {0.2351-0.2356) 5.96G5.980 l0.2349-0.2354) Valve stem diameter mm {in) Valve stem-to-guide clearance mm (in) Guide projection (Height "A) mm {in) Seat angle IN EX Maximum IN EX IN 45" EX 45" Gartner Banana

TECHNICAL DATA TI) G. ENGINE ELECTRICAL SYSTEM )ark current*' - Engine tem Voltage V 3attery Type and capacity (5-hour rate) Starter -. . BP DOHC MT mA 1 20.0 AT Tvm Ignition system 12, Negative ground S46A24L(S) (32 Ah) Maintenance-free A.C. ST- Output V-A Regulator type Regulated voltage V 12-65 Brush length mm {in) Drive belt deflection mm {in) 17.5 (0.69) 12.0 (0.471 - -- r-- I I hPe Spark plug 1 2-70 Standard Minimum New Used Brush length mm {in) BKR6E-11 (Standard ... MT) NIPPONDENSO : K16PR-U11 K20PR-U11 (Standard ... MT, AT) TYW OU~DU~ V-kW Standard 1 17.0 I0.67) Minimum 1 11.5 10.451 1 Type Spark advance control Ignition timing*2 BTDC ("CA)/rpm Transistorized (built-in voltage regulator) 14.3-1 4.9 21.5 (0.85) 8 I0.31) 5.5-7.0 {0.22--0.27) 6.0-7.5 {0.24--0.29) . . I . . Electronic spark advance (ESA) Powertrain control module (engine) controls spark advance Ignition coil H. CLUTCH Direct lot850 TY ~e Primary coil winding a Secondary coil winding ks2 . .- - Engine Item BP DOHC 1 Coaxial reduction 10/800 Molded (with igniter) - 8.7-1 2.9 NGK : BKR5E-11 *I Dark current is the.constant flow of current while the ignition switch is OFF. (i.e. powertrain control module (engine), audio, etc.) '2 With System Selector (49 B019 9AO) test switch at SELF TEST. , Plug gap mm (in) Firing order 124.95 1 .O-1.1 {0.040--0.043) 1-342 Clutch control Runout limit mm {in) 1 0.2 (0.008) I 12-1.4 Hydraulic Clutch pedal TYP Suspended A .- 6.13 120 (4.72) 175--185 {6.89--7.28) 0.G3.1 (0.02-0.12) 68 I2.68) Pedal ratio Full stroke mm {in) Height (with carpet) mm (in} Free play mm {in} Distance to carpet when clutch fully disengaged rnm [in Minimum Gartner Banana

ALPHABETICAL INDEX *a* ENGLISH S** - BELTtA1(L) ,FRT BELt'A1(R),FRT SEAT------ BOLT,JACK SET------------ BELTtB'(R),FRT SEAT------ BOLT,LAMP LID------------ BELTIB1,FRT SEAT--------- BELTlVl------------------ 1-05 2-KB BKACKETJCOUPLER-KNOCK SEN BHACKET,CRASH PAD-------- BRACK~T,E~G.K.PIPE------- BRACKET,FENDER----------- *********Y******* * * * A * * * **#*~******%***** ACTUATOR,A.C.C.---------- 2-Jl3 ACTUATOR, SHIFT LOCK---- -- 1-616 ADAPTERIDRIVE PLATE------ 1-J7 ADJUSTER NO .J-----.----- -- 2-M8 ADJUSTER N0.4------------ 2-M8 AGJUSTER,HYDRAULIC LASH-- 1-N3 ADJUSTER,NO.1------------ 2- J8 ADJUSTER,N0.2------------ ALTERNATOR--------------- 2-J8 1-C7 ANCHOR UNIT(L),BE?T------ 2-39 ANCHOR UNIT(R1,BELT------ 2-D9 ANTENNA,RADI3------------ 2-~141 ANTILOCK BRAKE----------- 1-N15 ARM NO.1, LINK------------ 2-H15 ARM N0.2,LINK------------ 2-115 ARM(L1,LOWER------------- 1-113 ARM(L),LOWER-REAR-------- 1-F12 ARM(L1,UPPER------------- 1 -H13 ARM(R),l.OWER------------- 1-H13 ARM(R),LOWER-REAR-------- 1-F121 ARM(R),UPPER------------- 1-H13 ARM,UPPFR-FRT------------ 1 -HI31 ARM.UPPER-REAR----------- 1-F121 - 1-~6 BEZEL(L1,HEAD LAMP------- 2-M3 BEZEL!"),HEAD LAMP------- 2 -M3 BLADE(d>,WIPER-FRONT----- 2-H15 BLADE WIPER-FRONT--------- 2-H15 BLOCK,CYLINDER----------- BLOCKIFUSE--------------- 1 -H3 2-614 BLOCK,MAIN FUSE---------- BLOWER UNIT-----.-------- 2-114 2-Fll BODY 8 PISTON(L),CALIPER- 1-F11 > -fit v BUSHlNG,RUBBER-LOWER ARM- A-LTAJ BODY & PISTON(R),CALIPER- 1-FS1 1-613 BODY(L),FRONT DOOR------- 2- J9 BODY(R),FRONT DOOR------- 2-J9 BODY,CONTROL VALVE-UP---- 1 -GB BODY,LOW-RADIO ANTENNA--- 2-El4 BODY,THROTTLE------------ 1 -K4 BODY.VALVE LWR----------- 1 -18 BRACKET,MEMBER----------- 2-J7 BRACKET.PARKING CABLE-FLO 2-K5 i-Miii SRACKET~STARTER----------- 1-~6 BRACKETISTOPPER-3kTTERY-- 1-i7 BRACKET,VANE PUMP-------- 1-C13 BRACKET, WASHER TANK ------ 2-C15 2-F15 BRACKET,WIRE CLIP-OXYGEN- 1-F3 BRACKET,WIRING----------- 2-H14 BREATHER---.-------------- 2-114 1-ti11 1 -L7 1-111 BRE/tTHER,AIR-T/MISSION--- 1-D6 BRKT(!i,BUMPER-RR SKIRT-- 2-L5 BdKT(L1,SEAT-F.FLOOR PAN- 2-L5 BRKT(L),TRK.BOARD-FENDER- 2-J5 BRKT(R),BUNPER-RR SKIRT-- 2-L5 BF!KT(R) ,SEAT-F. FLOOR PAN- 2-K5 BRKT,AIR CLNR-WHL APRON-- 2-C5 BRKT,BATT.CLANP-QTR PANEL 2-05 BRKT ,CAP-QUARTER PANEL--- 2- I5 BRKT,DIAGNOSlS UNIT------ 2-H13 BRKT,DIAGNOSIS/POWER UNIT 2-H13 BRKT,MOTOR-ANTENNA------- 2-El4 BRKTtA1,WASHER TANK-FRT-- 2-El5 BRUSH-.------------------- 1 -C7 1 -F7 BRUSH ,YOKE-- - - - - - --- - - - - -. 1-F7 BuLa--------------------- 1 -H7 2-C4 2-C7 2-D4 2-F.4 2-67 2-H4 2 -H7 2 - L 7 BULn 8 SOCKET------------ 2-L7 BUL0,MODE CONTROL-------- 2-El 1 BULB,RESISTOR------------ 2-C7 2-67 BULB'Bt,SWITCH-RR DEFOGER 2-El3 BUMPER, FRONT - --- - . -- -. .. - - BUMPER, REAR- - - - - - - - - - - - - - 2 - E3 2-H3 BUSH---------.----------- 1-1115 1-616 1 - r; 1 tl 1 - .I6 1 -Ll4 - .-.- - L A1 BRACKET------------------ 1 -LIB 1-K7 1-1.15 2-C15 2-G14 2-H141 2-L5 BRACKET NO 1,k.B.S.------ 1 -MI 5' BRACKET ~0.5,A.B.S.------ 1 -M! 5 BRACKET(L),CABLE--------- 1-GI1 BRACKET(L1,ENGINE-------- BRACKET(L),F. BUMPER SIDE 2-F3 BRACKET(L),FRONT-AUDIO--- BRACKETCL) ,HINGE-LAPP LID 2-M3 BRACKETfL),IHST.--------- 2-F5 BRACKET(L1,TUNER--------- BRACKET(L),RADTATOR------ 2-N4 BRACKET(L),STARILIZER---- 2-D5 2-N13 RRACKET(R),CABLE---------- 1 -Gll NRACKET(R),ENGINE-------- i l-cl41 BRACKET(P),FRONT-AUDIO--- BRACKET(R),HIHGE-LAMP LID 2-M3 IRAcKET(R),INsT.--------- 2-M131 2-F5 BRACKET(R1,RADIATOR------ 2-N4 I BRACVET(R),STARILIZER---- 2-C5 I bRACKET(R) ,TUNER--------- 2-N13 BRACKET(RR),AUDIO-------- 2-N131 BRACKET,ACCEL WIRE------- 1-04 BRACKET ,ACTUATOR--- - ----- 2-~131 BRACKET,ACTUATOR-P.C.C.-- 2-313 RRACKET,ACTUATUR-FRONT--- 2-J13 RRACKET,AIR CLEPAER------ 1-14 1 BRACKET,BATTERY CLAMP---- 1-17 BKACKET,BUHPER---- ------- 2-N4 I BRACKET,CAHISTER-- .--- .. - 1-F4 BRACKET,CLAMP------------ 2-1111 BRACKET ,CLIP ------ 2 - L 3 BRACKET,COMPRESSOR------- 1-65 1 BRACKE1,CONTROL UNIT- .--- 1-Cl5 2-C13' BRACKET,COUPLER----- ----- 1-1112' ... - - .- - --.A- €-001 BACK(L1,FRONT SEAT------- 2-C9 I BACK(R),FRONT SEAT----- -- 2-1 A BAG,TOOL----------------- 2-MB / 2-Dl6 BALL JOINT,LOWER--------- BALL, S'TEEL - - - - - - - - - - - - - - - 1-113 1-El4 1 -H7 BAUD--------------------- 1-Dl41 CAP SET,KESERVE TANK----- 1 -I 131 BOLT,AIR CLEANER--------- 1-14 BOLT,AIR C0K.------------ 2-Jll BOLT,ANCHOR END---------- 1.M7 BOLT,BAFFLE PLATE-------- 1 -K7 dOLT,BEARING CAP--------- 1 -H3 BOLT,CAMSHAFT CAP-------- 1-E3 BOLT,CARRIER------------- 1 -K11 ~OLT,CL&MP--------------. 1-14111 1-17 BOLT .COMPRESSOR---------- 2-1111 BOLT,COEPRESSOR-AIR CON.- 2-Kll BOLT,CONNECTOR----------- 1-~151 1-615 BEARlNG,BALL------------- 1-66 ! BFARING.BALL-ALT. FRONT- - 1 -C7 I BEARING~BALL-ALT. REAR--- 1-ci I REARING, BALL-COUNTER SHAF 1 -G6 I BEARING~BALL-FLY WHEEL--- BEARING,RALL-MAIN DRIVE G BEARING,BALL-MAI!i SHAFT-- BEARING,IIEEDLE----------- CA?,TOP LOCK---------.--- CAP,VANE PUMP TANK------- CARRIER,DlFFERENTIAL----- BOLT ]CONTROL VALVE------- 1-C8 I 1 -E8 1-KB I !!7LT,CROSS MEMBER-------- 2-C5 I BOL1,CYLINDER HEAD------- 1-E3 ' BOLT.UECK LOCK----------- 2-112' 1-LIZ; BEAR1NCi.WtiEEL--------- ---- 1-El11 BELT TIMING------ 1-NJ ! .. . CAT . AUNAOS - U3 Gartner Banana

ALPHABETICAL INDEX *%* ENGLISH *** CASE,T/MISSlON------------ CASE'A' , LLOWER UNIT- ----- CASE'A',COOLING UNIT----- CASE'A1 ,HEATER UNIT------ CASEIB' ,BLOWER UNLT------ CASE'B' ,COOLING UNIT----- CASE'B9,HEATER UNIT------ CASE'OUT',ASHTRAY-------- CASING,DIFFERENTIAL------ CASING,HYDRAULIC UNIT---- CASING,STOPPER----------- CATALYST ,THREE WAY------- CEILING,TOP-----.--------- CHANNEL( L) DIVISION-DOOR- CHANNEL(R)lDIVISION-DOOR- CHECKER,DOOR------------- CLAMP---------.-..--------- CLAMP,BATTERY------------ CLAMP,HOSE--------------- 1-L11 DRUM,CLUTCH-------------- 1-N8 DRUM,CONNECTING---------- 1 -H9 DRUM,DIRECT------------.- 1-F9 DRUMIREAR CLUTCH------ -- 1-C9 DUCT(L)---------------..-- 2-DB DUCT(L1 ,SIDE DEMI .-- .---- DUCT(R)----..------------- 2-C8 2-DB DUCT(R1,SIDE DEMT,------- DUCT,AIR- ---- ------------ 2-C8 DUCT,CENTER-------------- 2-Cll 2-C8 DUCTIFRESII AIR----------- 1-14 CLIP,WEATHLRSTRIP-OUTER-- 2-El1 CLIPtA',SPEEDOMETER CABLL 2-F7 CLIPIA',WEATHERSTRIP-OUT- 2-El1 CLIPIB',WIRE-BONNET------ 2-E5 CLGTH,REPAIR-TOP-------..- 2-Dli CLAMt3,HOSE-A 1 .P. /A. CLNR CLAMP,WATER HOSE--------- ELEMENTIAIR CLEANER------ 1-J4 EMBLEM,CAP-WIiE€I.--------- 1-Ll;? END,CONTROL LEVtR-------- 1 -K6 ENDlS/ROD<1ST82ND)------- 1-J6 ENl)rS/ROD(3RDB4TH;------- 1-J6 ENG:SHIFf ROD(O/TOI'&REV.) 1-K6 ENGINE,PARTIAL----------- ENGINE,SHORT------------.- 1-D3 ESCUTCHEON--------------- 1-D3 EVAPORATOR--------------- 2-ti9 2-Mll EYE BOLT K?T,31. GEAR---- 1-M12 2-116 2-L12 2-N5 COVER,5OIE-CC1----------- 2-Ki COVER,HOLE-ANTENNA------- 2-El4 COVER,HOLE-LIFT GATE----- 2-Dl0 COVER,INNER HANDLE----.--- 2-M9 COVER,INTERIOR MIRRORm--- 2-F16 COVER,JOINT-LOWER-------- 1-112 COVER,JOINT-UPPER-------- 1-112 COVER,LEVER-OPENER------- 2-L7 COVER,MAIN FUSE BLOCK---- 2- I1 4 COVER,OIL PUMP----------- COVER,REAR--------------- 1-N4 1-J3 1-K12 COVEK,RE&R-ALTERNATOR---- 1-C7 CQVER,RELAy------------..- 2-H1! COVER,ROD---------------- 1-1.6 COVER,SELECT LEVER------- 1-616 COVERISERVICE HOLE------- Z-F5 COVER,SERVO-------------- COVER,SIDE--------------- 1-N7 2-K7 COVERISPARE TIRE--------- 2-Cl6 COVER,l'HERHO------------- 1-D5 CQVER,THERMOSTAT--------- 1-D5 COVER,TIMING EELT-C. ----- 1-13 GASKET------------------- 1-C5 1-C15 1 -F3 1-H7 1-J14 1-L4 1 - L 14 1-N7 2- ~4 GASKET 8 SEAL KIT-------- 1-M9 GASKET KIT,COMPRESSOR---- 2-K11 GASKET SET ,CYL HEAD----- i -D3 GASKET SETIENGINE-------- 1-DY GASKET(C1 ,TIMING BELTCL) - 1-13 GASKEl'(INN),TIHIHG BELTCL 1-13 BASKET(L)---------------- GASKET,CAP--------------- 1-13 1-114 GASKETICONPRESSOR-------- 2-K11 GASKET,CONVERTER--------- !-Dl4 G0.SKET ,COVER PLATE------- 1-K6 GASKET,CYl.INDER WEAD----- 1-F3 GASKET,DRAIN PLUG-------- 1-li14 GASKETIDRUM SUPPORT- ----- 1 - D8 CASKET.E.G.R. VALVE------ 1-L4 CORD NO.1,HI.TENSION----- 1 -M6 CORD NO.2.HI.TENSION----- 1 -M6 CORD NO.~;HI.TENSION----- 1 -M6 CORD NU.4,HI.TENSION----- 1 -M6 CORD SET,HI.TENSION------ 1 -M6 CORa,EARTH--------------- 2-c14 2-Nl:! CORE,HEATER Ub!IT--------- 2-Dl1 COTTER,VALVE-IN.--------- 1 -N3 COUPLERISOLENOID VALVE--- 1-E0 COVER-------------------- l-Cl6 2-C6 COVER NO.l,ADJ-FRT------- 2-66 COVER NO.2,ADJ-FRT-a+----- 2-60 COVER N0.3.ADJ-FRT------- 2. SC COVER(C),SENSOK---------- 2-H9 COVER(L),BELT LINE------- 2-Kli COVER(L).BRACE BAR------- 2-C6 COVER,UNDER-------------- 2-C6 COVER,VALVE BODY--------- 1-10 COVER,WASHER TANK-------- 2-F1E COVER,WHEEL CORE--------- 1-Hli COVER, WIPER ARM-FRONT--- - 2-H15 COVER'L1,HYDRAULIC UNIT-- 1-Ml5 COWLING,RADIATOR--------- CRANKSHAFT--.. -- ------ ---- 1-E5 1 -K3 CUPISECONDARY------------ 1-H15 CUSHION(L),FRT SEAT------ 2-N8 CUSHIOW(R),FRT SEAT------ 2-K8 CUSHION,LID HINGE-------- 2-H4 CUSHION.RUBBER----------- 2-17 2-Ll CYL.,CLUTCH MASTER------- I -El4 CYL.,CLUTCH RELEASE------ 1-El4 CYL,,TAHDEM MASTER------- 1-F15 1-61 5 1-H15 /~ASKET;EX.MANIFOLD------- 1-E4 GASKET,EXH.PIPE-CONVERTER 1-Dl4 GASKET,EXTENSION--------- 1-C8 GASKET,FILLER PIPE------- 1-H14 GASKET ,FRONT COVER--- .--- I-C6 GASKET,HEAD COVER-------- 1-fi3 GASKET,IN.MANIFOl.D------- 1-D4 GASKET.LICENSE LAMP------ 2-H4 COVER( L) ;DECK LOCK------- 2- Jli COVER(I.),DRAIN-SOFT TOP-- 2-Hli COVER(L),DUST------------ 1-El2 1-Fl? COVER(L),HINGE----------- 2-D9 COVER( L) ,HOLE----------- - 2-Nl! COVER(L),KNUCKLE--------- 2-NB COVER(L).SEAT BACK------- 2-N8 - ... CLIP SET,DRlVE SI!AFT----- 1-DlI CLIP(L1 ,FORM PLATt .------ 2-El2 CLIP(R),FORM PLATE------- CLIP,CABiE--------------- 2-El2 1-Dl6 CLIP ,ENGINE HARNESS------ 2-N141 CLIP,FLEXIBLE Hi3SE------- 1-C16' l-~ld I-Ml5 2-1314 FASTENER SET ,TOP CLOTH--- 2- Dl2 FASTENER,BONNET RELEASE-- 2-KG FASTENER,DOOR TRIM------- 2-rl0 2-#7 GASKET,OIL PUMP---------- 1- J7 GASKET ,OIL STRAINER-- ---- 1-C5 1-rJ4 GASKET.RR.COH0.---------- 2-F4 1-1jsl CQv~~(~);S~~so~-l-------- 2-H9 I I-K~SI COVER( L) ,SENSOR-AIR BAG-- 2-H9 CLIP,HAHNESS------------- 2-E15: COVER(R),REL'I LINE------- FKl4 2-G13! COVER(R),BRACE BAR------- 2-C6 , 2-M14' CUVER(W),DECK LOCK------- 2-1121 2-N14( COVERIR) ,DRAIN-SOFT TOP-- 2-HIZi CLlP,HARNESS-HAND BRAKE-- 2-M7 I COVERCR) ,DUST.----------- 1-E13i CLlP,HEATER COtITKOL--- - -- 2-Elli 1-F131 CLIP, HOSE- SUB T.8 VATFR H 1 -F5 i COVER(R) ,HINGE- ---------- 2-C9 ! CLIP,OIL FJPE-------. ---- 1-L7 I CLIP ,PIPE--- -..- ---------. 2-N8 j I-El6: COVER(R),HOLE------------ Z-N1S1 x-~I(+ COVER(RI,KNUCKLE--------- 2-18 I 1-Fl6, COVER(R) ,SEAT BACK------- 2-K8 I FASTEHERILIFT GATE TRIM-- 2-F14 FASTENERBRAIN RAIL-REAR-- %-Eli FASTEHER; RAIN FASTENER. REAR 1 SIDE TUXN- - .SPRANG CAP- FASTEYER,SEEL------------ 1- J3 1-K4 FASTENER, STOP LAMP-HI . --- II D f FEEDER-ANTENNA- - - - - -- - - - - 2-F14j GASKET~VAC POWER ASSIST- !-El5 I )t s FILTER ,AIR--------..------ 2 - N 12 1-G15 FILTER, FUEL- - ..- - - - - - ----.. ~%*t*~x*rfi**tf%%w 1-F4 1 SASK6T.W.PUMP INLET------ 1-D5 I FII.TEP,FUEL PUMP--------- 1-H14 GASKET,WATER PUMP------ - 1-05 IlAl~,FRONT-WIND.---------- 2-~111 FINISHEPIWEAR------.----- 2-i4 GASKET,WINDOW REGULATOR-- 2-C10 . . . . . . . -. . . . . . -- .. - -- ------- L.- -.- --- -.-- CAT. AUNA04-03 F.-002 Gartner Banana