1994 JEEP CHEROKEE battery

MODES OF OPERATION, OPEN LOOP/
CLOSED LOOP.......................14-27
MODULE, ELECTRICAL TESTS
AT POWERTRAIN CONTROL.............8H-6
MODULE, FUEL PUMP..............14-2,14-56
MODULE, INTERMITTENT WIPER..........8K-5
MODULE (PCM) 60-WAY CONNECTOR,
POWERTRAIN CONTROL...............14-38
MODULE (PCM), POWERTRAIN
CONTROL; EMISSION CONTROL
SYSTEMS...........................25-9
MODULE (PCM), POWERTRAIN CONTROL;
FUEL SYSTEM..................14-18,14-58
MODULE (PCM), POWERTRAIN CONTROL;
IGNITION SYSTEMS.........8D-6,8D-15,8D-28
MODULE REPLACEMENT, DRL............8L-16
MODULE REPLACEMENTÐXJ VEHICLES,
HEADLAMP DELAY...................8L-16
MODULE (TCM) SERVICE, TRANSMISSION
CONTROL.........................21-173
MODULEÐXJ VEHICLES, SENTINEL
HEADLAMP DELAY...................8L-15
MOTOR, A/C BLOWER..................24-43
MOTOR DIAGNOSIS, DISCONNECT AXLE/
SHIFT...............................2-27
MOTOR, FRESH AIR DOOR VACUUM.......24-41
MOTOR, FRONT WIPER.................8K-10
MOTOR (HEATING), BLOWER............24-40
MOTOR, IDLE AIR CONTROL (IAC)........14-56
MOTOR NOISE DIAGNOSIS, 2.5L
STARTER...........................8A-13
MOTORÐPCM OUTPUT, IDLE AIR
CONTROL (IAC)......................14-25
MOTOR RELAY TEST, STARTER...........14-48
MOTOR REMOVAL/INSTALLATION, 2.5L
STARTER............................8B-5
MOTOR REMOVAL/INSTALLATION,
4.0L STARTER........................8B-6
MOTOR REPLACEMENT, A/C
RECIRCULATING AIR DOOR VACUUM.....24-31
MOTOR REPLACEMENT, HEATER/
DEFROSTER/INSTRUMENT PANEL
OUTLET DOOR VACUUM...............24-30
MOTOR REPLACEMENT, POWER SEAT......8R-2
MOTOR REPLACEMENT, REAR WIPER.....8K-13
MOTOR RESISTORS REPLACEMENT,
BLOWER...........................24-35
MOTOR SERVICE PROCEDURES,
ENGINE STARTER.....................8B-4
MOTOR SPECIFICATIONS, 2.5L STARTER . . . 8B-11
MOTOR STALL TEST, ACTUATOR...........8P-6
MOTOR SWITCH REPLACEMENT,
BLOWER MOTOR/AIR DOOR............24-39
MOTOR TEST, IDLE AIR CONTROL........14-46
MOTOR TEST PROCEDURES ON
VEHICLE, ENGINE STARTER.............8A-9
MOTOR TORQUE SPECIFICATIONS,
STARTER...........................8B-11
MOTOR, WINDSHIELD WIPER.............8K-2
MOTOR/AIR DOOR MOTOR SWITCH
REPLACEMENT, BLOWER..............24-39
MOTOR/FAN REPLACEMENT, BLOWER.....24-26
MOULDING, BODY SIDE STEP...........23-145
MOULDING, WINDSHIELD REVEAL . . 23-73,23-183
MOULDING, WOODGRAIN...............23-19
MOULDINGÐXJ VEHICLES, DRIP RAIL.....23-29
MOULDINGÐXJ VEHICLES, WINDSHIELD
SIDE.............................23-114
MOULDING/CLADDING, BODY SIDE........23-19
MOULDINGS, DOOR WINDOW EXTERIOR . . . 23-61
MOUNTING, MATCH TIRES...............22-7
MOUNTÐREAR, ENGINE.............9-12,9-52
MOUNTSÐFRONT, ENGINE...........9-10,9-51
MUFFLER AND EXHAUST TAILPIPEÐXJ
VEHICLES...........................11-5
MUFFLER AND EXHAUST TAILPIPEÐ
YJ VEHICLES.........................11-6
MUFFLER AND TAILPIPE HEAT SHIELDS....13-17
MUFFLER/TAILPIPE HANGER BRACKET
.....13-16
MULTI-PORT FUEL INJECTION (MFI)Ð
COMPONENT DESCRIPTION/
SYSTEM OPERATION
..................14-17
MULTI-PORT FUEL INJECTION (MFI)Ð
COMPONENT REMOVAL/INSTALLATION
. . . 14-54
MULTI-PORT FUEL INJECTION (MFI)Ð
GENERAL DIAGNOSIS
.................14-32NAMEPLATES (ADHESIVE-BACKED),
EXTERIOR.........................23-158
NAMEPLATES, EXTERIOR................23-30
NEUTRAL, HYDRAULIC FLOW IN PARK.....21-86
NEUTRAL SWITCH, PARK...............14-58
NOISE DIAGNOSIS......................3-45
NOISE DIAGNOSIS, 2.5L STARTER MOTOR . . . 8A-13
NOISE DIAGNOSIS, RADIO................8F-2
NOISE, GEAR AND BEARING; FRONT
SUSPENSION AND AXLE................2-16
NOISE, GEAR AND BEARING; REAR
SUSPENSION AND AXLES................3-7
NOISE OR VIBRATION, TIRE..............22-4
NOISE/VIBRATION DIAGNOSIS, AXLE;
FRONT SUSPENSION AND AXLE..........2-16
NOISE/VIBRATION DIAGNOSIS, AXLE;
REAR SUSPENSION AND AXLES..........3-7
NO-LEAD FUEL TANK FILLER TUBE........14-12
NON-INTERMITTENT WINDSHIELD
WASHER, DIAGNOSING...............8K-12
NON-TILT STEERING COLUMN............19-50
NORMAL BRAKING MODE, ABS
OPERATION IN.......................5-43
NOTATION, METRIC SYSTEM..........INTRO.-8
NOTATIONÐSAE AND METRIC, THREAD . INTRO.-9
NOTATIONS, SPECIFICATION...........INTRO.-8
NOZZLE AND DUCT, DEFROSTER..........24-40
NOZZLE REPLACEMENT, WASHER.........8K-13
NOZZLE/TUBE, FUEL FILLER.............23-30
NP231 SERVICE DIAGNOSIS............21-274
NP231 TRANSFER CASE.........21-272,21-291
NP231 TRANSFER CASE, LEGEND FOR....21-292
NP231/NP242 TORQUE SPECIFICATIONS . . . 21-331
NP242 SERVICE DIAGNOSIS............21-295
NP242 TRANSFER CASE...............21-293
NP242 TRANSFER CASE, LEGEND FOR....21-319
NUMBER (VIN) DECODING, VEHICLE
IDENTIFICATION...................INTRO.-2
NUMBER (VIN) PLATE, VEHICLE
IDENTIFICATION...................INTRO.-1
NUT TIGHTENING, WHEEL............5-32,5-37
NUT, WHEEL LUG......................22-11
OFF DRAW (IOD) DIAGNOSIS, IGNITION.....8A-8
OIL CHANGE AND FILTER REPLACEMENT,
ENGINE.............................0-15
OIL COOLERS, TRANSMISSION............7-29
OIL, ENGINE...........................0-13
OIL FILTER, ENGINE.....................0-14
OIL FILTER REPLACEMENT.............21-100
OIL LEVEL, COMPRESSOR................24-6
OIL PAN ..........................9-32,9-72
OIL PRESSURE GAUGE..................8E-1
OIL PRESSURE GAUGE INOPERATIVE.......8E-3
OIL PRESSURE INDICATOR...............8E-1
OIL PRESSURE INDICATOR INOPERATIVE....8E-3
OIL PUMP........................9-33,9-73
OIL PUMP OVERHAUL...........21-122,21-206
OIL PUMP SEAL REPLACEMENT.........21-189
OIL PUMP WEAR LIMITS, AW-4.........21-325
OIL SEAL REPLACEMENT, INNER AXLE
SHAFT..............................2-33
OIL SEAL REPLACEMENT, TIMING CASE
COVER..........................9-26,9-67
OIL SEALS, REAR MAIN..............9-44,9-84
OIL SEALS, VALVE SPRINGS..........9-21,9-62
ON-BOARD DIAGNOSTIC SYSTEM,
USING.............................8A-19
ON-BOARD DIAGNOSTICS (OBD);
COOLING SYSTEM.....................7-4
ON-BOARD DIAGNOSTICS (OBD); FUEL
SYSTEM............................14-48
ON-BOARD DIAGNOSTICS (OBD);
IGNITION SYSTEMS..................8D-19
ONE GAUGE INOPERATIVE...............8E-22
ONE-WAY CLUTCH OVERHAUL, NO. 2.....21-234
ONE-WAY CLUTCH OVERHAUL, NO. 1.....21-229
OPEN CIRCUIT VOLTAGE, BATTERY.........8A-4
OPEN CIRCUIT VOLTAGE TEST, BATTERY....8A-3
OPEN LOOP/CLOSED LOOP MODES OF
OPERATION
.........................14-27
OPENING PANEL (GOP), GRILLE AND
GRILLE
.............................23-3
OPENING WEATHERSTRIP SEAL,
LIFTGATE
...........................23-70
OPENING WEATHERSTRIP SEALS,
DOOR WINDOW GLASS AND DOOR
......23-62OPERATING SOUND LEVELS...............5-3
OPERATING SPECIFICATIONS, PUMP.......19-3
OPERATION, ABS SYSTEM................5-39
OPERATION, A/C........................24-1
OPERATION, ACCELERATION SWITCH.......5-45
OPERATION AND APPLICATION CHARTS,
GEARTRAIN........................21-159
OPERATION AND WEAR COMPENSATION,
CALIPER............................5-24
OPERATION, ANTILOCK BRAKE
SYSTEM............................5-43
OPERATION; CHIME/BUZZER
WARNING SYSTEMS...................8U-1
OPERATION, CLUTCH.....................6-2
OPERATION, COMPONENT
IDENTIFICATION/SYSTEM...............8D-1
OPERATION, COMPONENTS.............21-157
OPERATION, ECU
.......................5-46
OPERATION, HCU PUMP AND PEDAL
TRAVEL SENSOR
......................5-44
OPERATION, HCU SOLENOID VALVE
........5-43
OPERATION, HEATER/DEFROSTER
.........24-37
OPERATION IN ANTILOCK BRAKING
MODE, ABS
..........................5-43
OPERATION IN NORMAL BRAKING MODE,
ABS
................................5-43
OPERATION, MULTI-PORT FUEL
INJECTION (MFI)ÐCOMPONENT
DESCRIPTION/SYSTEM
................14-17
OPERATION, OPEN LOOP/CLOSED LOOP
MODES OF
..........................14-27
OPERATION, PARKING BRAKE
.............5-56
OPERATION, POWER BRAKE BOOSTER
......5-22
OPERATION, POWER STEERING PUMPÐ
INITIAL
............................19-13
OPERATION; REAR SUSPENSION AND
AXLES
..............................3-44
OPERATION, SYSTEM
...................8P-9
OPERATION, WHEEL SPEED SENSOR
.......5-45
OPERATION/DIAGNOSIS
..................8U-1
OPERATIONAL CHECK (ROAD TEST)
........8H-7
OPERATIONAL CHECK WITH BATTERY
INDICATOR (BASE CLUSTER ONLY)
......8A-14
OPERATIONAL CHECK WITH VOLTMETER
. . . 8A-15
O-RING SEAL, FLOW CONTROL VALVE
FITTING
............................19-12
ORNAMENTATION, WHEEL
................22-6
OUTER SCUFF PLATESÐXJ VEHICLES
....23-118
OUTLET DOOR VACUUM MOTOR
REPLACEMENT, HEATER/DEFROSTER/
INSTRUMENT PANEL
..................24-30
OUTPUT, AIR CONDITIONING CLUTCH
RELAYÐPCM
.......................14-24
OUTPUT, AUTO SHUT DOWN (ASD)
RELAYÐPCM
.......................14-24
OUTPUT, DATA LINK CONNECTORÐPCM
. . . 14-24
OUTPUT, EMR LAMPÐPCM
..............14-24
OUTPUT, FUEL INJECTORSÐPCM
.........14-25
OUTPUT, FUEL PUMP RELAYÐPCM
.......14-25
OUTPUT, GENERATOR FIELDÐPCM
.......14-25
OUTPUT, GENERATOR LAMPÐPCM
.......14-25
OUTPUT, IDLE AIR CONTROL (IAC)
MOTORÐPCM
.......................14-25
OUTPUT, IGNITION COILÐPCM
...........14-26
OUTPUT, MALFUNCTION INDICATOR
LAMPÐPCM
........................14-26
OUTPUT, RADIATOR FAN RELAYÐPCM
.....14-26
OUTPUT, SCI TRANSMITÐPCM
...........14-26
OUTPUT SHAFT OVERHAUL, NO. 2 ONE-
WAY CLUTCH
......................21-234
OUTPUT, SHIFT INDICATORÐPCM
........14-26
OUTPUT, SPEED CONTROLÐPCM
.........14-27
OUTPUT, TACHOMETERÐPCM
...........14-27
OUTPUT, TORQUE CONVERTER CLUTCH
RELAYÐPCM
.......................14-27
OUTPUT VOLTAGE SPECIFICATIONS
.......8B-12
OVERDRIVE COMPONENTS, FOURTH
GEAR
.............................21-158
OVERDRIVE PLANETARY GEAR AND
CLUTCH OVERHAUL
.................21-209
OVERDRIVE SUPPORT OVERHAUL
.......21-216
JINDEX15
Description Group-Page Description Group-Page Description Group-Page

OVERDRIVE/OVERRIDE SWITCH..........14-22
OVERHAUL, 30RH/32RH TRANSMISSION . . 21-112
OVERHAUL, ADAPTER HOUSING AND
PARK LOCK COMPONENT.............21-120
OVERHAUL, AW-4 TRANSMISSION.......21-192
OVERHAUL, COMPRESSOR..............24-17
OVERHAUL, DIFFERENTIAL...............3-45
OVERHAUL, DIRECT CLUTCH............21-219
OVERHAUL, FIRST-REVERSE BRAKE
PISTON AND TRANSMISSION CASE.....21-237
OVERHAUL, FORWARD CLUTCH.........21-223
OVERHAUL, FRONT CLUTCH............21-125
OVERHAUL, FRONT PLANETARY GEAR....21-228
OVERHAUL, FRONT SERVO AND BAND....21-136
OVERHAUL, GOVERNOR AND PARK
GEAR.............................21-121
OVERHAUL, MANUAL VALVE SHAFT......21-205
OVERHAUL, MASTER CYLINDER...........5-20
OVERHAUL, NO. 2 ONE-WAY CLUTCH
AND OUTPUT SHAFT.................21-234
OVERHAUL, OIL PUMP..........21-122,21-206
OVERHAUL, OVERDRIVE PLANETARY
GEAR AND CLUTCH..................21-209
OVERHAUL, OVERDRIVE SUPPORT.......21-216
OVERHAUL, OVERRUNNING CLUTCHÐ
LOW-REVERSE DRUMÐREAR
SUPPORT.........................21-118
OVERHAUL, PLANETARY GEAR
TRAIN............................21-131
OVERHAUL, REAR CLUTCH.............21-128
OVERHAUL, REAR SERVO AND BAND.....21-136
OVERHAUL, SECOND BRAKE............21-232
OVERHAUL SERVICE INFORMATION......21-118
OVERHAUL SERVICE TOOLS............21-192
OVERHAUL, SUN GEAR AND NO. 1 ONE-
WAY CLUTCH......................21-229
OVERHAUL, TRANSFER CASE
DISASSEMBLY................21-277,21-297
OVERHAUL, TRANSMISSION
DISASSEMBLY...................21-5,21-36
OVERHAUL, TRANSMISSION VALVE BODY . . 21-240
OVERHAUL, WHEEL CYLINDER............5-36
OVERHEAD CONSOLEÐXJ VEHICLES......8L-20
OVERLAY, WOODGRAIN.................23-22
OVERRUNNING CLUTCHÐLOW-
REVERSE DRUMÐREAR SUPPORT
OVERHAUL........................21-118
OXYGEN (O2S) SENSOR; EMISSION
CONTROL SYSTEMS...............25-7,25-9
OXYGEN (O2S) SENSOR; FUEL SYSTEM....14-57
OXYGEN (02S) SENSOR HEATING
ELEMENT TEST......................14-45
OXYGEN (O2S) SENSOR; IGNITION
SYSTEMS..........................8D-28
OXYGEN (O2S) SENSORÐPCM
INPUT.............................14-22
OXYGEN SENSOR TESTS................8D-19
PACK MEASUREMENT AND ADJUSTMENT,
DIFFERENTIAL SHIM...................2-42
PACK REQUIREMENTS, AW-4 CLUTCH
AND BRAKE........................21-328
PACKAGE DIAGNOSIS, GAUGE............8E-22
PACKAGE GAUGE REPLACEMENT,
GAUGE.............................8E-24
PACKAGE GENERAL INFORMATION,
GAUGE.............................8E-22
PACKAGE SERVICE PROCEDURES,
GAUGE.............................8E-24
PAINT, ACCENT.......................23-202
PAINT APPLICATION...................23-201
PAINT CODES, XJ EXTERIOR............23-205
PAINT CODES, XJ INTERIOR............23-205
PAINT CODES, YJ EXTERIOR............23-206
PAINT CODES, YJ INTERIOR............23-206
PAINT REPAIR ON GALVANIZED METALS . . 23-202
PAN, OIL..........................9-32,9-72
PANEL, A/C CONTROL..................24-41
PANEL AND GAUGES, INSTRUMENT........8A-1
PANEL AND GAUGESÐXJ, INSTRUMENT....8E-1
PANEL AND GAUGESÐYJ, INSTRUMENT....8E-1
PANEL COMPONENTS, INSTRUMENT.....23-191
PANEL, DASH PANEL INSULATION
........23-95
PANEL, DASH PANEL INSULATOR
.........23-11
PANEL, DOOR TRIM
....................23-35
PANEL EXTENSIONÐXJ VEHICLES,
QUARTER TRIM
.....................23-115PANEL, FULL-METAL DOOR TRIM........23-175
PANEL GAUGES, INSTRUMENT...........8E-27
PANEL (GOP), GRILLE AND GRILLE
OPENING............................23-3
PANEL, HOOD INSULATOR..............23-138
PANEL ILLUMINATION LAMPS,
INSTRUMENT.......................8E-16
PANEL, INSTRUMENT.............23-93,23-190
PANEL INSULATION PANEL, DASH........23-95
PANEL INSULATOR PANEL, DASH.........23-11
PANEL LAMPS, INSTRUMENT.............8E-4
PANEL, LIFTGATE TRIM.................23-66
PANEL OUTLET DOOR VACUUM MOTOR
REPLACEMENT, HEATER/DEFROSTER/
INSTRUMENT.......................24-30
PANEL REPLACEMENT, INSTRUMENT.......8E-8
PANEL REPLACEMENT, HEATER AND A/C
CONTROL..........................24-26
PANEL REPLACEMENT, HEATER
CONTROL..........................24-39
PANEL SERVICE, INSTRUMENT..........23-192
PANELÐXJ VEHICLES, FRONT INNER
SCUFF PLATE/COWL SIDE TRIM........23-114
PANELÐYJ RENEGADE VEHICLES,
FRONT FENDER EXTENSION...........23-149
PANELÐYJ RENEGADE VEHICLES, REAR
QUARTER EXTENSION................23-151
PANELÐYJ RENEGADE VEHICLES,
ROCKER EXTENSION.................23-150
PANELS AND FASCIASÐYJ RENEGADE
VEHICLES, BODY EXTENSION..........23-147
PANELS AND SCUFF PLATESÐXJ
VEHICLES, INTERIOR TRIM............23-112
PANELSÐXJ VEHICLES, QUARTER AND
WHEELHOUSE TRIM.................23-115
PARK AND NEUTRAL, HYDRAULIC FLOW
IN ................................21-86
PARK GEAR OVERHAUL, GOVERNOR.....21-121
PARK GEAR SERVICE, GOVERNOR.......21-101
PARK INTERLOCK CABLE ADJUSTMENT . . . 21-186
PARK INTERLOCK CABLE ADJUSTMENT
(XJ)...............................21-97
PARK LOCK COMPONENT OVERHAUL,
ADAPTER HOUSING.................21-120
PARK LOCK COMPONENT REPLACEMENT . . 21-102
PARK NEUTRAL SWITCH................14-58
PARK ROD AND PAWL SERVICE.........21-181
PARKING BRAKE ADJUSTMENT............5-63
PARKING BRAKE CABLE TENSIONER
REPLACEMENT (XJ)...................5-61
PARKING BRAKE FRONT CABLE
REPLACEMENT (YJ)...................5-62
PARKING BRAKE LEVER INSTALLATION
(XJ WITH FULL CONSOLE)..............5-60
PARKING BRAKE LEVER INSTALLATION
(XJ WITH MINI CONSOLE)..............5-58
PARKING BRAKE LEVER INSTALLATION
(XJ WITHOUT CONSOLE)...............5-60
PARKING BRAKE LEVER REMOVAL (XJ
WITH FULL CONSOLE).................5-59
PARKING BRAKE LEVER REMOVAL (XJ
WITH MINI CONSOLE).................5-58
PARKING BRAKE LEVER REMOVAL (XJ
WITHOUT CONSOLE)...................5-60
PARKING BRAKE OPERATION.............5-56
PARKING BRAKE PEDAL INSTALLATION
(YJ)................................5-61
PARKING BRAKE PEDAL REMOVAL (YJ).....5-61
PARKING BRAKE PROBLEMS,
DIAGNOSING.........................5-10
PARKING BRAKE REAR CABLE
REPLACEMENT (XJ)...................5-62
PARKING BRAKE REAR CABLE
REPLACEMENT (YJ)...................5-63
PARKING BRAKES......................5-56
PARK-LOCK CABLEÐCONSOLE SHIFT
AUTOMATIC.........................19-45
PARK/NEUTRAL POSITION SWITCH;
BATTERY/STARTER/GENERATOR SERVICE . . 8B-6
PARK/NEUTRAL POSITION SWITCH
SERVICE
..........................21-103
PARK/NEUTRAL POSITION SWITCH;
TRANSMISSION AND TRANSFER CASE
. . 21-173
PARK/NEUTRAL SWITCHÐPCM INPUT
.....14-22
PARK/TURN SIGNAL LAMP BULB
REPLACEMENT, FRONT
.................8L-8PART THROTTLE 3-2 DOWNSHIFT,
HYDRAULIC FLOW DURING............21-91
PARTS INTERCHANGEABILITY,
TRANSMISSION......................21-66
PARTS, RECOMMENDED LUBRICANT
AND REPLACEMENT....................0-3
PASSENGER DOOR LOCK SWITCH.........8P-5
PASSENGER DOOR WINDOW SWITCH......8S-8
PATTERN ANALYSIS, BACKLASH AND
CONTACT; FRONT SUSPENSION
AND AXLE...........................2-44
PATTERN ANALYSIS, BACKLASH
AND CONTACT; REAR SUSPENSION
AND AXLES..........................3-25
PATTERN, SHIFT........................21-2
PATTERN, TRANSMISSION SHIFT.........21-33
PATTERNS, TIRE WEAR..................22-4
PAWL SERVICE, PARK ROD.............21-181
PEDAL, ACCELERATOR..................14-16
PEDAL AND BRAKELIGHT SWITCH,
BRAKE..............................5-65
PEDAL AND THROTTLE CABLE,
ACCELERATOR.................14-16,14-54
PEDAL INSTALLATION, BRAKE.............5-66
PEDAL INSTALLATION, CLUTCH............6-15
PEDAL INSTALLATION (YJ), PARKING
BRAKE..............................5-61
PEDAL REMOVAL, BRAKE................5-65
PEDAL REMOVAL, CLUTCH...............6-15
PEDAL REMOVAL (YJ), PARKING BRAKE....5-61
PEDAL SERVICE, BRAKE.................5-65
PEDAL TRAVEL SENSOR.................5-41
PEDAL TRAVEL SENSOR OPERATION,
HCU PUMP..........................5-44
PEDAL TRAVEL SENSOR SERVICE..........5-51
PERFORMANCE DIAGNOSIS..............24-10
PERFORMANCE, ENGINE..................9-2
PERFORMANCE TEST, A/C................24-8
PILLAR TRIM COVERSÐXJ VEHICLES, B/
C-PILLAR AND LIFTGATE.............23-116
PILOT BEARING REPLACEMENT...........6-11
PIN REPLACEMENT, CAMSHAFT.......9-31,9-71
PIN REPLACEMENT, DOOR HINGE/HINGE . . . 23-58
PINION GEAR ASSEMBLY/INSTALLATION;
FRONT SUSPENSION AND AXLE..........2-40
PINION GEAR ASSEMBLY/INSTALLATION;
REAR SUSPENSION AND AXLES..........3-22
PINION GEAR DEPTH INFORMATION;
FRONT SUSPENSION AND AXLE..........2-37
PINION GEAR DEPTH INFORMATION;
REAR SUSPENSION AND AXLES..........3-19
PINION GEAR DEPTH VARIANCE; FRONT
SUSPENSION AND AXLE................2-38
PINION GEAR DEPTH VARIANCE; REAR
SUSPENSION AND AXLES...........3-20,3-38
PINION MEASUREMENT, DIFFERENTIAL
AND; FRONT SUSPENSION AND AXLE.....2-38
PINION MEASUREMENT, DIFFERENTIAL
AND; REAR SUSPENSION AND AXLES.....3-20
PINION REMOVAL/DISASSEMBLY; FRONT
SUSPENSION AND AXLE................2-34
PINION REMOVAL/DISASSEMBLY; REAR
SUSPENSION AND AXLES...............3-17
PINION SEAL REPLACEMENT; FRONT
SUSPENSION AND AXLE................2-23
PINION SEAL REPLACEMENT; REAR
SUSPENSION AND AXLES...............3-32
PINION SHAFT SEAL REPLACEMENT........3-13
PINS, RADIO CONNECTOR................8F-3
PIPEÐXJ VEHICLES, EXHAUST............11-3
PIPEÐYJ VEHICLES, EXHAUST............11-4
PISTON AND TRANSMISSION CASE
OVERHAUL, FIRST-REVERSE BRAKE....21-237
PISTON AND WORM SHAFT
REPLACEMENT, RACK.................19-30
PISTON CLEARANCE, AW-4 BUSHING.....21-326
PISTON SPECIFICATIONS, AW-4
RETAINER.........................21-327
PISTONS AND CONNECTING RODS.....9-34,9-74
PISTONS AND SPRINGS, ACCUMULATOR . . 21-179
PITMAN ARM
....................19-15,19-18
PITMAN SHAFT AND SIDE COVER
REPLACEMENT
......................19-26
PITMAN SHAFT SEAL REPLACEMENT
......19-35
PITMAN SHAFT SEALS AND BEARING
REPLACEMENT
......................19-32
16 INDEXJ
Description Group-Page Description Group-Page Description Group-Page

PITMAN SHAFT SEALSÐIN CAR
REPLACEMENT......................19-21
PIVOT ASSEMBLY REPLACEMENT, FRONT
WIPER ARM.........................8K-9
PLANETARY GEAR AND CLUTCH
OVERHAUL, OVERDRIVE..............21-209
PLANETARY GEAR OVERHAUL, FRONT....21-228
PLANETARY GEAR TRAIN OVERHAUL.....21-131
PLASTIC COMPONENTS................23-203
PLASTIC DUCTS/HOSES/TUBING, RUBBER . . . 0-19
PLASTIC HOSES/TUBING, RUBBER.........0-28
PLASTIC INSERT ÐXJ VEHICLES, QUARTER
WINDOW GLASS/REAR QUARTER.......23-80
PLASTIGAGE, MEASURING WITH...........9-3
PLATE, FRONT SKID....................23-84
PLATE, FUEL TANK SKID; BODY
COMPONENTSÐXJ VEHICLES..........23-84
PLATE, FUEL TANK SKID; FRAME AND
BUMPERS..........................13-16
PLATE LAMP HOUSING, LIFTGATE
LICENSE...........................23-72
PLATE LAMP, LICENSE..................8L-10
PLATEÐLEAK TESTS, COMPRESSOR
VALVE ..............................24-8
PLATE REPLACEMENT, SUPPORT..........5-37
PLATE SCREW ANCHOR AND BUMPER,
LIFTGATE LICENSE...................23-72
PLATE SERVICE, DRIVE................21-109
PLATE SPECIFICATIONS, 30RH/32RH SNAP
RING/THRUST WASHER/THRUST.......21-322
PLATE THICKNESS, AW-4 CLUTCH DISC . . . 21-325
PLATE, TRANSFER CASE SKID; BODY
COMPONENTSÐXJ VEHICLES.....13-15,23-84
PLATE, VEHICLE CODE...............INTRO.-2
PLATE, VEHICLE IDENTIFICATION
NUMBER (VIN)....................INTRO.-1
PLATEÐYJ RENEGADE VEHICLES, FRONT
FASCIA AND SKID...................23-148
PLATEÐYJ RENEGADE VEHICLES, REAR
FASCIA AND SKID...................23-152
PLATE/COWL SIDE TRIM PANELÐXJ
VEHICLES, FRONT INNER SCUFF.......23-114
PLATESÐXJ VEHICLES, INTERIOR TRIM
PANELS AND SCUFF.................23-112
PLATESÐXJ VEHICLES, OUTER SCUFF....23-118
PLATFORM AND TRACKS, BUCKET SEAT . . . 23-105
PLUG ASSEMBLY REPLACEMENT,
ADJUSTER..........................19-27
PLUG CABLE RESISTANCE, SPARK........8D-18
PLUG, HOUSING END...................19-26
PLUG LOCATIONS, TRANSMISSION
SWITCH............................21-33
PLUG SECONDARY CABLES, SPARK . . 8D-17,8D-29
PLUGS, SPARK; IGNITION SYSTEMS . 8D-16,8D-28,
8D-33
PLUGS, SPARK; LUBRICATION AND
MAINTENANCE.......................0-18
POLISHING, BUFFING..................23-203
POSITION, HYDRAULIC FLOW IN MANUAL
FIRST GEAR (1)......................21-94
POSITION SENSOR, CAMSHAFT; FUEL
SYSTEM............................14-54
POSITION SENSOR, CAMSHAFT;
IGNITION SYSTEMS..............8D-1,8D-20
POSITION SENSOR, CRANKSHAFT; FUEL
SYSTEM............................14-55
POSITION SENSOR, CRANKSHAFT;
IGNITION SYSTEMS..............8D-2,8D-21
POSITION SENSORÐPCM INPUT,
CAMSHAFT.........................14-20
POSITION SENSORÐPCM INPUT,
CRANKSHAFT.......................14-20
POSITION SENSOR TEST, CAMSHAFT;
FUEL SYSTEM.......................14-43
POSITION SENSOR TEST, CAMSHAFT;
IGNITION SYSTEMS...................8D-8
POSITION SENSOR TEST, CRANKSHAFT;
FUEL SYSTEM.......................14-44
POSITION SENSOR TEST, CRANKSHAFT;
IGNITION SYSTEMS...................8D-9
POSITION SENSOR TEST, THROTTLE
......8D-18
POSITION SENSOR, THROTTLE
............8D-6
POSITION SENSOR (TPS)ÐPCM INPUT,
THROTTLE
..........................14-23
POSITION SENSOR (TPS) SERVICE,
THROTTLE
.........................21-184POSITION SENSOR (TPS) TEST, THROTTLE . 14-45
POSITION SENSOR (TPS), THROTTLE;
FUEL SYSTEM.......................14-59
POSITION SENSOR (TPS), THROTTLE;
IGNITION SYSTEMS..................8D-29
POSITION SWITCH, PARK/NEUTRAL;
BATTERY/STARTER/GENERATOR SERVICE . . 8B-6
POSITION SWITCH, PARK/NEUTRAL;
TRANSMISSION AND TRANSFER CASE . . 21-173
POSITION SWITCH SERVICE, PARK/
NEUTRAL..........................21-103
POSITION, SWITCH TEST WITH SWITCH IN
LEFT................................8T-3
POSITION, SWITCH TEST WITH SWITCH
IN RIGHT............................8T-3
POSITIONS, TRANSMISSION RANGES
AND SHIFT LEVER...................21-157
POWER BOOSTER CHECK VALVE TEST......5-11
POWER BOOSTER VACUUM TEST..........5-12
POWER BRAKE BOOSTER............5-22,5-40
POWER BRAKE BOOSTER INSTALLATION . . . 5-23,
5-51
POWER BRAKE BOOSTER OPERATION......5-22
POWER BRAKE BOOSTER REMOVAL....5-22,5-51
POWER BRAKE SYSTEM.................0-32
POWER BRAKES........................5-1
POWER BUCKET SEAT COMPONENTS.....23-106
POWER DOOR LOCKS..............8P-1,8P-10
POWER DOOR LOCKS, DIAGNOSING . . . 8P-1,8P-9
POWER GROUND......................14-22
POWER LOCK SWITCHÐ2-DOOR LEFT
HAND DRIVE, DRIVERS DOOR...........8P-2
POWER LOCK SWITCHÐ2-DOOR RIGHT
HAND DRIVE, DRIVERS DOOR...........8P-3
POWER LOCK SWITCHÐ4-DOOR,
DRIVERS DOOR......................8P-4
POWER MIRROR REPLACEMENT...........8T-4
POWER MIRROR SWITCH................8T-2
POWER MIRROR SWITCH REPLACEMENT....8T-4
POWER MIRROR SWITCH TESTING.........8T-2
POWER SEAT MOTOR REPLACEMENT......8R-2
POWER STEERING GEAR................19-73
POWER STEERING GEAR,
RECIRCULATING BALL................19-19
POWER STEERING GEAR SPECIFICATIONS . . . 19-34
POWER STEERING GEARS,
RECIRCULATING-BALL................19-69
POWER STEERING PRESSURE SWITCHÐ
2.5L ENGINE ONLY...................14-58
POWER STEERING PRESSURE SWITCHÐ
PCM INPUT.........................14-22
POWER STEERING PUMP......19-9,19-69,19-73
POWER STEERING PUMPÐINITIAL
OPERATION.........................19-13
POWER STEERING SYSTEM..............0-31
POWER STEERING SYSTEM DIAGNOSIS....19-3,
19-4,19-5,19-6,19-7
POWER WINDOW SWITCHÐ2-DOOR
LEFT HAND DRIVE, DRIVERS DOOR.......8S-6
POWER WINDOW SWITCHÐ2-DOOR
RIGHT HAND DRIVE, DRIVERS DOOR.....8S-7
POWER WINDOW SWITCHÐ4-DOOR,
DRIVERS DOOR......................8S-5
POWERTRAIN CONTROL MODULE (PCM)
60-WAY CONNECTOR.................14-38
POWERTRAIN CONTROL MODULE,
ELECTRICAL TESTS AT.................8H-6
POWERTRAIN CONTROL MODULE
(PCM); EMISSION CONTROL SYSTEMS....25-9
POWERTRAIN CONTROL MODULE
(PCM); FUEL SYSTEM............14-18,14-58
POWERTRAIN CONTROL MODULE
(PCM); IGNITION SYSTEMS
. . . 8D-6,8D-15,8D-28
POWER-UP AND INITIALIZATION, SYSTEM
. . . 5-43
PRE-ALIGNMENT INSPECTION
..............2-6
PRECAUTIONS, BRAKE SAFETY
.............5-2
PRECAUTIONS, CLUTCH SAFETY
...........6-10
PRECAUTIONS; PROPELLER SHAFTS
. . . 16-7,16-9
PRECAUTIONS, SAFETY, REFINISHING
.....23-200
PRECAUTIONS, SERVICE (A/C)
............24-2
PRELIMINARY BRAKE CHECK
..............5-7
PRELIMINARY CHECKS
...................7-5
PRELIMINARY CHECKS FIRST, SYMPTOM
AND ACTIONÐSEE
.....................7-6
PRELIMINARY DIAGNOSIS
...............21-69PRELIMINARY INSPECTION AND
ADJUSTMENT......................21-167
PREPARATION, SURFACE...............23-201
PRESSURE AND RETURN HOSE
REPLACEMENT.......................19-9
PRESSURE CAP, RADIATOR...............7-20
PRESSURE DIAGNOSIS..................24-9
PRESSURE GAUGE AND MANIFOLD
ASSEMBLY..........................24-2
PRESSURE GAUGE INOPERATIVE, OIL......8E-3
PRESSURE GAUGE, OIL..................8E-1
PRESSURE GAUGES.....................22-2
PRESSURE INDICATOR INOPERATIVE, OIL . . . 8E-3
PRESSURE INDICATOR, OIL...............8E-1
PRESSURE LABEL, TIRE INFLATION.....INTRO.-3
PRESSURE LEAK DOWN TEST, FUEL........14-7
PRESSURE LEAKAGE TEST, CYLINDER
COMBUSTION.........................9-6
PRESSURE LEAKAGE TEST DIAGNOSIS,
CYLINDER COMBUSTION................9-6
PRESSURE (MAP) SENSOR, MANIFOLD
ABSOLUTE; FUEL SYSTEM.............14-57
PRESSURE (MAP) SENSOR, MANIFOLD
ABSOLUTE; IGNITION SYSTEMS....8D-5,8D-27
PRESSURE (MAP) SENSORÐPCM
INPUT, MANIFOLD ABSOLUTE...........14-21
PRESSURE (MAP) SENSOR TEST,
MANIFOLD ABSOLUTE; FUEL SYSTEM....14-44
PRESSURE (MAP) SENSOR TEST, MANIFOLD
ABSOLUTE; IGNITION SYSTEMS........8D-14
PRESSURE REGULATOR, FUEL...........14-30
PRESSURE RELEASE PROCEDURE, FUEL....14-5
PRESSURE RELEASE PROCEDURE, FUEL
SYSTEM............................14-56
PRESSURE RELIEF/ROLLOVER VALVE . . . 25-5,25-9
PRESSURE RELIEF/ROLLOVER VALVE,
FUEL TANK....................14-15,14-56
PRESSURE SWITCHÐ2.5L ENGINE ONLY,
POWER STEERING...................14-58
PRESSURE SWITCHÐPCM INPUT,
POWER STEERING...................14-22
PRESSURE TEST, AIR...................21-73
PRESSURE TEST, CYLINDER COMPRESSION . . 9-5
PRESSURE TEST, FUEL SYSTEM......14-5,14-48
PRESSURE TEST, HYDRAULIC......21-71,21-168
PRESSURE TEST, PUMP.................19-3
PRESSURE TEST SPECIFICATIONS,
30RH/32RH........................21-323
PRESSURES, TIRE INFLATION.............22-2
PRIMER............................23-201
PRINTED CIRCUIT.....................8E-22
PRINTED CIRCUIT REMOVAL.............8E-24
PRINTED CIRCUIT REPLACEMENT.........8E-19
PRINTED CIRCUIT REPLACEMENTÐ
INSTRUMENT CLUSTER REMOVED.......8E-6
PROBLEM CAUSES, CLUTCH...............6-3
PROBLEMS, DIAGNOSING PARKING BRAKE . . 5-10
PROBLEMS, DIAGNOSING SERVICE BRAKE . . . 5-8
PROBLEMS, TROUBLESHOOTING WIRING . . . 8W-3
PROGRAMMING, TRANSMITTER...........8P-9
PROPELLER SHAFT REPLACEMENT.........16-7
PROPELLER SHAFTS....................16-1
PROPELLER SHAFTS AND U-JOINTS.......16-14
PROTECTION, STONE CHIP.............23-201
PROTECTOR STRIP, DOOR EDGE GUARD/
EDGE..............................23-61
PROTECTOR/NOZZLE, FUEL FILLER.......23-158
PULLEY REPLACEMENT, DRIVE...........19-11
PUMP AND PEDAL TRAVEL SENSOR
OPERATION, HCU.....................5-44
PUMP CAPACITY TEST, FUEL..............14-7
PUMP ELECTRICAL CONTROL, FUEL........14-5
PUMPÐINITIAL OPERATION, POWER
STEERING
..........................19-13
PUMP LEAKAGE DIAGNOSIS
..............19-8
PUMP MODULE, FUEL
..............14-2,14-56
PUMP, OIL
........................9-33,9-73
PUMP OPERATING SPECIFICATIONS
........19-3
PUMP OVERHAUL, OIL
..........21-122,21-206
PUMP, POWER STEERING
......19-9,19-69,19-73
PUMP PRESSURE TEST
..................19-3
PUMP RELAY, FUEL
....................14-56
PUMP RELAYÐPCM OUTPUT, FUEL
.......14-25
PUMP RELAY TESTING, FUEL
............14-44
PUMP REPLACEMENT
..................19-10
JINDEX17
Description Group-Page Description Group-Page Description Group-Page

PUMP REPLACEMENTÐLEFT HAND
DRIVE, WASHER......................8K-2
PUMP REPLACEMENT, REAR WASHER.....8K-13
PUMP REPLACEMENTÐRIGHT HAND
DRIVE, WASHER......................8K-3
PUMP REPLACEMENT, WASHER......8K-6,8K-11
PUMP SEAL REPLACEMENT, OIL.........21-189
PUMP TESTS, WATER....................7-9
PUMP WEAR LIMITS, AW-4 OIL.........21-325
PUMPSÐGENERAL INFORMATION, WATER . . . 7-9
PUMPSÐREMOVAL/INSTALLATION, WATER . . 7-10
PURGING COMPRESSOR OF AIR..........24-17
QUARTER AND WHEELHOUSE TRIM
PANELSÐXJ VEHICLES..............23-115
QUARTER EXTENSION PANELÐYJ
RENEGADE VEHICLES, REAR..........23-151
QUARTER PLASTIC INSERT ÐXJ
VEHICLES, QUARTER WINDOW GLASS/
REAR..............................23-80
QUARTER TRIM PANEL EXTENSIONÐXJ
VEHICLES.........................23-115
QUARTER VENT WINDOW GLASSÐ
XJ VEHICLES, REAR..................23-80
QUARTER WINDOW APPLIQUEÐXJ
VEHICLES..........................23-29
QUARTER WINDOW GLASS, HARD TOP . . . 23-188
QUARTER WINDOW GLASS/REAR QUARTER
PLASTIC INSERT ÐXJ VEHICLES, REAR . . 23-80
QUICK-CONNECT FITTINGS..........14-9,14-59
RACK PISTON AND WORM SHAFT
REPLACEMENT......................19-30
RACKÐXJ VEHICLES, LUGGAGE..........23-32
RADIATOR FAN RELAYÐPCM OUTPUT.....14-26
RADIATOR GRILLE APPLIQUE...........23-134
RADIATOR PRESSURE CAP...............7-20
RADIATOR SUPPORT CROSSMEMBER......23-5
RADIATORS...........................7-22
RADIO ANTENNA.......................8F-8
RADIO CONNECTOR PINS................8F-3
RADIO ILLUMINATION RELAY.............8F-3
RADIO NOISE DIAGNOSIS................8F-2
RADIO REPLACEMENT...............8F-4,8F-6
RADIO SPEAKERS..................8F-4,8F-6
RADIO/CLOCK ILLUMINATION.............8E-4
RAIL ASSEMBLY, FUEL..................14-56
RAIL, FUEL...........................14-30
RAIL MOULDINGÐXJ VEHICLES, DRIP.....23-29
RANGE FIRST GEAR, HYDRAULIC FLOW
IN D...............................21-87
RANGE, HYDRAULIC FLOW IN MANUAL
SECOND (2).........................21-93
RANGE SECOND GEAR, HYDRAULIC FLOW
IN D...............................21-88
RANGE THIRD GEAR, HYDRAULIC FLOW
IN D...............................21-89
RANGES AND SHIFT LEVER POSITIONS,
TRANSMISSION.....................21-157
RATE, CHARGE.........................8A-6
RATINGS, BATTERY CLASSIFICATIONS......8A-8
RATINGSÐLEFT HAND DRIVE, BATTERY
CLASSIFICATIONS....................8B-10
RATINGSÐRIGHT HAND DRIVE, BATTERY
CLASSIFICATIONS....................8B-10
RATIOS, GEAR.........................21-2
RATIOS, TRANSMISSION GEAR...........21-33
REAR AXLE 8 1/4 INCH..................3-50
REAR AXLE ALIGNMENT..................3-8
REAR AXLE MODEL 35..................3-50
REAR AXLES, FRONT....................0-26
REAR BAND ADJUSTMENT..............21-99
REAR BUMPER....................13-6,13-18
REAR CABLE REPLACEMENT (XJ),
PARKING BRAKE......................5-62
REAR CABLE REPLACEMENT (YJ),
PARKING BRAKE......................5-63
REAR CARPET/MATÐXJ VEHICLES.......23-130
REAR CLUTCH OVERHAUL..............21-128
REAR DEFOGGER RELAY.................8N-4
REAR DEFOGGER/FOG LAMP/REAR
WIPER SWITCHES....................8E-21
REAR DOOR FIXED WINDOW GLASS
......23-53
REAR DOOR WINDOW GLASS
............23-52
REAR DOOR WINDOW GLASS
REGULATOR
........................23-51
REAR FASCIA AND SKID PLATEÐYJ
RENEGADE VEHICLES
................23-152REAR JOUNCE BUMPER................13-18
REAR MAIN OIL SEALS..............9-44,9-84
REAR QUARTER EXTENSION PANELÐYJ
RENEGADE VEHICLES................23-151
REAR QUARTER VENT WINDOW GLASSÐ
XJ VEHICLES........................23-80
REAR SEAT CUSHION COVERÐ
XJ VEHICLES.......................23-107
REAR SEAT CUSHION
RECONDITIONINGÐXJ VEHICLES.......23-108
REAR SEAT CUSHIONÐXJ VEHICLES.....23-107
REAR SEATBACK COVERÐXJ VEHICLES . . . 23-111
REAR SEATBACK LATCH STRIKER AND
BUMPERÐXJ VEHICLES..............23-111
REAR SEATBACK RECONDITIONINGÐXJ
VEHICLES.........................23-111
REAR SEATBACKÐXJ VEHICLES.........23-109
REAR SERVO AND BAND OVERHAUL.....21-136
REAR SHOULDER BELTS...............23-196
REAR SHOULDER/LAP BELT/BUCKLEÐ
XJ VEHICLES.......................23-120
REAR SPEED SENSOR AIR GAP............5-3
REAR SUSPENSION COMPONENTS, XJ......3-50
REAR SUSPENSION COMPONENTS, YJ......3-50
REAR TOW HOOKÐXJ VEHICLES.........23-87
REAR WASHER PUMP REPLACEMENT.....8K-13
REAR WHEEL SENSOR INSTALLATION......5-50
REAR WHEEL SENSOR REMOVAL..........5-49
REAR WHEELHOUSE FLARES AND
LINERS............................23-18
REAR WINDOW DEFOGGER GRID
REPAIR .............................8N-2
REAR WINDOW DEFOGGER GRID TEST.....8N-1
REAR WINDOW DEFOGGER SWITCH
REPLACEMENT.......................8N-4
REAR WIPER ARM REPLACEMENT........8K-12
REAR WIPER, DIAGNOSING...............8K-6
REAR WIPER MOTOR REPLACEMENT......8K-13
REAR WIPER SWITCH REPLACEMENT.....8K-13
REAR WIPER WASHER, DIAGNOSING.......8K-6
REAR WIPER/WASHER, DIAGNOSING......8K-14
REAR WIPER/WASHER SWITCH TESTING . . . 8K-7,
8K-14
REARVIEW MIRROR...................23-183
REARVIEW MIRROR, INTERIOR...........23-74
REARVIEW MIRROR RETAINING
BRACKET..........................23-183
REARVIEW MIRROR SUPPORT
BRACKET REPLACEMENT, INTERIOR.....23-75
RECEIVER.............................8P-8
RECEIVER DRIERÐ4.0L ENGINES.........24-32
RECEIVER-DRIER REPLACEMENT.........24-42
RECEIVER SERVICE....................8P-11
RECIRCULATING AIR DOOR VACUUM
MOTOR REPLACEMENT, A/C............24-31
RECIRCULATING BALL POWER
STEERING GEAR.....................19-19
RECIRCULATING-BALL POWER STEERING
GEARS.............................19-69
RECOMMENDATIONS, TOWING.............0-8
RECOMMENDED BRAKE FLUID........5-13,5-48
RECOMMENDED FLUID; TRANSMISSION
AND TRANSFER CASE............21-66,21-96
RECOMMENDED LUBRICANT..............21-2
RECOMMENDED LUBRICANT AND
REPLACEMENT PARTS..................0-3
RECONDITIONING, BUCKET SEATBACK....23-102
RECONDITIONINGÐXJ VEHICLES, REAR
SEAT CUSHION.....................23-108
RECONDITIONINGÐXJ VEHICLES, REAR
SEATBACK.........................23-111
REFILLING COOLING SYSTEM.............7-17
REFINISHING, BRAKE DRUM..............5-37
REFINISHING, DISC BRAKE ROTOR.........5-32
REFRIGERANT LEAK TEST................24-8
REFRIGERANT (R-12)....................24-1
REGULATOR, FRONT DOOR WINDOW
GLASS.............................23-48
REGULATOR, FUEL PRESSURE...........14-30
REGULATOR, FULL-METAL DOOR
WINDOW GLASS
....................23-177
REGULATOR HANDLE, FULL-METAL
DOOR WINDOW GLASS
..............23-175
REGULATOR, REAR DOOR WINDOW
GLASS
.............................23-51
REGULATOR REPLACEMENT, WINDOW
......8S-9RELAY, AIR CONDITIONING (A/C)
CLUTCH............................14-54
RELAY, AUTOMATIC SHUT DOWN
(ASD); FUEL SYSTEM.................14-54
RELAY, AUTOMATIC SHUT DOWN (ASD);
IGNITION SYSTEMS..........8D-1,8D-8,8D-20
RELAY BANKS, FUSE CHARTS............8W-8
RELAY CONNECTIONS, STARTER..........8A-12
RELAY, FUEL PUMP....................14-56
RELAYÐPCM OUTPUT, AIR
CONDITIONING CLUTCH...............14-24
RELAYÐPCM OUTPUT, AUTO SHUT
DOWN (ASD)........................14-24
RELAYÐPCM OUTPUT, FUEL PUMP.......14-25
RELAYÐPCM OUTPUT, RADIATOR FAN.....14-26
RELAYÐPCM OUTPUT, TORQUE
CONVERTER CLUTCH.................14-27
RELAY, RADIO ILLUMINATION.............8F-3
RELAY, REAR DEFOGGER................8N-4
RELAY REPLACEMENT, DOOR LOCK/
UNLOCK...........................8P-12
RELAY REPLACEMENT, STARTER..........8B-4
RELAY TEST, STARTER MOTOR...........14-48
RELAY TEST, TORQUE CONVERTER
CLUTCH............................14-45
RELAY TESTING, AUTOMATIC
SHUTDOWN (ASD)...................14-43
RELAY TESTING, FUEL PUMP............14-44
RELAY, TORQUE CONVERTER CLUTCH.....14-60
RELEASE AND LOCK HANDLE, FULL-
METAL DOOR LATCH INSIDE..........23-175
RELEASE AND LOCK RODS, DOOR
INSIDE LATCH.......................23-57
RELEASE BEARING REPLACEMENT.........6-11
RELEASE CABLE REPLACEMENT, LATCH....23-10
RELEASE HANDLE, FULL-METAL DOOR
LATCH EXTERNAL...................23-178
RELEASE HANDLE, TAILGATE LATCH......23-160
RELEASE PROCEDURE, FUEL PRESSURE....14-5
RELEASE PROCEDURE, FUEL SYSTEM
PRESSURE.........................14-56
RELIEF/ROLLOVER VALVE, FUEL TANK
PRESSURE....................14-15,14-56
RELIEF/ROLLOVER VALVE, PRESSURE . . 25-5,25-9
REMINDER INDICATOR (SRI) LAMP,
SERVICE............................25-1
REMINDER LAMP, SEAT BELT............8E-16
REMOVAL, ACCELERATION SENSOR........5-52
REMOVAL AND INSTALLATION, 30RH/
32RH TRANSMISSION................21-108
REMOVAL AND INSTALLATION, AW-4
TRANSMISSION.....................21-189
REMOVALÐAX 15, TRANSMISSION.......21-34
REMOVAL, BRAKE PEDAL................5-65
REMOVAL, BRAKELIGHT SWITCH..........5-66
REMOVAL, CALIPER.....................5-27
REMOVAL, CLUTCH COVER AND DISC......6-10
REMOVAL, CLUTCH HYDRAULIC
LINKAGE............................6-11
REMOVAL, CLUTCH PEDAL...............6-15
REMOVAL, DIFFERENTIAL; FRONT
SUSPENSION AND AXLE................2-32
REMOVAL, DIFFERENTIAL; REAR
SUSPENSION AND AXLES...............3-16
REMOVAL, DISC BRAKESHOE.............5-25
REMOVAL, DRUM BRAKESHOE............5-34
REMOVAL, FRONT WHEEL SENSOR........5-49
REMOVAL, IGNITION SWITCH............8D-30
REMOVAL, MASTER CYLINDER........5-20,5-50
REMOVAL, POWER BRAKE BOOSTER . . . 5-22,5-51
REMOVAL, PRINTED CIRCUIT
............8E-24
REMOVAL, REAR WHEEL SENSOR
.........5-49
REMOVAL, ROTOR
......................5-30
REMOVAL, TRANSFER CASE
......21-276,21-296
REMOVAL, TRANSMISSION
...............21-3
REMOVAL, TRANSMISSION AND
CONVERTER
.......................21-108
REMOVAL, TRANSMISSION AND TORQUE
CONVERTER
.......................21-189
REMOVAL, TRANSMISSION VALVE BODY
. . 21-176
REMOVAL, VALVE BODY
...............21-100
REMOVAL, WHEEL CYLINDER
.............5-36
REMOVALÐXJ, HCU
....................5-53
REMOVAL (XJ WITH FULL CONSOLE),
PARKING BRAKE LEVER
................5-59
18 INDEXJ
Description Group-Page Description Group-Page Description Group-Page

SNAP RING/THRUST WASHER/THRUST
PLATE SPECIFICATIONS, 30RH/32RH....21-322
SOFT TOP DOOR, HALF-METAL..........23-173
SOFT TOP SERVICE.............23-166,23-167
SOLENOID AND LATCH ASSEMBLY
REPLACEMENT.......................8P-6
SOLENOID VALVE OPERATION, HCU........5-43
SOLENOIDS, TRANSMISSION VALVE
BODY.............................21-175
SOLVENTS, BRAKE FLUID/LUBRICANTS/
CLEANING............................5-1
SOUND BAR REPLACEMENT..............8F-7
SOUND LEVELS, OPERATING...............5-3
SPACER BLOCKSÐTWO-DOOR
VEHICLES, FRONT DOOR..............23-60
SPARE TIRE/WHEEL HOLDDOWN AND
FLOOR BRACKETSÐXJ VEHICLES......23-128
SPARE/WHEEL TIRE CARRIER,
EXTERNAL.........................23-172
SPARK PLUG CABLE RESISTANCE........8D-18
SPARK PLUG SECONDARY CABLES . . 8D-17,8D-29
SPARK PLUGS; IGNITION SYSTEMS . 8D-16,8D-28,
8D-33
SPARK PLUGS; LUBRICATION AND
MAINTENANCE.......................0-18
SPEAKER/COURTESY LAMP SUPPORT
BRACKET,I/P TWEETER................23-95
SPEAKERS, RADIO..................8F-4,8F-6
SPECIFICATION NOTATIONS...........INTRO.-8
SPECIFICATIONS, 2.5L STARTER MOTOR . . . 8B-11
SPECIFICATIONS, 30RH/32RH GENERAL . . . 21-322
SPECIFICATIONS, 30RH/32RH PRESSURE
TEST.............................21-323
SPECIFICATIONS, 30RH/32RH SNAP RING/
THRUST WASHER/THRUST PLATE......21-322
SPECIFICATIONS, 30RH/32RH TORQUE....21-320
SPECIFICATIONSÐACCESSORIES,
TORQUE...........................23-208
SPECIFICATIONS AND BAND
ADJUSTMENTS......................21-66
SPECIFICATIONS, AW-4 GENERAL........21-324
SPECIFICATIONS, AW-4 RETAINER AND
PISTON...........................21-327
SPECIFICATIONS, AW-4 TORQUE.........21-331
SPECIFICATIONS, AXLE; FRONT
SUSPENSION AND AXLE................2-46
SPECIFICATIONS, AXLE; REAR SUSPENSION
AND AXLES......................3-28,3-44
SPECIFICATIONS, BATTERY TORQUE.......8B-10
SPECIFICATIONS, BELT TENSION...........7-34
SPECIFICATIONS, BODY LUBRICANT........0-35
SPECIFICATIONS, BRAKE TORQUE..........5-67
SPECIFICATIONS; BRAKES................5-67
SPECIFICATIONS; COOLING SYSTEM........7-38
SPECIFICATIONS; ELECTRICAL............8A-8
SPECIFICATIONS, ENGINE....9-48,9-49,9-88,9-89,
9-47,9-87
SPECIFICATIONS; ENGINES...........9-47,9-87
SPECIFICATIONS; FUEL SYSTEM..........14-62
SPECIFICATIONS, GENERATOR...........8B-12
SPECIFICATIONS; IGNITION SYSTEMS.....8D-33
SPECIFICATIONS; INSTRUMENT PANEL
AND GAUGESÐXJ...................8E-13
SPECIFICATIONS; INSTRUMENT PANEL
AND GAUGESÐYJ...................8E-27
SPECIFICATIONS; INTRODUCTION......INTRO.-8
SPECIFICATIONS; LAMPS................8L-23
SPECIFICATIONS, LUBRICANT; FRONT
SUSPENSION AND AXLE................2-20
SPECIFICATIONS, LUBRICANT; REAR
SUSPENSION AND AXLES...........3-11,3-30
SPECIFICATIONS, MANUAL STEERING
GEAR..............................19-44
SPECIFICATIONS, NP231/NP242 TORQUE . . 21-331
SPECIFICATIONS, OUTPUT VOLTAGE.......8B-12
SPECIFICATIONS, POWER STEERING
GEAR..............................19-34
SPECIFICATIONS, PUMP OPERATING.......19-3
SPECIFICATIONS, RUNOUT...............16-4
SPECIFICATIONS, STARTER MOTOR
TORQUE...........................8B-11
SPECIFICATIONS, TESTING
..............8B-11
SPECIFICATIONS, TORQUE; BATTERY/
STARTER/GENERATOR SERVICE
.........8B-12
SPECIFICATIONS, TORQUE; CLUTCH
........6-17
SPECIFICATIONS, TORQUE; ELECTRICAL
.....8A-8SPECIFICATIONS, TORQUE; ENGINES . . . 9-49,9-89
SPECIFICATIONS, TORQUE; EXHAUST
SYSTEM AND INTAKE MANIFOLD........11-10
SPECIFICATIONS, TORQUE; FRONT
SUSPENSION AND AXLE................2-47
SPECIFICATIONS, TORQUE; HEATING
AND AIR CONDITIONING...............24-45
SPECIFICATIONS, TORQUE; HORNS........8G-3
SPECIFICATIONS, TORQUE;
INTRODUCTION...................INTRO.-8
SPECIFICATIONS, TORQUE; PROPELLER
SHAFTS............................16-14
SPECIFICATIONS, TORQUE; REAR
SUSPENSION AND AXLES...............3-50
SPECIFICATIONS, TORQUE; STEERING.....19-73
SPECIFICATIONS, TRANSMISSION/
TRANSFER CASE....................21-320
SPECIFICATIONS; WHEELS AND TIRES.....22-11
SPECIFICATIONSÐXJ VEHICLES,
ALIGNMENT...........................2-9
SPECIFICATIONSÐYJ VEHICLES,
ALIGNMENT...........................2-9
SPEED CONTROLÐPCM INPUT...........14-23
SPEED CONTROLÐPCM OUTPUT.........14-27
SPEED CONTROL SERVO REPLACEMENT....8H-9
SPEED CONTROL SWITCH REPLACEMENT . . . 8H-9
SPEED CONTROL SWITCH TEST, STOP
LAMP..............................8H-7
SPEED CONTROL SWITCH (TURN
SIGNAL LEVER) TEST..................8H-7
SPEED CONTROL SYSTEM ELECTRICAL
TESTS, VEHICLE......................8H-5
SPEED CONTROL SYSTEM, VEHICLE........8A-1
SPEED SENSOR......................21-182
SPEED SENSOR AIR GAP, REAR............5-3
SPEED SENSOR OPERATION, WHEEL.......5-45
SPEED SENSORÐPCM INPUT, VEHICLE....14-23
SPEED SENSOR ROTORÐSPEEDOMETER
DRIVE GEAR.......................21-183
SPEED SENSOR TEST, VEHICLE; FUEL
SYSTEM............................14-45
SPEED SENSOR TEST, VEHICLE;
VEHICLE SPEED CONTROL SYSTEM......8H-5
SPEED SENSOR, VEHICLE...............14-60
SPEED SENSORS, WHEEL................5-41
SPEEDOMETER........................8E-14
SPEEDOMETER REPLACEMENT...........8E-17
SPEEDOMETER REPLACEMENTÐ
INSTRUMENT CLUSTER REMOVED.......8E-5
SPEEDOMETER SERVICE.........21-103,21-275,
21-296
SPEEDOMETER/ODOMETER INOPERATIVE . . . 8E-3
SPEEDOMETER/ODOMETER SYSTEM;
INSTRUMENT PANEL AND GAUGESÐXJ . . . 8E-2
SPEEDOMETER/ODOMETER SYSTEM;
INSTRUMENT PANEL AND GAUGESÐYJ . . 8E-14
SPLASH APRONS, FENDER.............23-147
SPLASH LINERS, WHEELHOUSE.........23-146
SPLASH SHIELD, GENERATOR............13-14
SPLASH SHIELDÐXJ VEHICLES, FUEL
FILLER HOSE........................23-86
SPLASH SHIELDS, FENDER INNER.......23-147
SPLICE LOCATIONS; WIRING DIAGRAMS . . . 8W-2,
8W-53
SPLICE LOCATIONS, XJ................8W-59
SPLICE LOCATIONS, XJ RHD............8W-67
SPLICE LOCATIONS, YJ................8W-53
SPORT BAR.........................23-171
SPRING AND SHOCK DIAGNOSIS;
FRONT SUSPENSION AND AXLE......2-12,2-14
SPRING AND SHOCK DIAGNOSIS; REAR
SUSPENSION AND AXLES.............3-3,3-5
SPRING, COIL.........................2-13
SPRING EYE BUSHING REPLACEMENT,
FRONT..............................2-15
SPRING EYE BUSHING REPLACEMENT,
REAR.............................3-4,3-6
SPRING IDENTIFICATION, AW-4..........21-330
SPRING, LEAF; FRONT...................2-14
SPRING, LEAF; REAR..................3-3,3-6
SPRINGS, ACCUMULATOR PISTONS......21-179
SPRINGS AND OIL SEALS, VALVE......9-21,9-62
SPRINGS, VALVES AND VALVE
........9-22,9-63
SPROCKETS, TIMING CHAIN
..........9-28,9-68
STABILIZER BAR
...................2-10,2-14
STABILIZER BARÐXJ VEHICLES
............3-4STALL TEST, ACTUATOR MOTOR...........8P-6
STALL TEST, CONVERTER...............21-72
STALL TEST, TORQUE CONVERTER.......21-169
STANDARD MASTER CYLINDER...........5-20
STANDARD TORQUE VALUES..........INTRO.-9
STARTER CONTROL CIRCUIT TESTS.......8A-11
STARTER FEED CIRCUIT TESTS -
(VOLTAGE DROP METHOD)..............8A-9
STARTER GENERAL INFORMATION, 2.5L....8B-4
STARTER GENERAL INFORMATION, 4.0L....8B-6
STARTER MOTOR NOISE DIAGNOSIS, 2.5L . . 8A-13
STARTER MOTOR RELAY TEST...........14-48
STARTER MOTOR REMOVAL/
INSTALLATION, 2.5L...................8B-5
STARTER MOTOR
REMOVAL/INSTALLATION, 4.0L..........8B-6
STARTER MOTOR SERVICE PROCEDURES,
ENGINE.............................8B-4
STARTER MOTOR SPECIFICATIONS, 2.5L . . . 8B-11
STARTER MOTOR TEST PROCEDURES
ON VEHICLE, ENGINE..................8A-9
STARTER MOTOR TORQUE
SPECIFICATIONS.....................8B-11
STARTER RELAY CONNECTIONS..........8A-12
STARTER RELAY REPLACEMENT...........8B-4
STARTER SYSTEM DIAGNOSTIC
INSPECTIONS........................8A-9
STARTING, JUMP........................0-7
STARTING SYSTEM COLD CRANKING TEST . . 8A-9
STARTING SYSTEM DIAGNOSIS..........8A-10
STATOR CLUTCH INSPECTION, TORQUE
CONVERTER.......................21-189
STEERING COLUMN GENERAL SERVICE....19-45
STEERING COLUMN, NON-TILT
...........19-50
STEERING COLUMN, TILT
...............19-59
STEERING COLUMNÐXJ
................19-73
STEERING COLUMNÐYJ
................19-73
STEERING DAMPENER
.............19-15,19-18
STEERING GEAR ADJUSTMENTS
..........19-22
STEERING GEAR, MANUAL
.........19-35,19-73
STEERING GEAR, POWER
...............19-73
STEERING GEAR, RECIRCULATING BALL
POWER
............................19-19
STEERING GEAR REPLACEMENT
.....19-21,19-43
STEERING GEAR SPECIFICATIONS,
MANUAL
...........................19-44
STEERING GEAR SPECIFICATIONS,
POWER
............................19-34
STEERING GEARÐYJ VEHICLES,
MANUAL
............................0-32
STEERING GEARS, RECIRCULATING-
BALL POWER
.......................19-69
STEERING KNUCKLE AND BALL STUDS
.....2-30
STEERING LINKAGE AND BALL STUDS
......0-30
STEERING LINKAGEÐXJ
...........19-14,19-73
STEERING LINKAGEÐYJ
...........19-17,19-73
STEERING PRESSURE SWITCHÐ2.5L
ENGINE ONLY, POWER
................14-58
STEERING PRESSURE SWITCHÐPCM
INPUT, POWER
......................14-22
STEERING PUMPÐINITIAL OPERATION,
POWER
............................19-13
STEERING PUMP, POWER
......19-9,19-69,19-73
STEERING RESPONSE
....................5-3
STEERING RHD
.......................19-69
STEERING SYSTEM COMPONENTS
.........19-1
STEERING SYSTEM DIAGNOSIS, MANUAL
. . 19-36
STEERING SYSTEM DIAGNOSIS, POWER
....19-3,
19-4,19-5,19-6,19-7
STEERING SYSTEM DIAGNOSIS,
SUSPENSION
..........................2-7
STEERING SYSTEM, POWER
..............0-31
STEERING WHEEL
.....................19-45
STEP MOULDING, BODY SIDE
...........23-145
STONE CHIP PROTECTION
..............23-201
STOP LAMP (CHMSL)ÐXJ, CENTER
HIGH MOUNTED
.....................8L-10
STOP LAMP (CHMSL)ÐYJ, CENTER
HIGH MOUNTED
.....................8L-11
STOP LAMP SPEED CONTROL SWITCH
TEST
...............................8H-7
STORAGEÐXJ VEHICLES, JACK
.........23-127
JINDEX21
Description Group-Page Description Group-Page Description Group-Page

STRAP, FUEL TANK SUPPORT............23-86
STRIKER AND BUMPERÐXJ VEHICLES,
REAR SEATBACK LATCH..............23-111
STRIKER, HALF-METAL DOOR LATCH.....23-175
STRIKER REPLACEMENT, HOOD LATCH....23-10
STRIKER REPLACEMENT, SAFETY LATCH . . . 23-10
STRIKER, TAILGATE LATCH.............23-161
STRIP, DOOR EDGE GUARD/EDGE
PROTECTOR........................23-61
STRIPES/DECALS, BODY..........23-25,23-153
STUD REPLACEMENT, LIFTGATE SUPPORT
ROD BALL..........................23-70
STUDS, STEERING KNUCKLE AND BALL.....2-30
STUDS, STEERING LINKAGE AND BALL.....0-30
SUN GEAR AND NO. 1 ONE-WAY
CLUTCH OVERHAUL.................21-229
SUNVISORS...................23-124,23-196
SUPPORT BRACKET, I/P TWEETER
SPEAKER/COURTESY LAMP............23-95
SUPPORT BRACKET REPLACEMENT,
INTERIOR REARVIEW MIRROR..........23-75
SUPPORT BRACKETS, CATALYTIC
CONVERTER/MUFFLER/TAILPIPE.........23-85
SUPPORT CUSHION, ENGINE FRONT.......13-15
SUPPORT OVERHAUL, OVERDRIVE.......21-216
SUPPORT OVERHAUL, OVERRUNNING
CLUTCHÐLOW-REVERSE DRUMÐ
REAR.............................21-118
SUPPORT PLATE REPLACEMENT...........5-37
SUPPORT ROD BALL STUD
REPLACEMENT, LIFTGATE..............23-70
SUPPORT ROD CYLINDER DISPOSAL,
LIFTGATE...........................23-70
SUPPORT ROD CYLINDER, LIFTGATE......23-69
SUPPORT STRAP, FUEL TANK............23-86
SUPPORTS, ENGINE (MOUNTS)............0-20
SURFACE PREPARATION...............23-201
SUSPENSION, REAR.....................3-1
SUSPENSION AND STEERING SYSTEM
DIAGNOSIS...........................2-7
SUSPENSION ARM, LOWER...............2-11
SUSPENSION ARM, UPPER...............2-11
SUSPENSION COMPONENTS, XJ FRONT.....2-47
SUSPENSION COMPONENTS, XJ REAR......3-50
SUSPENSION COMPONENTS, YJ FRONT.....2-47
SUSPENSION COMPONENTS, YJ REAR......3-50
SUSPENSION, FRONT............2-1,2-10,2-13
SUSPENSION, REAR..................2-1,3-5
SWITCHÐ2.5L ENGINE ONLY, POWER
STEERING PRESSURE.................14-58
SWITCH, ACCELERATION.................5-41
SWITCH ADJUSTMENT, BRAKELIGHT.......5-66
SWITCH AND PLUG LOCATIONS,
TRANSMISSION......................21-33
SWITCH, BRAKE.......................14-54
SWITCH, BRAKE PEDAL AND BRAKELIGHT....5-65
SWITCH CONTINUITY TESTS, IGNITION....8D-31
SWITCHÐDRIVERS DOOR POWER LOCK . . . 8P-2,
8P-3,8P-4
SWITCHÐDRIVERS DOOR POWER
WINDOW...................8S-5,8S-6,8S-7
SWITCH (HORN PAD) REPLACEMENT, HORN . 8G-3
SWITCH, IGNITION; BRAKES..............5-42
SWITCH, IGNITION; IGNITION SYSTEMS....8D-30
SWITCH INSTALLATION, BRAKELIGHT.......5-66
SWITCH INSTALLATION/ADJUSTMENT,
IGNITION...........................8D-31
SWITCH OPERATION, ACCELERATION.......5-45
SWITCH, OVERDRIVE (OVERRIDE)........14-22
SWITCH, PARK/NEUTRAL POSITION . . 8B-6,14-58,
21-173
SWITCH, PASSENGER DOOR LOCK.........8P-5
SWITCH, PASSENGER DOOR WINDOW......8S-8
SWITCHÐPCM INPUT, BRAKE............14-20
SWITCHÐPCM INPUT, EXTENDED IDLE....14-21
SWITCHÐPCM INPUT, PARK/NEUTRAL.....14-22
SWITCHÐPCM INPUT, POWER
STEERING PRESSURE.................14-22
SWITCH, POWER MIRROR................8T-2
SWITCH REMOVAL, BRAKELIGHT..........5-66
SWITCH REMOVAL, IGNITION
............8D-30
SWITCH REPLACEMENT - ALL MODELS,
TURN/HAZARD
........................8J-3
SWITCH REPLACEMENT, BLOWER
MOTOR/AIR DOOR MOTOR
.............24-39
SWITCH REPLACEMENT, FOG LAMP
.......8L-14SWITCH REPLACEMENT, HEADLAMP.......8L-4
SWITCH REPLACEMENT, HEADLAMP
DIMMER............................8L-6
SWITCH REPLACEMENT, IGNITION
KEY WARNING.......................8U-4
SWITCH REPLACEMENT, LIFTGATE WIPER . . . 8K-6
SWITCH REPLACEMENT, POWER MIRROR . . . 8T-4
SWITCH REPLACEMENT, REAR WINDOW
DEFOGGER..........................8N-4
SWITCH REPLACEMENT, REAR WIPER.....8K-13
SWITCH REPLACEMENT, SPEED CONTROL . . . 8H-9
SWITCH REPLACEMENT, WIPER CONTROL . . 8K-15
SWITCH SERVICE, PARK/NEUTRAL
POSITION.........................21-103
SWITCH TEST, EXTENDED IDLE...........14-45
SWITCH TEST, STOP LAMP SPEED
CONTROL...........................8H-7
SWITCH TESTING; POWER SEATS.........8R-2
SWITCH TESTING; POWER WINDOWS......8S-5
SWITCH TESTING; REAR WINDOW
DEFOGGER..........................8N-2
SWITCH TESTING, IGNITION.............8D-30
SWITCH TESTING, POWER MIRROR........8T-2
SWITCH TESTING, REAR WIPER/
WASHER.......................8K-7,8K-14
SWITCH TESTING, WIPER...............8K-19
SWITCH (TURN SIGNAL LEVER) TEST,
SPEED CONTROL.....................8H-7
SWITCHES, REAR DEFOGGER/FOG LAMP/
REAR WIPER........................8E-21
SWITCH/ILLUMINATION RHEOSTAT,
HEADLAMP.........................8E-21
SYMBOLS, FUSES AND ABBREVIATIONS,
WIRING............................8W-6
SYMBOLS, INTERNATIONAL VEHICLE
CONTROL AND DISPLAY............INTRO.-3
SYMBOLS, VEHICLE CONTROL AND
DISPLAY.........................INTRO.-7
SYSTEMÐAIR CONDITIONING.......24-14,24-15
SYSTEM (ABS), ANTILOCK BRAKE..........5-1
SYSTEM (ABS) INDICATOR LAMP, ANTI-
LOCK BRAKE.........................8E-2
SYSTEM CAPACITIES, COOLING...........7-38
SYSTEM CHARGE, A/C...................24-5
SYSTEM, CHIME/WARNING BUZZER........8A-1
SYSTEM CLEANING/REVERSE FLUSHING,
COOLING............................7-17
SYSTEMÐCLIMATE CONTROL.......24-22,24-37
SYSTEM COLD CRANKING TEST,
STARTING...........................8A-9
SYSTEM COMPONENTS, COOLING..........7-1
SYSTEM COMPONENTS, STEERING.........19-1
SYSTEM, COOLANT RESERVE/
OVERFLOW..........................7-19
SYSTEM COOLANT ROUTING..............7-1
SYSTEM, COOLING..................0-16,7-1
SYSTEM, CRANKCASE VENTILATION;
EMISSION CONTROL SYSTEMS..........25-5
SYSTEM, CRANKCASE VENTILATION;
LUBRICATION AND MAINTENANCE........0-17
SYSTEM DIAGNOSIS, COOLING.............7-7
SYSTEM DIAGNOSIS, AIR CONDITIONING . . . 24-12
SYSTEM DIAGNOSIS, EXHAUST............11-2
SYSTEM DIAGNOSIS, HEATING...........24-11
SYSTEM DIAGNOSIS, MANUAL
STEERING..........................19-36
SYSTEM DIAGNOSIS, POWER
STEERING...........19-3,19-4,19-5,19-6,19-7
SYSTEM DIAGNOSIS, STARTING..........8A-10
SYSTEM DIAGNOSIS, SUSPENSION AND
STEERING............................2-7
SYSTEM DIAGNOSTIC INSPECTIONS,
STARTER............................8A-9
SYSTEM DISCHARGE, A/C................24-4
SYSTEM, DRAINING COOLING.............7-16
SYSTEM ELECTRICAL TESTS, VEHICLE
SPEED CONTROL.....................8H-5
SYSTEM EVACUATION A/C................24-4
SYSTEM, EVAP (EVAPORATION)
CONTROL...........................25-4
SYSTEM, EXHAUST; INTAKE
MANIFOLD.......................0-20,11-1
SYSTEM FANS, COOLING
.................7-26
SYSTEM, FUEL
........................14-62
SYSTEM, FUEL DELIVERY
................14-2
SYSTEM HOSES, COOLING
...............7-26SYSTEM, HYDRAULIC.................21-160
SYSTEM, ILLUMINATED ENTRY...........8L-20
SYSTEM, INOPERATIVE..................8H-5
SYSTEM, LOCATING A ELECTRICAL........8W-2
SYSTEM NOTATION, METRIC..........INTRO.-8
SYSTEM OPERATION, ABS................5-39
SYSTEM OPERATION, ANTILOCK BRAKE.....5-43
SYSTEM, POWER BRAKE.................0-32
SYSTEM, POWER STEERING..............0-31
SYSTEM POWER-UP AND INITIALIZATION....5-43
SYSTEM PRESSURE RELEASE
PROCEDURE, FUEL...................14-56
SYSTEM PRESSURE TEST, FUEL......14-5,14-48
SYSTEM, REFILLING COOLING............7-17
SYSTEM RELAYS.......................5-42
SYSTEM REPAIR PROCEDURES,
THERMOMETER AND SENSOR...........8C-6
SYSTEM, SPEEDOMETER/ODOMETER;
INSTRUMENT PANEL AND GAUGESÐXJ . . . 8E-2
SYSTEM, SPEEDOMETER/ODOMETER;
INSTRUMENT PANEL AND GAUGESÐYJ . . 8E-14
SYSTEM TROUBLE DIAGNOSIS,
ILLUMINATED ENTRY............8L-21,8L-22
SYSTEM, USING ON-BOARD DIAGNOSTIC . . . 8A-19
SYSTEM, VEHICLE SPEED CONTROL........8A-1
SYSTEM WARNING LIGHTS...............5-42
SYSTEM WIRING AND ELECTRICAL
CIRCUITS, ABS........................5-4
SYSTEMÐYJ VEHICLES, HEATING........24-14
SYSTEMS, AUDIO......................8A-1
SYSTEMS DIAGNOSTICS, BATTERY/
STARTING/CHARGING..................8A-1
SYSTEMS, IGNITION....................8A-1
TABLE, BATTERY CHARGING TIME.........8A-5
TACHOMETER; INSTRUMENT PANEL
AND GAUGESÐXJ....................8E-2
TACHOMETER; INSTRUMENT PANEL
AND GAUGESÐYJ...................8E-14
TACHOMETER INOPERATIVE..............8E-3
TACHOMETERÐPCM OUTPUT............14-27
TACHOMETER REPLACEMENT........8E-5,8E-17
TAILGATE ADJUSTMENT...............23-160
TAILGATE HINGE.....................23-159
TAILGATE LATCH AND RELEASE HANDLE . . 23-160
TAILGATE LATCH STRIKER..............23-161
TAILGATE LOCK CYLINDER.............23-160
TAILGATE SERVICE....................23-159
TAILGATE SERVICE INFORMATION........23-159
TAILGATE WEATHERSTRIP SEAL.........23-161
TAILPIPE HEAT SHIELDS, MUFFLER.......13-17
TAILPIPEÐEXHAUST................11-5,11-6
TANK CAPACITIES, FUEL...........14-12,14-62
TANK FILLER TUBE CAP, FUEL....14-12,25-4,25-9
TANK FILLER TUBE, NO-LEAD FUEL.......14-12
TANK, FUEL..........................14-12
TANK PRESSURE RELIEF/ROLLOVER
VALVE, FUEL...................14-15,14-56
TANK, FUEL, SKID PLATE,
BODYCOMPONENTS.............13-16,23-84
TANK SUPPORT STRAP, FUEL............23-86
TANKS, FUEL....................14-12,14-56
TAPPETS, HYDRAULIC...............9-24,9-65
TEMPERATURE CONTROL THERMOSTAT....24-35
TEMPERATURE GAUGE, COOLANT
..........8E-1
TEMPERATURE GAUGE INOPERATIVE,
COOLANT
............................8E-3
TEMPERATURE INDICATOR INOPERATIVE,
COOLANT
............................8E-3
TEMPERATURE INDICATOR LAMP,
COOLANT
............................8E-1
TEMPERATURE SENSOR, COOLANT
........25-9
TEMPERATURE SENSOR, ENGINE
COOLANT; FUEL SYSTEM
..............14-55
TEMPERATURE SENSOR, ENGINE
COOLANT; IGNITION SYSTEMS
.....8D-4,8D-22
TEMPERATURE SENSOR, INTAKE AIR
......14-54
TEMPERATURE SENSOR, INTAKE
MANIFOLD AIR
..................8D-5,8D-27
TEMPERATURE SENSORÐPCM INPUT,
ENGINE COOLANT
....................14-21
TEMPERATURE SENSORÐPCM INPUT,
INTAKE AIR
.........................14-20
TEMPERATURE, SENSOR RESISTANCE
(OHMS)ÐCOOLANT TEMPERATURE
SENSOR/MANIFOLD
..................14-43
22 INDEXJ
Description Group-Page Description Group-Page Description Group-Page

TEMPERATURE SENSOR TEST, ENGINE
COOLANT; FUEL SYSTEM..............14-43
TEMPERATURE SENSOR TEST, ENGINE
COOLANT; IGNITION SYSTEMS..........8D-12
TEMPERATURE SENSOR TEST, INTAKE
AIR ...............................14-43
TEMPERATURE SENSOR TEST, INTAKE
MANIFOLD AIR......................8D-14
TENSION, BELT.......................8B-10
TENSION, DRIVE BELT...............7-33,7-38
TENSIONÐRIGHT HAND DRIVE
(RHD),BELT..........................7-34
TENSION SPECIFICATIONS, BELT...........7-34
TENSIONER REPLACEMENT (XJ), PARKING
BRAKE CABLE........................5-61
TENSIONERÐXJ MODELS, AUTOMATIC
BELT ...............................7-36
TERMINAL ASSEMBLY REPLACEMENT,
CONNECTOR.........................8W-5
TERMINAL REPLACEMENT...............8W-5
TEST, A/C PERFORMANCE................24-8
TEST, ACTUATOR MOTOR STALL...........8P-6
TEST, AIR PRESSURE...................21-73
TEST, ANALYZING THE ROAD.............21-70
TEST, BATTERY LOAD...................8A-4
TEST, BATTERY OPEN CIRCUIT VOLTAGE....8A-3
TEST, CAMSHAFT POSITION SENSOR;
FUEL SYSTEM.......................14-43
TEST, CAMSHAFT POSITION SENSOR;
IGNITION SYSTEMS...................8D-8
TEST, CONVERTER STALL...............21-72
TEST, CRANKSHAFT POSITION SENSOR;
FUEL SYSTEM.......................14-44
TEST, CRANKSHAFT POSITION SENSOR;
IGNITION SYSTEMS...................8D-9
TEST, CYLINDER COMBUSTION
PRESSURE LEAKAGE...................9-6
TEST, CYLINDER COMBUSTION
PRESSURE LEAKAGE DIAGNOSIS..........9-6
TEST, CYLINDER COMPRESSION PRESSURE . . 9-5
TEST, ENGINE COOLANT TEMPERATURE
SENSOR......................8D-12,14-43
TEST, EXTENDED IDLE SWITCH...........14-45
TEST, FUEL PRESSURE LEAK DOWN........14-7
TEST, FUEL PUMP CAPACITY..............14-7
TEST, FUEL SYSTEM PRESSURE......14-5,14-48
TEST, HYDRAULIC PRESSURE......21-71,21-168
TEST, HYDROMETER....................8A-3
TEST, IDLE AIR CONTROL MOTOR........14-46
TEST, INJECTOR.......................14-48
TEST, INTAKE AIR TEMPERATURE SENSOR . . 8D-14,
14-43
TEST, MANIFOLD ABSOLUTE PRESSURE
(MAP) SENSOR.................8D-14,14-44
TEST, MANUAL SHIFTING...............21-168
TEST, MASTER CYLINDER/POWER
BOOSTER............................5-11
TEST, OXYGEN SENSOR (O2S)
HEATING ELEMENT...................14-45
TEST, POWER BOOSTER CHECK VALVE......5-11
TEST, POWER BOOSTER VACUUM..........5-12
TEST PROCEDURES, BATTERY............8A-2
TEST PROCEDURES ON VEHICLE,
ENGINE STARTER MOTOR..............8A-9
TEST PROCEDURES ON VEHICLE,
GENERATOR........................8A-14
TEST, PUMP PRESSURE.................19-3
TEST, REAR WINDOW DEFOGGER GRID.....8N-1
TEST, REFRIGERANT LEAK................24-8
TEST, ROAD; TRANSMISSION AND
TRANSFER CASE.....................21-70
TEST, ROAD; VEHICLE SPEED CONTROL
SYSTEM............................8H-5
TEST SPECIFICATIONS, 30RH/32RH
PRESSURE........................21-323
TEST, SPEED CONTROL SWITCH (TURN
SIGNAL LEVER)......................8H-7
TEST, STARTER MOTOR RELAY...........14-48
TEST, STARTING SYSTEM COLD
CRANKING...........................8A-9
TEST, STOP LAMP SPEED CONTROL
SWITCH
............................8H-7
TEST, THROTTLE POSITION SENSOR
......8D-18
TEST, THROTTLE POSITION SENSOR
(TPS)
..............................14-45
TEST, TIME LAG
......................21-169TEST, TORQUE CONVERTER CLUTCH
RELAY.............................14-45
TEST, TORQUE CONVERTER STALL.......21-169
TEST, VACUUM SUPPLY.................8H-7
TEST, VEHICLE SPEED SENSOR......8H-5,14-45
TESTING, AUTOMATIC SHUTDOWN
(ASD) RELAY........................14-43
TESTING COOLING SYSTEM FOR LEAKS.....7-18
TESTING, FUEL PUMP RELAY............14-44
TESTING GENERAL INFORMATION,
BATTERY............................8A-3
TESTING, IGNITION SWITCH.............8D-30
TESTING, POWER MIRROR SWITCH........8T-2
TESTING, REAR WIPER/WASHER
SWITCH.......................8K-7,8K-14
TESTING, SWITCH; POWER SEATS.........8R-2
TESTING, SWITCH; POWER WINDOWS......8S-5
TESTING, SWITCH; REAR WINDOW
DEFOGGER..........................8N-2
TESTING, TRANSMISSION COOLER FLOW . . 21-106
TESTING, WIPER SWITCH...............8K-19
TESTS - (VOLTAGE DROP METHOD),
STARTER FEED CIRCUIT................8A-9
TESTS, ANTENNA.......................8F-9
TESTS AT POWERTRAIN CONTROL
MODULE, ELECTRICAL.................8H-6
TESTS AT SERVO, ELECTRICAL............8H-5
TESTS, COMPRESSOR VALVE PLATEÐ
LEAK...............................24-8
TESTS, IGNITION SWITCH CONTINUITY....8D-31
TESTS, OXYGEN SENSOR...............8D-19
TESTS, STARTER CONTROL CIRCUIT......8A-11
TESTS, VEHICLE SPEED CONTROL
SYSTEM............................8H-5
TESTS, WATER PUMP....................7-9
THERMOMETER AND SENSOR SYSTEM
REPAIR PROCEDURES.................8C-6
THERMOSTAT..........................7-13
THERMOSTAT, TEMPERATURE CONTROL . . . 24-35
THICKNESS, AW-4 CLUTCH DISC AND
PLATE ............................21-325
THICKNESS, DISC BRAKE ROTOR..........5-31
THICKNESS VARIATION, DISC BRAKE
ROTOR.............................5-31
THIRD GEAR (CONVERTER CLUTCH
ENGAGED), HYDRAULIC FLOW IN.......21-90
THIRD GEAR, HYDRAULIC FLOW IN D
RANGE.............................21-89
THREAD NOTATIONÐSAE AND METRIC . . INTRO.-9
THREADS, REPAIR DAMAGED OR WORN.....9-4
THROTTLE 3-2 DOWNSHIFT, HYDRAULIC
FLOW DURING FULL..................21-92
THROTTLE 3-2 DOWNSHIFT, HYDRAULIC
FLOW DURING PART..................21-91
THROTTLE BODY; FUEL SYSTEM.....14-29,14-59
THROTTLE CABLE.....................14-16
THROTTLE CABLE, ACCELERATOR PEDAL . . 14-16,
14-54
THROTTLE CABLE ADJUSTMENT,
TRANSMISSION.....................21-185
THROTTLE CABLE ADJUSTMENT,
TRANSMISSION......................21-98
THROTTLE CABLE REPLACEMENT,
TRANSMISSION.....................21-184
THROTTLE POSITION SENSOR............8D-6
THROTTLE POSITION SENSOR TEST.......8D-18
THROTTLE POSITION SENSOR (TPS);
FUEL SYSTEM.......................14-59
THROTTLE POSITION SENSOR (TPS);
IGNITION SYSTEMS..................8D-29
THROTTLE POSITION SENSOR (TPS)
SERVICE..........................21-184
THROTTLE POSITION SENSOR (TPS)
TEST..............................14-45
THROTTLE POSITION SENSOR (TPS)Ð
PCM INPUT.........................14-23
THROTTLE VALVE CABLE ADJUSTMENT,
TRANSMISSION......................21-70
TIE ROD ........................19-14,19-17
TIGHTENING, WHEEL NUT............5-32,5-37
TILT STEERING COLUMN................19-59
TIME LAG TEST
......................21-169
TIMING CASE COVER
................9-27,9-67
TIMING CASE COVER OIL SEAL
REPLACEMENT
...................9-26,9-67
TIMING CHAIN AND SPROCKETS
......9-28,9-68TIMING, IGNITION.....................8D-14
TIMING, VALVE.....................9-26,9-66
TIPS, TRANSMISSION ASSEMBLY........21-146
TIRE AND WHEEL BALANCE..............22-6
TIRE AND WHEEL RUNOUT...............22-8
TIRE CARRIER, EXTERNAL SPARE/WHEEL . 23-172
TIRE INFLATION PRESSURE LABEL.....INTRO.-3
TIRE INFLATION PRESSURES.............22-2
TIRE NOISE OR VIBRATION...............22-4
TIRE WEAR PATTERNS..................22-4
TIRES; LUBRICATION AND MAINTENANCE....0-34
TIRES................................22-1
TIRES, CLEANING OF....................22-2
TIRES, REPLACEMENT...................22-2
TIRE/WHEEL HOLDDOWN AND FLOOR
BRACKETS.........................23-128
TOOL, DRB SCAN; COOLING SYSTEM........7-5
TOOL, DRB SCAN; EMISSION CONTROL
SYSTEMS...........................25-2
TOOL, DRB SCAN; FUEL SYSTEM.........14-51
TOOL, DRB SCAN; IGNITION SYSTEMS.....8D-10
TOP REPAIR, HARD...................23-165
TOP ROOF VENT......................23-165
TOP SERVICE............23-164,23-166,23-167
TORQUE; COOLING SYSTEM..............7-39
TORQUE; FUEL SYSTEM................14-62
TORQUE; IGNITION SYSTEMS............8D-33
TORQUE, COLLISION DAMAGE............13-1
TORQUE CONVERSION..............INTRO.-10
TORQUE CONVERTER; TRANSMISSION
AND TRANSFER CASE...........21-66,21-158
TORQUE CONVERTER CLUTCH RELAY......14-60
TORQUE CONVERTER CLUTCH RELAY
TEST..............................14-45
TORQUE CONVERTER CLUTCH RELAYÐ
PCM OUTPUT.......................14-27
TORQUE CONVERTER INSTALLATION,
TRANSMISSION.....................21-190
TORQUE CONVERTER REMOVAL,
TRANSMISSION.....................21-189
TORQUE CONVERTER STALL TEST.......21-169
TORQUE CONVERTER STATOR CLUTCH
INSPECTION.......................21-189
TORQUE SPECIFICATIONS, 30RH/32RH....21-323
TORQUE SPECIFICATIONSÐ AX 15
MANUAL TRANSMISSION.............21-320
TORQUE SPECIFICATIONSÐACCESSORIES . 23-208
TORQUE SPECIFICATIONS, AW-4
.........21-331
TORQUE SPECIFICATIONS, BATTERY
.......8B-10
TORQUE SPECIFICATIONS; BATTERY/
STARTER/GENERATOR SERVICE
.........8B-12
TORQUE SPECIFICATIONS, BRAKE
..........5-67
TORQUE SPECIFICATIONS; CLUTCH
........6-17
TORQUE SPECIFICATIONS; ELECTRICAL
.....8A-8
TORQUE SPECIFICATIONS; ENGINES
....9-49,9-89
TORQUE SPECIFICATIONS; EXHAUST
SYSTEM AND INTAKE MANIFOLD
........11-10
TORQUE SPECIFICATIONS; FRONT
SUSPENSION AND AXLE
................2-47
TORQUE SPECIFICATIONS; HEATING AND
AIR CONDITIONING
...................24-45
TORQUE SPECIFICATIONS; HORNS
.........8G-3
TORQUE SPECIFICATIONS;
INTRODUCTION
...................INTRO.-8
TORQUE SPECIFICATIONS, NP231/NP242
. . 21-331
TORQUE SPECIFICATIONS; PROPELLER
SHAFTS
............................16-14
TORQUE SPECIFICATIONS; REAR
SUSPENSION AND AXLES
...............3-50
TORQUE SPECIFICATIONS, STARTER
MOTOR
............................8B-11
TORQUE SPECIFICATIONS; STEERING
......19-73
TORQUE SPECIFICATIONS XJ
.............8K-7
TORQUE SPECIFICATIONSÐXJ VEHICLES
. . 23-207
TORQUE VALUES, STANDARD
.........INTRO.-9
TOW HOOKÐXJ VEHICLES, REAR
.........23-87
TOW HOOKS
..........................13-14
TOW HOOKS, FRONT
....................13-5
TOWING, JUMP STARTING, HOISTING
.......0-7
TOWING RECOMMENDATIONS
..............0-8
TRACK BAR
....................2-10,2-13,3-6
TRACKS, BUCKET SEAT PLATFORM
.......23-105
TRAC-LOK DIFFERENTIAL
................3-44
JINDEX23
Description Group-Page Description Group-Page Description Group-Page

TRAILER HITCHES.....................23-88
TRANSFER CASE...........0-25,21-292,21-319...........
TRANSFER CASE ASSEMBLY......21-282,21-306
TRANSFER CASE DISASSEMBLY AND
OVERHAUL..................21-277,21-297
TRANSFER CASE FILL LEVEL............21-294
TRANSFER CASE IDENTIFICATION . . 21-273,21-293
TRANSFER CASE INSTALLATION . . . 21-276,21-296
TRANSFER CASE LUBRICANT.....21-273,21-294
TRANSFER CASE, NP231.........21-272,21-291
TRANSFER CASE, NP242...............21-293
TRANSFER CASE REMOVAL.......21-276,21-296
TRANSFER CASE SKID PLATE; BODY
COMPONENTSÐXJ VEHICLES.....13-15,23-84
TRANSMISSION, 30RH/32RH AUTOMATIC . . . 21-66
TRANSMISSION AND CONVERTER
INSTALLATION......................21-109
TRANSMISSION AND CONVERTER
REMOVAL.........................21-108
TRANSMISSION AND TORQUE
CONVERTER INSTALLATION...........21-190
TRANSMISSION AND TORQUE
CONVERTER REMOVAL...............21-189
TRANSMISSION APPLICATION............21-66
TRANSMISSION ASSEMBLY AND
ADJUSTMENT............21-15,21-51,21-255
TRANSMISSION ASSEMBLY AND
ADJUSTMENT PROCEDURES..........21-146
TRANSMISSION ASSEMBLY TIPS........21-146
TRANSMISSION, AUTOMATIC.............0-23
TRANSMISSION, AW-4 AUTOMATIC.......21-156
TRANSMISSION, AX 15 MANUAL.........21-32
TRANSMISSION, AX 4/5 MANUAL..........21-1
TRANSMISSION CASE CLEANING AND
INSPECTION.......................21-118
TRANSMISSION CASE OVERHAUL, FIRST-
REVERSE BRAKE PISTON.............21-237
TRANSMISSION CONTROL MODULE
(TCM) SERVICE.....................21-173
TRANSMISSION CONTROLS
AND COMPONENTS...................21-66
TRANSMISSION COOLER FLOW TESTING . . 21-106
TRANSMISSION COOLER LINE FITTINGS . . 21-187
TRANSMISSION COOLER LINES AND
FITTINGS, SERVICING................21-106
TRANSMISSION COOLER REVERSE
FLUSHING.........................21-105
TRANSMISSION COOLER SERVICE.......21-187
TRANSMISSION DIAGNOSIS, 30RH/32RH . . 21-69,
21-77,21-77,21-79,21-80,21-81,21-82,21-83,21-84,
21-85
TRANSMISSION DIAGNOSIS, AW-4.......21-167
TRANSMISSION DISASSEMBLY....21-112,21-192
TRANSMISSION DISASSEMBLY AND
OVERHAUL.....................21-5,21-36
TRANSMISSION GEAR RATIOS...........21-33
TRANSMISSION IDENTIFICATION.....21-1,21-32,
21-66,21-157
TRANSMISSION INSTALLATION............21-4
TRANSMISSION INSTALLATIONÐAX 15....21-35
TRANSMISSION LUBRICANT.............21-33
TRANSMISSION OIL COOLERS............7-29
TRANSMISSION OVERHAUL, 30RH/32RH . . 21-112
TRANSMISSION OVERHAUL, AW-4.......21-192
TRANSMISSION RANGES AND SHIFT
LEVER POSITIONS
...................21-157
TRANSMISSION REMOVALÐAX 4/5
........21-3
TRANSMISSION REMOVAL AND
INSTALLATION, 30RH/32RH
...........21-108
TRANSMISSION REMOVAL AND
INSTALLATION, AW-4
................21-189
TRANSMISSION REMOVALÐAX 15
........21-34
TRANSMISSION, SELECTIVE SNAP RING
CHARTÐAX 15 MANUAL
.............21-321
TRANSMISSION SHIFT PATTERNÐAX 15
. . . 21-33
TRANSMISSION SWITCH AND PLUG
LOCATIONS
.........................21-33
TRANSMISSION THROTTLE CABLE
ADJUSTMENT
......................21-185
TRANSMISSION THROTTLE CABLE
ADJUSTMENT
.......................21-98
TRANSMISSION THROTTLE CABLE
REPLACEMENT
.....................21-184
TRANSMISSION THROTTLE VALVE CABLE
ADJUSTMENT
.......................21-70TRANSMISSION, TORQUE
SPECIFICATIONSÐ AX 15 MANUAL.....21-320
TRANSMISSION VALVE BODY
INSTALLATION......................21-177
TRANSMISSION VALVE BODY OVERHAUL . . 21-240
TRANSMISSION VALVE BODY REMOVAL . . . 21-176
TRANSMISSION VALVE BODY
SOLENOIDS........................21-175
TRANSMISSION/TRANSFER CASE
IDENTIFICATION, ENGINE............INTRO.-3
TRANSMISSION/TRANSFER CASE
SPECIFICATIONS....................21-320
TRANSMITÐPCM OUTPUT, SCI...........14-26
TRANSMITTER.........................8P-8
TRANSMITTER PROGRAMMING...........8P-9
TRANSMITTER SERVICE.................8P-9
TRAVEL SENSOR OPERATION, HCU
PUMP AND PEDAL....................5-44
TRAVEL SENSOR, PEDAL.................5-41
TRAVEL SENSOR SERVICE, PEDAL.........5-51
TRAY, BATTERY.................23-13,23-140
TRAY LAMP, I/P ASH RECEIVER..........23-92
TREAD WEAR INDICATORS...............22-3
TRIM COVERSÐXJ VEHICLES, B/C-
PILLAR AND LIFTGATE PILLAR.........23-116
TRIM PANEL, DOOR....................23-35
TRIM PANEL EXTENSIONÐXJ VEHICLES,
QUARTER.........................23-115
TRIM PANEL, FULL-METAL DOOR........23-175
TRIM PANEL, LIFTGATE.................23-66
TRIM PANELÐXJ VEHICLES, FRONT
INNER SCUFF PLATE/COWL SIDE.......23-114
TRIM PANELS AND SCUFF PLATESÐXJ
VEHICLES, INTERIOR................23-112
TRIM PANELSÐXJ VEHICLES, QUARTER
AND WHEELHOUSE..................23-115
TROUBLE CODE, CHECKING FOR
DIAGNOSTIC.........................8H-5
TROUBLE CODE (DTC), DIAGNOSTIC.......14-51
TROUBLE CODE (DTC), GENERATOR
DIAGNOSTIC........................8A-19
TROUBLE CODES, INDICATOR (CHECK
ENGINE) LAMP FOR DIAGNOSTIC.......8A-19
TROUBLE DIAGNOSIS, DOME/COURTESY
LAMP..............................8L-19
TROUBLE DIAGNOSIS, FOG LAMP.........8L-12
TROUBLE DIAGNOSIS, ILLUMINATED
ENTRY SYSTEM; LAMPS..........8L-21,8L-22
TROUBLE DIAGNOSIS, LIGHTED VANITY
MIRROR...........................8L-19
TROUBLE DIAGNOSISÐHEADLAMP....8L-1,8L-2
TROUBLE DIAGNOSISÐXJ VEHICLES,
HEADLAMP DELAY FUNCTION..........8L-16
TROUBLESHOOTING WIRING PROBLEMS . . . 8W-3
TUBE AXLE (2WD), MODEL 30 AXLE........2-20
TUBE CAP, FUEL TANK FILLER;
EMISSION CONTROL SYSTEMS......25-4,25-9
TUBE CAP, FUEL TANK FILLER; FUEL
SYSTEM............................14-12
TUBE, NO-LEAD FUEL TANK FILLER.......14-12
TUBE RETAINER CLIP, FUEL AND BRAKE
FLUID; BODY COMPONENTSÐXJ VEHICLES . 23-86
TUBE RETAINER CLIP, FUEL AND BRAKE
FLUID; FRAME AND BUMPERS..........13-16
TUBES/LINES/HOSES AND CLAMPS,
FUEL..........................14-9,14-56
TURN/HAZARD SWITCH REPLACEMENT -
ALL MODELS.........................8J-3
TURN SIGNAL LEVER TEST, SPEED
CONTROL SWITCH....................8H-7
TURN SIGNALSÐXJ.....................8J-1
TURN SIGNALSÐYJ.....................8J-2
TURN SIGNAL/TAIL LAMP BULB
REPLACEMENT, BACK-UP/REAR..........8L-9
TWEETER SPEAKER/COURTESY LAMP
SUPPORT BRACKET, I/P...............23-95
U-JOINT, AXLE SHAFTÐCARDAN..........2-25
U-JOINTS, PROPELLER SHAFTS..........16-14
UNBALANCE...........................16-3
UNDERBODY COMPONENTS.............23-84
UNDERCOAT, BODY...................23-203
UNDERHOOD LAMP BULB REPLACEMENT
. . . 8L-18
UNDERHOOD LAMP REPLACEMENT
.......8L-18
UNDERHOOD LAMP SERVICE
INFORMATION
.......................8L-17
UNIBODY CONSTRUCTION, XJ
.............13-1UNIT (ECU), ELECTRONIC CONTROL........5-41
UNIT, FUEL GAUGE SENDING.............14-15
UNIT (HCU), HYDRAULIC CONTROL........5-39
UNIVERSAL JOINT ANGLE
MEASUREMENT.......................16-4
UNIVERSAL JOINT REPLACEMENT.........16-9
UNIVERSAL JOINTS.....................16-2
UPPER SUSPENSION ARM...............2-11
UPSHIFT INDICATOR INOPERATIVE.........8E-4
UPSHIFT INDICATOR LAMP; INSTRUMENT
PANELAND GAUGESÐXJ...............8E-2
UPSHIFT INDICATOR LAMP; INSTRUMENT
PANELAND GAUGESÐYJ..............8E-16
USAGE STATEMENT, FUEL................14-1
USAGE STATEMENTÐGAS ENGINES, FUEL . . . 0-17
USING ON-BOARD DIAGNOSTIC SYSTEM . . . 8A-19
VACUUM DISCONNECT AXLE Ð YJ
VEHICLES...........................2-26
VACUUM HOSE ROUTING SCHEMATICS......25-1
VACUUM MOTOR, FRESH AIR DOOR.......24-41
VACUUM MOTOR REPLACEMENT, A/C
RECIRCULATING AIR DOOR............24-31
VACUUM MOTOR REPLACEMENT,
HEATER/DEFROSTER/INSTRUMENT
PANEL OUTLET DOOR.................24-30
VACUUM ROUTING SCHEMATICÐ2.5L 4
CYLINDER ENGINE....................25-2
VACUUM ROUTING SCHEMATICÐ4.0L 6
CYLINDER ENGINE....................25-3
VACUUM SUPPLY TEST..................8H-7
VACUUM TEST, POWER BOOSTER..........5-12
VALUES, CONVERSION FORMULAS AND
EQUIVALENT.....................INTRO.-8
VALUES, GAUGE CALIBRATION...........8E-22
VALUES, STANDARD TORQUE.........INTRO.-9
VALVE AND SPRING IDENTIFICATION, AW-
4 ................................21-330
VALVE BODY ASSEMBLY AND
ADJUSTMENT......................21-144
VALVE BODY CHECK BALL DIMENSIONS,
AW-4 .............................21-328
VALVE BODY DISASSEMBLY AND
INSPECTION.......................21-138
VALVE BODY INSTALLATION............21-101
VALVE BODY INSTALLATION,
TRANSMISSION.....................21-177
VALVE BODY OVERHAUL, TRANSMISSION . . 21-240
VALVE BODY REMOVAL................21-100
VALVE BODY REMOVAL, TRANSMISSION . . 21-176
VALVE BODY SERVICE.................21-100
VALVE BODY SOLENOIDS,
TRANSMISSION.....................21-175
VALVE CABLE ADJUSTMENT,
TRANSMISSION THROTTLE............21-70
VALVE, COMBINATION; BRAKES.......5-15,5-42
VALVE, EXPANSION (H); HEATING AND
AIR CONDITIONING..............24-35,24-43
VALVE FITTING O-RING SEAL, FLOW
CONTROL..........................19-12
VALVE, FUEL TANK PRESSURE
RELIEF/ROLLOVER..............14-15,14-56
VALVE OPERATION, HCU SOLENOID........5-43
VALVE PLATEÐLEAK TESTS, COMPRESSOR . . 24-8
VALVE, PRESSURE RELIEF/ROLLOVER;
EMISSION CONTROL SYSTEMS......25-5,25-9
VALVE REPLACEMENT..................19-28
VALVE REPLACEMENT, CHECK............19-33
VALVE REPLACEMENTÐXJ, COMBINATION . . . 5-55
VALVE REPLACEMENTÐYJ, COMBINATION . . . 5-55
VALVE SHAFT OVERHAUL, MANUAL......21-205
VALVE SHAFT SEAL REPLACEMENT,
MANUAL..........................21-178
VALVE SPRINGS AND OIL SEALS......9-21,9-62
VALVE SPRINGS, VALVES............9-22,9-63
VALVE TEST, POWER BOOSTER CHECK......5-11
VALVE TIMING.....................9-26,9-66
VALVES AND VALVE SPRINGS.........9-22,9-63
VALVES, SERVICE.......................24-3
VANITY MIRROR, LIGHTED
..............8L-19
VANITY MIRROR TROUBLE DIAGNOSIS,
LIGHTED
...........................8L-19
VARIANCE, PINION GEAR DEPTH;
FRONT SUSPENSION AND AXLE
..........2-38
VARIANCE, PINION GEAR DEPTH; REAR
SUSPENSION AND AXLES
...........3-20,3-38
24 INDEXJ
Description Group-Page Description Group-Page Description Group-Page