1994 JEEP CHEROKEE warning lights

CHIME/BUZZER WARNING SYSTEMS
CONTENTS
page page
GENERAL.............................. 1
IGNITION KEY WARNING SWITCH REPLACEMENT.4OPERATION/DIAGNOSIS.................. 1
GENERAL
The buzzer or optional chime module is mounted on
the left side of the fuse block (above and to the left of
the brake/clutch pedal). The buzzer or chime sounds
an audible warning tone in any of the following con-
ditions:
²Vehicle lights are ON when the ignition has been
switched OFF and the key is removed and then the
driver's door is opened (except YJ).²The key is in the ignition and the driver's door is
open (On some vehicles, the buzzer will not sound if
the ignition switch is in the ON position).
²The ignition is switched ON and the driver's seat
belt is not buckled. Buzzer will quit after 4 to 8 sec-
onds. Besides the buzzer, a seat belt indicator lamp
turns on as a reminder to fasten seat belt.
OPERATION/DIAGNOSIS
OPERATION
Battery voltage for module operation is supplied to
two pins. Voltage is always present at pin 7. Pin 1
receives voltage when the ignition switch is in the
ON or START position.
SEAT BELT WARNING
The seat belt warning system uses both visual and
audible signals. These consist of a buzzer that is part
of a combined seat belt and key warning buzzer and
a red light on the instrument panel.
The system will always illuminate the seat belt
warning lamp for four to eight seconds when the ig-
nition switch is turned to the ON position. Also, only
if the driver does not fasten his seat belt, the buzzer
will sound during the same time interval. Passenger
belts are not connected to the system.
A timed buzzer-relay is used to operate the system
for the time period. It has a time delay mechanism
and buzzer assembly. Only the driver's seat belt
buckle has a switch that is connected to the system.
KEY-IN-IGNITION WARNING
To sound the key-in-ignition warning, the following
must occur:
²the ignition key warning switch must be closed
²the driver's door jamb switch must be closed.
These conditions ground pin 6 of the module. These
switches are closed when the key is in the ignition
and the driver's door is open.On some vehicles the chime/buzzer will not
sound if the door is open and the key is in the
ON position.
LIGHTS-ON WARNING (EXCEPT YJ)
To sound the lights-on warning, the following must
occur:
²the headlamp switch must be closed
²the driver's door jamb switch must be closed.
These conditions ground pin 6 of the module. These
switches are closed when the headlamp switch is ON
and the driver's door is open.
DIAGNOSIS
If the buzzer/chime unit does not operate as de-
scribed, check the two fuses for pins 1 and 7 (Figs. 1
and 2) and replace as required. If the fuses are not
defective, perform the following tests to determine if
the problem is in the module or in the wiring. Using
a flat head screwdriver, release the locking plastic
clip while carefully pulling out the module. Plug in a
known good module and check its operation. If the
problem is not corrected by replacing the module, re-
move the module and continue as follows:
VOLTAGE TESTS
Ignition in ON position, measure between the
following pins and vehicle ground.
²Measure voltage at buzzer/chime module connector
pin 1. Meter should read battery voltage. If not, re-
pair open to ignition switch.
Turn ignition OFF and remove the key from the ig-
nition.
JCHIME/BUZZER WARNING SYSTEMS 8U - 1

BODY SOLENOIDS, TRANSMISSION
VALVE ............................21-175
BODY STRIPES/DECALS...........23-25,23-153
BODY, THROTTLE.................14-29,14-59
BODY UNDERCOAT....................23-203
BOOSTER CHECK VALVE TEST, POWER......5-11
BOOSTER INSTALLATION, POWER
BRAKE..........................5-23,5-51
BOOSTER OPERATION, POWER BRAKE......5-22
BOOSTER, POWER BRAKE............5-22,5-40
BOOSTER REMOVAL, POWER BRAKE . . . 5-22,5-51
BOOSTER TEST, MASTER CYLINDER/
POWER.............................5-11
BOOSTER VACUUM TEST, POWER..........5-12
BORES, HONING CYLINDER................9-2
BOX, GLOVE.........................23-194
BRACKET, FUEL FILTER.................23-86
BRACKET, FUEL FILTER SHIELD...........13-17
BRACKET, I/P TWEETER SPEAKER/
COURTESY LAMP SUPPORT............23-95
BRACKET, MUFFLER/TAILPIPE HANGER.....13-16
BRACKET, REARVIEW MIRROR
RETAINING........................23-183
BRACKET REPLACEMENT, INTERIOR
REARVIEW MIRROR SUPPORT..........23-75
BRACKETS, CATALYTIC CONVERTER/
MUFFLER/TAILPIPE SUPPORT...........23-85
BRACKETSÐXJ VEHICLES, SPARE TIRE/
WHEEL HOLDDOWN AND FLOOR.......23-128
BRAKE ADJUSTMENT, DRUM..............5-35
BRAKE ADJUSTMENT PARKING............5-63
BRAKE BLEEDINGÐBRAKE FLUID AND
LEVELÐBRAKELINES AND HOSES........5-13
BRAKE BLEEDINGÐWITH ABS BRAKES.....5-14
BRAKE BLEEDINGÐWITH STANDARD
BRAKES.............................5-13
BRAKE BOOSTER INSTALLATION,
POWER.........................5-23,5-51
BRAKE BOOSTER OPERATION, POWER......5-22
BRAKE BOOSTER, POWER............5-22,5-40
BRAKE BOOSTER REMOVAL, POWER . . . 5-22,5-51
BRAKE CABLE TENSIONER REPLACEMENT
(XJ), PARKING........................5-61
BRAKE CHECK, PRELIMINARY..............5-7
BRAKE COMPONENTS, WHEEL.............5-1
BRAKE DIAGNOSIS, ABS..................5-3
BRAKE DIAGNOSIS, SERVICE..............5-7
BRAKE DRUM REFINISHING..............5-37
BRAKE FLUID CONTAMINATION............5-13
BRAKE FLUID, IMPORTANCE OF CLEAN.....5-48
BRAKE FLUID LEVEL....................5-13
BRAKE FLUID, RECOMMENDED........5-13,5-48
BRAKE FLUID TUBE RETAINER CLIP,
FUEL AND; BODY COMPONENTSÐXJ
VEHICLES..........................23-86
BRAKE FLUID TUBE RETAINER CLIP,
FUEL AND; FRAME AND BUMPERS......13-16
BRAKE FLUID/LUBRICANTS/CLEANING
SOLVENTS............................5-1
BRAKE FRONT CABLE REPLACEMENT
(YJ), PARKING........................5-62
BRAKE INDICATOR INOPERATIVE..........8E-4
BRAKE INDICATOR LAMP; INSTRUMENT
PANEL AND GAUGESÐXJ...............8E-2
BRAKE INDICATOR LAMP; INSTRUMENT
PANEL AND GAUGESÐYJ
..............8E-16
BRAKE LEVER INSTALLATION (XJ WITH
FULLCONSOLE), PARKING
..............5-60
BRAKE LEVER INSTALLATION (XJ WITH
MINICONSOLE), PARKING
...............5-58
BRAKE LEVER INSTALLATION (XJ
WITHOUT CONSOLE), PARKING
..........5-60
BRAKE LEVER REMOVAL (XJ WITH FULL
CONSOLE), PARKING
..................5-59
BRAKE LEVER REMOVAL (XJ WITH MINI
CONSOLE), PARKING
..................5-58
BRAKE LEVER REMOVAL (XJ WITHOUT
CONSOLE), PARKING
..................5-60
BRAKE OPERATION, PARKING
.............5-56
BRAKE OVERHAUL, SECOND
............21-232
BRAKE PACK REQUIREMENTS, AW-4
CLUTCH
...........................21-328
BRAKE PEDAL AND BRAKELIGHT
SWITCH
.............................5-65
BRAKE PEDAL INSTALLATION
.............5-66BRAKE PEDAL INSTALLATION (YJ),
PARKING............................5-61
BRAKE PEDAL REMOVAL.................5-65
BRAKE PEDAL REMOVAL (YJ), PARKING....5-61
BRAKE PEDAL SERVICE..................5-65
BRAKE PISTON AND TRANSMISSION
CASE OVERHAUL, FIRST-REVERSE......21-237
BRAKE PROBLEMS, DIAGNOSING
PARKING............................5-10
BRAKE PROBLEMS, DIAGNOSING
SERVICE.............................5-8
BRAKE REAR CABLE REPLACEMENT
(XJ), PARKING........................5-62
BRAKE REAR CABLE REPLACEMENT (YJ),
PARKING............................5-63
BRAKE ROTOR REFINISHING, DISC.........5-32
BRAKE ROTOR RUNOUT, DISC............5-31
BRAKE ROTOR THICKNESS, DISC..........5-31
BRAKE ROTOR THICKNESS VARIATION,
DISC...............................5-31
BRAKE SAFETY PRECAUTIONS.............5-2
BRAKE SERVO, SECOND COAST.........21-181
BRAKE SWITCH.......................14-54
BRAKE SWITCHÐPCM INPUT............14-20
BRAKE SYSTEM (ABS), ANTILOCK..........5-1
BRAKE SYSTEM (ABS) INDICATOR
LAMP, ANTI-LOCK.....................8E-2
BRAKE SYSTEM OPERATION, ANTILOCK.....5-43
BRAKE SYSTEM, POWER.................0-32
BRAKE TORQUE SPECIFICATIONS..........5-67
BRAKE WARNING LIGHT DISPLAY...........5-4
BRAKE WARNING LIGHTS.................5-1
BRAKELIGHT SWITCH ADJUSTMENT........5-66
BRAKELIGHT SWITCH, BRAKE PEDAL.......5-65
BRAKELIGHT SWITCH INSTALLATION.......5-66
BRAKELIGHT SWITCH REMOVAL...........5-66
BRAKELINE CHARTS....................5-15
BRAKELINES AND HOSES................5-15
BRAKELINING MATERIAL..................5-1
BRAKES, BRAKE BLEEDINGÐWITH ABS.....5-14
BRAKES, BRAKE BLEEDINGÐWITH
STANDARD..........................5-13
BRAKES, DISC.........................5-24
BRAKES, DRUM........................5-34
BRAKES, PARKING......................5-56
BRAKES, POWER........................5-1
BRAKESHOE INSTALLATION, DISC..........5-26
BRAKESHOE INSTALLATION, DRUM........5-34
BRAKESHOE REMOVAL, DISC.............5-25
BRAKESHOE REMOVAL, DRUM............5-34
BRAKING MODE, ABS OPERATION IN
ANTILOCK...........................5-43
BRAKING MODE, ABS OPERATION
IN NORMAL..........................5-43
BREAK-IN, ENGINE......................0-13
BRUSH GUARD........................23-3
BUCKET SEAT COMPONENTS, POWER....23-106
BUCKET SEAT CUSHION AND COVER......23-98
BUCKET SEAT PLATFORM AND TRACKS . . . 23-105
BUCKET SEATBACK COVER AND FRAME . . . 23-100
BUCKET SEATBACK RECONDITIONING.....23-102
BUCKET SEATS, FRONT.................23-97
BUFFING AND POLISHING..............23-203
BULB REPLACEMENT, BACK-UP/REAR
TURN SIGNAL/TAIL LAMP...............8L-9
BULB REPLACEMENT, FRONT PARK/
TURN SIGNAL LAMP
...................8L-8
BULB REPLACEMENT, HEADLAMP
..........8L-3
BULB REPLACEMENT, INSTRUMENT
CLUSTER
...........................8E-19
BULB REPLACEMENT, SIDE MARKER
LAMP
...............................8L-7
BULB REPLACEMENT, UNDERHOOD
LAMP
..............................8L-18
BULB REPLACEMENTÐYJ VEHICLES,
HARDTOP DOME/CARGO LAMP
.........8L-20
BULB/ELEMENT REPLACEMENT, FOG
LAMP
..............................8L-13
BUMPER, FRONT
..................13-3,13-14
BUMPER, LIFTGATE LICENSE PLATE
SCREW ANCHOR
.....................23-72
BUMPER, REAR
...................13-6,13-18
BUMPER, REAR JOUNCE
................13-18
BUMPERÐXJ VEHICLES, REAR
SEATBACK LATCH STRIKER
...........23-111BUMPERS AND FRAME ATTACHED
COMPONENTS, YJ....................13-14
BUMPERS, FUEL FILLER DOOR...........23-31
BUMPERS, XJ.........................13-3
BUSHING AND PISTON CLEARANCE, AW-
4 ................................21-326
BUSHING REPLACEMENT, AXLE.......2-11,2-32
BUSHING REPLACEMENT, LEAF SPRING
EYE; FRONT SUSPENSION AND AXLE.....2-15
BUSHING REPLACEMENT, LEAF SPRING
EYE; REAR SUSPENSION AND AXLES . . . 3-4,3-6
BUZZER SYSTEM, CHIME/WARNING........8A-1
CABLE, ACCELERATOR PEDAL AND
THROTTLE.....................14-16,14-54
CABLE ADJUSTMENT, PARK INTERLOCK . . . 21-186
CABLE ADJUSTMENT, SHIFT............21-186
CABLE ADJUSTMENT, TRANSMISSION
THROTTLE....................21-98,21-185
CABLE ADJUSTMENT, TRANSMISSION
THROTTLE VALVE....................21-70
CABLE ADJUSTMENT (XJ), PARK
INTERLOCK.........................21-97
CABLE ADJUSTMENT (XJ), SHIFT.........21-97
CABLE REPLACEMENT, HEATER
CONTROL..........................24-30
CABLE REPLACEMENT, LATCH
RELEASE...........................23-10
CABLE REPLACEMENT, SERVO............8H-9
CABLE REPLACEMENT, TRANSMISSION
THROTTLE.........................21-184
CABLE REPLACEMENT (XJ),
PARKING BRAKE REAR.................5-62
CABLE REPLACEMENT (YJ), PARKING
BRAKE FRONT........................5-62
CABLE REPLACEMENT (YJ), PARKING
BRAKE REAR.........................5-63
CABLE RESISTANCE, SPARK PLUG........8D-18
CABLE TENSIONER REPLACEMENT (XJ),
PARKING BRAKE......................5-61
CABLE, THROTTLE.....................14-16
CABLEÐCONSOLE SHIFT AUTOMATIC,
PARK-LOCK.........................19-45
CABLES, DISTRIBUTOR CAP AND ROTOR,
IGNITION............................0-18
CABLES, SPARK PLUG SECONDARY . . 8D-17,8D-29
CABLES, VENT DOOR CONTROL..........24-39
CALIBRATION VALUES, GAUGE...........8E-22
CALIPER ASSEMBLY....................5-29
CALIPER CLEANING AND INSPECTION......5-28
CALIPER DISASSEMBLY..................5-27
CALIPER INSTALLATION..................5-30
CALIPER OPERATION AND WEAR
COMPENSATION......................5-24
CALIPER REMOVAL.....................5-27
CAMSHAFT........................9-29,9-69
CAMSHAFT PIN REPLACEMENT........9-31,9-71
CAMSHAFT POSITION SENSOR; FUEL
SYSTEM............................14-54
CAMSHAFT POSITION SENSOR;
IGNITION SYSTEMS..............8D-1,8D-20
CAMSHAFT POSITION SENSORÐPCM
INPUT.............................14-20
CAMSHAFT POSITION SENSOR TEST;
FUEL SYSTEM.......................14-43
CAMSHAFT POSITION SENSOR TEST;
IGNITION SYSTEMS...................8D-8
CANADA ONLY, DAYTIME RUNNING
LIGHTS............................8L-16
CANISTER, EVAP...................25-4,25-9
CAP AND ROTOR, IGNITION CABLES,
DISTRIBUTOR........................0-18
CAP, DISTRIBUTOR.....................8D-9
CAP, FUEL TANK FILLER TUBE; EMISSION
CONTROL SYSTEMS...............25-4,25-9
CAP, FUEL TANK FILLER TUBE; FUEL
SYSTEM............................14-12
CAP, RADIATOR PRESSURE...............7-20
CAPACITIES, COOLING SYSTEM...........7-38
CAPACITIES, FLUID......................0-4
CAPACITIES, FUEL TANK...........14-12,14-62
CAPACITY TEST, FUEL PUMP..............14-7
CAR REPLACEMENT, PITMAN SHAFT
SEALSÐIN
.........................19-21
CARDAN (CV), DOUBLE
.................16-10
CARDAN, SINGLE
.......................16-9
CARDAN U-JOINT, AXLE SHAFT
............2-25
JINDEX3
Description Group-Page Description Group-Page Description Group-Page

CRANKSHAFT POSITION SENSORÐPCM
INPUT.............................14-20
CRANKSHAFT POSITION SENSOR TEST;
FUEL SYSTEM.......................14-44
CRANKSHAFT POSITION SENSOR TEST;
IGNITION SYSTEMS...................8D-9
CROSSMEMBER COVER, FRAME..........13-14
CROSSMEMBER, RADIATOR SUPPORT......23-5
CUSHION AND COVER, BUCKET SEAT......23-98
CUSHION COVERÐXJ VEHICLES, REAR
SEAT .............................23-107
CUSHION, ENGINE FRONT SUPPORT.......13-15
CUSHION RECONDITIONINGÐXJ
VEHICLES, REAR SEAT...............23-108
CUSHIONÐXJ VEHICLES, REAR SEAT.....23-107
CYLINDER BLOCK..................9-45,9-85
CYLINDER BORES, HONING................9-2
CYLINDER COMBUSTION PRESSURE
LEAKAGE TEST DIAGNOSIS...........9-5,9-6
CYLINDER DISPOSAL, LIFTGATE
SUPPORT ROD......................23-70
CYLINDER, DOOR KEY LOCK.............23-54
CYLINDER ENGINE, VACUUM ROUTING
SCHEMATICÐ2.5L 4...................25-2
CYLINDER ENGINE, VACUUM ROUTING
SCHEMATICÐ4.0L 6...................25-3
CYLINDER, FULL-METAL DOOR KEY
LOCK.............................23-178
CYLINDER HEAD COVER, ENGINE......9-18,9-59
CYLINDER HEAD, ENGINE............9-19,9-60
CYLINDER HEAD GASKET FAILURE
DIAGNOSIS, ENGINE....................9-5
CYLINDER INSTALLATION, MASTER....5-20,5-50
CYLINDER INSTALLATION, WHEEL.........5-37
CYLINDER, LIFTGATE SUPPORT ROD......23-69
CYLINDER, MASTER.....................5-40
CYLINDER OVERHAUL, WHEEL............5-36
CYLINDER OVERHAUL, MASTER...........5-20
CYLINDER REMOVAL, MASTER........5-20,5-50
CYLINDER REMOVAL, WHEEL.............5-36
CYLINDER REPLACEMENT, LIFTGATE
LOCK...............................8P-7
CYLINDER, STANDARD MASTER...........5-20
CYLINDER, TAILGATE LOCK.............23-160
CYLINDER/POWER BOOSTER TEST,
MASTER............................5-11
CYLINDER/STRIKER, LIFTGATE LATCH/
KEY LOCK..........................23-68
CYLINDERS, KEY LOCK............23-2,23-132
D RANGE FIRST GEAR, HYDRAULIC
FLOW IN...........................21-87
D RANGE SECOND GEAR, HYDRAULIC
FLOW IN...........................21-88
D RANGE THIRD GEAR, HYDRAULIC
FLOW IN...........................21-89
DAMAGE TORQUE, COLLISION............13-1
DAMAGED OR WORN THREADS, REPAIR.....9-4
DAMPENER, STEERING............19-15,19-18
DAMPER, ENGINE......................9-13
DAMPER, VIBRATION................9-26,9-67
DASH PANEL INSULATION PANEL.........23-95
DASH PANEL INSULATOR PANEL.........23-11
DATA LINK CONNECTORÐPCM INPUT.....14-20
DATA LINK CONNECTORÐPCM OUTPUT....14-24
DATA, VEHICLE DIMENSION . . . INTRO.-3,INTRO.-4
DATA, VEHICLE LOAD................INTRO.-3
DATA, XJ VEHICLE LOAD.............INTRO.-5
DATA, YJ-VEHICLE LOAD.............INTRO.-6
DAYTIME RUNNING LIGHTS (CANADA
ONLY) .............................8L-16
DECODING, VEHICLE CODE...........INTRO.-3
DECODING, VEHICLE IDENTIFICATION
NUMBER (VIN)....................INTRO.-2
DEFLECTOR, COWL WEATHERSTRIP
SEAL/CROSSMEMBER AIR.............23-10
DEFOGGER GRID REPAIR, REAR
WINDOW............................8N-2
DEFOGGER GRID TEST, REAR
WINDOW............................8N-1
DEFOGGER, REAR WINDOW..............8A-1
DEFOGGER RELAY, REAR
................8N-4
DEFOGGER SWITCH REPLACEMENT,
REAR WINDOW
.......................8N-4
DEFOGGER/FOG LAMP/REAR WIPER
SWITCHES, REAR
....................8E-21
DEFROSTER DUCT REPLACEMENT
........24-29DEFROSTER NOZZLE AND DUCT..........24-40
DELAY FUNCTION TROUBLE
DIAGNOSISÐXJ VEHICLES, HEADLAMP . . . 8L-16
DELAY MODULE REPLACEMENTÐXJ
VEHICLES, HEADLAMP................8L-16
DELAY MODULEÐXJ VEHICLES,
SENTINEL HEADLAMP.................8L-15
DELIVERY SYSTEM, FUEL................14-2
DEPTH INFORMATION, PINION GEAR;
FRONT SUSPENSION AND AXLE..........2-37
DEPTH INFORMATION, PINION GEAR;
REAR SUSPENSION AND AXLES..........3-19
DEPTH VARIANCE, PINION GEAR; FRONT
SUSPENSION AND AXLE................2-38
DEPTH VARIANCE, PINION GEAR; REAR
SUSPENSION AND AXLES...........3-20,3-38
DESCRIPTION (AIR CONDITIONING).......24-41
DESCRIPTION; AUDIO SYSTEMS...........8F-1
DESCRIPTION (HEATING)................24-37
DESCRIPTION; HEATING AND AIR
CONDITIONING.................24-17,24-22
DESCRIPTION; OVERHEAD CONSOLE.......8C-1
DESCRIPTION; POWER DOOR LOCKS.......8P-1
DESCRIPTION; POWER WINDOWS.........8S-1
DESCRIPTION; TRANSMISSION AND
TRANSFER CASE....................21-156
DESCRIPTION; TURN SIGNALS AND
HAZARD WARNING FLASHER........8J-1,8J-2
DESCRIPTION/SYSTEM OPERATION,
MULTI-PORT FUEL INJECTION (MFI)Ð
COMPONENT........................14-17
DESIGNATION CODES, VEHICLE........INTRO.-1
DESIGNATIONS, LABELS/PLATES, CODES
AND DIMENSIONS.................INTRO.-1
DESIGNATIONS, VEHICLE.............INTRO.-1
DETECTION AND REPAIR, FIXED GLASS
WATER LEAK..................23-83,23-189
DIAGNOSING INTERMITTENT
WINDSHIELD WASHER................8K-12
DIAGNOSING NON-INTERMITTENT
WINDSHIELD WASHER................8K-12
DIAGNOSING PARKING BRAKE
PROBLEMS..........................5-10
DIAGNOSING POWER DOOR LOCKS....8P-1,8P-9
DIAGNOSING REAR WIPER...............8K-6
DIAGNOSING REAR WIPER WASHER.......8K-6
DIAGNOSING REAR WIPER/WASHER......8K-14
DIAGNOSING SERVICE BRAKE
PROBLEMS...........................5-8
DIAGNOSING WINDSHIELD WASHER
(INTERMITTENT)......................8K-4
DIAGNOSING WINDSHIELD WASHER
(NON-INTERMITTENT)..................8K-4
DIAGNOSING WINDSHIELD WIPERS . . . 8K-3,8K-11
DIAGNOSINGÐALL LAMPS OUT..........8E-16
DIAGNOSINGÐTURN SIGNAL
INOPERATIVE.........................8J-2
DIAGNOSIS, 2.5L STARTER MOTOR NOISE . . . 8A-13
DIAGNOSIS, 30RH/32RH TRANSMISSION . . 21-69,
21-77,21-78,21-79,21-80,21-81,21-82,21-83,21-84,
21-85
DIAGNOSIS, ABS BRAKE..................5-3
DIAGNOSIS, ABS FAULT................5-4,5-6
DIAGNOSIS, AIR CONDITIONING
SYSTEM............................24-12
DIAGNOSIS AND REPAIR............8G-1,8G-2
DIAGNOSIS; AUDIO SYSTEMS.............8F-1
DIAGNOSIS, AW-4 TRANSMISSION
.......21-167
DIAGNOSIS, AXLE NOISE/VIBRATION;
FRONT SUSPENSION AND AXLE
..........2-16
DIAGNOSIS, AXLE NOISE/VIBRATION;
REAR SUSPENSION AND AXLES
..........3-7
DIAGNOSIS, BELT
.......................7-31
DIAGNOSIS CHARTS, INSPECTION
..........6-4
DIAGNOSIS; CHIME/BUZZER WARNING
SYSTEMS
...........................8U-1
DIAGNOSIS, CLUTCH
.....................6-3
DIAGNOSIS, COMPRESSOR
..............24-13
DIAGNOSIS, CONVERTER HOUSING
LEAK
..............................21-73
DIAGNOSIS; COOLING SYSTEM
.............7-4
DIAGNOSIS, CYLINDER COMBUSTION
PRESSURE LEAKAGE TEST
...............9-6
DIAGNOSIS, DISCONNECT AXLE/SHIFT
MOTOR
.............................2-27DIAGNOSIS, DOME/COURTESY LAMP
TROUBLE...........................8L-19
DIAGNOSIS, ECU........................5-4
DIAGNOSISÐELECTRICAL, SERVICE.......24-14
DIAGNOSIS, ENGINE.....................9-5
DIAGNOSIS, ENGINE CYLINDER HEAD
GASKET FAILURE......................9-5
DIAGNOSIS, EXHAUST SYSTEM............11-2
DIAGNOSIS, FOG LAMP TROUBLE.........8L-12
DIAGNOSIS, GAUGE PACKAGE............8E-22
DIAGNOSIS, GEAR LEAKAGE..............19-8
DIAGNOSIS GUIDES AND CHARTS........21-76
DIAGNOSISÐHAZARD LAMPS
INOPERATIVE.....................8J-1,8J-2
DIAGNOSIS, HCU........................5-4
DIAGNOSIS, HEATING SYSTEM...........24-11
DIAGNOSIS, IGNITION OFF DRAW (IOD).....8A-8
DIAGNOSIS, IGNITION SECONDARY
CIRCUIT...........................8D-12
DIAGNOSIS, ILLUMINATED ENTRY
SYSTEM TROUBLE..............8L-21,8L-22
DIAGNOSIS INFORMATION, GENERAL;
CLUTCH..............................6-3
DIAGNOSIS INFORMATION, GENERAL;
TRANSMISSION AND TRANSFER
CASE.............................21-167
DIAGNOSIS, INSTRUMENT CLUSTER;
INSTRUMENT PANEL AND
GAUGESÐXJ.........................8E-3
DIAGNOSIS, INSTRUMENT CLUSTER;
INSTRUMENT PANEL AND
GAUGESÐYJ........................8E-14
DIAGNOSIS, INTAKE MANIFOLD LEAKAGE.....9-5
DIAGNOSIS, LIGHTED VANITY MIRROR
TROUBLE...........................8L-19
DIAGNOSIS, MANUAL STEERING
SYSTEM............................19-36
DIAGNOSISÐMECHANICAL, SERVICE;
ENGINES.............................9-8
DIAGNOSISÐMECHANICAL, SERVICE;
HEATING AND AIR CONDITIONING........24-8
DIAGNOSIS, MULTI-PORT FUEL
INJECTION (MFI)ÐGENERAL...........14-32
DIAGNOSIS, NOISE.....................3-45
DIAGNOSIS, NP231 SERVICE............21-274
DIAGNOSIS, NP242 SERVICE............21-295
DIAGNOSIS, PERFORMANCE.............24-10
DIAGNOSIS; POWER MIRRORS............8T-1
DIAGNOSIS; POWER SEATS..............8R-1
DIAGNOSIS, POWER STEERING SYSTEM....19-3,
19-4,19-5,19-6,19-7
DIAGNOSIS, PRELIMINARY..............21-69
DIAGNOSIS, PRESSURE..................24-9
DIAGNOSIS PROCEDURES; BRAKES......5-3,5-7
DIAGNOSIS, PUMP LEAKAGE..............19-8
DIAGNOSIS, RADIO NOISE................8F-2
DIAGNOSIS; REAR WINDOW DEFOGGER....8N-2
DIAGNOSIS, SERPENTINE DRIVE BELT......7-32
DIAGNOSIS, SERVICE BRAKE..............5-7
DIAGNOSIS, SERVICE; FRONT
SUSPENSION AND AXLE................2-18
DIAGNOSIS, SERVICE; REAR
SUSPENSION AND AXLES................3-9
DIAGNOSIS, SERVICE; TRANSMISSION
AND TRANSFER CASE . 21-2,21-33,21-171,21-172
DIAGNOSIS, SPRING AND SHOCK;
FRONT SUSPENSIONAND AXLE
......2-12,2-14
DIAGNOSIS, SPRING AND SHOCK; REAR
SUSPENSIONAND AXLES
.............3-3,3-5
DIAGNOSIS, STARTING SYSTEM
..........8A-10
DIAGNOSIS; STEERING
.................19-35
DIAGNOSIS, SUSPENSION AND
STEERING SYSTEM
.....................2-7
DIAGNOSIS, SYSTEM
.....................7-7
DIAGNOSISÐTURN SIGNAL
INOPERATIVE
.........................8J-1
DIAGNOSISÐVEHICLE RUNS ROUGH
AND/OR HAS A MISS, INJECTOR
........14-49
DIAGNOSIS, VIBRATION
.............22-9,22-10
DIAGNOSISÐXJ VEHICLES, HEADLAMP
DELAY FUNCTION TROUBLE
............8L-16
DIAGNOSISÐXJ VEHICLES, HEADLAMP
TROUBLE
............................8L-1
DIAGNOSISÐYJ VEHICLES,
HEADLAMP TROUBLE
..................8L-2
6 INDEXJ
Description Group-Page Description Group-Page Description Group-Page

LIFTGATE LOCK CYLINDER
REPLACEMENT.......................8P-7
LIFTGATE OPENING WEATHERSTRIP SEAL . . . 23-70
LIFTGATE PILLAR TRIM COVERSÐXJ
VEHICLES.........................23-116
LIFTGATE REMOVAL/INSTALLATION........23-65
LIFTGATE SERVICE INFORMATIONÐXJ
VEHICLES..........................23-65
LIFTGATE SUPPORT ROD BALL
STUD REPLACEMENT.................23-70
LIFTGATE SUPPORT ROD CYLINDER.......23-69
LIFTGATE SUPPORT ROD CYLINDER
DISPOSAL..........................23-70
LIFTGATE TRIM PANEL.................23-66
LIFTGATE WINDOW GLASSÐXJ
VEHICLES..........................23-81
LIFTGATE WIPER.......................8K-5
LIFTGATE WIPER SWITCH REPLACEMENT....8K-6
LIGHT DISPLAY, ABS WARNING............5-3
LIGHT DISPLAY, BRAKE WARNING..........5-4
LIGHTED VANITY MIRROR...............8L-19
LIGHTED VANITY MIRROR TROUBLE
DIAGNOSIS.........................8L-19
LIGHTS, BRAKE WARNING.................5-1
LIGHTS (CANADA ONLY), DAYTIME
RUNNING...........................8L-16
LIGHTS, SYSTEM WARNING..............5-42
LIMITED SLIP DIFFERENTIAL...............3-8
LIMITS, AW-4 OIL PUMP WEAR.........21-325
LINE CLUSTER, HIGH...................8E-12
LINE CLUSTER, LOW...................8E-11
LINE FITTINGS, TRANSMISSION COOLER . . 21-187
LINERS, REAR WHEELHOUSE FLARES.....23-18
LINERS, WHEELHOUSE SPLASH.........23-146
LINES AND FITTINGS, SERVICING
TRANSMISSION COOLER.............21-106
LINK CONNECTORÐPCM INPUT, DATA.....14-20
LINK CONNECTORÐPCM OUTPUT, DATA . . . 14-24
LINK, DRAG.....................19-14,19-17
LINK REPLACEMENT, FUSIBLE............8W-4
LINKAGE ADJUSTMENT, SHIFT....21-275,21-296
LINKAGE ADJUSTMENT (YJ), GEARSHIFT . . . 21-96
LINKAGE AND BALL STUDS, STEERING.....0-30
LINKAGE FLUID, CLUTCH..................6-1
LINKAGE, GEARSHIFT..................21-70
LINKAGE INSTALLATION, CLUTCH
HYDRAULIC..........................6-12
LINKAGE REMOVAL, CLUTCH HYDRAULIC....6-11
LINKAGEÐXJ, STEERING..........19-14,19-73
LINKAGEÐYJ, STEERING..........19-17,19-73
LINKS, FUSIBLE.......................8W-3
LOAD DATA, VEHICLE................INTRO.-3
LOAD DATA, XJ VEHICLE.............INTRO.-5
LOAD DATA, YJ-VEHICLE.............INTRO.-6
LOAD TEST, BATTERY...................8A-4
LOCATING A SYSTEM...................8W-2
LOCATIONS, SPLICE..............8W-2,8W-53
LOCATIONS, TRANSMISSION SWITCH
AND PLUG..........................21-33
LOCATIONS, XJ RHD SPLICE............8W-67
LOCATIONS, XJ SPLICE................8W-59
LOCATIONS, YJ SPLICE................8W-53
LOCK COMPONENT OVERHAUL,
ADAPTER HOUSING AND PARK........21-120
LOCK COMPONENT REPLACEMENT,
PARK .............................21-102
LOCK CYLINDER, DOOR KEY.............23-54
LOCK CYLINDER, FULL-METAL DOOR
KEY ..............................23-178
LOCK CYLINDER REPLACEMENT,
LIFTGATE............................8P-7
LOCK CYLINDER, TAILGATE.............23-160
LOCK CYLINDER/STRIKER, LIFTGATE
LATCH/KEY.........................23-68
LOCK CYLINDERS, KEY............23-2,23-132
LOCK HANDLE, FULL-METAL DOOR.......23-175
LOCK, HYDROSTATIC.....................9-4
LOCK RODS, DOOR INSIDE LATCH
RELEASE...........................23-57
LOCK SWITCH, PASSENGER DOOR
.........8P-5
LOCK SWITCHÐ2-DOOR LEFT HAND
DRIVE, DRIVERS DOOR POWER
..........8P-2
LOCK SWITCHÐ2-DOOR RIGHT HAND
DRIVE,DRIVERS DOOR POWER
..........8P-3
LOCK SWITCHÐ4-DOOR, DRIVERS
DOOR POWER
........................8P-4LOCKS, DIAGNOSING POWER DOOR . . . 8P-1,8P-9
LOCKS, POWER; ELECTRICAL.............8A-1
LOCKS, POWER; POWER DOOR LOCKS.....8P-1
LOCKS, POWER DOOR..................8P-10
LOCK/UNLOCK RELAY REPLACEMENT,
DOOR.............................8P-12
LOOP MODES OF OPERATION, OPEN
LOOP/CLOSED.......................14-27
LOOP/CLOSED LOOP MODES OF
OPERATION, OPEN...................14-27
LOSS OF SENSOR INPUT..................5-3
LOW FUEL WARNING INOPERATIVE........8E-4
LOW FUEL WARNING LAMP..............8E-2
LOW LINE CLUSTER...................8E-11
LOW SPEED KNOCK; FRONT SUSPENSION
AND AXLE...........................2-17
LOW SPEED KNOCK; REAR SUSPENSION
AND AXLES...........................3-8
LOW WASHER INDICATOR INOPERATIVE....8E-4
LOWER SUSPENSION ARM...............2-11
LUBRICANT AND REPLACEMENT PARTS,
RECOMMENDED.......................0-3
LUBRICANT CHANGE; FRONT
SUSPENSION AND AXLE................2-22
LUBRICANT CHANGE; REAR SUSPENSION
AND AXLES......................3-13,3-30
LUBRICANT, RECOMMENDED.............21-2
LUBRICANT SPECIFICATIONS, BODY........0-35
LUBRICANT SPECIFICATIONS; FRONT
SUSPENSION AND AXLE................2-20
LUBRICANT SPECIFICATIONS; REAR
SUSPENSION AND AXLES...........3-11,3-30
LUBRICANT, TRANSFER CASE.....21-273,21-294
LUBRICANT, TRANSMISSION.............21-33
LUBRICANTS, CHASSIS COMPONENT
AND WHEEL BEARING.................0-30
LUBRICANTS, CLASSIFICATION OF..........0-2
LUBRICATION, CLUTCH COMPONENT........6-1
LUBRICATION, COMPONENTS
REQUIRING NO........................0-3
LUG NUT, WHEEL......................22-11
LUGGAGE RACKÐXJ VEHICLES..........23-32
MAGNETIC CLUTCH....................24-18
MAIN BEARING FITTING CHART.......9-43,9-83
MAIN BEARINGS, CRANKSHAFT.......9-40,9-80
MAIN OIL SEALS, REAR..............9-44,9-84
MAINTENANCE, BATTERY................8B-1
MAINTENANCE, ENGINE..................0-13
MAINTENANCE SCHEDULES...............0-5
MAINTENANCE, SEVERE SERVICE...........0-5
MAJOR COMPONENT IDENTIFICATION . . . INTRO.-3
MALFUNCTION INDICATOR LAMP
(CHECK ENGINE); INSTRUMENT PANEL
AND GAUGESÐXJ................8E-2,8E-4
MALFUNCTION INDICATOR LAMP
(CHECK ENGINE); INSTRUMENT PANEL
AND GAUGESÐYJ...................8E-16
MALFUNCTION INDICATOR LAMPÐPCM
OUTPUT............................14-26
MANIFOLDÐ2.5L ENGINE, ENGINE
EXHAUST............................11-7
MANIFOLDÐ2.5L ENGINE, INTAKE.........11-8
MANIFOLDÐ4.0L ENGINE, ENGINE
EXHAUST............................11-7
MANIFOLDÐ4.0L ENGINE, INTAKE
.........11-9
MANIFOLD ABSOLUTE PRESSURE (MAP)
SENSOR; FUEL SYSTEM
...............14-57
MANIFOLD ABSOLUTE PRESSURE (MAP)
SENSOR; IGNITION SYSTEMS
......8D-5,8D-27
MANIFOLD ABSOLUTE PRESSURE (MAP)
SENSORÐPCM INPUT
................14-21
MANIFOLD ABSOLUTE PRESSURE (MAP)
SENSOR TEST; FUEL SYSTEM
..........14-44
MANIFOLD ABSOLUTE PRESSURE (MAP)
SENSOR TEST; IGNITION SYSTEMS
......8D-14
MANIFOLD AIR TEMPERATURE SENSOR,
INTAKE
........................8D-5,8D-27
MANIFOLD AIR TEMPERATURE
SENSOR TEST, INTAKE
................8D-14
MANIFOLD ASSEMBLY, PRESSURE
GAUGE
..............................24-2
MANIFOLD, INTAKE
....................14-57
MANIFOLD LEAKAGE DIAGNOSIS, INTAKE
.....9-5
MANUAL FIRST GEAR (1) POSITION,
HYDRAULIC FLOW IN
.................21-94MANUAL SECOND (2) RANGE,
HYDRAULIC FLOW IN.................21-93
MANUAL SHIFTING TEST...............21-168
MANUAL STEERING GEAR..........19-35,19-73
MANUAL STEERING GEAR
SPECIFICATIONS.....................19-44
MANUAL STEERING GEARÐYJ VEHICLES....0-32
MANUAL STEERING SYSTEM DIAGNOSIS . . . 19-36
MANUAL TRANSMISSION................0-22
MANUAL TRANSMISSION, AX 15.........21-32
MANUAL TRANSMISSION, AX 4/5..........21-1
MANUAL TRANSMISSION, SELECTIVE
SNAP RING CHARTÐAX 15...........21-321
MANUAL TRANSMISSION, TORQUE
SPECIFICATIONSÐ AX 15.............21-320
MANUAL VALVE SHAFT OVERHAUL.......21-205
MANUAL VALVE SHAFT SEAL
REPLACEMENT.....................21-178
MARKER LAMP BULB REPLACEMENT,
SIDE...............................8L-7
MASTER CYLINDER.....................5-40
MASTER CYLINDER INSTALLATION.....5-20,5-50
MASTER CYLINDER OVERHAUL...........5-20
MASTER CYLINDER REMOVAL........5-20,5-50
MASTER CYLINDER, STANDARD...........5-20
MASTER CYLINDER/POWER BOOSTER
TEST...............................5-11
MATCH MOUNTING TIRES................22-7
MATERIAL, BRAKELINING.................5-1
MATS, CARPET/FLOOR.................23-198
MATS, CARPETS AND FLOOR...........23-129
MEASUREMENT AND ADJUSTMENT,
DIFFERENTIAL SHIM PACK..............2-42
MEASUREMENT, DIFFERENTIAL AND
PINION; FRONT SUSPENSION AND AXLE....2-38
MEASUREMENT, DIFFERENTIAL AND
PINION; REAR SUSPENSION AND AXLES....3-20
MEASUREMENT, UNIVERSAL JOINT
ANGLE..............................16-4
MEASUREMENTS AND ADJUSTMENTS,
ALIGNMENT...........................2-6
MEASURING WITH PLASTIGAGE............9-3
METALS, PAINT REPAIR ON GALVANIZED . . 23-202
METRIC SYSTEM NOTATION...........INTRO.-8
METRIC, THREAD NOTATIONÐSAE.....INTRO.-9
(MFI)ÐCOMPONENT DESCRIPTION/
SYSTEM OPERATION, MULTI-
PORT FUEL INJECTION................14-17
(MFI)ÐCOMPONENT REMOVAL/
INSTALLATION, MULTI-PORT FUEL
INJECTION..........................14-54
(MFI)ÐGENERAL DIAGNOSIS,
MULTI-PORT FUEL INJECTION..........14-32
MINI-FLOOR CONSOLEÐXJ VEHICLES....23-124
MIRROR (EXTERNAL), HALF METAL
DOOR
............................23-158
MIRROR, INTERIOR REARVIEW
...........23-74
MIRROR, LIGHTED VANITY
..............8L-19
MIRROR, REARVIEW
..................23-183
MIRROR REPLACEMENT, POWER
..........8T-4
MIRROR RETAINING BRACKET,
REARVIEW
.........................23-183
MIRROR SUPPORT BRACKET
REPLACEMENT, INTERIOR REARVIEW
....23-75
MIRROR SWITCH, POWER
................8T-2
MIRROR SWITCH REPLACEMENT,
POWER
.............................8T-4
MIRROR SWITCH TESTING, POWER
........8T-2
MIRROR TROUBLE DIAGNOSIS, LIGHTED
VANITY
............................8L-19
MIRRORS, EXTERNAL
..................23-31
MIRRORS, POWER
.....................8A-1
MISS, INJECTOR DIAGNOSISÐVEHICLE
RUNS ROUGH AND/OR HAS A
..........14-49
MODE, ABS OPERATION IN ANTILOCK
BRAKING
............................5-43
MODE, ABS OPERATION IN NORMAL
BRAKING
............................5-43
MODE, VEHICLE RESPONSE IN
ANTILOCK
............................5-3
MODEL 30 AXLE AND TUBE AXLE
(2WD)
..............................2-20
MODEL 30 FRONT AXLE
.............2-46,2-47
MODEL 35, REAR AXLE
..........3-11,3-28,3-50
14 INDEXJ
Description Group-Page Description Group-Page Description Group-Page

STRAP, FUEL TANK SUPPORT............23-86
STRIKER AND BUMPERÐXJ VEHICLES,
REAR SEATBACK LATCH..............23-111
STRIKER, HALF-METAL DOOR LATCH.....23-175
STRIKER REPLACEMENT, HOOD LATCH....23-10
STRIKER REPLACEMENT, SAFETY LATCH . . . 23-10
STRIKER, TAILGATE LATCH.............23-161
STRIP, DOOR EDGE GUARD/EDGE
PROTECTOR........................23-61
STRIPES/DECALS, BODY..........23-25,23-153
STUD REPLACEMENT, LIFTGATE SUPPORT
ROD BALL..........................23-70
STUDS, STEERING KNUCKLE AND BALL.....2-30
STUDS, STEERING LINKAGE AND BALL.....0-30
SUN GEAR AND NO. 1 ONE-WAY
CLUTCH OVERHAUL.................21-229
SUNVISORS...................23-124,23-196
SUPPORT BRACKET, I/P TWEETER
SPEAKER/COURTESY LAMP............23-95
SUPPORT BRACKET REPLACEMENT,
INTERIOR REARVIEW MIRROR..........23-75
SUPPORT BRACKETS, CATALYTIC
CONVERTER/MUFFLER/TAILPIPE.........23-85
SUPPORT CUSHION, ENGINE FRONT.......13-15
SUPPORT OVERHAUL, OVERDRIVE.......21-216
SUPPORT OVERHAUL, OVERRUNNING
CLUTCHÐLOW-REVERSE DRUMÐ
REAR.............................21-118
SUPPORT PLATE REPLACEMENT...........5-37
SUPPORT ROD BALL STUD
REPLACEMENT, LIFTGATE..............23-70
SUPPORT ROD CYLINDER DISPOSAL,
LIFTGATE...........................23-70
SUPPORT ROD CYLINDER, LIFTGATE......23-69
SUPPORT STRAP, FUEL TANK............23-86
SUPPORTS, ENGINE (MOUNTS)............0-20
SURFACE PREPARATION...............23-201
SUSPENSION, REAR.....................3-1
SUSPENSION AND STEERING SYSTEM
DIAGNOSIS...........................2-7
SUSPENSION ARM, LOWER...............2-11
SUSPENSION ARM, UPPER...............2-11
SUSPENSION COMPONENTS, XJ FRONT.....2-47
SUSPENSION COMPONENTS, XJ REAR......3-50
SUSPENSION COMPONENTS, YJ FRONT.....2-47
SUSPENSION COMPONENTS, YJ REAR......3-50
SUSPENSION, FRONT............2-1,2-10,2-13
SUSPENSION, REAR..................2-1,3-5
SWITCHÐ2.5L ENGINE ONLY, POWER
STEERING PRESSURE.................14-58
SWITCH, ACCELERATION.................5-41
SWITCH ADJUSTMENT, BRAKELIGHT.......5-66
SWITCH AND PLUG LOCATIONS,
TRANSMISSION......................21-33
SWITCH, BRAKE.......................14-54
SWITCH, BRAKE PEDAL AND BRAKELIGHT....5-65
SWITCH CONTINUITY TESTS, IGNITION....8D-31
SWITCHÐDRIVERS DOOR POWER LOCK . . . 8P-2,
8P-3,8P-4
SWITCHÐDRIVERS DOOR POWER
WINDOW...................8S-5,8S-6,8S-7
SWITCH (HORN PAD) REPLACEMENT, HORN . 8G-3
SWITCH, IGNITION; BRAKES..............5-42
SWITCH, IGNITION; IGNITION SYSTEMS....8D-30
SWITCH INSTALLATION, BRAKELIGHT.......5-66
SWITCH INSTALLATION/ADJUSTMENT,
IGNITION...........................8D-31
SWITCH OPERATION, ACCELERATION.......5-45
SWITCH, OVERDRIVE (OVERRIDE)........14-22
SWITCH, PARK/NEUTRAL POSITION . . 8B-6,14-58,
21-173
SWITCH, PASSENGER DOOR LOCK.........8P-5
SWITCH, PASSENGER DOOR WINDOW......8S-8
SWITCHÐPCM INPUT, BRAKE............14-20
SWITCHÐPCM INPUT, EXTENDED IDLE....14-21
SWITCHÐPCM INPUT, PARK/NEUTRAL.....14-22
SWITCHÐPCM INPUT, POWER
STEERING PRESSURE.................14-22
SWITCH, POWER MIRROR................8T-2
SWITCH REMOVAL, BRAKELIGHT..........5-66
SWITCH REMOVAL, IGNITION
............8D-30
SWITCH REPLACEMENT - ALL MODELS,
TURN/HAZARD
........................8J-3
SWITCH REPLACEMENT, BLOWER
MOTOR/AIR DOOR MOTOR
.............24-39
SWITCH REPLACEMENT, FOG LAMP
.......8L-14SWITCH REPLACEMENT, HEADLAMP.......8L-4
SWITCH REPLACEMENT, HEADLAMP
DIMMER............................8L-6
SWITCH REPLACEMENT, IGNITION
KEY WARNING.......................8U-4
SWITCH REPLACEMENT, LIFTGATE WIPER . . . 8K-6
SWITCH REPLACEMENT, POWER MIRROR . . . 8T-4
SWITCH REPLACEMENT, REAR WINDOW
DEFOGGER..........................8N-4
SWITCH REPLACEMENT, REAR WIPER.....8K-13
SWITCH REPLACEMENT, SPEED CONTROL . . . 8H-9
SWITCH REPLACEMENT, WIPER CONTROL . . 8K-15
SWITCH SERVICE, PARK/NEUTRAL
POSITION.........................21-103
SWITCH TEST, EXTENDED IDLE...........14-45
SWITCH TEST, STOP LAMP SPEED
CONTROL...........................8H-7
SWITCH TESTING; POWER SEATS.........8R-2
SWITCH TESTING; POWER WINDOWS......8S-5
SWITCH TESTING; REAR WINDOW
DEFOGGER..........................8N-2
SWITCH TESTING, IGNITION.............8D-30
SWITCH TESTING, POWER MIRROR........8T-2
SWITCH TESTING, REAR WIPER/
WASHER.......................8K-7,8K-14
SWITCH TESTING, WIPER...............8K-19
SWITCH (TURN SIGNAL LEVER) TEST,
SPEED CONTROL.....................8H-7
SWITCHES, REAR DEFOGGER/FOG LAMP/
REAR WIPER........................8E-21
SWITCH/ILLUMINATION RHEOSTAT,
HEADLAMP.........................8E-21
SYMBOLS, FUSES AND ABBREVIATIONS,
WIRING............................8W-6
SYMBOLS, INTERNATIONAL VEHICLE
CONTROL AND DISPLAY............INTRO.-3
SYMBOLS, VEHICLE CONTROL AND
DISPLAY.........................INTRO.-7
SYSTEMÐAIR CONDITIONING.......24-14,24-15
SYSTEM (ABS), ANTILOCK BRAKE..........5-1
SYSTEM (ABS) INDICATOR LAMP, ANTI-
LOCK BRAKE.........................8E-2
SYSTEM CAPACITIES, COOLING...........7-38
SYSTEM CHARGE, A/C...................24-5
SYSTEM, CHIME/WARNING BUZZER........8A-1
SYSTEM CLEANING/REVERSE FLUSHING,
COOLING............................7-17
SYSTEMÐCLIMATE CONTROL.......24-22,24-37
SYSTEM COLD CRANKING TEST,
STARTING...........................8A-9
SYSTEM COMPONENTS, COOLING..........7-1
SYSTEM COMPONENTS, STEERING.........19-1
SYSTEM, COOLANT RESERVE/
OVERFLOW..........................7-19
SYSTEM COOLANT ROUTING..............7-1
SYSTEM, COOLING..................0-16,7-1
SYSTEM, CRANKCASE VENTILATION;
EMISSION CONTROL SYSTEMS..........25-5
SYSTEM, CRANKCASE VENTILATION;
LUBRICATION AND MAINTENANCE........0-17
SYSTEM DIAGNOSIS, COOLING.............7-7
SYSTEM DIAGNOSIS, AIR CONDITIONING . . . 24-12
SYSTEM DIAGNOSIS, EXHAUST............11-2
SYSTEM DIAGNOSIS, HEATING...........24-11
SYSTEM DIAGNOSIS, MANUAL
STEERING..........................19-36
SYSTEM DIAGNOSIS, POWER
STEERING...........19-3,19-4,19-5,19-6,19-7
SYSTEM DIAGNOSIS, STARTING..........8A-10
SYSTEM DIAGNOSIS, SUSPENSION AND
STEERING............................2-7
SYSTEM DIAGNOSTIC INSPECTIONS,
STARTER............................8A-9
SYSTEM DISCHARGE, A/C................24-4
SYSTEM, DRAINING COOLING.............7-16
SYSTEM ELECTRICAL TESTS, VEHICLE
SPEED CONTROL.....................8H-5
SYSTEM EVACUATION A/C................24-4
SYSTEM, EVAP (EVAPORATION)
CONTROL...........................25-4
SYSTEM, EXHAUST; INTAKE
MANIFOLD.......................0-20,11-1
SYSTEM FANS, COOLING
.................7-26
SYSTEM, FUEL
........................14-62
SYSTEM, FUEL DELIVERY
................14-2
SYSTEM HOSES, COOLING
...............7-26SYSTEM, HYDRAULIC.................21-160
SYSTEM, ILLUMINATED ENTRY...........8L-20
SYSTEM, INOPERATIVE..................8H-5
SYSTEM, LOCATING A ELECTRICAL........8W-2
SYSTEM NOTATION, METRIC..........INTRO.-8
SYSTEM OPERATION, ABS................5-39
SYSTEM OPERATION, ANTILOCK BRAKE.....5-43
SYSTEM, POWER BRAKE.................0-32
SYSTEM, POWER STEERING..............0-31
SYSTEM POWER-UP AND INITIALIZATION....5-43
SYSTEM PRESSURE RELEASE
PROCEDURE, FUEL...................14-56
SYSTEM PRESSURE TEST, FUEL......14-5,14-48
SYSTEM, REFILLING COOLING............7-17
SYSTEM RELAYS.......................5-42
SYSTEM REPAIR PROCEDURES,
THERMOMETER AND SENSOR...........8C-6
SYSTEM, SPEEDOMETER/ODOMETER;
INSTRUMENT PANEL AND GAUGESÐXJ . . . 8E-2
SYSTEM, SPEEDOMETER/ODOMETER;
INSTRUMENT PANEL AND GAUGESÐYJ . . 8E-14
SYSTEM TROUBLE DIAGNOSIS,
ILLUMINATED ENTRY............8L-21,8L-22
SYSTEM, USING ON-BOARD DIAGNOSTIC . . . 8A-19
SYSTEM, VEHICLE SPEED CONTROL........8A-1
SYSTEM WARNING LIGHTS...............5-42
SYSTEM WIRING AND ELECTRICAL
CIRCUITS, ABS........................5-4
SYSTEMÐYJ VEHICLES, HEATING........24-14
SYSTEMS, AUDIO......................8A-1
SYSTEMS DIAGNOSTICS, BATTERY/
STARTING/CHARGING..................8A-1
SYSTEMS, IGNITION....................8A-1
TABLE, BATTERY CHARGING TIME.........8A-5
TACHOMETER; INSTRUMENT PANEL
AND GAUGESÐXJ....................8E-2
TACHOMETER; INSTRUMENT PANEL
AND GAUGESÐYJ...................8E-14
TACHOMETER INOPERATIVE..............8E-3
TACHOMETERÐPCM OUTPUT............14-27
TACHOMETER REPLACEMENT........8E-5,8E-17
TAILGATE ADJUSTMENT...............23-160
TAILGATE HINGE.....................23-159
TAILGATE LATCH AND RELEASE HANDLE . . 23-160
TAILGATE LATCH STRIKER..............23-161
TAILGATE LOCK CYLINDER.............23-160
TAILGATE SERVICE....................23-159
TAILGATE SERVICE INFORMATION........23-159
TAILGATE WEATHERSTRIP SEAL.........23-161
TAILPIPE HEAT SHIELDS, MUFFLER.......13-17
TAILPIPEÐEXHAUST................11-5,11-6
TANK CAPACITIES, FUEL...........14-12,14-62
TANK FILLER TUBE CAP, FUEL....14-12,25-4,25-9
TANK FILLER TUBE, NO-LEAD FUEL.......14-12
TANK, FUEL..........................14-12
TANK PRESSURE RELIEF/ROLLOVER
VALVE, FUEL...................14-15,14-56
TANK, FUEL, SKID PLATE,
BODYCOMPONENTS.............13-16,23-84
TANK SUPPORT STRAP, FUEL............23-86
TANKS, FUEL....................14-12,14-56
TAPPETS, HYDRAULIC...............9-24,9-65
TEMPERATURE CONTROL THERMOSTAT....24-35
TEMPERATURE GAUGE, COOLANT
..........8E-1
TEMPERATURE GAUGE INOPERATIVE,
COOLANT
............................8E-3
TEMPERATURE INDICATOR INOPERATIVE,
COOLANT
............................8E-3
TEMPERATURE INDICATOR LAMP,
COOLANT
............................8E-1
TEMPERATURE SENSOR, COOLANT
........25-9
TEMPERATURE SENSOR, ENGINE
COOLANT; FUEL SYSTEM
..............14-55
TEMPERATURE SENSOR, ENGINE
COOLANT; IGNITION SYSTEMS
.....8D-4,8D-22
TEMPERATURE SENSOR, INTAKE AIR
......14-54
TEMPERATURE SENSOR, INTAKE
MANIFOLD AIR
..................8D-5,8D-27
TEMPERATURE SENSORÐPCM INPUT,
ENGINE COOLANT
....................14-21
TEMPERATURE SENSORÐPCM INPUT,
INTAKE AIR
.........................14-20
TEMPERATURE, SENSOR RESISTANCE
(OHMS)ÐCOOLANT TEMPERATURE
SENSOR/MANIFOLD
..................14-43
22 INDEXJ
Description Group-Page Description Group-Page Description Group-Page

VARIATION, DISC BRAKE ROTOR
THICKNESS..........................5-31
VEHICLE CODE DECODING............INTRO.-3
VEHICLE CODE PLATE................INTRO.-2
VEHICLE CONTROL AND DISPLAY
SYMBOLS........................INTRO.-7
VEHICLE CONTROL AND DISPLAY
SYMBOLS, INTERNATIONAL.........INTRO.-3
VEHICLE DESIGNATION CODES........INTRO.-1
VEHICLE DESIGNATIONS.............INTRO.-1
VEHICLE DIMENSION DATA....INTRO.-3,INTRO.-4
VEHICLE EMISSION CONTROL
INFORMATION (VECI) LABEL............25-1
VEHICLE, ENGINE STARTER MOTOR
TEST PROCEDURES ON................8A-9
VEHICLE, GEAR ADJUSTMENTS IN........19-37
VEHICLE, GENERATOR TEST
PROCEDURES ON....................8A-14
VEHICLE IDENTIFICATION NUMBER (VIN)
DECODING.......................INTRO.-2
VEHICLE IDENTIFICATION NUMBER (VIN)
PLATE...........................INTRO.-1
VEHICLE LOAD DATA................INTRO.-3
VEHICLE LOAD DATA, XJ.............INTRO.-5
VEHICLE RESPONSE IN ANTILOCK MODE.....5-3
VEHICLE SAFETY CERTIFICATION LABEL . INTRO.-1
VEHICLE SPEED CONTROL SYSTEM
ELECTRICAL TESTS...................8H-5
VEHICLE SPEED SENSOR................14-60
VEHICLE SPEED SENSOR TEST; FUEL
SYSTEM............................14-45
VEHICLE SPEED SENSOR TEST;
VEHICLE SPEEDCONTROL SYSTEM.......8H-5
VEHICLE SPEED SENSORÐPCM INPUT....14-23
VEHICLE VIBRATION....................22-9
VENT DOOR CONTROL CABLES...........24-39
VENT, HARD TOP ROOF................23-165
VENT WINDOW, FRONT DOOR............23-50
VENT WINDOW GLASS, FULL-METAL
DOOR............................23-177
VENT WINDOW GLASSÐXJ VEHICLES,
REAR QUARTER.....................23-80
VENTILATION, FRESH AIR...............24-39
VENTILATION SYSTEM, CRANKCASE;
EMISSIONCONTROL SYSTEMS...........25-5
VENTILATION SYSTEM, CRANKCASE;
LUBRICATIONAND MAINTENANCE........0-17
VIBRATION; FRONT SUSPENSION AND AXLE . 2-17
VIBRATION; PROPELLER SHAFTS..........16-3
VIBRATION; REAR SUSPENSION AND AXLES . . 3-8
VIBRATION DAMPER; ENGINES........9-26,9-67
VIBRATION DIAGNOSIS; WHEELS AND
TIRES.........................22-9,22-10
VIBRATION, DRIVELINE..................16-3
VIBRATION, TIRE NOISE OR..............22-4
VIBRATION TYPES......................22-9
VIBRATION, VEHICLE....................22-9
VISUAL INSPECTION...................14-32
VOLTAGE, BATTERY OPEN CIRCUIT.........8A-4
VOLTAGE DROP METHOD, STARTER
FEED CIRCUITTESTS -.................8A-9
VOLTAGE SPECIFICATIONS, OUTPUT.......8B-12
VOLTAGE TEST, BATTERY OPEN CIRCUIT....8A-3
VOLTAGEÐPCM INPUT, BATTERY.........14-19
VOLTMETER...........................8E-1
VOLTMETER INOPERATIVE................8E-3
VOLTMETER, OPERATIONAL CHECK.......8A-15
WARNING INOPERATIVE, LOW FUEL........8E-4
WARNING LAMP, LOW FUEL..............8E-2
WARNING LIGHT DISPLAY, ABS............5-3
WARNING LIGHT DISPLAY, BRAKE..........5-4
WARNING LIGHTS, BRAKE.................5-1
WARNING SWITCH REPLACEMENT,
IGNITION KEY........................8U-4
WASHER, DIAGNOSING INTERMITTENT
WINDSHIELD........................8K-12
WASHER, DIAGNOSING NON-
INTERMITTENTWINDSHIELD............8K-12
WASHER, DIAGNOSING REAR WIPER.......8K-6
WASHER INDICATOR INOPERATIVE, LOW....8E-4
WASHER (INTERMITTENT), DIAGNOSING
WINDSHIELD
.........................8K-4
WASHER, INTERMITTENT WIPER
.........8K-20
WASHER (NON-INTERMITTENT),
DIAGNOSINGWINDSHIELD
..............8K-4
WASHER NOZZLE REPLACEMENT
.........8K-13WASHER PUMP REPLACEMENT . . 8K-2 8K-6,8K-11
WASHER PUMP REPLACEMENT, REAR.....8K-13
WASHER PUMP REPLACEMENTÐRIGHT
HAND DRIVE.........................8K-3
WASHER, STANDARD WIPER............8K-19
WASHERS, WINDSHIELD WIPERS..........8A-1
WASHER/THRUST PLATE SPECIFICATIONS,
30RH/32RH SNAP RING/THRUST.......21-322
WATER LEAK DETECTION AND REPAIR,
FIXEDGLASS..................23-83,23-189
WATER PUMPS.....................7-9,7-10
WATER PUMP TESTS.....................7-9
WATERDAM, FULL-METAL DOOR.........23-176
WEAR COMPENSATION, CALIPER
OPERATION..........................5-24
WEAR INDICATORS, TREAD...............22-3
WEAR PATTERNS, TIRE..................22-4
WEATHERSTRIP SEAL, COWL...........23-139
WEATHERSTRIP SEAL, LIFTGATE
OPENING...........................23-70
WEATHERSTRIP SEAL REPLACEMENT,
LIFTGATEGLASS....................23-163
WEATHERSTRIP SEAL, TAILGATE........23-161
WEATHERSTRIP SEAL, WINDSHIELD
FRAME............................23-185
WEATHERSTRIP SEAL/CROSSMEMBER
AIRDEFLECTOR, COWL................23-10
WEATHERSTRIP SEALS, DOOR WINDOW
GLASSAND DOOR OPENING............23-62
WEATHERSTRIP SEALS, FULL-METAL
DOOR............................23-180
WHEEL ALIGNMENT, FRONT...............2-5
WHEEL BALANCE, TIRE..................22-6
WHEEL BEARING LUBRICANTS, CHASSIS
COMPONENT.........................0-30
WHEEL BEARINGS, FRONT...............0-31
WHEEL BRAKE COMPONENTS..............5-1
WHEEL CYLINDER INSTALLATION..........5-37
WHEEL CYLINDER OVERHAUL.............5-36
WHEEL CYLINDER REMOVAL.............5-36
WHEEL INSTALLATION...................22-6
WHEEL LUG NUT......................22-11
WHEEL NUT TIGHTENING............5-32,5-37
WHEEL ORNAMENTATION................22-6
WHEEL REPLACEMENT..................22-6
WHEEL RUNOUT, TIRE...................22-8
WHEEL SENSOR AIR GAP ADJUSTMENT....5-49
WHEEL SENSOR INSTALLATION, FRONT.....5-49
WHEEL SENSOR INSTALLATION, REAR......5-50
WHEEL SENSOR REMOVAL, FRONT........5-49
WHEEL SENSOR REMOVAL, REAR.........5-49
WHEEL SPEED SENSOR OPERATION........5-45
WHEEL SPEED SENSORS.................5-41
WHEEL, STEERING.....................19-45
WHEEL/TIRE SIZE AND INPUT SIGNALS......5-3
WHEELHOUSE FLARES AND LINERS, REAR . 23-18
WHEELHOUSE SPLASH LINERS..........23-146
WHEELHOUSE TRIM PANELSÐXJ
VEHICLES,QUARTER.................23-115
WHEELS..............................22-6
WINDOW APPLIQUEÐXJ VEHICLES,
QUARTER..........................23-29
WINDOW DEFOGGER GRID REPAIR, REAR . . . 8N-2
WINDOW DEFOGGER GRID TEST, REAR.....8N-1
WINDOW DEFOGGER, REAR..............8A-1
WINDOW DEFOGGER SWITCH
REPLACEMENT, REAR..................8N-4
WINDOW EXTERIOR MOULDINGS, DOOR . . . 23-61
WINDOW, FRONT DOOR VENT
............23-50
WINDOW GLASS AND DOOR OPENING
WEATHERSTRIP SEALS, DOOR
..........23-62
WINDOW GLASS, FIXED
..........23-73,23-183
WINDOW GLASS, FRONT DOOR
..........23-49
WINDOW GLASS, FULL-METAL DOOR
.....23-178
WINDOW GLASS, FULL-METAL DOOR
VENT
.............................23-177
WINDOW GLASS, HARD TOP QUARTER
. . . 23-188
WINDOW GLASS, REAR DOOR
...........23-52
WINDOW GLASS, REAR DOOR FIXED
......23-53
WINDOW GLASS REGULATOR, FRONT
DOOR
.............................23-48
WINDOW GLASS REGULATOR, FULL-
METAL DOOR
......................23-177
WINDOW GLASS REGULATOR HANDLE,
FULL-METALDOOR
..................23-175WINDOW GLASS REGULATOR, REAR
DOOR
.............................23-51
WINDOW GLASSÐXJ VEHICLES,
LIFTGATE
...........................23-81
WINDOW GLASSÐXJ VEHICLES,
REAR QUARTERVENT
.................23-80
WINDOW GLASS/REAR QUARTER
PLASTIC INSERTÐXJ VEHICLES,
QUARTER
..........................23-80
WINDOW REGULATOR REPLACEMENT
.......8S-9
WINDOW SWITCH, PASSENGER DOOR
......8S-8
WINDOW SWITCH
..............8S-5,8S-6,8S-7
WINDSHIELD FRAME
..................23-184
WINDSHIELD FRAME WEATHERSTRIP
SEAL
.............................23-185
WINDSHIELD GLASS
..................23-185
WINDSHIELD GLASS REPLACEMENT
......23-75
WINDSHIELD REVEAL MOULDING
. . . 23-73,23-183
WINDSHIELD SERVICE INFORMATION
......23-75
WINDSHIELD SIDE MOULDINGÐXJ
VEHICLES
.........................23-114
WINDSHIELD WASHER, DIAGNOSING
INTERMITTENT
......................8K-12
WINDSHIELD WASHER,
DIAGNOSINGNON-INTERMITTENT
.......8K-12
WINDSHIELD WASHER (INTERMITTENT),
DIAGNOSING
.........................8K-4
WINDSHIELD WASHER (NON-
INTERMITTENT),DIAGNOSING
............8K-4
WINDSHIELD WIPER MOTOR
.............8K-2
WINDSHIELD WIPERS, DIAGNOSING
. . 8K-3,8K-11
WIPER ARM AND PIVOT ASSEMBLY
REPLACEMENT,FRONT
.................8K-9
WIPER ARM REPLACEMENT, FRONT
........8K-8
WIPER ARM REPLACEMENT, REAR
........8K-12
WIPER BLADE REPLACEMENT, FRONT
......8K-8
WIPER CONTROL SWITCH REPLACEMENT
. . . 8K-15
WIPER, DIAGNOSING REAR
...............8K-6
WIPER, LIFTGATE
.......................8K-5
WIPER MODULE, INTERMITTENT
..........8K-5
WIPER MOTOR, FRONT
.................8K-10
WIPER MOTOR REPLACEMENT, REAR
.....8K-13
WIPER MOTOR, WINDSHIELD
.............8K-2
WIPER SWITCH REPLACEMENT,
LIFTGATE
............................8K-6
WIPER SWITCH REPLACEMENT,
REAR
..............................8K-13
WIPER SWITCH TESTING
...............8K-19
WIPER SWITCHES, REAR DEFOGGER/
FOGLAMP/REAR
.....................8E-21
WIPER WASHER, DIAGNOSING REAR
.......8K-6
WIPER WASHER, INTERMITTENT
.........8K-20
WIPER WASHER, STANDARD
............8K-19
WIPERS, DIAGNOSING WINDSHIELD
. . 8K-3,8K-11
WIPERS/WASHERS, FRONT
...............8K-1
WIPERS/WASHERS GENERAL INFORMATION,
FRONT
..............................8K-8
WIPER/WASHER, DIAGNOSING REAR
......8K-14
WIPER/WASHER SWITCH TESTING,
REAR
..........................8K-7,8K-14
WIRE CODE IDENTIFICATION
.............8W-2
WIRING AND COMPONENT IDENTIFICATION
. 8W-13
WIRING AND ELECTRICAL CIRCUITS,
ABS SYSTEM
..........................5-4
WIRING DIAGRAM SHEETS AND INDEXES
. . . 8W-1
WIRING DIAGRAMS YJ
.................8W-73
WIRING PROBLEMS, TROUBLESHOOTING
. . . 8W-3
WIRING REPAIR
.......................8W-4
WIRING, SECONDARY IGNITION
...........8W-1
WOODGRAIN MOULDING
................23-19
WOODGRAIN OVERLAY
.................23-22
WORM SHAFT REPLACEMENT, RACK
PISTON
............................19-30
WORN THREADS, REPAIR DAMAGED OR
.....9-4
JINDEX25
Description Group-Page Description Group-Page Description Group-Page