1994 CHEVROLET CORVETTE battery

Downloaded from www.Manualslib.com manuals search engine 2. Add fluid at the filler plug hole. Add only enough fluid to bring the fluid
level up to the bottom
of the filler
plug hole.
3. Install the filler plug. Be sure the plug
is fully seated.
Hydraulic Clutch
The clutch linkage in your vehicle is
self-adjusting. The clutch master cylinder
reservoir is filled with hydraulic clutch
fluid.
It isn’t a good idea to “top
off’ your
clutch fluid. Adding fluid won’t correct a
leak.
A fluid loss in this system could indicate
a problem. Have the system inspected and
repaired.
When to Check and What to Use
Refer to the Maintenance Schedule to
determine how often you should check
the fluid level in your clutch master
cylinder reservoir and for the proper fluid. See
“Owner Checks and Services’’ and
“Recommended Fluids and Lubricants”
in the Index.
How to Check and Add Fluid
The clutch master cylinder is under the
Engine Control Module
(ECM) in the left
rear area of the engine compartment.
To check the fluid, look at the area
between the
ECM and the battery.
To add fluid, remove the ECM unit.
187 ...

Downloaded from www.Manualslib.com manuals search engine Battery
Every new Corvette has a Delco
Freedom@ battery.
You never have to add
water to one of these. When it’s time for
a new battery, we recommend a Delco
Freedom@ battery. Get one that has the catalog number shown on the original
battery’s label. For battery replacement,
see your dealer or the Corvette Service
Manual.
To purchase a service manual,
see “Service Publications” in the Index.
Vehicle Storage
If you’re not going to drive your vehicle
for
25 days or more, take off the black,
negative
(-) cable from the battery. This
will help keep your battery from running
down. Contact your
dealer to learn how to
prepare your vehicle for longer storage
periods.
Bulb Replacement
For the proper type of replacement bulb,
see “Replacement Bulbs” in the Index.
Halogen Bulbs
Headlight
1. Open the hood.
2. The headlights need to be halfway
open. Turn the headlight switch on,
then quickly back to the parking lights
setting.
You may have to do this a few
times to get the half-open position.
You can also open the headlights
manually. See “Concealed
Headlights”
in the Index.
of the headlight.
3. Remove the two screws on each side
195..

Downloaded from www.Manualslib.com manuals search engine 23 - Injectors #2, 3, 5, 8 (LTI);
Secondary Injector Relays (#1,2
(LT5); Secondary SF1 Control
Modules (LT5)
(10 Amp.)
24 - Turn Signal Flashers (10 Amp.)
25 - Ignition Coil and Ignition Coil
26 - Passive Keyless Entry Module
27 - Instrument Cluster; Driver Module (10 Amp.)
(5 Amp.)
Information Center; Air Bag Derm; Acceleration Slip Regulation
Switch
(15 Amp.)
Transmission Position Switch; One
to Four Shift Solenoid
(10 Amp.)
29 - Primary Cooling Fan Relay Coil;
Secondary Cooling Fan Relay Coil
28 - Backup Lights Switch;
(5 Amp.)
30 - Direct Ignition Module; Camshaft Sensor; Canister Purge Solenoid;
Throttle Position Sensor Buffer
Module; EGR Circuit (LT1);
31
32
Secondary Air Inlet Solenoid
(LT5); Electronic Ignition Control
Module (LT5); One to Four Shift
Relay
( 10 Amp.)
Power Mirror Adjuster Control;
Lighted Rearview Mirror; Visor
Vanity Mirrors
(5 Amp.)
Cruise Control Engage Switch;
Daytime Running Lights Module;
Low Tire Pressure Warning
Module
(5 Amp.)
33 - Engine Control Module (5 Amp.)
34 - Air Bag System (15 Amp.)
35 - Central Control Module (5 Amp.)
36 - Footwell Courtesy Lights; Door
Courtesy Lights; Glove
Compartment Lights; Lighted
Rearview Mirror
(5 Amp.)
37 - Bose Amplifier Relay; Power
Antenna Relay; Cargo
Compartment Lights
(20 Amp.)
Relay
(5 Amp.)
38 - LCD; Tone Generator; Dome Light
39 - Central Control Module (5 Amp.)
40 - Radio Receiver Box (Battery);
Radio Control Head; Passive
Keyless Entry Module
(5 Amp.)
41 - Sport Seat (10 Amp.)
42 - Power Door Lock Switches; Driver
Information Center; Passive
Keyless Entry Module
(20 Amp.)
43 - A/C Programmer (5 Amp.)
44 - Cigar Lighter; Accessory Plug
45 - Hatch or Deck Lid Release Relay
K - Power Seats (30 Amp. Circuit
L - Blank
M - Power Windows (30 Amp: Circuit
N - Blank
P - Blank
(15 Amp.)
(25 Amp.)
Breaker)
Breaker)
221 . I

Downloaded from www.Manualslib.com manuals search engine Replacement Parts
AirCleanerFilter .............................................. A1097C
Battery VINEngineCodeJ
........................................... 752-72
VIN Engine Code P
........................................... 75B-72
Coolant High Fill Reservoir Cap
.................................... RC36
Crankcase Ventilation Valve VIN Engine Code J
.............................. CV746CB and CV9 13C
VIN Engine Code P
................. : ........................ CV895C
VIN Engine Code
J .................................... PF970C (black)
VINEngineCodeP
............................................. PF51
VIN Engine Code J
.............................. GM Part No. 10067477
VIN Engine Code P
.............................. GM Part No. 10230259
VIN Engine Code
J ................................... 907 (0.050" Gap)
VIN Engine Code P
.................................... 906 (0.050" Gap)
Thermostat Temperature Specification
......................... 1 80 "F (82 O C)
Wheel Nuts
Wheel Nut Torque ................................... 100 lb. ft. ( 140 Nam)
Engine Oil Filter
Serpentine Belt
Spark Plug
225. ..

Downloaded from www.Manualslib.com manuals search engine ABS ........................ 125
Acceleration Slip Regulation
System
..................... 126
Accessory Plug
.................. 76
Acrylic Roof Panel
............... 70
Adding Coolant
................ 189
Add-on Electrical Equipment
..... 21 8
Air Bag System ................. 23
How the System Works
......... 24
Servicing Your Air Bag-
Equipped Corvette
........... 26
Readiness Light
................ 24
Air Cleaner
.................... 182
Air Conditioner Controls
......... 106
Air Control Buttons
............. 106
Air Filter Replacement
........... 183
Alignment and Tire Balance. Wheel
. 208
Aluminum Wheels
.............. 2 15
AMPM Stereo
With Cassette Tape Player
...... 11 3
With Cassette Tape and
Compact Disc Player
........ 11 5
Antenna. Power Mast. Care
....... 11 8
Anti-Lock Brakes
.............. ‘125
System Active Light
............ 86
System Warning Light
.......... 85
To Use
..................... 126
Appearance Care
............... 21 0
Appearance Care and Materials .... 21 7
Appearance Care. Service and
..... 171 Ashtray and
Lighter
.............. 75
ASR System
................... 126
Active Light
.................. 87
Off Light .................... 86
Warning Light
................ 86
Audio Systems
................. 112
Audio Systems. Comfort Controls and
................. 105
Automatic Electronic Climate
Control
..................... 108
Air Control Buttons
........... 108
Automatic Control
............ 109
Defogging and Defrosting
Windows
................. 110
Fan
Control Buttons ........... 108
Manual Bi-Level
............. 109
Manual Cooling
.............. 109
-Manual Heating
.............. 109
Manual Ventilation
............ 109
System Problems
............. 110
Temperature Control Switch .... 108
Temperature Sensors
.......... 108
Automatic Transmission
.......... 5 1
Automatic Transmission Fluid
..... 184
Axle. Limited-Slip Rear
........... 56
Axle. Rear
.................... 188
Babies. Smaller Children
Balance. Wheel Alignment and
(Safety Belts)
.............. 28
and Tire
.................... 208 Battery
....................... 195
Battery Replacement. Passive Keyless
Entry System
................. 41
BBB Auto Line
. Alternative
Dispute Resolution Program.
GM Participation in
......... 253
Before Leaving on a Long Trip
.... 135
Belt. Lap-Shoulder
............... 20
Bi-Level
...................... 107
Blizzard. If You’re Caught in a
.... 138
Block Heater. Engine
............. 50
Brakes Adjustment
.................. 194
Anti-Lock (ABS)
............. 125
Fluid
....................... 193
Master Cylinder
.............. 193
Parking
...................... 56
PedalTravel
................. 194
System Parts. Replacing
........ 194
System Warning Light
.......... 84
Wear Indicators. Disc
.......... 194
Braking (Control of a Vehicle)
..... 124
Braking in Emergencies
.......... 127
“Break.In.
.. New Vehicle ......... 46
Brightness Control
............... 67
Bulb Replacement
.............. 195
Back-up Light
............... 198
Center High-Mounted Stoplight
.............. 200. 201
Cornering Light
.............. 199
Fog Lamp
................... 196
261 ...

Downloaded from www.Manualslib.com manuals search engine Replacement Air Filter
.................... 183
Battery. Passive Keyless Entry
System
.................... 41
Bulbs (Part Numbers)
.......... 223
Bulbs (Service)
............... 195
Parts
....................... 225
Wheel
...................... 208
Wheels. Used
................ 209
Replacing Brake System Parts
..... 194
Replacing Safety Belts after
a Crash
...................... 33
Reporting Safety Defects
......... 254
Restraint Systems. Seats and
....... 11
Restraints Checking Your System
.......... 33
Child
........................ 29
Ride Control. Selective
........... 56
Road. Problems on the
........... 141
Road. Your Driving and the
....... 12 1
Roads. Hill and Mountain
........ 136
Roadside Assistance. Canadian
.... 255
Roadside Assistance. Chevrolet
.... 255
Rocking Your Vehicle to Get It Out
. . 170
Roof Panel Installing
.................... 72
Removing
.................... 70
Storing
...................... 71
Rotation. Tire
.................. 206
Rough Idling
................... 50
Running Lights. Daytime .......... 68 Running
Your Engine while
Safety Belts
You’re Parked
................. 59
Adults ....................... 19
Care of
..................... 212
Checking
.................... 33
Children
..................... 28
Extender
..................... 33
How to Wear Properly
.......... 19
Label
....................... 33
Lap Belt Cinch Feature
......... 21
Lap-Shoulder
................. 20
Larger Children
............... 31
Air Bag System
............... 21
Passenger Position
............. 27
Questions People Ask
.......... 18
Reminder Light
............... 19
Replacing after a Crash
......... 33
Smaller Children and Babies
..... 28
Use during Pregnancy
.......... 27
Why They Work
............... 15
Reporting to General Motors
.... 254
Reporting to the Canadian
Government
............... 254
Reporting to
the United States
Government
............... 254
Safety Warnings and Symbols
....... 8
Schedule. Maintenance
.......... 229
They’re for Everyone
........... 14
Safety Defects Scheduled Maintenance
Services
... 231
Scheduled Maintenance Services.
Explanation of
............... 236
Seatback Latches
...................... 13
Manual Reclining
.............. 13
And Restraint Systems
.......... 11
And Seat Controls ............. 12
Manual Front
................. 12
Power
....................... 12
Seats
sport
........................ 13
Securing a Child Restraint in the
Passenger Seat
................ 30
Security Light
................... 96
Security Shade
.................. 74
Selective Ride Control
............ 56
Service
....................... 172
and Appearance Care
.......... 171
Engine
Soon Light ............. 91
LTPWS Light
................. 89
Parts Identification Label
....... 218
Publications
................. 256
Publications Ordering Information,
Chevrolet
................. 258
Ride Control Light
............. 95
Work, Doing Your Own
........ 172
Servicing Your Air Bag-Equipped
Corvette
..................... 26
Setting the Clock
............... 113
Shade, Security
................. 74
267 . .

Downloaded from www.Manualslib.com manuals search engine Service Station Information
Battery
The Delco Freedoms battery needs
no water.
See Page 195
r
Cold Tire Pressure
See Tire-Loading Information
driver’s door.
See Page 206
label on inside edge of
Fuel,
Use unleaded gas only,
91 octane or higher.
See Page 173
I
i
tank
by using the dipstick. Add coolant only at
the coolant fill reservoir. The fluid should
be at or a little above the “HOT” mark
on
the dipstick when the engine is warm. If
the engine is cool, the level should be at
“COLD” on the dipstick. See Page 188
‘Engine Oil Dipstick and Fill Cap
‘Windshield Washer Fluid
See Page 178
See Page 192
1. Special Wheel Nut Socket and
f Wheel Lock Key
See Page 160
0 Spare Tire Pressure
See Tire-Loading Information
label
on inside edge of
driver’s door. See Page 206